Mitsubishi Lancer Evolution Complaints

229 consumer complaints on file.

#10692803March 8, 2015
ELECTRICAL SYSTEM
THE VEHICLES KICK PLATE WHERE ALL THE WIRES CONNECT ARE ALL CORRODED ITS A MAJOR PROBLEM WITH ALL EVOS THERE SHOULD BE A RECALL TO GET THIS PROBLEM FIXED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10672344January 14, 2015
POWER TRAIN
WHILE DRIVING NORMALLY THE MESSAGE "4WD SYSTEM REQUIRE SERVICE" CAME UP. I BOUGHT THE CAR USED 40K MILES AND NOW IT ONLY HAS 43K MILES. I HAVE DRIVEN MILDLY SINCE I BOUGHT IT AND HAVE NEVER ABUSED THE CAR. I HEARD IT'S CAUSED BY AYC ACD PUMP FAILURE, ACD C161E. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10664740December 17, 2014
POWER TRAIN
ACD/ AYC PUMP FAILURE, ONE TIME I WAS DOING FLUID INSPECTION ON MY CAR WHEN I NOTICE THE CARS ATF FLUID RESERVOIR IN THE TRUNK IS LOSING OIL. LOOKED AT THE FLOOR FOUND SOME RED OIL DRIPPING. IT MAY HAVE SEEM THAT PUMP MAY HAVE BEEN FAILING TO HOLD PRESSURE AND LOSE OIL. POSSIBLE GASKET FAILURE OR PUMP CRACK. BEEN SEARCHING ONLINE FOR SIMILAR PROBLEMS, I FOUND OUT IT SEEMED TO BE MOSTLY EVERY OWNERS PROBLEM. IS THIS SUPPOSE TO BE COVERED BY MANUFACTURER? SEEM LIKE POOR MATERIAL BUILD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10662884December 8, 2014
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN
VEHICLE WAS IN COLD WEATHER, AYC SYSTEM LIGHT TURNED ON. I CHECKED THE FORUMS AND FOUND THAT THIS IS A COMMON ISSUE THAT INDICATES THE PUMP IS BAD. THIS IS A VERY COMMON PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10659722November 20, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC)
IT WAS A COLD WINTER DAY, I STARTED DRIVING MY EVO TO A NEARBY GROCERY STORE. ENROUTE, THE AWD SYSTEM WOULD THROW A WARNING AND A DASHBOARD LIGHT LIT UP. I WAS CONCERNED, STOPPED THE VEHICLE AND FOUND NO LEAKS OR NO WEIRD NOISES. THE VEHICLE WAS UNABLE TO SHIFT INTO SNOW/TARMAC/GRAVEL MODE. FORTUNATELY I WAS NOT STRANDED ON THE ROAD SIDE. UPON FURTHER INVESTIGATION I CAME TO KNOW THAT THE ACD PUMP FAILED AND HENCE IT THREW AN AWD ERROR. ITS COSTING ABOUT 2200 DOLLARS TO FIX THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10651868November 1, 2014
POWER TRAIN
THE AYC PUMP FAILED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10650428October 27, 2014
ENGINE, POWER TRAIN
ON SEPTEMBER 2, 2014, I PURCHASED A 2014 MITSUBISHI LANCER EVOLUTION GSR. ON OCTOBER 17, 2014, WITH A LITTLE OVER 2700 MILES THE SERVICE/MAINTENANCE LIGHT COMES ON AND I DROVE THE CAR TO MITSUBISHI TO HAVE THEM CHECK THE CAR OUT. ON OCTOBER 21, 2014, I RETURNED TO DEALER AND THE CAR WAS IMMEDIATELY WAS DRIVEN INSIDE AND PLACED ON A LIFT TO BE INSPECTED. I WAS TOLD BY THE SERVICE MANAGER THAT IT WOULD BE A LONGER WAIT THEN EXPECTED DUE TO MITSUBISHI'S HEAD OFFICE BEING LOCATED IN CALIFORNIA, AND TIME ZONE DIFFERENCE. I WAS NOT GIVEN A LOANER CAR, STANDARD PRACTICE ON A BRAND NEW VEHICLE WITH FULL WARRANTY AND HE ( SVR. MANAGER) DID NOT GIVE ME ANY INFORMATION WHILE I WAITED. THE NEXT DAY, I RECEIVED A CALL FROM VIN FROM MITSUBISHI SERVICE DEPARTMENT WHO TOLD ME MITSUBISHI, WANTS TO GET AUTHORIZATION FROM ME TO BREAK DOWN THE CARS ENGINE/TRANSMISSION IN ORDER TO MOVE FORWARD AND IT WOULD COST ME $1100, IF THEY SAW THAT IT WASN'T A DEFECT ON MITSUBISHI'S PART. I GAVE THE AUTHORIZATION AND WAS CALLED AGAIN BY VIN, WHO ADVISED ME THAT THE CAR HAD A DEFECTIVE SEAL AND THE CAR IS COVERED UNDER WARRANTY. ON OCTOBER 22, 2014, AT ABOUT APPROX. 4:25PM I RECEIVED A CALL FROM MITSUBISHI SERVICE DEPARTMENT TO GIVE ME A NEW UPDATE ON THE DEFECTIVE PARTS AND REPAIRS. VIN TOLD ME THAT THE CLUTCH & FLY WHEEL HAD BURNED OUT AND THAT MITSUBISHI WAS NO LONGER GOING TO COVER REPAIRS, WHICH HAD NOW REACHED $3,200. THIS IS AN EXPENSIVE CAR FROM MITSUBSHI; WE BOUGHT IT WITH 11 MILES ON IT AND IT IS INCONCEIVABLE THAT A BRAND NEW CAR CAN HAVE SUCH DEFECTIVE PROBLEMS. MITSUBISHI IS NOT UPHOLDING THEIR RESPONSIBILITIES AND WE FEEL WE HAVE BEEN SOLD A LEMON. HOW CAN A VEHICLE GO IN FOR AN OIL LEAK AND SUDDENLY HAVE ALL THESE MAJOR ISSUES? OCTOBER 27TH I WAS TOLD BY THE DISTRICT MANAGER OF MITSUBISHI THAT THE CAR WAS NOT GOING TO BE COVERED AND MITSUBISHI TOLD ME TO "DO AS YOU PLEASE." *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10650095October 26, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
THE AYC PUMP FAILED BY DISPLAYING A BLINKING TARMAC LIGHT. IT CONSTANTLY FLASHES WHILE DRIVING. THE AYC PUMP CORRELATES WITH THE STEERING AND STABILITY CONTROL FOR THE REAR DIFFERENTIAL. THIS IS A BIG HAZARD. THE AYC PUMP SHOULD BE RELOCATED TO THE TRUNK COMPARTMENT SO IT IS NOT EXPOSED TO WEATHER CONDITIONS LIKE SNOW AND RAIN. THIS WILL PROTECT THE AYC PUMP FROM FAILING. THE WARRANTY WILL NOT COVER THIS FAILED PUMP AT ALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10643292October 8, 2014
POWER TRAIN
ACD C161E WAS READ IN THE ECU. IT'S AYC ACD PUMP FAILURE. I DIDN'T DRIVE HARD. I DROVE NORMALLY WHICH I USUALLY DO. AND 4WD SERVICE REQUIRED COMES ON. I SEARCHED A LOT ABOUT THE ISSUE. MITSUBISHI SHOULD HAVE A RECALL ABOUT THIS ITS A COMMON PROBLEM FOR EVO I READ. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10640971October 2, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC), EQUIPMENT ADAPTIVE/MOBILITY
WHEN STARTING MY 2008 MITSUBISHI LANCER EVOLUTION GSR, I RECEIVED A WARNING MESSAGE ON THE CLUSTER DISPLAY SHOWING A YELLOW-ORANGE SYMBOL THAT SHOWS 4 WHEELS CONNECTED BY AXLES AND THE MIDDLE-SHAFT, WHERE THE FRONT TWO WHEELS ARE FACING AT AN ANGLE TO THE SIDE. THE ERROR CODE READ AS C161E: DTC C161E: ELECTRIC PUMP RELAY CIRCUIT SYSTEM (STUCK). THIS HAS BECOME A VERY COMMON ISSUE WITH THE 2008 MITSUBISHI LANCER EVOLUTION. SO COMMON THAT WHEN YOU SEARCH FOR THE CODE C161E, YOU CAN FIND COUNTLESS FORUM DISCUSSIONS ON MULTIPLE WEBSITES COMMENTING ON THE FREQUENCY OF THIS ISSUE. INCLUDING MYSELF, A SINGLE DISCUSSION IDENTIFIES AT LEAST 48 UNIQUE CARS, 42 OF WHICH ARE THE 2008 MODEL YEAR, WHERE THE ACD PUMP FAILED, ALL OF WHICH HAVING DRIVEN FEWER THAN 75,000 MILES AND NEARLY 60% WITH LESS THAN 50,000 MILES (HTTP://WWW.EVOXFORUMS.COM/FORUMS/SHOWTHREAD.PHP?T=58221&HIGHLIGHT=C161E&PAGE=1). SEVERAL OF THESE VEHICLES REQUIRED MULTIPLE REPLACEMENTS OF THE SAME PART. THIS PROBLEM AFFECTS THE SAFETY AND EFFECTIVENESS OF THE VEHICLE'S ALL-WHEEL-DRIVE SYSTEM, LIKELY INCLUDING THE VEHICLE'S TRACTION CONTROL AND NEEDS TO BE RECALLED IMMEDIATELY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10639384September 26, 2014
SUSPENSION, POWER TRAIN
TARMAC ICON BLINKS INCESSANTLY ON THE DISPLAY PANEL, AS ONE DRIVES. THE BLINKING CAN CAUSE PHOTOSENSITIVE EPILEPSY (PSE), WHICH IS A FORM OF EPILEPSY SEIZURES TRIGGERED BY VISUAL STIMULI THAT FORM PATTERNS IN TIME OR SPACE, SUCH AS FLASHING LIGHTS, BOLD, REGULAR PATTERNS, OR REGULAR MOVING PATTERNS. I FOUND OUT LATER, THE BLINKING IS AN INDICATOR THE ACD PUMP - ACTIVE CENTER DIFFERENTIAL - IS FAILING AND IT'S ONLY A MATTER OF TIME BEFORE THE COMPONENT COMPLETELY GIVES OUT. MANY, MANY INDIVIDUALS FROM THE COMMUNITY EXPERIENCES THE ACD PUMP FAILURE DUE TO DESIGN AND PLACEMENT OF THE COMPONENT IN AN INOPPORTUNE LOCATION. AS SUCH, CORROSION FROM MOISTURE AND SALT DEPOSIT ON THE ROAD CAN EASILY INFILTRATE INTO THE PUMP COMPONENT, CAUSING FAILURE IN DUE TIME. FURTHER POOR SEALING, LACK OF WEATHER PROTECTION (ANTI-CORROSION SPRAY) AND POOR PLACEMENT ALL CONTRIBUTES TO THE SYSTEMATIC, PREMATURE FAILURE OF A $1500 PUMP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10633068September 14, 2014
POWER TRAIN, ENGINE
THERE IS AN ACTIVE CENTER DIFFERENTIAL PUMP FAILURE THAT IS BECOMING COMMON IN ALL LANCER EVOLUTIONS OF THIS YEAR. MINE WENT OUT LAST YEAR AND I HAVE BEEN HAVING TO DRIVE WITH IT FOR A YEAR NOW NOT KNOWING WHETHER THE DIFFERENTIAL IS CORRODING AT AN ACCELERATED RATE OF NOT. I DID THIS BECAUSE AFTER I HAD MY VEHICLE ASSESSED THEY TOLD IT WOULD BE $2500 TO REPLACE. I RESEARCHED ONLINE AND FOUND THAT THIS IS A VERY COMMON PROBLEM AND CAN BE DANGEROUS THEREFORE CAUSING ME TO HAVE TO PAY THIS ABSURD AMOUNT EVEN WITH KNOWING THAT ALMOST 60% OF EVO DRIVERS HAVE TO DEAL WITH THIS SAME ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10626474August 19, 2014
SUSPENSION
SPRING SEAT BROKE AT WELD JOINT TO SHOCK TUBE. SPRING TRANSLATED IN THE Z DIRECTION UNTIL IT WAS IN DIRECT CONTACT WITH THE TIRE. UPON BREAKAGE VEHICLE HAD EXTENSIVE SPRING RUBBING AGAINST TIRE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10621577August 11, 2014
ELECTRONIC STABILITY CONTROL (ESC)
MONDAY MORNING I WARMED UP MY CAR FOR 5 MINUTES. STARTED TO DRIVE MY CAR FOR ABOUT 15 SECONDS, AWD SERVICE REQUIRED POPPED UP ON MY DISPLAY. I STOPPED THE CAR AND BROUGHT IT BACK HOME. LOOKED UP WHAT THE ISSUE COULD BE AND FOUND OUT THAT THE ACD PUMP HAS FAILED. THIS IS A WELL KNOWN PROBLEM FROM MITSUBISHI FOR THESE CARS AND THEY HAVE NOT ISSUED A RECALL OR REAL FIX. WITHOUT THE ACD PUMP FUNCTIONING, THERE IS A POSSIBILITY THAT THE CAR CAN LOSE TRACTION IN CERTAIN SITUATIONS OR DAMAGE THE ENTIRE DRIVETRAIN SYSTEM. MITSUBISHI CLAIMS THAT ITS NOT PART OF THE DRIVETRAIN SO THERE IS NO WARRANTY AND IT'S ALSO A "LUXURY" SYSTEM. CONTROLLING WHEEL TRACTION IS NOT A LUXURY ITS A SAFETY FEATURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616432July 25, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC)
2012 EVO X GSR - FROM JBA MITSUBISHI (GLEN BURNIE, MD). AT 31,651 MILES - I WAS IN A FAST-FOOD DRIVE THRU LINE ORDERING BREAKFAST. THAT IS, 0MPH. ALL OF A SUDDEN, I HEAR A CHIME AND SEE MY INSTRUMENT PANEL FLASH. MY DRIVING-MODE/STATUS LIGHT (WHICH SHOWS TARMAC/SNOW/GRAVEL) HAD TURNED OFF. ANOTHER LIGHT ILLUMINATED, SAYING '4WD SERVICE REQUIRED'. MY EVO IS 100% BONE STOCK, NO MODS/TUNE. I CALL AROUND AND DO SOME RESEARCH. I CHECK MY FLUIDS, TIRES (ALL 4, BRAND NEW, PROPERLY BALANCED), ETC. A LITTLE WHILE LATER, I DISCOVER THAT IT IS MY AYC PUMP. THIS IS A KNOWN ISSUE WITH EVO'S AND NEEDS TO BE RECALLED. LUCKILY, MINE WENT OUT JUST BEFORE WARRANTY. OTHERWISE, IT'D COST BETWEEN $2500-$3K TO FIX ON MY OWN DIME. I LIVE IN MD - WE GET SNOW EVERY SINGLE YEAR. APPARENTLY, THE SALT AND WEATHER CHANGES CAN CAUSE CORROSION AND DAMAGE TO THE PUMP. MITSUBISHI OFFERS A REPLACEMENT (WITH 1YR, 12K MILE WARRANTY). BUT I'VE SEEN FOLKS IN CANADA WHO BURN THRU 3-4 PUMPS A YEAR. MEANING JUST BECAUSE OF THIS 1 PART, AN EVO IS A TERRIBLE CAR TO HAVE IN COLD-WEATHER STATES. MITSUBISHI NEEDS TO RECALL THIS PART - OR OFFER TO REPAIR FREE WHENEVER THE PUMP GOES OUT. EVEN WITH PROPER PREVENTATIVE MAINTENANCE - I DO NOT WANT TO PAY $2500+ EVERY TIME THE PUMP GOES OUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609206July 9, 2014
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN, EQUIPMENT ADAPTIVE/MOBILITY
THE AYC PUMP FAILED AS NOTED BY A TROUBLE CODE. THE AYC PUMP DIRECTLY CORRELATES WITH THE STEERING AND STABILITY CONTROL FOR THE REAR DIFFERENTIAL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609478July 9, 2014
POWER TRAIN
ACTIVE YAW CONTROL PUMP THAT IS PART OF THE CAR'S ALL WHEEL CONTROL SYSTEM IS FAILING. PUMP IS NOT COVERED BY MANUFACTURER POWER TRAIN WARRANTY EVEN THOUGH IT'S PART OF THE POWER TRAIN. DUE TO LOCATION OF THE PUMP, IT GETS SPRAYED WITH WATER ON THE ROAD. THIS CAUSED THE PUMP TO FAIL PREMATURELY DUE TO CORROSION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10607970July 3, 2014
ELECTRONIC STABILITY CONTROL (ESC)
LOSS OF ELECTRONIC STABILITY CONTROL. AYC/ACD PUMP FAILURE DUE TO POOR ENGINEERING. CAR HAS NO STABILITY CONTROL AND DRIVER IS MORE LIKELY TO LOSE CONTROL IN SEVERE WEATHER CONDITIONS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10595963June 4, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC), EQUIPMENT ADAPTIVE/MOBILITY
ACTIVE YAW CONTROL (AYC) AND ACTIVE CENTER DIFFERENTIAL (ACD) PUMP FAILED. NOT COVERED UNDER POWER TRAIN WARRANTY PUMP WAS CORRODED AND COULD NO LONGER PRODUCE ENOUGH PRESSURE. PUMP IN LOCATED DIRECTLY BEHIND PASSENGER REAR WHEEL EXPOSED TO WATER, SALT, AND OTHER ROAD DEBRIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10594401May 27, 2014
POWER TRAIN, ELECTRONIC STABILITY CONTROL (ESC)
WENT TO DEALER FOR TRANSMISSION CHECK AND AFTER A MILE AWC LIGHT CAME ON THEY SAID IT HAD NOTHING TO DO WITH COMPUTER UPDATE THEY DID.MIND YOU MY TRANNY WAS GOING BAD AND DEALER DID NOT WANT NOTHING TO DO WITH IT EVEN UNDER WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mitsubishi Lancer Evolution