I purchased a brand-new 2026 Volvo EX90 just 4days ago from a volvo dealership . Yesterday, the vehicle’s software proximity logic malfunctioned and auto-locked the doors while my baby was strapped inside. My physical key card and my phone with the digital key were both inside the cabin. To make matters worse, when I tried to use the Volvo remote app to unlock it with a different phone, the app failed completely because the car was not “connected”. Volvo roadside assistance could not unlock the vehicle either. Because of this total software failure, I had no choice but to have firefighters physically break into my brand-new car to rescue my child."
No injuries · No fire · No crash
While driving the vehicle at a low rate of speed it presenter a Critical Error message which appeared across the drivers screen for approximately 5-10 seconds. The message then immediately disappeared and the vehicle shut down mid operation and came to an abrupt stop on its own. From there it was unable to be moved, switched into neutral/drive or park. Luckily this happened on a neighborhood street, but the warning didn’t allow any time to pull over to find a safe location. To reiterate, the vehicle then suddenly and abruptly came to a complete stop mid operation on its own. If this would have happened on the highway or a busy street, it could have been a life threatening event.
No injuries · No fire · No crash
Software updates causing mechanical issues. Most recent software update blew the compressor and pump causing the AC to go out. According to volvo service department this is a widespread issue with their software updates for the EX90, who knows what other mechanical issues it may be causing. Safety issue as its 115 degrees outside and car only blows hot air.
No injuries · No fire · No crash
While driving the car on a state road (45 mph) the car suddenly notified me of an "electrical fault", a light that looks like a turtle came on, and the vehicle lost power and couldn't go any faster than 5 mph. Another vehicle almost rear-ended me around a blind curve because I was moving significantly slower than normal traffic. I pulled into a parking lot, shutdown and restarted the car and everything seemed fine. It happened again a few minutes later so we started to head back home. But the real issue happened a minute or so after the second fault - the fault cleared itself and all of a sudden the vehicle's speed shot up to over 60 mph with very little throttle response or control from me. I slowed the car down using the brakes and continued home. The fault happened again, and cleared itself again in the same manner but this time while I was turning causing me to almost hit a curb while trying to turn. The car is dangerous. These should be taken off the road permanently.
No injuries · No fire · No crash
the vehicle exhibits a persistent defect in which the doors lock and unlock without driver command. Specific effects I have experienced: The vehicle has locked itself while I was exiting, locking me out with the key in my possession. On multiple occasions this has occurred with my child inside the vehicle, with my dogs inside the vehicle, and with personal belongings inside the vehicle, with no ability to unlock it. These incidents have occurred in extreme heat conditions, where the interior of a closed vehicle can reach lethal temperatures within minutes. Volvo telephone support instructed me to call a locksmith. In the referenced conditions this response is not a remedy. It is an unacceptable exposure of a child and animals to serious injury or death. The vehicle has also unlocked itself spontaneously while I was nowhere near it, leaving it and its contents unsecured. Repair history: The vehicle has been presented to an authorized Volvo dealership on 3 occasions for this concern. The dealership's lead engineer performed multiple system resets, none of which resolved the condition. He advised that the vehicle may need to be "put to sleep," that the condition is likely not repairable, and that seat and seat-belt occupancy sensors are the suspected source of the uncommanded locking and unlocking. He further advised that he would document the file in support of a manufacturer repurchase, and that I should move to the 2026 model year, in which he stated these faults have been addressed.
No injuries · No fire · No crash