Audi · Model Report
Showing safety data for the 2002 model year only.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
The clutch experienced failure while on the highway and wouldn’t go into gear without being put into neutral first then into second gear . Then while driving one day I couldn’t put it in reverse it’s just gone so now the car will roll slightly even with the emergency brake on but I was put in danger the day it wouldn’t shift gears as it should while on the highway leaving me pretty much in fast motion but unable to continue in gear as it should which caused me to have to drift to the side of the road to then experience the effect of it being in neutral to second to continue driving however the vehicle seems to be high reviving in all gears after this experience happened
No injuries · No fire · No crash
TIRE CAME OFF CAR. REAR LOWER CONTROL ARM BROKE, LOWER LEFT KNUCKLE BUSHING SEIZED, SWAY BAR LINK BROKE, AXEL SHAFT COMPROMISED THIS ACTUALLY HAPPENED TWICE BEFORE THE KNUCKLE BUSHING WAS REPLACED. SECOND OCCURRENCE WAS 11/18/2017
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 AUDI TT. WHILE DRIVING 60 MPH, THE GEAR SHIFTER FAILED TO MOVE OUT OF FIRST GEAR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.
No injuries · No fire · No crash
LEFT HEADLIGHT OCCASIONALLY WONT TURN ON. WOULD HAVE TO SWITCH ON/ OFF A FEW TIMES TO GET THEM TO TURN ON. TENDS TO HAPPEN MORE WHEN VEHICLE IS COLD.
No injuries · No fire · No crash
ONE MORNING STARTED UP THE ENGINE ON MY AUDI, AND THE ENGINE SOUNDED LIKE IT HAD ROUGH IDLING, STUTTERING SOUND TO IT. I HAD TOOK IT FOR A TEST DRIVE AND EXPERIENCED LACK OF POWER, HESITATION IN ENGINE, ROUGH IDLING, AND THEN CHECK ENGINE LIGHT CAME ON. CHECKED OUT THE CODE. IT CAME UP TO BE (P0304) CYLINDER 4 MISFIRE. I TOOK IT TO A MECHANIC, AND HE REPLACED SPARK PLUGS, COIL PACKS. THE PROBLEM STILL EXISTED. HE HAD CHECKED THE COMPRESSION. IT WAS GOOD. CHECK ALL WIRES, SENORS...ECT. ANYTHING HE COULD THINK OF AND IT ALL CHECKED OUT GOOD. TIMING BELT AND WATER PUMP WAS REPLACED COUPLE MONTHS BEFORE THIS PROBLEM EXISTED. THE PROBLEM ONLY EXISTS WHEN THE ENGINE IS COLD. ONCE YOU WARM UP THE ENGINE, RESTART THE CAR, AND IT DRIVES PERFECTLY FINE! ENGINE COOLS DOWN, AND ROUGH IDLING, LACK OF POWER AND ALL THE COMES BACK AGAIN. THE MECHANIC DOESN'T KNOW WHAT THE PROBLEM COULD BE.
No injuries · No fire · No crash