BMW ActiveHybrid 3 Service Bulletins
601 manufacturer communications on file.
- April 1, 2013•Document ID: 10149336Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 120113
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
Summary"Transmission Intermittently Goes into ""P"" or ""N"" after MSA Engine Start. The transmission can intermittently go into the Park (P) or Neutral (N) position after an MSA engine start without any customer influence. This problem is very sporadic, difficult to reproduce, and no relevant faults are stored. Unfavorable DME/EGS software"
Associated Products (16)Associated Documents - March 1, 2013•Document ID: 10150135Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 840413
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
Summary"TCB: Emergency Call Is Disabled. A Check Control message shows ""Emergency call failure."" When the SOS button is pressed, the call is not made by the TCB (Telematics Communication Box). Fault code 0XB7F33F is stored in the TCB. CAUSE TCB application error"
Associated Products (42)Associated Documents - March 1, 2013•Document ID: 10150130Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM); EQUIPMENT
- Mfr Comm. #:
- 651009
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
SummaryThe vehicle position is missing or incorrect on the navigation map. The navigation system integrated in the Car Information Computer (CIC) is not calibrated correctly.
Associated Products (173)Associated Documents - March 1, 2013•Document ID: 10150114Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 610211
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
SummaryAdvanced Onboard Battery Diagnostics. INFORMATION Starting with the introduction of the F10 (5 Series), an advanced intelligent battery sensor has been used. This now makes it possible for the vehicle to monitor the condition of the battery in order to determine if the battery needs to be recharged or replaced, along with the remaining capacity of the battery. The analysis and testing of the battery's SoC (State of Charge) and SoH (State of Health) is now performed using ISTA (Integrated Service Technical Application) diagnosis. A separate test using a battery tester is no longer needed.
Associated Products (68)Associated Documents - March 1, 2013•Document ID: 10150108Service Bulletin/Repair InstructionsSERVICE BRAKES, HYDRAULIC
- Mfr Comm. #:
- 340313
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
Summaryncorrect Remaining Service Life from CBS Data for Brake pads. The calculated remaining service life for the brake pads (front and/or rear axle) from the CBS data does not match the actual brake pad thickness. The customer notices implausible remaining distances (too high or too low) on the front and/or the rear axle brake system. Software calculation in the brake pad wear model
Associated Products (6)Associated Documents - March 1, 2013•Document ID: 10150102Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 170113
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
SummaryService Action: Replace Coolant Expansion Tank. The low coolant level warning may come on in the information display. CAUSE Insufficient contact at the electrical connector for the coolant level sensor causes an inaccurate reading of the coolant level.
Associated Products (11)Associated Documents - March 1, 2013•Document ID: 10150098Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- 130113
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
SummaryFuel Tank Pressure Plausibility. A check engine light may be illuminated and the following fault is stored in the DME: 19401B: Fuel tank temperature-pressure sensor, plausibility; pressure to low opposed to ambient The integrated PT (pressure/temperature) sensor in the NVLD module must be calibrated at all times. If not calibrated, this fault will set when the pressure monitored has drifted out of the specified range. This condition is most common on vehicles that have had a software update with a version of ISTA/P up to 2.48.3. However, the fault may not occur immediately following programming. NOTE: If additional faults are stored for communication with the temperature sensor, further investigation is necessary. If the in-tank temperature reads a default high value such as 471°C, continue with the applicable test plan to determine the root cause. CAUSE ISTA/P versions up to 2.49.0 did not incorporate the PT sensor calibration in the update.
Associated Products (4)Associated Documents - March 1, 2013•Document ID: 10150096Service Bulletin/Repair InstructionsPOWER TRAIN; ENGINE
- Mfr Comm. #:
- 121611
- Date Added:
- December 3, 2018
- Manufacturer:
- BMW
SummaryN55 Engine Failsafe - FC 120308 Boost Pressure Control, Plausibility: Pressure Too Low Stored in DME Fault Memory. INFORMATION The customer complains the SES is illuminated and the engine has reduced power (engine failsafe mode).
Associated Products (134)Associated Documents - February 1, 2013•Document ID: 10149457Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 651412
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryHeadunit High: Vehicle Position Is Incorrect on the Navigation Map. The vehicle position on the navigation map is incorrect. With route guidance active, the vehicle is displayed: * In an incorrect location Or * Outside the planned route The navigation system integrated in the Headunit High (HU-H) is not calibrated correctly.
Associated Products (51)2014 BMW 528i2014 BMW 535d2014 BMW 535i2014 BMW 550i2014 BMW 740i2014 BMW 740Li2014 BMW 750i2014 BMW 750Li2014 BMW 760Li2014 BMW ActiveHybrid 32014 BMW ActiveHybrid 72014 BMW M52013 BMW 528i2013 BMW 535i2013 BMW 550i2013 BMW 740i2013 BMW 740Li2013 BMW 750i2013 BMW 750Li2013 BMW ActiveHybrid 3+ 31 moreAssociated Documents - February 1, 2013•Document ID: 10149453Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 650413
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryService Action: Real Time Traffic Information Activation. The Real Time Traffic Information (RTTI) is inoperative. ??The traffic information icon is missing from the menu in the navigation map screen. CAUSE Option 6UH (RTTI) is missing from the Vehicle Order (VO).
Associated Products (11)Associated Documents - February 1, 2013•Document ID: 10149447Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 610413
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
Summary"After FEM Replacement, ISTA/P Unable to Read Vehicle Order. After the FEM (Front Electronic Module) is replaced, ISTA/P states ""The vehicle order could not be read from the vehicle. Import of the vehicle order required."" The replacement FEM does not contain the vehicle-specific data, including the Vehicle Order (VO). The proper ISTA/P parts replacement procedure was not performed."
Associated Products (11)Associated Documents - February 1, 2013•Document ID: 10149446Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 610211
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryAdvanced Onboard Battery Diagnostics. Starting with the introduction of the F10 (5 Series), an advanced intelligent battery sensor has been used. This now makes it possible for the vehicle to monitor the condition of the battery in order to determine if the battery needs to be recharged or replaced, along with the remaining capacity of the battery. The analysis and testing of the battery's SoC (Stateof Charge) and SoH (State of Health) is now performed using ISTA (Integrated Service Technical Application) diagnosis. A separate test using a battery tester is no longer needed.
Associated Products (72)Associated Documents - February 1, 2013•Document ID: 10149445Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- 520213
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryFront Seat Headrest Height Changes. The left or right front seat headrest can no longer be lowered to its lowest position, and is at a different height than before.
Associated Products (11)Associated Documents - February 1, 2013•Document ID: 10149444Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- 520113
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
Summary"Front Crash-Active Headrest Has Limited Height Adjustment. INFORMATION This bulletin will help you understand the features of the crash-active headrest and explain the benefits to your customers and center staff. 1. Learn the safety features and operation of the front seat and crash-active headrest. Photos A and B: In the event of an accident, the rear passenger must be able to move the front seatback forward, regardless of the seat position. This allows the rear passenger an easy exit from the rear seat of the vehicle, even if the electrical power source is no longer available. 2. When the seatback is manually moved, the headrest must have free movement throughout the full range of the seatback. Photos C and D: The headrest and seatback must be able to move fore and aft without contacting the roof or sun visor, regardless of seat position. The headrest height will automatically adjust to maintain this clearance, regardless of seat position. 3. In case of an accident, the crash-active headrest will be automatically activated forward to reduce the distance between the occupant's head and the headrest. This results in increased safety for the occupant. Photo E shows the headrest in the normal position. Photo F shows the headrest in the ""active"" position and will not contact the roof. Note: The headrest's chrome bar supports can be seen. "
Associated Products (11)Associated Documents - February 1, 2013•Document ID: 10149442Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 513712
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryService Action: Replace B-pillar Manufacturer's Certification Label. The B-pillar manufacturer's certification label data does not match the vehicle.
Associated Products (6)Associated Documents - February 1, 2013•Document ID: 10149437Service Bulletin/Repair InstructionsVISIBILITY
- Mfr Comm. #:
- 510413
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryNoise from Front Windshield. When driving at varying road speeds, a wind or whistling noise may be heard coming from the windshield at the Apillars. The gap between the drip molding and the A-pillar is excessive or uneven.
Associated Products (6)Associated Documents - February 1, 2013•Document ID: 10149435Service Bulletin/Repair InstructionsVISIBILITY
- Mfr Comm. #:
- 510213
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryNoise from the Door Mirror when Opening the Front Door. A grating noise may occur in the area of the mirror triangle when the door is opened or closed. CAUSE The door mirror triangle fitment to the mirror recessed cover
Associated Products (11)Associated Documents - February 1, 2013•Document ID: 10149433Service Bulletin/Repair InstructionsWHEELS
- Mfr Comm. #:
- 360113
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummarySteering Wheel Vibration at Speeds of 42-55mph. The customer complains of vibration at speeds between 42-55 mph. Wheel/tire combination Drive flange/wheel bearing Alloy wheel to wheel hub clearance out of tolerance Tension strut hydro-mount leaking
Associated Products (11)Associated Documents - February 1, 2013•Document ID: 10149427Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 111212
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryN20 Engine: Engine Oil Filter Application. INFORMATION The current version of EPC does not provide all available options for the engine oil filters that are used in the N20 engine. The illustrations below will help identify the proper engine oil filter application until the EPC is corrected. Vehicles produced prior to 6/2012 will be equipped with a black plastic oil filter housing (1). In this case, engine oil filter kit P/N 11 42 7 634 291 should be used. Vehicles produced as of 6/2012 and later will be equipped with a silver aluminum oil filter housing (1). In this case, engine oil filter kit P/N 11 42 7 640 862 should be used.
Associated Products (41)Associated Documents - January 1, 2013•Document ID: 10149315Service Bulletin/Repair InstructionsSEAT BELTS:FRONT:WARNING LIGHT/DEVICES; AIR BAGS; EQUIPMENT; SEAT BELTS
- Mfr Comm. #:
- 651712
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryCheck Control Message "Restraint System Faulty" Is Displayed. Intermittently the check control message "Front Passenger Restraint System Faulty" is displayed in the Central Information Display. The following information is read from the vehicle: 1. Key Reader Vehicle Defects Details shows DTC: 930AB3. 2. ISTA fault code "930AB3-POL: indicator lamp for passenger airbag deactivation: short-circuit to plus" The fault condition is not present. 3. ISTA check control message ID 109 CAUSE FZD (Operating Unit for Roof) software error causes the POL (Passenger Airbag Off Lamp) to intermittently malfunction.
Associated Products (6)Associated Documents