Chevrolet Cobalt Complaints

7,975 consumer complaints on file.

#11673793July 15, 2025
UNKNOWN OR OTHER
Our daughter observed a significant puddle forming under her vehicle and noticed a strong smell of gasoline. She sent us a video, which clearly showed gasoline leaking from the driver-side rear area of the car. Due to the proximity of the fuel leak to the exhaust pipe, we had the car towed to a mechanic, as it was too dangerous to drive. The mechanic diagnosed the issue as a severely rusted-out fuel line that required immediate repair. At no point did the vehicle display any warning lights or alerts related to this issue. Alarmingly, our daughter had unknowingly driven the car while the leak was occurring, unaware of the serious fire risk this posed. We believe this is a serious safety hazard that could lead to a fire or explosion and strongly urge an investigation. This failure occurred without warning and could have resulted in a catastrophic outcome. We are fortunate this was caught in time, but others may not be as lucky.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673114July 13, 2025
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
The fuel tank has an evap leak that somehow breaks on top the tank so it leaks the gas vapors and could potentially start a fire but the part that breaks is a non serviceable part so it can’t be fixed without purchasing a whole new gas tank that isn’t cheap. My other concern is the infamous grounding issue with the wires on the ground g105 I believe right next to oil filter that grounds the transmission and engine control modules well it shorts at times when driving and suddenly your car dies while driving how scary it could cause a wreak and kill somebody it’s a very scary issue that constantly comes back even after trying to re ground it needs to be recalled and fixed it’s going to kill somebody and it’s a well known issue for this make and model that should have already gotten attention to be resolved.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669269June 25, 2025
STEERING
The contact owns a 2008 Chevrolet Cobalt. The contact stated that the power steering suddenly failed to operate as needed. The vehicle was turned off for a while and restarted for the power steering functionality to return. The failure was persistent. The contact stated that the power steering warning light flashed on the instrument panel. The vehicle was taken to a certified mechanic, who informed the contact that it was a known failure with the power steering. The mechanic confirmed the power steering failure and referred the contact to the dealer for assistance. The dealer was contacted and confirmed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667876June 19, 2025
STEERING
I have been experiencing the loss of steering assist. This occurs at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds. Steering control is maintained in manual mode, but requires greater driver effort at low vehicle speeds. In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed. The occurs at speeds in excess of 60mph.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665285June 6, 2025
FUEL/PROPULSION SYSTEM
The fuel line is leaking fuel on the drivers side near the passenger door. The leak is to the point where it is pooling under the door on the ground.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664917June 4, 2025
STEERING
The contact owns a 2005 Chevrolet Cobalt. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the desired direction. The contact stated the power steering warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact referenced an unknown recall; however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662262May 21, 2025
POWER TRAIN
UNKNOWN
Crash:
Yes
Fire:
Yes
Injuries:
6
Deaths:
3
#11661851May 19, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, STEERING
The ignition doest work right n want release the key the car dies n stalls while driving we was almost hit by a trooper n he called we spoke to 2 people n they had a gm call us n they said that this has been a big concern of these cars n we tried n tried to get it fixed n they say sorry can't can they when something they built wrong kills me or my family my vin [XXX] 2008 CHEVY COBALT [XXX] IS MY NUMBER INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11656377April 23, 2025
ELECTRICAL SYSTEM, STEERING, SERVICE BRAKES, HYDRAULIC
The contact owns a 2007 Chevrolet Cobalt. The contact stated that while driving approximately 35 MPH, the power steering warning light illuminated, and the contact had to manually steer the vehicle. The contact continued to drive the vehicle without power steering functionality. The contact stated that additional electrical failures had occurred. The contact also stated that the ABS activated and deactivated independently, and the traction control became inoperable. The instrument panel also became inoperable, and the contact was unable to see the speedometer and fuel gauge functions on the instrument panel. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653303April 7, 2025
AIR BAGS, ELECTRICAL SYSTEM
Our vehicle has had zero accidents the airbag light showed up on dashboard stating check airbags. Then as far as electrical the headlights seem to turn on there own at times. We feel this perhaps is a recall not known yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647813March 12, 2025
STEERING
Steering went out while driving
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631947December 21, 2024
AIR BAGS, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
The air bag never deployed I bought car in 2018 from original owner with car only having 33,000 miles on it and still under warranty til car had 100,000 miles and I hit a deer head on 2 months after getting car which bought in may of 2018 hit the deer in July 2018 . The deer was hit with the front passenger side it broke my headlight n messed my hood up and smashed in the grill little and my air bags never deployed I hit deer at 50 mph , after that had happened I took it in to Chevy dealership and had them look at car cause I told them I hit that deer and air bag never deployed and that my air bag light came on once in awhile and said service air bag . The dealership said they do that sometimes and did something to make light go off that was it my air vag light still comes on and says service air bag . Also ignition switch and fuel smell foul coming from car a lot and is as I speak . My reduce engine power light comes on a lot and have no power to gas pedal n car won’t stay running . I have try to get two recalls fixed back in 2-21 I was having problems with my car back then too special reach called me in Jan of 2021 and told me that there were two recalls on my car ignition switch and fuel module so I informed dealership when I took my car in That next month in feb 21 told them I was informed on 2 active recalls on my car . When they were done with my car later that day I asked them if they fixed the recalls they said no cause it was map sensor so I then made an appt to get recalls fixed when I got there for the recalls to be fixed one of the technicians told me it shows that they were done . I called Chevy and complained about the issue I just had and never had recalls fixed but they must of put it in computer they fixed them So I’ve been really upset that I been trying to get past recalls fixed that are on my car and I get run around and told there isn’t any I know about a past recall on shift selnoid low circuit too that was a past recal
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11629405December 7, 2024
UNKNOWN OR OTHER
I have 2 recalls with the ignition and switch. I went to Regal chevrolet in Lakeland Florida and was told essentially there's nothing they could do and if they did look at it I'd be charged $200 to have it looked at plus $219 a hour based on what needed to be done. I then called Stingray Chevrolet in Plant City Florida and was told that there was no listed recall or it had already been serviced, which on the national website clearly states the opposite, and they refused to even look at it or attempt to fix it, recall or not. My key snapped in the ignition so after being told by 2 chevrolet dealerships essentially "sorry about my luck" I called out a locksmith who extracted the piece of key in ignition and attempted to code several new cut keys. Everything failed. I'm now out almost $500 based off 2 dealerships refusing to assist with a clear recall. I need this fixed and have been without a vehicle for 3 weeks. If somebody could please assist me I'd greatly appreciate it. I feel like it is wrong and somewhat cruel for Chevrolet dealerships to be as they were based off a clearly stated and documented issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628768December 4, 2024
AIR BAGS, VEHICLE SPEED CONTROL
The contact owns a 2009 Chevrolet Cobalt. The contact stated that while driving 55 MPH, the contact struck a deer. The air bags did not deploy. Additionally, while driving at slow speeds, the vehicle lost motive power. The contact restarted the vehicle. There was an abnormal sulfur and fuel odor detected. The air bag warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the MAP sensor needed to be reset. The mechanic reset the air bag light. The mechanic was unable to determine the cause of the air bag failure. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 33,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11628474December 3, 2024
AIR BAGS, ELECTRICAL SYSTEM
The contact owns a 2008 Chevrolet Cobalt. The contact stated that upon starting the vehicle, the air bag warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621929October 25, 2024
STRUCTURE:BODY
Internal mechanism of the driver-side door handle broke and the door would not open from the inside. Tne dealership confirmed that the inside door ah glue is broken. The cable retainer snapped apart and the cable cannot stay connected. This might be available for inspection. Driver must exit the vehicle by crawling over to the passenger side. The problem has been confirmed by a Chevrolet dealer. There were no warning lamps or messages. The manufacturer no longer makes this part and it could not be replaced. Service description says that the customer had an electrical concern and that the door would not unlock from the inside. This was inaccurate. It was mechanical. The door could unlock, it could not open. The dealership would not let the diagnosis proceed until the customer agreed to that statement. The dealership inaccurately recorded the mileage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11616719September 26, 2024
STEERING, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
My Power Steering is going out and then coming back in to use. Today is the second time it has happened. It went out just now, I reversed down the road to my house, and turn it off once I crank it again the steering is back. I haven’t gotten any pictures of it as I’m more worried about making it back to my house so I’m not in the road but will be more than happy to get a picture if this happens again. I’m also not sure which ADAS this connects to so I put cruise control.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613382September 9, 2024
FUEL/PROPULSION SYSTEM
The gas lines rusted out and the fuel pump is pooring gas out of it. I just bought the car 2 weeks ago smelled gas hit u set the car it was pouring out. I was going to fix it my self then while looking up the parts I ran across the fact they recalled both parts but not for my vin . What can I do. I'm gonna catch on fire
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613220September 7, 2024
STEERING
Was driving home from work on i70 through the canyon when out of no where I wasn't able to steer my car...was able to stop the car, turned it off .waited a minute then started back up that is when power steering came across my dash .nothing was wrong with my car ,drove normal then out of nowhere going the speed limit 75mph. I'm not able to steer my car. This never happened before ,scared the crap out of me with no warning almost crashed cause I could not steer my car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609896August 21, 2024
FUEL/PROPULSION SYSTEM
There is a leak in the fuel lines that is just awful. Constant while driving Many others have experienced as well. Leaves huge puddles of gas
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Cobalt