Volkswagen Routan Complaints

784 consumer complaints on file.

#11365372October 20, 2020
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2012 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE AND RESUMED NORMAL DRIVING. THE CONTACT INITIALLY CONTACTED THE MANUFACTURER BY PHONE AND WAS REFERRED TO THE DODGE MANUFACTURER FOR ASSISTANCE. THE CONTACT REACHED OUT TO THE DODGE MANUFACTURER AND SHE WAS REFERRED TO A LOCAL DODGE DEALER FOR ASSISTANCE. THE CONTACT TOOK THE VEHICLE TO TANNER MOTORS (620 W. WASHINGTON ST, BRAINERD, MN 56401) WHERE THE VEHICLE WAS TEST DRIVEN AND THE CONTACT WAS INFORMED THAT THE ISSUE COULD POSSIBLY BE LINKED TO A DEFECTIVE WIRELESS IGNITION NODE (WIN) MODULE. THE CONTACT WAS PROVIDED AN ESTIMATE FOR THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 99,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11364829October 17, 2020
ELECTRICAL SYSTEM
THIS VEHICLE IS BASICALLY A CHRYSLER/DODGE WITH VW BRANDING, AND ONE OF THE KEYS IS EVEN A DODGE KEY. IT HAS THE SAME ISSUE WITH THE TIPM AND FUEL RELAY MODULE THAT WAS RECALLED ON THE 2011 CHRYSLER AND DODGE VANS. SEE FUEL PUMP RELAY RECALL NHTSA 14V-530. I'M ASKING THAT IT ALSO BE RECALLED FOR THE 2011 VW ROUTAN SINCE IT'S VERY DANGEROUS THAT MY CAR COULD STOP AT ANY MOMENT. VEHICLE WILL SHUT OFF WHEN DRIVING AND WILL NOT START ON MANY OCCASIONS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11364690October 16, 2020
SERVICE BRAKES, ELECTRICAL SYSTEM, STEERING
FIVE TIMES IN THE PAST 6 MONTHS THE POWER IN THE VAN BASICALLY TURNS OFF. THE STEERING BECOMES NEXT TO IMPOSSIBLE AND THE BRAKES BECOME EXTREMELY TIGHT TO THE POINT YOU CAN'T EVEN USE THEM. IT IS TERRIFYING TO HAVE ZERO CONTROL OVER YOUR CAR CONSIDERING I HAVE 4 CHILDREN. IT HAS HAPPENED WHILE I WAS GOING ONLY 30MPH AND ALSO WHEN I WAS GOING 45 MPH. IT HAPPENS WHEN I'M GOING STRAIGHT AND HAS ALSO HAPPENED WHILE TURNING. SINCE THE LATEST ISSUE I REFUSE TO DRIVE ANYWHERE THAT I CAN'T TAKE BACK ROADS TO.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11363943October 12, 2020
ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM, SEATS
THE WHOLE ELECTRICAL SYSTEM HAS GONE OUT WHILE DRIVING IN LIMESTONE COUNTY ALABAMA. KEYS DON'T START IT NONE OF AUTOMATIC DOORS WILL OPEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11363447October 8, 2020
ENGINE
TL* THE CONTACT OWNS A 2011 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE LOSS POWER STEERING AND BRAKES DURING THE FAILURE. THE CONTACT STATED THAT THE FUEL PUMP RELAY FAILED. THE CONTACT STATED THAT THE RELAY CONTINUED TO RUN AFTER THE VEHICLE STALLED AND DRAINED THE BATTERY. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT CALLED VOLKSWAGEN OF MARIETTA (1860 COBB PKWY SE, MARIETTA, GA 30060) AND INFORMED THE DEALER OF THE FAILURE. THE CONTACT CALLED THREE OTHER UNKNOWN DEALERS BUT WAS NOT PROVIDED ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11360225September 21, 2020
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
VEHICLE HAS EXPERIENCED STALLING, ENGINE SHUTDOWN, AND DIFFICULTY STARTING MULTIPLE TIMES. ENGINE HAS NOW STALLED MORE FREQUENTLY AT BOTH LOW SPEEDS AND WHILE DRIVING ON HIGHWAY. EACH TIME, RPM'S HAVE GONE TO ZERO AND IT'S COMPLETELY LOST POWER TO STEERING. I'VE HAD TRY AND COAST/NAVIGATE SAFELY TO SIDE OF ROAD, BERM, ETC., STOP, AND RESTART THE VAN. AT TIMES THE DASH LIGHTS WILL FLASH, OTHER TIMES THERE IS NO INDICATION THAT A FAILURE HAD OCCURRED, JUST NO POWER/RPMS. NO CHECK ENGINE LIGHT REMAINS, NO CODES DISPLAYED, NOTHING. THE LOCAL VOLKSWAGEN DEALER WILL NOT EVEN ADDRESS THE ISSUE AS THEY DEEM IT A "CHRYSLER PROBLEM". WE NOW TAKE IT TO AN INDEPENDENT MECHANIC AND REPLACED THE CRANKSHAFT & CAMSHAFT POSITION SENSORS, KEY FOBS, BATTERY, AND HAVE DONE ALL PREVENTATIVE MAINTENANCE. THE PROBLEM STILL REMAINS. THERE ARE SIMILAR COMPLAINTS (VW, CHRYSLER, & DODGE) FOR THIS EXACT ENGINE & SYMPTOMS THAT MAY BE RELATED TO THE TIPM, THE MAIN CONTROL MODULE. THIS IS A VERY SERIOUS SAFETY ISSUE AS IT RANDOM AND CAUSES A COMPLETE SHUTDOWN OF VEHICLE WHILE IN MOTION AND LOSS OF OPERATOR CONTROL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11355049September 15, 2020
ELECTRICAL SYSTEM, ENGINE, EXTERIOR LIGHTING
DASH FLASHING, HARD START AFTER PUTTING IN A NEW FUSE BOX AND AFTER FLASH FROM THE DEALER
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11354945September 14, 2020
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V194000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TOWED TO VOLKSWAGEN OF MACON LOCATED AT 4786 RIVERSIDE DR, MACON, GA 31210, (478)781-7701, TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO START THE VEHICLE. THE CONTACT STATED THAT THE MECHANIC WAS UNABLE TO RETRIEVE ANY INFORMATION FROM THE COMPUTERS IN THE VEHICLE. THE CONTACT WAS INFORMED THAT THE PART NEEDED TO REPAIR THE VEHICLE WAS ON BACK ORDER. THE CONTACT STATED THAT THE TOW TRUCK OPERATOR PROVIDED A DIAGNOSTIC TEST AND INFORMED THE CONTACT THAT THE IGNITION SWITCH MODULE NEEDED TO BE REPLACED. THE IGNITION SWITCH MODULE WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11354796September 13, 2020
ENGINE
WHEN GETTING OFF HIGHWAY WHILE AT LIGHT MY CAR SPUTTERED AND STALLED. THE CAR WOULD NOT RESTART AND I HAD TO HAVE TOWED. THE RIGHT SIDE CYLINDER HEAD HAD TO BE REPLACED AT A COST OF OVER $4000. VW IS REPLACING THE LEFT SIDE UNDER WARRANTY FOR 10 YEARS BUT NOT THE RIGHT SIDE FOR SOME REASON SO I HAVE TO PAY. THERE HAVE BEEN MANY PROBLEMS WITH THIS ENGINE AND I HAVE ONLY 89000 MILES. THE ENGINE IN THE VW IS A CHRYSLER 3.6 LITER PENTASTAR. WHILE FIXING THAT IT WAS FOUND THAT THE OIL FILTER HOUSING UNIT WAS LEAKING AND NEEDED TO BE REPLACED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11354495September 11, 2020
SERVICE BRAKES, ELECTRICAL SYSTEM, STEERING
I WAS DRIVING HOME FROM WORK APPROX. 30-35 MILES PER HOUR AND MY VAN DIED. I LOST POWER STEERING AND BRAKES. LUCKILY I WASN'T SERIOUSLY INJURED. THERE WAS NO WARNING. NO SERVICE ENGINE LIGHT. WITHIN A SPAN OF LESS THAN 2 YEARS IVE ALREADY REPLACED THE FUEL PUMP, THE BATTERY, AND THE ALTERNATOR IS STILL NEW AND UNDER WARRANTY. THE IGNITION/POWER WINDOWS FUSE CONSTANTLY NEEDS ADJUSTING SO I CAN ROLL MY WINDOW UP OR DOWN. ALL THE DASH LIGHTS COME ON RANDOMLY AS WELL. SOMETIMES THE WINDSHIELD WIPERS WOULD COME ON. NEVER HAD A VEHICLE DIE ON ME WHILE DRIVING DUE TO MANUFACTURERS ISSUES. AFTER READING OTHER CONSUMER COMPLAINTS ABOUT THE SAME ISSUES IM VERY CONFIDENT ITS THE TIPM. SOME COMPLAIN THAT THIS COSTS PEOPLE $1 000S ON A CHANCE THAT YOU CAN GET A COUPLE MORE YEARS OUT OF IT. THE VAN WANTS TO TURN OVER AND CONTINUES CRANKING WHEN KEY FOB IS IN IGNITION BUT DOESN'T TURN OVER. I CANNOT GET IT TO START AT ALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11353892September 8, 2020
AIR BAGS
THE PASSENGER SIDE AIRBAG COVER ARE INFLATED , CRACK , BUBBLE, LOOK LIKE THE AIRBAG MAY EXPLOTED.. I CALL VW AND THEY SAY IS IT NORMAL AND NOT SALE THE PART. 2009 MINI VAN. .?? I REALLY NOT THINK THEY CHANGE OR OVERHEATING.. GETTING WORDS .. AND YESTERDAY FROM NOT WEAR THE ROUTAN NOT DRIVE OVER 35 MPH WHEN MY WIFE DRIVING ON THE HIGHWAY AND CHECK ENGINE CAME , 4 CODE ,P0733,P0734, P0792. AND ALMOST A TRUCK HIT MY WIFE.. I LOOK ON VW FORUMS AND IT IS COMMON PROBLEM,, WHY THIS IT NOT A RECALL WITH SO MANY PEOPLE COMPLAINING AND PROBLEMS.. UNSAFE TO DRIVE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11348466August 10, 2020
ELECTRICAL SYSTEM
WHILE DRIVING MY 2011 VW ROUTAN AT 45 MPH SPEED SUDDENLY THE SPEED DROPPED DOWN TO 20 MPH ON A BUSY ROAD AND EVENTUALLY STOPPED. LUCKILY I WAS ABLE TO PULL MY VEHICLE OVER TO A LOCAL ROAD. AFTER SHOWING THE VEHICLE TO DEALER THE PROBLEM WAS IDENTIFIED AS TIMP ISSUE AND REPAIR WOULD COST $1500. LUCKILY IT WASN'T A FREEWAY WITH 65 MPH ROAD, I COULDN'T THINK OF THIS THING HAPPENS ON SUCH ROAD WITH KIDS INSIDE THE CAR. I HAVE CAME ACROSS CHRYSLER GOT SAME SORT OF ISSUES AND THEY RECALLED SUCH VEHICLES. VW ROUTAN IS ALSO SAME BUILT AS CHRYSLER TOWN AND COUNTY AND VW DIDN'T OFFER ANY RECALLS FOR THESE ISSUES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11344079August 8, 2020
ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
THIS VEHICLE IS BASICALLY A CHRYSLER/DODGE WITH VW BRANDING, AND ONE OF THE KEYS IS EVEN A DODGE KEY. IT HAS THE SAME ISSUE WITH THE TIPM AND FUEL RELAY MODULE THAT WAS RECALLED ON THE 2011 CHRYSLER AND DODGE VANS. SEE FUEL PUMP RELAY RECALL NHTSA 14V-530. I'M ASKING THAT IT ALSO BE RECALLED FOR THE 2011 VW ROUTAN SINCE IT'S VERY DANGEROUS THAT MY CAR COULD STOP AT ANY MOMENT. I RECENTLY PURCHASED MY VAN FROM A USED CAR DEALER IN NEW JERSEY WHO NEGLECTED TO EVEN INFORM ME THAT THIS WAS A KNOWN ISSUE EVEN THOUGH I INFORMED THEM THAT I'D BE DRIVING THE CAR CROSS COUNTRY. WHEN I WAS IN GEORGIA THE CAR STARTED CRANKING, BUT WOULDN'T START AND IT HAS HAD THIS SAME INTERMITTENT ISSUE SINCE I ARRIVED IN FL. IT TOOK A WHILE FOR US TO FIGURE OUT WHAT WAS EVEN WRONG WITH IT BECAUSE WHEN THE AUTO SHOP RAN A DIAGNOSTIC, NO CODES WERE RETURNED. HOWEVER, WHEN THEY FINALLY GOT THE ISSUE TO OCCUR AGAIN, THEY FOUND THAT TAPPING ON THE FUEL RELAY MODULE IN THE TIPM WOULD ALLOW THE CAR TO START. THEY ADVISED TO TAKE IT TO CHRYSLER BECAUSE IT'S ACTUALLY A CHRYSLER VAN UNDER THE HOOD. WHEN I CALLED CHRYSLER, THEY TURNED ME AWAY BECAUSE THE VIN IS FOR A VW. WHEN I CALLED VW, THEY SAID NO RECALL EXISTED FOR THIS VAN EVEN THOUGH IT'S THE SAME ISSUE. SO, I'M ASKING THAT A RECALL ALSO BE DONE ON 2011 VW ROUTAN'S SINCE THEY ARE EXPERIENCING THE EXACT SAME DANGEROUS ISSUE CALLED OUT IN THE CHRYSLER RECALL. LASTLY, I EXPERIENCED THIS ISSUE BOTH WHILE THE CAR WAS STATIONARY AND WHILE IT WAS ON THE HIGHWAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11342789August 2, 2020
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
WHEN CAR IS RUNNING, EITHER IN PARK OR DRIVE, THE ENGINE CUTS OUT. WE MUST WAIT 30 SEC TO RESTART. IT WILL THEN RESTART. THIS ACTION HAPPEND BOTH WHEN THE CAR IS IN PARK AND DRIVE. THE ACTION HAPPENED ONCE IN OUR DRIVEWAY AND ONCE COMING OUT OF A CARRY OUT DRIVEWAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11340223July 19, 2020
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
HARD START CAUSED BY FUEL PUMP NOT ENGAGING. ENGINE SHUTDOWN AT STOPLIGHTS. ISSUE WITH FUEL PUMP RELAY. FUEL PUMP RELAY IS FULLY INTEGRATED AND IS COSTLY TO REPLACE. VOLKSWAGEN DOES NOT SUPPORT THE VEHICLE AND CHRYLSTLER WHO MADE THE VEHICLE DOES NOT HAVE THE FIRMWARE TO CORRECT THE ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11338410July 9, 2020
ELECTRICAL SYSTEM
MY DRIVERS SIDE BACK SEAT DOOR WILL NOT CLOSE ALL THE WAY AND WILL OPEN BACK UP IF IT DOES NOT LATCH CORRECTLY. THE ENGINE WIRING WILL MAKE MY CARS DASH LIGHTS ALL COME ON AND MAKE THE WIPERS GO OFF. THE DOOR ONLY DOES THIS WHILE STATIONARY HOWEVER, THE DASH LIGHTS GO OFF WHILE IN MOTION ON A REGULAR STREET GOING LESS THAN 40MPH
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11331811June 30, 2020
POWER TRAIN
MY CAR RECENTLY STARTED HAVING ISSUES SHIFTING INTO THE NEXT GEAR. TYPICALLY HAPPENS WHEN I HAVE BEEN DRIVING FOR A WHILE. ALL OF A SUDDEN IT WILL GET STUCK IN A GEAR AND IT WON'T SHIFT. THE CAR CAN BE IN MOTION OR EVEN STATIONARY (STOP LIGHT) WHEN IT HAPPENS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11328804June 14, 2020
ELECTRICAL SYSTEM
MY 2011 VE TOUTAN MINIVAN WILL RANDOMLY CUT OFF WHILE I'M DRIVING DOWN THE ROAD. THERE ARE TIMES WHEN IT WILL NOT START AT ALL. VW ROUTANS ARE KNOWN FOR HAVING IGNITION AND TIPM ISSUES BUT VW WILL NOT TAKE RESPONSIBILITY AND FIX THE ISSUES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11327207June 4, 2020
STEERING, SUSPENSION
HAD TO REPLACE RIGHT REAR WHEEL BEARING AT APPROXIMATELY 60,000 MILES. HAD TO REPLACE LEFT REAR WHEEL BEARING AT 80,500 MILES. BOTH WHEEL BEARINGS WERE MAKING GRINDING NOISES. RACK AND PINION HYDRAULIC LINE CRACKED AT ELBOW AND HAD TO BE REPLACED. RACK AND PINION PROBLEM OCCURRED WHILE DRIVING CLOSE TO HOME. LOST ALL STEERING IN DRIVEWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11326519May 29, 2020
ELECTRICAL SYSTEM
WHILE DRIVING CAR IT TURNS OFF. HAS TO BE RESTARTED. FAULTY IGNITION SWITCH. NOTICED A PAST RECALL.*DT*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen Routan