Toyota · Model Report
Showing safety data for the 2008 model year only.
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Water pump failed after replacement in 2013 with 30k miles, car had only 93k miles when failed again in 2016. The potentiometer part failed, there is corrosion in the part. Was in freeway when it failed. I have reported this to different representatives. I was charged more 1.5k for a replacement of a faulty part that should last more than 50k miles.
No injuries · No fire · No crash
the cruise control was inop, technician said it was a clockspring failure, replaced the clockspring with a new part from walmart, then at times, the airbag failure light would come on, paid a technician to replace the replacement clockspring with an new one and the failure stopped, walmart is selling a part that could result in death
No injuries · No fire · No crash
2008 Toyota Prius gen2 with 139k miles. ABS, Brake, parking brake, and Traction Control lights all illuminated while driving the other day. Potential is losing all electronically assisted braking function in the car. Problem has been confirmed by local independent service center. Independent service center pulled codes: C1256 Accumulator low pressure C1378 Capacitor Communication Malfunction C1391 Abnormal leak of ACC pressure all consistent with ABS accumulator failure. Recommending ABS modulator assembly replacement at $2742.66 Toyota had a warranty enhancement program that covered this component: Warranty Enhancement Program – ZG1 2006-2007 Model Year Highlander Hybrid & 2004-2009 Model Year Prius Vehicles Extension of Warranty Coverage for Brake Actuator Assembly This Warranty Enhancement Program provides enhanced coverage to the vehicle’s “New Vehicle Limited Warranty” as it applies to the Brake Actuator Assembly. The specific condition covered by this program are repairs related to an internal malfunction of the Brake Actuator Assembly. If the condition is verified, the vehicle will be repaired with a new Brake Actuator Assembly at no charge under the terms of this Warranty Enhancement Program. • The Primary Coverage offers warranty enhancement until December 31, 2017, regardless of mileage. • After the Primary Coverage end, the Secondary Coverage is applicable for 10 years from the date of first use, or 150,000 miles, whichever occurs first
No injuries · No fire · No crash
Brake pedal became hard and vehicle was difficult to stop. ABS warning light appeared on dashboard. This is a problem that Toyota has addressed previously by extending the warranty period to 10 Years/150,000 miles. My vehicle has 122,000 miles on it but the 10 year extended warranty has expired. I took the vehicle to a local repair shop and they confirmed that there was a problem with the brake actuator assembly. Now, Toyota says it would cost over $3000 to remove and replace their already defective part.
No injuries · No fire · No crash
In 2025 I decided to clean the hybrid battery fan. I removed the side panels and found that the fan to battery duct had never been installed. I am the original owner and no one had ever removed the inside panels or had reason to remove the duct. This has likely resulted in the overheated battery which now needs replacing even though I have only 161,000 miles on this car which I have always maintained without fail regarding oil changes and other maintenance tasks.
No injuries · No fire · No crash