Toyota Prius Complaints (2012)

449 consumer complaints on file.

#11634157January 5, 2025
SUSPENSION, WHEELS, SERVICE BRAKES
2012 Prius in very good condition with 180k miles- only 12 years old. Driving on back roads (thankfully) and the drivers side rear wheel compelely fell off while driving. I was doing about 30 MPH and felt like there was a flat tire so I was in the process of pulling over when the whole rear assembly snapped. The wheel hit the rear quarter of the car and bounced about 100 feet down the road. I could have been on the highway and this could have been fatal I believe. Very, Very scary. As can be seen in attached photos the issue was rust from the inside. This is very concerning since there was no way for me to know this was an issue. I could have been killed or killed someone else. I believe Toyota needs to look into this since there are other Prius' out there the same thing happened to on this very thread. Although this is a Massachusetts car I have owed it since 25k miles and have maintained it impeccably. I always have the undercarriage cleaned after driving on salty roads. Safety inspection was current- only done the month before. Had that wheel bearing replaced about 2 weeks before the incident and the reputable mechanic reported no issues. There was no warning except for maybe a minute before it happened- the car was vibrating like I had a flat tire. The damage repair estimate on this was $8500. Catastrophic fail Toyota. Is this a rust issue like the Tacoma, Tundra, and Sequoia?????
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631904December 21, 2024
SERVICE BRAKES
2012 Toyota Prius 5 with 105k miles. ABS, Brake, and Traction Control lights all illuminated while driving to work. Drove to the dealership and had their service department run a diagnosis for 200$. Their scanner reported CODE C1391, and that a new BRAKE PUMP and MASTER CYLINDER ASSEMBLY would need to be replaced for a total cost of $4,000. Toyota has a Customer Support Program Bulletin indicating that certain 2010-2015 Toyota Prius will experience internal malfunctions and require repair for BRAKE BOOSTER AND BRAKE BOOSTER PUMP ASSEMBLIES. Since this is a safety issue, Toyota should extend the program indefinite and repair their faulty systems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631892December 20, 2024
SERVICE BRAKES, ELECTRICAL SYSTEM
Wednesday morning I went to start my car to go to work. I noticed the brake would not go down. It was difficult to press. I was unable to go to work safely. I brought my car to a mechanic where I was informed it was a faulty brake booster. When I researched online, I saw many many other Toyota owners went through the exact same issue. There is no recall but it’s a huge issue and a a safety problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630423December 12, 2024
SERVICE BRAKES
ABS Pump and Actuator failed at 100,000 miles. Traction control, ebrake, ABS light came on while driving. Many other stories of Toyota vehicles with the same failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11610069August 21, 2024
SERVICE BRAKES
1. The ABS system failed upon inspection at a dealership. Specifically the ABS accumulator and booster. 2. The ABS system put us at risk by failing prematurely, and traction control and ABS functions seemingly stopped working while driving on the road. 3. Yes, dealership confirmed the issue with a full diagnostic, and the part has a customer support program bulletin/TSB out for this specific issue. 4. inspected by manufacturer dealership service center. 5. Lights such as the parking brake, ABS, and (!) lit up while driving and the failure occurred at the same time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11606386August 5, 2024
SERVICE BRAKES
My actuator is failing. This is a known issue for Priuses and a danger to those on the road. Toyota issued a voluntary service program on these parts to avoid a recall and now many are on the road with actautors that should have been replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11605705July 31, 2024
SERVICE BRAKES
ABS brake system doesn't work with three warning lights on and warning beeping sound. I'v learned that Brake actuator failed. Current mileage is only 67300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604854July 27, 2024
SERVICE BRAKES
ABS Break Lights turned ON and it need replacement. Toyota have faulty ABS this is my 3rd Prius that have the same Issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604414July 25, 2024
SERVICE BRAKES
I started noticing a strange noise when I applied the brakes. It was an electronic type of almost grinding sound. When I looked into it, it was determined that the brake actuator was failing despite no warning lights coming on. This started around the beginning of March. Finally in the beginning of July the noise stopped and a lot of dashboard lights came on including ABS, BRAKE, and others. This is when the brake actuator actually failed, and the battery no longer was charged when the brakes were applied. This is extremely concerning that a major brake component can fail like this and affect the safety of the vehicle. I am attaching a photo of the dash that shows the lights that came on when this failure occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11602473July 15, 2024
UNKNOWN OR OTHER
I contacted Toyota about the peeling paint on my car. The Toyota representative told me to file a complaint with your agency. The paint is peeling on the roof of my car. There are many similar cars with the same problem. Toyota is unresponsive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11601457July 12, 2024
SUSPENSION
On 07-June-2024 @14:47 my 2012 Toyota Prius suffered a catastrophic failure. I was attempting to back my 2012 Toyota Prius vehicle a few meters back into my driveway while turning slightly. This was a very slow speed backup. Suddenly, the rear passenger side wheel collapsed inward, and rendered the vehicle unmovable. A video of the incident is attached for viewing The vehicle has low mileage approximately 58,000 miles. The vehicle is in excellent condition and the service records provide evidence of proper maintenance, often at Toyota dealership. This vehicle was originally from Cape Cod Massachusetts and perhaps suffered adverse effects from ocean salt air? Although the rest of the vehicle does not show any significant rusting. . I am impressed by the engineering of the Prius hybrid technology, but this point of failure seems to be an engineering weakness.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11599257July 5, 2024
SERVICE BRAKES
In 2019, I took my Prius in for service. I reported that when I suddenly brake, the pedal feels spongy as if the brakes will not stop vehicle and lights on dash lit up. Toyota did diagnostic, no action taken by service department at Toyota dealership. I have service history documentation. On June 29, 2024 we had routine maintenance and the service department of the Toyota dealership recommended brake fluid serviced. On July 1, 2024, I was driving my child home from his summer camp and when I tried to stop the brake did not work. I started pumping the brakes several times until the car slowed and came to a stop. The lights on the dash lit up again. The brake failure put my son and I in danger. We had the car towed to the service department of the Toyota dealership. The service department sent the following information after their diagnostic. "The warning lights re-appeared after we drove it a few times. Now regarding the brake fluid service we performed, it is not related to those warning lights. Your accumulator is internally failing. The accumulator is a computer that distributes and controls the amount of pressure going into the brake system, and the computer was not untouched. Unfortunately it was bad timing and the computer started to internally fail. These vehicle's are known to have bad brake actuators, and Toyota created a type of recall for it to get replaced under no charge. Unfortunately they only cover up to 10 years and your warranty expired last year." My husband and I did not receive information regarding this recall. We did an online search to find out more about this recall and found several pages and posts of people describing the same situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11594703June 17, 2024
SERVICE BRAKES
Completely lost vacuum brake assist without any prior warning, while driving on the interstate. Got warning lights on the dash for brake and ABS, when it happened. Fortunately there was little traffic, but if there had been even moderate traffic, it could have caused a crash. Checked the codes and found a C1391 leak in the accumulator. Dealer has quoted me $3200 to repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11591860June 1, 2024
SERVICE BRAKES
Hi NHTSA, I have a 2012 Toyota Prius and all the Brake-related lights came on the dash. ABS and TC stopped working and the Brake Pedal lost sensitivity. I was about to crash the car and immediately took my car to the Toyota Dealership. They said that there was a Recall unfortunately the program has expired on my vehicle. I asked a couple of Toyota Prius owner friends and half of them had the same issue and they have been fixed under a program. But they said my 95k miles Prius is barely out of the program. My concern is that they charged the diagnosis cost released my vehicle and said that it was not safe to drive! I don't have the budget to cover the Manufacturer's low-quality BRAKE Booster production and I have to drive my car every day! I don't want to risk anyone but I have no choice. I hope you can help!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11591346May 29, 2024
SERVICE BRAKES
The contact owns a 2012 Toyota Prius. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle did not stop as intended. In addition, several unknown warning lights were illuminated. The contact used the parking brake to stop the vehicle. The vehicle was towed to the dealer where it was diagnosed with a failed brake master cylinder, accumulator, and brake booster. The contact was informed that the brake master cylinder, accumulator, and brake booster needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed of an unknown recall for the failure; however, the contact was informed that the recall had expired. The failure mileage was approximately 136,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11590779May 25, 2024
SUSPENSION, WHEELS
Today 05/25/2024 noticed a slight camber on the right rear wheel. Jacked up the car and removed the right rear to take a closer look and realized the rear axle/subframe was splitting in half along the weld point. If I hadn't caught this today and my daughter was driving it I'm confident she or others would have been killed or severely injured since most of her driving is highway related. The part that is blowing my mind is the vehicle was at the dealership twice in the last month and no one noticed when on a lift. The car is now permanently on jack stands till it can be repaired. I'm not sure it will even hold together to get onto a tow truck. I will not attempt driving do to safety specially others. I witnessed a tire go through a vehicle resulting in the death of someone.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11590785May 25, 2024
SERVICE BRAKES
Traction control, brake, and abs warning lights all came on at once while driving on freeway. Braking became harder. Car has fewer than 60,000 miles. I took it to the mechanic. He says I need a new booster pump.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11590056May 22, 2024
SERVICE BRAKES
Decreased braking performance. Sudden loss of ABS and Traction Control capabilities. (ABS light and Traction Control lights are now permanently illuminated on the dash). During the drive home, the brake response changed dramatically. More force is now required to operate the brakes. This failure occurred during a merge into traffic while on a merge ramp, going about 35 mph. It took what felt like a few seconds for both the vehicle and myself to adjust to the new braking requirements. During this time, it felt like a brief loss of braking ability. I continued to depress the brake pedal, and finally noticed a slowing of the vehicle. The pedal clearly requires much more effort and depress distance to begin slowing down the car. This decreased braking performance appears to be sustained until repairs are made to the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11589889May 21, 2024
SERVICE BRAKES
ABS, Stability Control and Brake warning lamps on dashboard. Faulty Brake Booster/Pump/Accumulator doesn't allow for safe stopping. Looking on the world wide web, it appears to be a common issue with this generation Prius (and it is COSTLY to repair).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11588659May 14, 2024
SERVICE BRAKES
Was 8 days out of warranty so Toyota would not honor offer to replace the brake booster/actuator. Paid personally to have it done with genuine Toyota parts. 16 months later same parts need replacing. Toyota refuses to help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Prius