Toyota · Model Report
Showing safety data for the 2023 model year only.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2023 Toyota 4Runner vehicles. The load carrying capacity modification label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Purchased size 265/70R17 tires (Michelin Defender LTX M/S2) exhibiting severe highway vibration immediately post-installation. The vibration persisted continuously for two years across every rotation, posing serious handling and steering risks. For two years, local shop staff gaslit the customer, claiming an "out-of-round" tire or casing defect was impossible to avoid warranty obligations. During a visit in front of store management, staff repeated the claim in front of management. The customer then presented real-time technical data from Google on the spot, forcing staff to admit casing defects happen. Despite this, management cleared the driver to leave, assuring the vehicle was safe to operate with an infant inside. To obtain objective proof, an authorized TOYOTA dealership inspected the vehicle. The dealer verified steering, suspension, and alignment were completely sound and documented the root cause in writing: "Found front left tire has casing deformation." When escalated to corporate executives—including Robert Moyer and top management—an internal email chain revealed local shop management and corporate leadership actively placing profit over safety, contradicting logs and technical facts to deny warranty coverage. Confronted with dealer documentation and caught in their deceptive paper trail, the company fully refunded all tire replacement and balancing costs. Internal casing deformation is a critical safety hazard; belt/casing failure at highway speeds creates extreme risk of sudden tread separation or blowout. Dealership diagnostic documentation and the deceitful Executive email chain are available upon request. I also have video of shaking while on the freeway with my infant child in the car moments after Costco management assured me we were safe.
No injuries · No fire · No crash
New, strange noise started in Dec'25 (41K miles; 2yrs 9 months). No warning lights. Diagnosed as failed brake accumulator (first at an independent shop, later at the dealer). Apparently the accumulator is part of the full master cylinder assembly which must be replaced. Toyota has quoted $3,200 to complete this repair and is telling me it must be out of pocket.
No injuries · No fire · No crash
I was driving the vehicle and suddenly the steering wheel started to getting hard to turn it and the dash board doesn’t show any failure I went right away to dealership close by they inspected the vehicle they states there is a power steering failure but the car never showed any failure on dashboard or safety system
No injuries · No fire · No crash
Windshield cracked approximately 2” from the bottom all the way across while using the defroster to clear ice from it. I was still parked at the time. I am unsure how long it will stay water tight or become worse. One concern is the crash avoidance and the automatic high beam sensor are both attached to the windshield and don’t want them to fail. I also don’t want the entire piece of glass to shatter and land in my lap while driving. The dealer refused honoring the repair under warranty. They only use one particular repair shop (which I suspect they own) and even quoted me a price for replacing the ruined glass. In addition to paying for that I would need to pay the dealer to recalibrate the crash avoidance and headlight sensor. I have yet to report the damage to my insurance. As of yet there are no warning lights showing.
No injuries · No fire · No crash
The contact owned a 2023 Toyota 4Runner. The contact stated that while her father was driving under 30 MPH on a side road, the driver swerved to miss a deer. The vehicle drove off a hill, rolled over and landed on its top, and all the seat belts simultaneously unbuckled, causing all the passengers to hit their heads against the roof simultaneously. Additionally, the contact noticed an abnormal fuel odor. The contact stated that she was unable to exit the vehicle. The contact's brother assisted the contact in exiting the vehicle, and all passengers were able to exit the vehicle. The vehicle then caught on fire. The fire department arrived at the scene, but it was unknown whether the fire was extinguished by the fire department. The origin of the fire was unknown. A police report was filed. It was unknown whether the air bags deployed. The vehicle was towed and deemed a total loss. The contact sustained neck and back pain, bruises and headaches. The contact stated that the headaches could be due to an impact on the brain cyst in the back of the contact's head. The contact's son sustained neck pain, back pain and bruises. The contact's brother and father sustained unknown injuries. All the passengers went to the hospital the following day and were still receiving medical assistance. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 10,000.