BMW 328i Service Bulletins
739 manufacturer communications on file.
- April 1, 2016•Document ID: 10151255Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT
- Mfr Comm. #:
- B121116
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryISTA/P Cannot Program an E-Series N55 Replacement DME. ISTA/P fails when attempting to program a replacement DME (MEVD172) on BN2000 E-Series vehicles with the Continental HPP. Part number: 12 14 8 618 483. DME logistic error between the replacement hardware and basic software prevents correct programming with ISTA/P.
Associated Products (45)Associated Documents - April 1, 2016•Document ID: 10151253Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
- Mfr Comm. #:
- B120916
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryN20 - The Service Engine Soon Light is On with DME Fault 118602 Stored. The Service Engine Soon light is on (MIL) with only the following oxygen sensor fault stored. 118602 - Oxygen sensor before catalytic converter, fine mixture control: exhaust gas after catalytic converter too lean CAUSE An actual engine related problem and/or DME software diagnostic
Associated Products (61)Associated Documents - April 1, 2016•Document ID: 10151249Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM
- Mfr Comm. #:
- B111615
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryN20 and N26 engine: Smoke from Exhaust when Starting a Cold Engine. When starting a cold engine, blue smoke can be seen emitting from the exhaust tailpipe for approximately 10-20 seconds. No turbo charger boost faults are stored and no drivability issues can be detected. CAUSE When the vehicle is parked overnight the engine oil pressure will equalize and may leak past the turbo charger exhaust side turbine seal.
Associated Products (83)Associated Documents - April 1, 2016•Document ID: 10151247Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B110616
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryN51, N52, N52K and N52T Engines: Various Eccentric Shaft Sensor Faults stored in the DME - Diagnostic Hints. The customer may complain about one of the following: Rough engine running Engine cannot be started (crank no start) Check Engine Light illuminated One or more of the following faults may be stored in the DME: 2A37 - Valvetronic, eccentric shaft sensor plausibility 2A47 - Valvetronic, eccentric shaft, signal plausibility 134E08 - Eccentric shaft plausibility (on F10, F25 vehicles only) CAUSE The VVT eccentric shaft sensor connector, and/or DME connector may have oil contamination due to oil leakage at the VVT sensor gasket.
Associated Products (50)Associated Documents - March 21, 2016•Document ID: 10216792Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TEC25
- Date Added:
- August 1, 2022
- Manufacturer:
- BMW
SummaryTec25 Wishbone Return
Associated Products (59)Associated Documents - March 1, 2016•Document ID: 10216758Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SIM110115
- Date Added:
- August 1, 2022
- Manufacturer:
- BMW
SummaryMINI engine oil part number transition and model year 2016 engine oils
Associated Products (59)Associated Documents - March 1, 2016•Document ID: 10216757Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SIM010603
- Date Added:
- August 1, 2022
- Manufacturer:
- BMW
SummaryMINI "Enhanced" dealer self authorized (DSA)K goodwill program
Associated Products (59)Associated Documents - March 1, 2016•Document ID: 10151207Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- B840815
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"During the QC1 the BMW Assist Test Call Fails. After the transport mode is deleted (during the QC1), a BMW Assist (SOS) test call is made by pressing the SOS/ E-Call button. However, the call only connects via voice (no data is transmitted). The operator indicates that a crash call has been sent. ATM fault code ""B7F348 - Provisioning without signature OTA"" is stored. The provisioning of the ATM (Advanced Telematics Module) has failed."
Associated Products (52)Associated Documents - March 1, 2016•Document ID: 10151200Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT
- Mfr Comm. #:
- B651316
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"NBT-EVO Head Unit Cannot Be Swapped Between Vehicles for Testing. If an NBT-EVO head unit is swapped into a different vehicle it will enter a locked mode once it recognizes a different VIN. This will require REPLACEMENT of the head unit to restore operation. To prevent easy re-use of stolen Head units additional features are introduced with 11/15 ISTA/P software to bring NBT-EVO to a higher security level. In NBT-EVO the mechanism is called ""Trusted VIN"""
Associated Products (79)Associated Documents - March 1, 2016•Document ID: 10151197Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- Mfr Comm. #:
- B650716
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryNBT and Entry Head Unit Software Update for Improved Satellite Radio Reception. Poor Satellite Radio reception CAUSE After this software update there is a slight improvement in Satellite Radio reception for these vehicles when receiving their signal from XM Satellites. This is due to the changeover from Sirius Satellite broadcasting to XM Satellite broadcasting in 2016 (See SI B65 19 15).
Associated Products (158)Associated Documents - March 1, 2016•Document ID: 10151196Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
- Mfr Comm. #:
- B650616
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryNBT Head Unit Aborts Import of CD. While importing a CD to the internal music collection of an NBT head unit the process aborts. You will see 'import error' on the radio display when this occurs. NBT Head Unit software
Associated Products (159)Associated Documents - March 1, 2016•Document ID: 10151190Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B640316
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
Summary"Air Conditioning Refrigerant R1234yf Introduction. Highlights of R-1234yf Meets SAE J2888_201301 ""This SAE Standard covers fittings, couplers, and hoses intended for connecting service hoses from mobile air- conditioning Systems to service equipment such as charging, recovery and recycling equipment"" New tools and equipment are required. To service vehicles equipped with R-1234yf refer to SI B04 02 16. Air conditioning technician certification is required to work on system. Refer to your State Law. Unique low and high side fittings. Revised evaporator core as per SAE J2842. System will use about 5% more refrigerant than a comparable R134a system. System oil is a specific PAG oil. Refer to ISTA repair recommendation. Do not interchange components between systems using other refrigerants. Do not reuse Seals / O-ring material from another system. The system piping has internal heat exchangers (IHX or IWT) as introduced in the G12 (7 series). SAFETY INFORMATION Several precautions need to be observed when working on automotive air conditioning systems: Always wear eye protection and gloves while handling refrigerant or servicing air conditioning system. Avoid breathing R1234yf lubricant vapor or mist. Use only approved service equipment to discharge A/C systems. If refrigerant or compressor oil contacts the skin or eyes, large quantities of cool water should be used to flush the affected area. Never heat a refrigerant container with an open flame. Keep all refrigerant away from open flames. Under no circumstances should R1234yf service equipment or vehicle A/C systems be pressure tested or leak tested with air/R1234yf mixtures. NOTE: The use of compressed air (shop air) for leak detection in an R1234yf system can contaminate the system and/or refrigerant with moisture. Leak detection equipment that meets the SAE J2791 standard will work with R1234yf Never use fittings for an R12 or R134a system on an R1234yf system. Any difficulty in connecting service equipm
Associated Products (117)Associated Documents - March 1, 2016•Document ID: 10151175Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY; POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
- Mfr Comm. #:
- B330216
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryHowling Noise from the Rear Differential. When coasting from 85 - 70 mph, there is a howling noise from the rear differential. CAUSE Resonance behavior during the running-in phase of the PHEV rear differential
Associated Products (27)Associated Documents - March 1, 2016•Document ID: 10151174Service Bulletin/Repair InstructionsSTEERING
- Mfr Comm. #:
- B320316
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryVibrations Felt In Steering Wheel Only When Steering Wheel Heating Is Active. The customer states there is a small twitch/pulse of the steering wheel (1 second intervals) when the steering wheel heating is active. Note: The complaint is more noticeable with a cold steering wheel and vehicle voltage higher than 14 volts. Steering wheel control unit
Associated Products (19)Associated Documents - March 1, 2016•Document ID: 10151170Service Bulletin/Repair InstructionsENGINE; FUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- B122110
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryN51 Engine: Service Engine Soon Lamp Illuminated - Loss of Power and Various Faults Stored in the DME. The customer complains that the Service Engine Soon lamp is illuminated. The vehicle has lost power; the engine cranks but will not start; and various faults are stored in the DME for engine misfire and/or mixture adaptations. CAUSE The vehicle has lost fuel system delivery pressure due to a loose or split fuel line inside the fuel tank. The failure is related to an unfavorable stacking of tolerances between the rubber fuel hose and the plastic regulator nipple or deterioration of the rubber hose construction material.
Associated Products (44)Associated Documents - March 1, 2016•Document ID: 10151167Service Bulletin/Repair InstructionsPOWER TRAIN; EQUIPMENT ADAPTIVE/MOBILITY; ENGINE
- Mfr Comm. #:
- B112615
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummarySI B11 26 15 March 2016 Engine Technical Service This Service Information Bulletin supersedes SI B11 26 15 dated February 2016. The upper crankshaft guide bearing may wear out prematurely. The wear on the upper guide bearing can cause the clutch pedal to malfunction during shifting. The Engine Malfunction warning may be illuminated and a fault will be stored in the DME memory for the crankshaft sensor. Noise may be heard from the lower engine and transmission bell housing area. Engine damage can occur in rare occasions.
Associated Products (27)Associated Documents - March 1, 2016•Document ID: 10151156Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B010116
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummaryN20 Engine Coolant Thermostat: Limited Warranty Extension to 10 Years/120,000 Miles F30 (320i Sedan) Model Years 2013 and 2014 produced from 2/28/2013 to 3/31/2014 F30 (320i xDrive Sedan) Model Years 2013 and 2014 produced from 2/26/2013 to 3/31/2014 F30 (328i Sedan) Model Years 2012, 2013 and 2014 produced from 10/19/2011 to 3/31/2014 F30 (328i xDrive Sedan) Model Years 2013 and 2014 produced from 11/23/2011 to 3/29/2014 F31 (328i xDrive Sports Wagon) Model Year 2014 produced from 12/05/2012 to 3/29/2014 F32 (428i Coupe) Model Year 2014 produced from 6/27/2013 to 3/31/2014 F32 (428i xDrive Coupe) Model Year 2014 produced from 3/13/2013 to 3/28/2014 F33 (428i xDrive Convertible) Model Year 2014 produced from 7/17/2013 to 3/31/2014 F34 (328i xDrive Gran Turismo) Model Year 2014 produced from 6/12/2013 to 3/31/2014 With the N20 engine. This is NOT a notice of a Recall or Service Action. There is no immediate repair required unless the BMW vehicle is currently experiencing this problem. Customer Notification Letter - VIN and Component-specific Warranty Extension Even though this is NOT a Recall, BMW NA will be sending VIN-specific customer notification letters in a phased release.
Associated Products (6)Associated Documents - February 1, 2016•Document ID: 10151119Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- B840314
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummarySI B84 03 14 February 2016 Communication Systems Technical Service This Service Information bulletin supersedes SI B84 03 14 dated October 2014. SUBJECT Bluetooth Connection Failures. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure examples are: Call disconnection - Call is transferred back to the handset. In some instances the call is then transferred back to the vehicle. Contact List incomplete General connection failures CAUSE Apple iOS software (issue started with iOS 8.3 continues with iOS 9.x and its variants) Samsung S6 and S6 Edge device firmware CORRECTOPM None available at this time. We are currently working with the device manufacturer on a solution.
Associated Products (267)Associated Documents - February 1, 2016•Document ID: 10151115Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY; ELECTRICAL SYSTEM
- Mfr Comm. #:
- B650216
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummarySUBJECT Audio System Speaker Testing. For audio system speaker testing there is a NED (Non Electrical Diagnosis) Test Plan available. CAUSE We previously recommended use of the Audio Test CD (ATC) from BMW. This CD has been discontinued.
Associated Products (277)Associated Documents - February 1, 2016•Document ID: 10151114Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B650116
- Date Added:
- December 10, 2018
- Manufacturer:
- BMW
SummarySUBJECT Entry Head Unit Resets After Pairing a Bluetooth Phone. The Entry Head Unit may reset after pairing an Iphone or Android phone via Bluetooth to the vehicle. Incompatibility between stored characters in the phone (emoticon/emoji) and the Head Unit. See SI B84 03 12 about emoticon's effects on the vehicle.
Associated Products (24)Associated Documents