Volkswagen · Model Report
Showing safety data for the 2003 model year only.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
The contact owns a 2003 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled. There were no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The manufacturer was made aware of the failure and informed the contact that the parts needed for the repair could not be found. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 07V375000 (Fuel System, Gasoline); however, the VIN was included but the vehicle was not repaired. The failure mileage was approximately 133,000.
No injuries · No fire · No crash
The contact owns a 2003 Volkswagen Passat. The contact received notification of NHTSA Campaign Number: 06V017000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
No injuries · No fire · No crash
The contact owns a 2003 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, coolant leaked onto the front passenger’s side floorboard. The contact stated that the coolant leak was underneath the glove compartment area. The vehicle was taken to an independent mechanic, and the contact was advised to have the vehicle taken to the Volkswagen dealer. The contact visited the dealer and discussed the reoccurring failure and was informed that the heater coil was designed incorrectly, and the failure was due to the design of the heater coil. The contact was informed that the heater coil needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 72,000.
No injuries · No fire · No crash
Vehicle has major fuel pump issue, currently at 132,000 and noticing loss of power, car shaking, and occasional stall. A code reader is unable able to detect the issue which is a major concern. I have contacted the volkswagen Manufacturer and I consistently keep getting ignored after bringing up the recall that was put out for the fuel pump. While driving on the highway my rear and front suspension failed and dropped suddenly while moving slowly during traffic. I whave only been able to repair the front shocks and struts so far, but the rear are needed as well. I would like to state that all the parts are original manufacturer parts.
No injuries · No fire · No crash
The contact owns a 2003 Volkswagen Passat. The contact stated that while driving approximately 35 mph the vehicle's speed suddenly begin to reduce and smoke was present coming from the engine compartment. After stopping and exiting the vehicle became engulfed in flames. The fire department was called to the scene and extinguished the flames and the vehicle was towed away. During the incident, the vehicle was destroyed. The local dealer and manufacturer were notified of the incident but no assistance was offered. The failure mileage was 150,000.