Volvo XC60 Recalls

36 recalls on file.

Recall16V918000December 21, 2016
AIR BAGS
Volvo Car USA LLC (Volvo) is recalling certain model year 2017 S60 and S60 Cross Country, V60 and V60 Cross Country, and XC60 vehicles manufactured August 16, 2016, through October 21, 2016. The affected vehicles have driver and front passenger seat side mounted side air bags (SAB) with inflator initiators that may fail to ignite during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection" and number 214, "Side Impact Protection."
Remedy
Volvo will notify owners, and dealers will inspect and, if necessary, replace the front seat side air bags, free of charge. The recall is expected to begin on February 13, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89712.
Recall16V798000November 2, 2016
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."
Remedy
Volvo will notify owners, and dealers will inspect the front passenger seat belt buckle stud, replacing the seat belt buckle as needed, free of charge. The recall began January 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89708.
Recall15V555000September 2, 2015
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Volvo Cars of North America, LLC. (Volvo) is recalling certain model year 2016 Volvo S60, V60, V60CC, XC60, XC70, and S80 vehicles manufactured April 8, 2015 to August 19, 2015. In certain driving conditions when using the automatic engine stop/start function, the starter motor fuse may blow, preventing the car from restarting when necessary.
Remedy
Volvo will notify owners, and dealers will replace the existing starter motor fuse with a higher amperage fuse, free of charge. The recall began on October 26, 2015. Owners may contact Volvo customer service at 1-800-458-1552 or by visiting http://volvo.custhelp.com. Volvo's number for this recall is R39574.
Recall13V377000August 21, 2013
ELECTRICAL SYSTEM
Volvo is recalling certain model year 2014 S60, S80, XC60 and XC70 vehicles equipped with keyless ignition. In the affected vehicles, the Central Electronic Module (CEM) will not perform as intended. As a result, the front windshield wipers might run continuously when the ignition is on. Also, the turn signals, high beams, and headlight switch might not work.
Remedy
Volvo will notify owners, and dealers will upgrade the CEM software, free of charge. The recall began on October 3, 2013. Owners may contact Volvo at 1-800-458-1552.
Recall13V084000March 5, 2013
EQUIPMENT:OTHER:LABELS
Volvo is recalling certain model year 2013 S60 and XC60 vehicles, manufactured on January 7, 2013. The product identification labels were printed with the incorrect manufacture year. Thus, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification Regulation."
Remedy
Volvo has quarantined the affected vehicles and will install correct labels prior to sale. The recall began during March 2013. Owner notification letters will not be sent.
Recall12V439000September 10, 2012
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
Volvo is recalling certain model year 2013 S60 and XC60 vehicles. A manufacturing defect within the Supplemental Restraint System (SRS) control unit may lead to an inadvertent deployment of the seat belt pretensioner and/or inflatable curtain.
Remedy
These vehicles have not been sold and the SRS control unit will be replaced prior to the cars being sold. Owners may contact Volvo at 1-800-458-1552.
Recall12V101000March 14, 2012
STRUCTURE:BODY
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 AND XC60 PASSENGER VEHICLES. AN INCORRECT MIXTURE OF UNDERBODY COATING AND OVER-APPLICATION CAN RESULT IN RIGID, ICICLE-LIKE AREAS HANGING FROM VEHICLEÂS UNDERCARRIAGE.
Remedy
DEALERS WILL INSPECT THE VEHICLE UNDERCARRIAGE, AND IF EXCESSIVE UNDERBODY COATING IS FOUND IN THE FUEL LINE AREA, IT WILL BE REMOVED. IF THE INSPECTION REVEALS THAT THE FUEL LINES ARE DAMAGED, THEY WILL BE REPLACED. THE SAFETY RECALL BEGAN ON APRIL 25, 2012. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.
Recall12V075000February 28, 2012
ELECTRICAL SYSTEM:WIRING
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE SEATING POSITION, THE WIRE HARNESS MAY GET PULLED, CAUSING IT TO DISCONNECT.
Remedy
VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND, IF NECESSARY, SECURE THE SEAT WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Recall10V591000November 22, 2010
SEATS
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
Remedy
DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT [email protected].
Recall10V579000November 17, 2010
ENGINE AND ENGINE COOLING
VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES. THE SOFTWARE CALIBRATION FOR THE FUEL CUT-OFF FUNCTIONALITY IN THE ENGINE CONTROL MODULE (ECM) IS TOO SENSITIVE.
Remedy
DEALERS WILL UPDATE THE ECM AND TCM WITH NEW SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 10, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT [email protected].
Recall10V564000November 10, 2010
AIR BAGS
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010 XC60 VEHICLES. THE CURTAIN AIR BAGS MAY HAVE BEEN MIS-ASSEMBLED DURING THE MANUFACTURING PROCESS. THIS MAY CAUSE AN AIR BAG TO NOT DEPLOY OR NOT DEPLOY AS INTENDED.
Remedy
DEALERS WILL INSPECT THE LEFT AND RIGHT CURTAIN AIR BAG ASSEMBLY AND ADJUST IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 9, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT [email protected].
Recall10V489000October 13, 2010
AIR BAGS:FRONTAL
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 S80, XC70, MODEL YEAR 2011 XC60 AND MODEL YEAR 2010 V70 VEHICLES. THERE MAY BE AN INTERMITTENT FAULT IN THE DRIVER'S AIRBAG CLOCKSPRING WIRING CONNECTOR FOR THE SUPPLEMENTAL RESTRAINT SYSTEM.
Remedy
DEALERS WILL INSTALL A METAL SHIM IN THE DRIVER'S AIR BAG CLOCKSPRING WIRING CONNECTOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Recall09V477000December 15, 2009
FUEL SYSTEM, OTHER
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE FUEL LINE RAIL COVER THAT PROTECTS THE FUEL LINES UNDER THE VEHICLE MAY NOT BE PROPERLY ATTACHED EXPOSING THE FUEL LINES TO DAMAGE.
Remedy
DEALERS WILL INSPECT THE FUEL LINE RAIL COVER FOR PROPER ATTACHMENT AND REATTACH IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 28, 2009. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Recall09V463000December 1, 2009
STRUCTURE:BODY:ROOF AND PILLARS
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES BUILT WITHOUT THE PANORAMIC ROOF AND DELIVERED TO PUERTO RICO FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Remedy
THESE FOUR VEHICLES ARE IN THE POSSESSION OF DEALERS IN PUERTO RICO AND DEALERS WILL REPLACE THE HEADLINER IN THE VEHICLE PRIOR TO SALE.
Recall09V445000November 18, 2009
SEATS
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE DRIVER'S SEAT SIDE COVER PANEL (SEAT CONTROL PANEL) IN CERTAIN DRIVER'S SIDE IMPACTS MAY RELEASE THE ATTACHMENT OF THE SEATBELT TO THE SEAT FRAME.
Remedy
DEALERS WILL MODIFY THE INSIDE OF THE DRIVER'S SEAT SIDE COVER PANEL FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Recall09V343000September 1, 2009
ELECTRICAL SYSTEM:SOFTWARE
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.
Remedy
DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

← Back to Volvo XC60