Chevrolet Cobalt Complaints

7,975 consumer complaints on file.

#11455761March 8, 2022
FUEL/PROPULSION SYSTEM
Fuel line was leaking on driver's side rear wheel close to heat shield and muffler. Cost me 1,000 to have lines replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455292March 5, 2022
ELECTRICAL SYSTEM, STEERING, ENGINE
The problem that sent it to a different mechanic than the chevy dealer where it came from after a month and 900.00 bill for 550.00 ecm and diagnostic test they did without my permission, there labor for the test and ecm was a total of 900.00. Plus claimed it was throwing a code for a peddle that it needed. We just put a brand new peddle and brand new throttle body on it, it was idled to high, so reason for them getting it was to get the old ecm and new throttle sinked up to reduce the idle , at the time of it leaving me it started and ran just idle to high. Throwing no codes. They got it, claim it wouldn't start so did a diagnostic claimed it needed a new peddle. I said I'm coming to get it, they didn't tell me at any time I couldn't drive it home. I left there lot and pulled about 150 feet off the side of road because it wouldn't shift. Called them , botched did no good. Called same tow truck to tow it home. Got here it was idled normal but was throwing a different codes, I turned the car off it wouldn't stop running for about 3 to 4 minutes, then it died. I had it towed to different mechanic for the ignition to be replaced. He said it was throwing a couple codes still ignition not fixed yet, and it ran for about 15 minutes after shutting off the key. At no time here or at the new place did it throw a code for a defective peddle. So now it's be gone for 2 months , new ecm , new throttle body ,new peddle, idle is fixed and car runs but won't shift. Codes its throwing is now are just needing coil on #4 checked and throttle position sensor adjusted. So far that's it. 2 months later. Still not ready for pick up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455230March 4, 2022
STEERING:ELECTRIC POWER ASSIST SYSTEM
The contact owns a 2010 Chevrolet Cobalt. The contact stated while driving 20 MPH, she attempted to make a right turn and the steering wheel seized. The contact was able to stop the vehicle, turn off the vehicle, and after restarting the vehicle, the power steering was functioning as needed. The contact stated that no warning light was illuminated. The vehicle was taken to a dealer where the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 71,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11452095February 15, 2022
STEERING
The contact owns a 2006 Chevrolet Cobalt. The contact stated that while reversing out of a parking space, the vehicle lost power steering assist functionality. The contact stated that excessive force was needed to steer the vehicle. The contact was uncertain if any warning lights were illuminated. Upon investigation, the contact discovered NHTSA Campaign Number: 10V073000 (Steering) which he linked to the failure. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 89,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451477February 11, 2022
FUEL/PROPULSION SYSTEM
There is gas puddling around the driver rear tire. I saw an article, which can be found here: https://www.thecarconnection.com/news/1128764_more-than-600-000-chevy-cobalt-and-hhr-models-investigated-for-fuel-leaks Gas leaking is an obvious safety problem due to the risk of fire or worse. The symptoms began yesterday - February 11, 2022. I did bring the vehicle to Bob McCosh Chevrolet in Columbia, Missouri. They reported there are no recalls on that system. But as the article link above confirms, I am certainly not alone in this problem. I believe this problem is being investigated but no recall has been issued. I will also follow up with the service manager at Bob McCosh Chevrolet in Columbia, Missouri. I will escalate to the regional service manager for Chevrolet. In the meantime, it would be very helpful if the weight of the FHTSA could get behind this problem. I can be reached at [XXX] if you have additional questions. My email is [XXX]. Thank you. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450922February 8, 2022
STEERING
The contact owns a 2006 Chevrolet Cobalt. The contact stated that while driving at 35 MPH, the power steering warning light illuminated on the instrument panel. The contact stated that excessive force was needed to steer the vehicle while making a right turn into a parking lot. The contact returned to the vehicle and the failure persisted. After making a second stop, the light disappeared and the steering wheel resumed normal operation. The dealer nor the manufacturer had yet to be notified of the failure. Upon investigation, the contact discovered NHTSA Campaign Number: 10V073000 (Steering) which she linked to the failure. The vehicle had yet to be repaired. The failure mileage was approximately 132,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448886January 25, 2022
ELECTRICAL SYSTEM, ENGINE, STEERING
My power steering alert came up and immediately I start having trouble driving as the steering wheel got tight. Almost had a accident and there is other problems with my 2006 chevy cobalt lt that have been on recall and I cannot get any help at local dealership
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11448653January 24, 2022
AIR BAGS, ELECTRICAL SYSTEM, ELECTRICAL SYSTEM:IGNITION:SWITCH
The contact owns a 2007 Chevrolet Cobalt. The contact’s mother stated that while driving at various speeds, the vehicle would stall without warning. The contact stated no warning lights was illuminated. The vehicle was towed to a local dealer where it was diagnosed with needing the ignition switch replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System) however, the VIN was not included. The manufacturer was informed of the failure but offered no assistance. The failure mileage was approximately 107,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11447449January 14, 2022
FUEL/PROPULSION SYSTEM
I noticed the smell of fuel originating from the near the left rear well a few days ago (~1/1/2022). I took my car to a mechanic who confirmed fuel leaking out from a line located near the left rear well. The mechanic claims the leaks are caused by corroding metal fuel lines and was due to poor engineering/ design of the car. The gas line is rusted and leaking, there is a strong odor of gasoline at the rear drivers side tire of my car and I can feel/ see the fuel leaking. I have been driving my 4 month old son around in that car for months and had no idea fuel was leaking and I was putting both of our safety at risk! I called my local chevy dealership about fixing it and they said it will be at least $1300 to repair the leak and more if the gas tank needs to be replaced. I am taking the car to the dealership on 1/18/2022. There were no signs of anything wrong besides the strong smell of gas.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11447314January 13, 2022
ENGINE, FUEL SYSTEM, GASOLINE
The contact's mother owns a 2009 Chevrolet Cobalt. The contact stated that while his mother was starting the vehicle, the passenger's side air bag made clicking sounds. Additionally, the engine would rev, and the vehicle would shake while idle. The vehicle was taken to an independent mechanic who replaced the fuel filter, spark plugs, and ignition coils; however, the failure recurred. The vehicle was not repaired. The dealer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The manufacturer was not made aware of the failure. The failure mileage was 106,864.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11446863January 10, 2022
STEERING
The contact owns a 2009 Chevrolet Cobalt. The contact stated that while reversing at an undisclosed speed, the electric power steering assist failed, and the steering wheel was difficult to maneuver. The power steering warning message was displayed. The dealer was made aware of the failure and informed the contact of NHTSA Campaign Number: 10V073000 (Steering) that was associated with the VIN. The dealer also informed the contact to bring the vehicle in for diagnostic testing. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 113,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11445668December 30, 2021
FUEL/PROPULSION SYSTEM
Around Dec. 22, 2021, I started smelling gas outside and inside of my car (particularly the right back seat near the gas tank). I took it to a local mechanic and he urged me to take it to the dealership for service and to not drive the car a lot because it could be dangerous. He said it was the gas tank pump and that there was a recall that I should look into. I took my car to a local dealership for service and upon inspection, they removed and replaced the fuel pump and plastic lines - they confirmed there was an issue with the gas pumps.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11444985December 26, 2021
FUEL/PROPULSION SYSTEM
Gas leaking near rear drivers side wheel well causing puddle of gas underneath the car on the ground
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11444221December 18, 2021
FUEL/PROPULSION SYSTEM
I can smell a gas leak inside and outside of car just bought car for girlfriend don't want it to catch fire and kill her and daughter baby in car
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11444055December 16, 2021
AIR BAGS
Derive airbag idiot light is on and service airbag message is on
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443907December 15, 2021
STEERING
The contact owns a 2007 Chevrolet Cobalt. The contact stated while reversing, there was an abnormal sound and a message was displayed "Power Steering" as the steering wheel became difficult to maneuver. The vehicle was turned off and restarted to resume normal operation. The vehicle was not taken to a dealer or independent mechanic for diagnosis or repairs. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443649December 13, 2021
FUEL/PROPULSION SYSTEM
Strong smell of gas when driving, also strong smell of gas around car in general. Underneath the car you can see gas pouring from fuel tank, looks like it’s coming from top of gas tank. Whenever I park in a parking space, in my driveway or park for any period of time I always leave a puddle of gas. I just started my car and looked underneath at gas tank, there is a steady stream of fuel coming from somewhere on gas tank.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11443153December 8, 2021
FUEL/PROPULSION SYSTEM
Vehicle leaks fuel from the fuel line underneath the vehicle near the left rear wheel well adjacent to the exhaust pipe and muffler in a manner in accordance with currently open USDOT/NHTSA investigation (PE 20-011). A substantial puddling of fuel occurs on the ground from fuel dripping through the subframe. This is currently still happening and is available for inspection. Severe risk of fire is apparent, a highly volatile fuel in substantial amount is leaking/exposed to a substantial heat source, and could be ignited. Problem can be reproduced. Situation has been brought to the attention of two local GM dealerships, and a complaint filed with GM Corporation (Case# 9-7117335295). Prior to this finding, a substantial fuel odor was present in the cabin.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11442328December 1, 2021
FUEL/PROPULSION SYSTEM
Fuel line rusted to the point of major leakage. Inside the heat wrap near the exhaust pipe, just forward of rear drivers side tire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11442331December 1, 2021
AIR BAGS
Passenger side seat caused a situation where the air bags were turned off and warning lights to come on in dash. This occurs sporadically, it happens if I move the seat or if some one sits in it then gets out of the car. Has happened since I first bought the car used.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Cobalt