Volvo S70 Complaints

593 consumer complaints on file.

#10152703March 14, 2006
VEHICLE SPEED CONTROL
OWNER OF MODEL YEAR 2000 S70 VOLVO WITH ETM PROBLEMS. WAS REPLACE AT EXACTLY OVER 100K MILES IN MARCH OF 2004 AND NOW THE PROBLEM IS HAPPENING AGAIN AT 165K MILES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151956February 24, 2006
ENGINE AND ENGINE COOLING, SEATS
CONSUMER 1998 S70 ENGINE HAS FAILED ON TWO DIFFERENT OCCASIONS, TIMING BELT SERPENTINE BELT HAS BEEN REPLACED. *TS ***NAR*** THE CONSUMER BELIEVED THIS WAS A PREMATURE FAILURE. THE WATER PUMP WAS LEAKING. THE FRONT SPRING SEAT WAS REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151949February 24, 2006
VEHICLE SPEED CONTROL
2000 S70 STALLS AFTER APPLYING BRAKES. *TS THE VEHICLE HAS BEEN TAKEN TOT HE DEALER SEVERAL TIMES BUT THE TECHNICIANS WERE UNABLE TO DETERMINE THE CAUSE OF THE STALLING. THE CONSUMER DID SOME RESEARCH AND FOUND SOME INFORMATION ON FAULTY ELECTRONIC THROTTLE MODULE IN VOLVOS WHICH CAUSE STALLING. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10149394February 3, 2006
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
DT*: THE CONTACT STATED THE DRIVER SIDE DOOR IS COMING OFF THE HINGES. THE DEALERSHIP DETERMINED THE VEHICLE SHOULD BE SEEN BY AN AUTO BODY SHOP TO BE WELDED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148869January 27, 2006
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
DRIVER'S SIDE VEHICLE DOOR HAS DEFECTIVE DOOR HINGES. MAKES A LOUD POPING NOISE WHEN OPENED AND CLOSED. TAKEN TO CAR DEALER, AND WAS TOLD NOT A WARRANTY ITEM. VEHICLE IS BEING DRIVEN UNDER UNSAFE CONDITION DUE TO FACTORY DEFECT.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148364January 23, 2006
VEHICLE SPEED CONTROL
THEELECTRONIC THROTTLE SYSTEM (ETS) LIGHT HAS BEEN ON DASHBOARD INTERMITTENTLY SINCE A 50,000 MILES. THE CAR CURRENTLY HAS NEARLY 95,000 MILES. ON NUMEROUS OCCASIONS THE TACHOMETER REACHED INTO THE RED LINE WHEN CRANKED WITHOUT ANY USE OF THE ACCELERATOR. IN TRAFFIC, WHEN BEGINNING TO COAST AT CRUISING SPEEDS, THE CAR WILL SURGE SLIGHTLY WITHOUT THE HELP OF THE ACCELERATOR. THE ETS LIGHT WILL APPEAR AND THEN THE PROBLEM WILL CEASE. TOOK THE VEHICLE TO DON BEYER VOLVO-DULLES ON JANUARY 18, 2005, AND AFTER BEING TOLD THE WARRANTY ON THE THROTTLE MODULE WAS EXTENDED, THE DEALER REFUSED TO FIX THE PROBLEM STATING THE APPROPRIATE CODES WERE NOT EVIDENT. HOWEVER, THE SERVICE REPRESENTATIVE SAID THE THROTTLE BODY NEEDED TO BE CLEANED, AND THAT THE UNIT WOULD EVENTUALLY FAIL. HE SAID THAT WHEN THE UNIT FAILED, DEFINED BY HIM AS THE CAR FAILING TO START OR STALLING WHILE DRIVING, THE DEALER WOULD THEN REPLACE IT. UNTIL THEN WOULD HAVE TO WAIT FOR THE UNIT TO FAIL, PUTTING MYSELF AND PASSENGERS IN DANGER OF THE CAR MALFUNCTIONING IN TRAFFIC.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10137282January 23, 2006
VEHICLE SPEED CONTROL
WE OWN A 1999 VOLVO S70 AWD SEDAN. WE HAVE BEEN EXPERIENCING DIFFICULTIES RELATED TO THE LACK OF ACCELERATION AT UNANTICIPATED TIMES OR A SUDDEN DECLINE IN POWER AT OTHER TIMES. THE ETS WARNING LIGHT IS ON. THIS UNEXPECTED LOSS OF ACCELERATION IS ESPECIALLY HAZARDOUS/DANGEROUS WHEN PULLING OUT INTO TRAFFIC THINKING THAT YOU HAVE PLENTY OF SPACE AND TIME ONLY TO FIND OUT THAT YOU CANNOT ACCELERATE. I HAVE FORWARDED MY CONCERN TO VOLVO CARS OF AMERICA AND RECEIVED BACK A NONCOMMITTAL RESPONSE SUGGESTING THAT WE HAVE IT INSPECTED. WE DID AND THE TECHNICIAN SAID THAT I SHOULD CHECK WITH VOLVO AS THERE HAS BEEN SOME DISCUSSION OF THIS PROBLEM IN THE NEWSPAPER. THE CODES THAT WERE IDENTIFIED INCLUDED: ECM - 914F THROTTLE UNIT INTERNAL FAULT ECM - 9150 THROTTLE UNIT INTERNAL FAULT ECM - 91B7 THROTTLE UNIT INTERNAL FAULT ECM - 903C THROTTLE UNIT INTERNAL FAULT ECM - 903F THROTTLE UNIT INTERNAL FAULT IF THIS IS A SAFETY DEFECT SHOULDN'T VOLVO RECALL AND REPLACE THIS THROTTLE UNIT? YOUR ASSISTANCE AND RESPONSE IS APPRECIATED. THANK YOU, WILL BRUCKER NOTE: IN THE SECTION BELOW ABOUT THE VEHICLE IT SAY OEM YES?NO (I DO NOT KNOW WHAT IS BEING REFERRED TO THEREFORE THE ANSWER HAS NO RELEVANCE BUT IT HAD TO BE ANSWERED WITH A YES OR NO.) THE NUMBER OF TIMES THIS SITUATION HAS OCCURRED IS NUMEROUS AND THE DATES HAVE BEEN VARIED NOT JUST SEPTEMBER 10, 2005. THANK YOU. *JB *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147988January 18, 2006
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
MY 1999 VOLVO S70 HAS BEEN STALLING ON A DAILY BASIS FOR SOME TIME NOW. I STALL ON MY WAY TO WORK; A SEVEN MILE DRIVE. I HAVE TRIED TO GET IT IN FOR SERVICE AT A LOCAL VOLVO DEALERSHIP, BUT THEY ARE "BOOKED UP". I HAVE NO OTHER MEANS OF TRANSPORTATION BESIDE THIS DEATH TRAP. I PRAY ALL THE WAY TO WORK. TODAY IT REFUSED TO IDLE UP TO A NORMAL SPEED (35) AND STUCK SOMEWHERE AT 15, SO I COASTED IN UNTIL IT FINALLY STALLED IN THE PARKING LOT. THIS IS A DAILY OCCURRENCE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147822January 15, 2006
VEHICLE SPEED CONTROL
UNEXPLAINED, INVOLUNTARY ACCELERATION FROM LOW SPEED. 2000 VOLVO MODEL S70 PASSENGER CAR, AWD. DURING A SLOW-SPEED TURN THE VEHICLE ACCELERATED AT FULL THROTTLE. IMPACT WITH RESIDENTIAL STRUCTURE SEVERED A WHEEL AND BENT THE FRONT FRAME 90 DEGREES. WHAT HAPPENED: DURING A SLOW TURN INTO A NEIGHBORS DRIVEWAY, SPEED ABOUT 5 MPH, TURNING RIGHT, TOUCHING THE ACCELERATOR, THE CAR ENGINE ACCELERATED AT FULL SPEED. DESPITE FOOT FULLY INTO THE BRAKE THE CAR CONTINUED TO ACCELERATE 40-50 FEET UNTIL IMPACTING THE FOUNDATION OF THE HOUSE. SPEED A TIME OF IMPACT 40+ MPH. TRIED TO TURN OFF IGNITION BUT HIT HOUSE FIRST. CONSIDERABLE DAMAGE TO HOUSE AND CAR, WHICH WAS TOTALED BY THE INSURANCE COMPANY. REPORTED THROTTLE ACCELERATION PROBLEM TO VOLVO IN NEW JERSEY, THEY STATED NO SUCH PREVIOUS COMPLAINTS ABOUT UNEXPLAINED ACCELERATION. KNEW OF THE NHTSA RESEARCH INTO ACCELERATOR MODULE SLOWING UNEXPLAINED TO 5 MPH, BUT THEN SAW A NEWS REPORT ABOUT UNEXPLAINED ACCELERATION AND WANTED TO INCLUDE THIS CASE IN YOUR LIST. *JB
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10147688January 13, 2006
EQUIPMENT
NARRATIVE DESCRIPTION: #1: IN MID/LATE 2003, THE INTERIOR LEATHER DOOR PANELS BEGAN TO "BUBBLE" OR PULL AWAY FROM THE DOOR FRAME. HAVING PURCHASED A FOUR DOOR MODEL, EACH DOOR HAD NOTICABLE DEFECTS WHICH BECAME SIGNIFICANT OVER A SHORT PERIOD OF TIME. #2: UPON FURTHER INVESTIGATION THROUGH LOCAL VOLVO DEALERSHIPS, THE "BUBBLES" WERE ACTUALLY DUE TO A POOR QUALITY ENVIRONMENTALLY FRIENDLY GLUE FROM EUROPE, THAT WAS USED TO ATTACH THE INTERIOR LEATHER DOOR PANELS TO THE DOOR FRAMES, WHICH VOLVO DID NOT APPARENTLY TEST IN THE UNITED STATES. AS FOR MY MODEL, THE CONSEQUENCE OF THE DEFECT RESULTED IN SEVERE FAILURE OF THE INTERIOR LEATHER DOOR PANELS. ALTHOUGH MY MODEL YEAR IS A 2000, I UNDERSTAND THAT THIS HAS ALSO HAPPENED ON BOTH EARLIER AND LATER MODEL YEAR VEHICLES. #3: VOLVO "IS" AWARE OF THIS DEFECT AND HOW EXTENSIVE IT HAS AFFECTED ITS VEHICLES INCLUDING THE MODEL YEAR 2000. IN SPEAKING WITH LOCAL VOLVO DEALERSHIPS, VOLVO MADE A SUBTLE ATTEMPT TO CORRECT THE PROBLEMS INCLUDING SUPPLYING THE DEALERSHIPS WITH A REPAIR KIT THAT EACH DEALERSHIP WAS RESPONSIBLE FOR COMPLETING. ALTHOUGH INITIALLY REPORTED TO VOLVO, MY COMPLAINTS WERE NOT IDENTIFIED AS SAFETY RELATED ISSUES BUT RATHER COSMETIC AND REQUIRED APPROXIMATELY TWO YEARS BEFORE FINALLY AGREEING TO A THREE WAY SPLIT IN THE COST TO REPLACE THE INTERIOR LEATHER DOOR PANELS. ALTHOUGH THE DEFECT IS COSMETIC IN NATURE, IT WAS TO OEM PARTS THAT VOLVO INSTALLED WITH THE VEHICLE AND NOT OPTIONAL UPGRADES ON MY PART. PLEASE HELP US...
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147689January 13, 2006
ELECTRICAL SYSTEM:IGNITION:SWITCH
NARRATIVE DESCRIPTION: #1: IN EARLY 2005, AN INTERMITTENT PROBLEM BEGAN OCCURRING WITH THE IGNITION AND STARTING OF THE VEHICLE. #2: UPON FURTHER INVESTIGATION THROUGH LOCAL VOLVO DEALERSHIPS, THE PROBLEM WAS IDENTIFIED AS THE IMMOBLIZER (ANTENNA RING) WHICH READS THE COMPUTER CHIP WITHIN THE KEY TO DETERMINE IF THE CORRECT KEY IS BEING USED TO START THE VEHICLE. INITIALLY, THE PROBLEM WAS INTERMITTENT BUT HAS BECOME INCREASINGLY WORSE WITH AN INABILITY TO START THE VEHICLE. #3: VOLVO "IS" AWARE OF MY PROBLEM, HOWEVER, THE ONLY ASSISTANCE THEY HAVE PROVIDED IS TO TURN THE KEY BACK TO THE START POSITION, REMOVE THE KEY, TURN 180 DEGREES, RE-ENTER THE KEY AND THE VEHICLE SHOULD START. ALTHOUGH THIS IS ONE SOLUTION TO A RECURRING AND ON-GOING PROBLEM, IT DOES REQUIRE REPAIR AS THIS PROBLEM IS OEM EQUIPMENT INSTALLED BY VOLVO AND I BELIEVE REPRESENTS A SAFETY ISSUE. PLEASE HELP US...*NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147435January 11, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED WHILE DRIVING THE VEHICLE SURGED AND HESITATED. THE CHECK ENGINE LIGHT AND ETS LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, BUT THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147321January 9, 2006
VEHICLE SPEED CONTROL
THE ELECTRONIC THROTTLE MODULE ON MY 2000 VOLVO S70 MALFUNCTIONED CAUSING INABILITY TO ACCELERATE. MILEAGE = 61,694. THE ETS LIGHT CAME ON THE DAY PRIOR TO THE INCIDENT. ETM WAS REPLACED. AFTER THE ETM MODULE WAS REPLACED, THE ELECTRONIC WINDOWS WOULD NOT FUNCTION. I WAS INFORMED BY THE VOLVO TECHNICIAN THAT THIS WAS A COINCIDENCE AND NOT RELATED TO THE ETM REPLACEMENT. PRIOR TO ETM REPLACEMENT, I HAD NO PROBLEMS WITH THE ELECTRONIC WINDOWS. LAST WEEK WHILE I WAS DRIVING ALONE IN MY 2000 S70 VOLVO, THE PASSENGER SEAT FULLY RECLINED ON ITS OWN. THIS INCIDENT REMINDED ME OF A SIMILAR SCENARIO ONE WEEK AFTER PURCHASING THE VEHICLE. THE DRIVER'S SEAT FULLY RECLINED WITHOUT ANYONE TOUCHING THE ELECTRONIC SEAT CONTROL. IN DECEMBER 2000, THE TURN SIGNALS AND HAZARD LIGHTS SWITCH WAS FOUND TO BE FAULTY AND WAS REPLACED UNDER THE WARRANTY. THEN, IN MAY, 2001, THE DRIVERS TURN SIGNAL STARTED BLINKING RAPIDLY WHICH WAS REPLACED UNDER THE RECALL CAMPAIGN 101A AND 101B. THIS MAKES ME BELIEVE MY ENTIRE VEHICLE'S ELECTRONIC SYSTEM WAS DEFECTIVE FROM THE DAY I PURCHASED THE VEHICLE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147076January 6, 2006
VEHICLE SPEED CONTROL
REPEATED FAILURE AND REPLACEMENT OF ELECTRONIC THROTTLE MANAGEMENT SYSTEM. SINCE THE MOST RECENT REPLACEMENT 3 MONTHS AGO, THE CAR HAS STUTTERED WHEN ROUNDING TIGHTER CORNERS. NOW, THE CAR STALLS ON TIGHT CORNERS, CAUSING A LOSS OF POWER STEERING AND BRAKES LEADING TO A LOSS OF VEHICLE CONTROL. A CRASH WAS AVOIDED BY NEARBY VEHICLES WHEN THE CAR STALLED MID CORNER, SENDING THE CAR AND DRIVER INTO THE OPPOSITE LANE. THE DEALER/MANUFACTURER CONTINUES TO OFFER REPLACEMENT, BUT THE REPLACEMENTS QUICKLY WEAR CAUSING SIMILAR RESULTS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146854January 4, 2006
VEHICLE SPEED CONTROL
VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT ROADS WET, BUT NOT FROZEN (LUCKILY). ON MAKING TURN IN RESIDENTIAL NEIGHBORHOOD, VOLVO S70 SURGED WITHOUT ACCELERATOR INPUT REQUIRING DRIVER TO TAKE CORRECTIVE ACTION AND BRAKE HARD. IN 2005, THIS VEHICLE EXPERIENCED ENGINE STALL, VEHICLE HESITATION UPON ACCELERATION. VEHICLE HESITATION WAS CONSISTENT AT APPROXIMATELY 2100 RPM AT FREEWAY SPEEDS. ON TAKING IT TO THE DEALER THEY REPROGRAMMED THE ETM. AFTER THIS REPAIR, WITHIN DAYS, THE VEEHICLE EXPERIENCED AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE) WHILE DRIVING ON THE PA TURNPIKE. DEALER INSTRUCTED US TO BRING CAR IN WHERE THEY INSTALLED A NEW ETM AND REPROGRAMMED IT WITH THE NEW SOFTWARE UPGRADE. AFTER FURTHER NEGOTIATIONS WITH THE DEALER, THE COST OF THESE REPAIRS WERE REIMBURSED BY THE DEALER IN AN AGREEMENT WITH VOLVO (SO-CALLED SECRET WARRANTY). NOTE THAT THIS OCCURED PRIOR TO THE SETTLEMENT IN CALIFORNIA. VOLVO WOULD REFER ME ONLY TO THE DEALER, AND WOULD NOT DISCUSS THE POSSIBLE PROBLEMN WITH ME. I BELIEVE THAT WE HAVE PREVIOUSLY HAD THE ETM CLEANED WHEN WE HAD SIMILAR PROBLEMS IN THE PAST. THE CURRENT SURGING AND HESITATION AT FREEWAY SPEEDS (2000-2200 RPM) AND THE SURGING WITH ACCELERATOR INPUTS ARE HAPPENING WITH THE NEW ETM THAT IS ONLY ABOUT FOUR MONTHS OLD IN THE VEHICLE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146186December 27, 2005
VEHICLE SPEED CONTROL
I OWN A 99 VOLVO S70. THE ETS LIGHT HAS BEEN COMING ON REGULARLY. THE INFO IN THE OWNERS MANUAL JUST SAYS TO TURN THE CAR OFF AND THEN TURN IT ON AGAIN AND SEE IF THE LIGHT GOES AWAY. IT HAS IN THE PAST BUT IT'S COMING ON ALL THE TIME NOW. I LOOKED ON" EDMUNDS" TO SEE IF THERE WAS A RECALL.. AND THERE WAS NOTHING THERE.. BUT THEN I SAW A VOLVO OWNERS FORUM AND THERE WERE LOTS OF EMAILS ABOUT THIS PROBLEM. THEY SAID IT WAS PRETTY DANGEROUS BECAUSE YOUR THROTTLE JUST STOPS WORKING. WE COMMUTE TO BOSTON EVERYDAY ( MY HUSBAND DOES NOT GET OUT OF WORK UNTIL AFTER 10:00PM ).. AND IT'S VERY DANGEROUS AS IT IS.. BUT TO THINK ABOUT LOSING THE THROTTLE SCARES THE HECK OUT OF ME. I CAN'T IMAGINE THAT HAPPENING AT MIDNIGHT ON ROUTE 128. IT WOULD BE SUICIDE. I WAS UNABLE TO FIND RECALL.. BUT A MECHANIC AROUND HERE TOLD ME THE COST TO REPAIR IS ABOUT 850.00!L I HAVE AN APPOINTMENT AT A DEALER ON FRIDAY.. BUT IT WOULD SURE HELP TO KNOW IF THERE WAS RECALL. THANK YOU FOR YOUR HELP. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146074December 26, 2005
VEHICLE SPEED CONTROL
2000 VOLVO S70 NEEDED A THROTTLE BODY MODULE INSTALLED. I UNDERSTAND THIS VEHICLE HAS HAD A NUMBER OF COMPLAINTS ABOUT TIS MODULE. I ALSO UNDERSTAND THAT CALIFORNIA IS ASKING VOLVO TO EITHER HAVE A RECALL OR EXTEND THE WARRANTY. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10145462December 16, 2005
EXTERIOR LIGHTING:TURN SIGNAL, EXTERIOR LIGHTING:HEADLIGHTS:SWITCH, EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
DT: THE CONTACT STATED PRIOR TO PURCHASING THE VEHICLE THERE WAS NHTSA RECALL CAMPAIGN 00V405000 CONCERNING THE TURN SIGNAL. THE RECALL REPAIR WORK WAS COMPLETED AND THE VEHICLE WORKED PROPERLY. THEN, SHE RECEIVED RECALL 04V504000 CONCERNING THE HEADLIGHT SWITCH. THE VEHICLE WAS TAKEN TO DEALER FOR THE REPAIRS. WHEN SHE GOT THE VEHICLE HOME SHE TRIED TO TURN THE HEADLIGHTS ON AND NOTICED THEY DID NOT WORK. SHE TOOK THE VEHICLE BACK TO THE DEALERSHIP, AND THEY REPAIRED THE HEADLIGHTS. THE HEADLIGHTS FAILED AGAIN FIVE DAYS LATER. THE DEALERSHIP DETERMINED THAT THE TURN SIGNAL SWITCH NEEDED TO BE REPLACED IN ORDER TO FIX THE HEADLIGHTS. SHE CONTACTED THE MANUFACTURER, AND THEY AGREED WITH THE DEALERSHIP. THEY STATED NONE OF THE RECALLS INCLUDED THE TURN SIGNAL SWITCH, AND SHE WOULD HAVE TO PAY FOR THE REPAIRS. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT FELT THE HEADLIGHT FAILURE WAS RELATED TO ONE OF THE TWO PREVIOUS RECALLS. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144887December 10, 2005
ENGINE AND ENGINE COOLING
1999 VOLVO S70'S ETM (THROTTLE) HAD ACTED UP IN JUNE/JULY 2004, PAID AROUND $900 IN JULY 2004 TO HAVE IT FIXED. THE THROTTLE CAUSED THE CAR TO GO DEAD MULTIPLE TIMES & STRONGLY REV ITSELF OCCASIONALLY. THIS WOULD OCCUR WHEN SLOWING DOWN OR WHEN STOPPED. I WOULD OCCASIONALLY HAVE TO KEEP FOOT ON THE GAS TO KEEP THE CAR FROM GOING DEAD. ***NOW LESS THAN A YEAR AND A HALF AFTER HAVING THE PROBLEM "FIXED" (REPLACED UNIT) - THE PROBLEM IS BACK. THE CAR HAS GONE BACK TO SAME ISSUES. THIS PROBLEM DOES NOT OCCUR SLOWLY, FROM GOOD PERFORMANCE TO BAD, IT TOOK ONLY ONE WEEK FOR IT TO RECCUR. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10144606December 6, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
THE ABS ANTILOCK BRAKE SYSTEM IN MY 1998 VOLVO S70 FAILED. THE DASHBOARD LIGHT INDICATED ABS & TRACTION CONTROL (TRACS) FAILURE. NORMAL NON-ABS BRAKING REMAINED. RESEARCH ON SEVERAL VOLVO OWNERS WEB SITES (SUCH AS BRICKBOARD: HTTP://WWW.BRICKBOARD.COM/AWD/?MODEL=S70) SHOWED SYSTEMIC FAILURE OF THE ABS CONTROL MODULE VOLVO PART # 9162675 DUE TO PRINTED CIRCUIT BOARD SOLDER CRACKING AFTER 6 YEARS. THE CAR WAS TESTED BY A VOLVO DEALER CONFIRMING ABS CONTROL MODULE FAILEDURE. VOLVO CHARGES A TOTAL $650 TO REPLACE THE UNIT. THE "BRICKBOARD" OWNERS GROUP SUGGESTED A REPAIR SHOP IN CALIFORNIA THAT RESOLDERS THE CIRCUIT BOARD, REPLACES AND UPGRADES FAILED COMPONENTS, TESTS & RETURNS IT FOR $130 PLUS SHIPPING. WE HAD THE OLD BOARD REPAIRED, SINCE A NEW EXACT REPLACEMENT BOARD FROM VOLVO WOULD HAVE THE SAME FAILURE AFTER ANOTHER 5 YEARS. THE REPAIRED ABS CONTROL UNIT HAS BEEN REINSTALLED & THE CAR NOW WORKS PROPERLY, WITH FULL ABS AND TRACS CONTROL. THIS IS NOT THE FIRST PRINTED CIRCUIT FAILURE FROM VOLVO. OUR 1993 VOLVO 940 TURBO HAD TWO BOARD FAILURES: 1, THE RELAY BASE BOARD SOLDER CRACKED, AND RESULTED IN THE OVERDRIVE RELAY NOT WORKING; 2, CRUISE CONTROL OPERATED ERRATICALLY, DUE TO BAD BOARD SOLDER. BOTH OF THESE BOARDS WERE REPAIRED BY OUR LOCAL SERVICE SHOP. WE ARE VERY CONCERNED THAT TWO CRITICAL SAFETY ELEMENTS - THE ABS SYSTEM AND TRACTION CONTROL - ARE FAILING IN A RELATIVELY SHORT PERIOD OF TIME, & BECAUSE OF A FAILURE OF WHAT SHOULD BE A SIMPLE ASSEMBLY OF TESTED PARTS. FURTHER, WE ARE MOST DISTURBED THAT VOLVO'S REMEDY IS A VERY EXPENSIVE REPLACEMENT, WITH THE SAME FAILURE PRONE PART. WORSE, ALTHOUGH WE OPTED FOR A COMPLETE REPAIR, THERE ARE OWNERS WHO CANNOT AFFORD THE FIX. THESE WILL BE DRIVING WITH FAR LESS BRAKING AND CONTROL THAN THE CAR IS CAPABLE OF PROVIDING. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S70