KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
While driving on the roadway, I was almost to a four way intersection, as i was going to get into the left turn lane, I turned the steering wheel slightly to the left as the steering wheel turned but the car almost did little adjusting to turn into the left turn lane. As this occurred you could here a noise underneath the vehicle . As I wasn't sure exactly what had happened, I attempted to limp the vehicle down the road to a friend's. As I did the steering got worse and as I could nearly stear the vehicle something was in the road which because of the steering I couldn't avoid it as it was late at night and raining and I ran over something that gave me a flat on the passenger side front tire . I got to my friends drive a few feet away and almost didn't get it pulled in because of the steering. As I took a look at my car, I noticed that two bolts on the driver side on the rack and pinion were almost about to fall out, two ball joints were bent and one nut was completely missing from the lower ball joint, as well as the sway bar was out of place and If I would have been driving down the highway, I do belive I would have wrecked.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2003 KIA OPTIMA. THE CONTACT NOTICED THAT THE VEHICLE WAS OUT OF ALIGNMENT. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC AND WAS INFORMED THAT AN ALIGNMENT COULD NOT BE PERFORMED BECAUSE THE SUBFRAME WAS FRACTURED. THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 09V183000(SUSPENSION). THE CONTACT CALLED BOB ROHRMAN KIA (801 SAGAMORE PKWY S, LAFAYETTE, IN 47905, 765-746-7301) AND WAS INFORMED THAT THE RECALL REPAIR HAD ALREADY BEEN PERFORMED ON THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY COULD NOT ASSIST SINCE THE RECALL REPAIR HAD BEEN COMPLETED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 168,531.
No injuries · No fire · No crash
THE FRAME IS RUSTED THROUGH CAUSING THE VEHICLE TO BE UNSAFE, THOUGH IT HAD A RECALL FOR THIS EXACT PROBLEM AND IT WAS ONLY INSPECTED AND NOT REPLACED. THE CAR WAS INITIALLY TAKEN TO A LOCAL AUTO REPAIR SHOP FOR AN ALIGNMENT AS IT PULLED TO THE RIGHT, THE SHOP SAID THE FRAME WAS RUSTED SO BADLY THAT AN ALIGNMENT COULD NOT BE DONE. IT WAS DETERMINED THAT A RECALL HAD BEEN MADE FOR THIS VEHICLE. RECALL #09V183000. GURLEY LEEP KIA IN MISHAWAKA, INDIANA WAS CONTACTED AND AN APPOINTMENT WAS MADE. THE TECHNICIAN SAID THE FRAME WAS RUSTED BUT KIA WOULD NOT REPAIR THE VEHICLE AS THE RECALL HAD ALREADY BEEN MADE.
No injuries · No fire · No crash
DRIVERS SIDE DOOR WILL NOT UNLOCK WITH KEY OR INSIDE DOOR LOOK SWITCH. THIS IS A REAL SAFETY HAZZARD.
No injuries · No fire · No crash
AT 24,000 MILES MY VEHICLE STARTED LOCKING DOORS WHEN TEMPERATURES REACH 32 DEGREES OR LOWER. VEHICLE OUTSIDE ON CITY STREET OR DRIVEWAY. WHEN TEMPERATURES GET TO 32 DEGREES, DOORS LOCK AND DO NOT UNLOCK TO ALLOW ACCESS. IF YOU ARE INSIDE OF CAR IT LOCKS YOU INSIDE OF CAR, AS WELL AS OUT OF CAR. LOCKS UNLOCK THEN LOCK INSTANTLY EVEN WHEN USING KEY, NOT KEY FOB TO UNLOCK CAR~ NO ACCESS TO ENTER VEHICLE UNTIL ABOVE 32 DEGREES. IN CASE OF EMERGENCY...YOU HAVE NO VEHICLE. THIS HAS HAPPENED EVERY YEAR WHEN TEMPERATURE GETS BELOW 32 DEGREES. I HAVE REPORTED THIS PROBLEM IN PAST.RECALL AND FIX IT PLEASE!!!
No injuries · No fire · No crash