Kia Forte Complaints (2015)

262 consumer complaints on file.

#11774120October 27, 2026
ENGINE
This is the report copy and reference number for 911. I have contacted Kia multiple times during lunch breaks sent emails, and they still are not responding even after photos were sent to them. They told me in 5 days I would here back form them an still Ive heard nothing.Reference # XXX The fire dep “# INCIDENT REPORT Reference #XXX **Vehicle Smoke Incident and 911 Emergency Call** **Date of Incident:** Monday, XXX **Time of 911 Call:** 10:11 a.m. **Location:** Kaiser Permanente Riverside Medical Center [XXX] [XXX] **Vehicle Involved:** 2015 Kia Forte ### Description of Incident On Monday, XXX, at approximately 10:11 a.m., a 911 emergency call was placed regarding a 2015 Kia Forte that was experiencing smoke coming from underneath the hood in the engine compartment while at Kaiser Permanente Riverside Medical Center, located at [XXX]. Due to the smoke coming from the engine compartment, the vehicle had to be parked in a red-designated area. The situation raised concerns about a potential vehicle fire and the safety of operating the vehicle. The fire department responded to the incident and inspected the area underneath the hood. Following the inspection, I was advised not to drive the vehicle because it was smoking and there appeared to be oil that had leaked, dripped, or spread across various components inside the engine compartment. I was further advised that driving the vehicle could create a serious safety hazard and could potentially result in the vehicle catching fire until it could be properly inspected and evaluated by a qualified automotive professional. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11773589October 26, 2026
ENGINE
On October the 14th, around 10:30 AM I noticed smoke coming from my car and acceleration was lost. The vehicle continued to smoke further. As I Had someone maneuver the car out of traffic into the parking lot.\n While reaching the parking lot, more smoke was noticed, so I dispatch the Riverside fire department. After one of the fire responders checked under the hood, they noticed that there was oil in various places, including the engine area and in the PAN underneath, they checked the oil and found oil still inside. Unit. The fire man check , both told me to not drive the car any further because if I did it would catch on fire , I then had the car towed to my home address.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11768141September 30, 2026
ENGINE
Vehicle has developed a severe knocking during acceleration, that stops during deceleration, and returns when in idle. I'm sure it is poison slap. I know there is an extension warranty, but the dealer says my car doesn't qualify. Then NHTSA has the SC200 safety recall. I need help with this car. My engine is failing. Can you help me?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763301September 10, 2026
ENGINE
While driving my 2015 Kia Forte5 at approximately 80 mph on GA-400, I was traveling in the far-left lane when the vehicle suddenly and unexpectedly lost acceleration and engine power. Pressing the accelerator produced little to no response. There was no gradual reduction in speed or sufficient warning that the vehicle was about to lose propulsion. Because I was in the far-left lane, I had to maneuver across approximately four lanes of highway traffic to reach the shoulder. Fortunately, this occurred at night when traffic was relatively light, allowing me to get the vehicle to safety. GA-400 normally carries very heavy traffic during the daytime, and I believe the same sudden loss of propulsion under those conditions could have resulted in a serious collision because the driver may have no safe way to cross multiple lanes while rapidly losing speed. After the initial incident, I was able to drive approximately five minutes to my brother’s house. An independent mechanic inspected the vehicle, and the following day we brought it to an authorized Kia dealership and explained the loss-of-power condition. At that time, the engine had not yet completely failed. The dealership did not proceed with an engine repair/replacement and indicated that the engine/check-engine-light condition needed to be present. After leaving Kia, the problem became substantially worse. While the vehicle was being driven back, the engine completely lost power and the vehicle became disabled. We had to physically push the vehicle to a safe location. The vehicle is currently available for inspection. Kia later informed us that the vehicle had been reported as a total loss in 2017 and therefore they consider it ineligible for warranty coverage. Regardless of warranty eligibility, my reason for filing this complaint is the serious safety risk created by the sudden loss of propulsion at highway speed. I am requesting that NHTSA document and review this incident as a potential vehicle safety defect
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749789July 12, 2026
ENGINE
Recently had oil change . Right after B oil change engine light came on, a solid yellow light car is driving rough it’s a 2015 Kia Forte. Have an appointment Monday 7/13/2026 to have dealer to do a B diagnostic. The same place I had oil change
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748470July 6, 2026
ENGINE
respectfully submit this correspondence to request formal assistance regarding my 2015 Kia Forte EX, a vehicle covered under the class settlement. The vehicle is exhibiting severe symptoms consistent with KSDS‑related engine failure, yet the required diagnostic protocol has not been completed by the servicing dealership. The KSDS software update was performed in May 2022, and the vehicle currently has only 92,000 miles on the odometer, placing it well within the settlement’s mileage parameters. Despite this, the dealership has failed to follow KSDS procedures and has not produced any written documentation of its findings. All communication with the dealership has occurred exclusively by telephone. Despite repeated attempts to obtain information, I have not received a diagnostic sheet, video recording, code report, KSDS documentation, or any written summary of the vehicle’s condition. All statements provided to me have been verbal and inconsistent. My **primary symptoms** include: - Persistent and worsening **engine ticking** - **Burning excessive amounts of oil** - Activation of **limp mode** - A **flashing check engine light** These symptoms align with known indicators of KSDS‑related engine failure and warrant immediate and proper diagnostic evaluation under the settlement terms. The dealership has verbally stated that the issue may be related to **spark plugs and ignition coils**. However, plugs and coils are a **well‑documented secondary symptom** of rod bearing failure, caused by oil contamination and misfires resulting from internal engine damage. This further supports the likelihood of KSDS‑related engine failure. Kia corporate has not referenced documentation of any kind. They have not requested it, indicated they are awaiting it, or provided guidance regarding its submission. Instead, corporate has repeatedly stated that they “must defer to the dealership,” despite the dealership’s failure to perform or submit the required KSDS diagnostic materials.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747107June 29, 2026
ELECTRICAL SYSTEM
The contact owns a 2015 Kia Forte. The contact stated that an anti-theft protection software update was performed in 2024. After the update was performed, while driving at various speeds, the vehicle unexpectedly turned off without warning. The transmission was shifted into neutral(N) and restarted to continue driving. The vehicle was reset and self-corrected after being restarted. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The vehicle was taken to another dealer, Fred Anderson Toyota of Raleigh (9101 Glenwood Ave, Raleigh, NC 27617); and the dealer was unable to diagnose the vehicle. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744259June 15, 2026
ENGINE, FUEL/PROPULSION SYSTEM
The car is jerking while driving. It's caused the car to overheat. It's hard to start up and usually stalls out. It has stalled out while driving almost causing a accident. The engine light came on. I took it for a diagnostic and it was code P0172 for high pressure fuel pump. Before the incident date it was already hard to start prior to the engine light coming on. It sometimes causes smoke to come out of the exhaust. There was also smoke from under the hood in the engine compartment and as soon as I put gas in the car it runs out very quickly. This issue could have caused and accident or even a fire. It's unsafe to drive and from other reviews I've seen several other Kia drivers have experienced issues with this same faulty part, which is expensive to fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720085February 24, 2026
ENGINE
The contact owns a 2015 Kia Forte. The contact stated that while driving in the fast lane at 70 MPH on the interstate and attempting to move over to the emergency lane, the vehicle stalled. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 20V750000 (Engine); after the failure. The vehicle was towed to the local dealer, where it was determined that the vehicle was in LIMP Mode. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 100,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717120February 10, 2026
ENGINE, SERVICE BRAKES, AIR BAGS
Plese can you fex may car
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716424February 7, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Car goes into limp mode or cuts power when trying to accelerate. Refuses to shift or will shift down and revs highers rpms then necessary, especially at any incline. Started around 70k miles and got worse when brought in for other recalls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706002December 18, 2025
ENGINE, FUEL/PROPULSION SYSTEM
The vehicle began experiencing persistent engine misfires and rough running. Fuel contamination was found in the engine oil, and the spark plugs were fouled with oil and fuel. The catalytic converter has become clogged and failed multiple times due to excess fuel and oil entering the exhaust system. The Kia dealership documented these conditions but refused to perform recall-related engine repairs. Kia Consumer Affairs stated the vehicle does not meet warranty extension guidelines and would not repair the engine. Due to fuel in the oil, misfires, overheating exhaust components, and repeated catalytic converter failure, the vehicle is unsafe to drive and presents a potential fire risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702693December 3, 2025
ENGINE, ELECTRICAL SYSTEM
The contact owns a 2015 Kia Forte. The contact stated while driving 64 MPH, the vehicle jerked and vibrated, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle then stalled. The contact was able to coast to the side of the road. Multiple warning lights were illuminated. The contact was assisted with jumpstarting the vehicle. The contact was able to continue driving; however, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light illuminated, and the battery light illuminated intermittently. The contact was able to pull into a gas station. The contact called his daughter, who went to the gas station and jumpstarted the vehicle. The contact stopped by Auto Zone to have the vehicle diagnosed, where it was diagnosed and DTCs: P2191, P0562, C1101, C1102, C1201, C1204, C1207, C1208, C1210, C1211, C1237, C1260, C1513, C1613, and C1688 were retrieved. In addition, the battery showed codes that fluctuated constantly. The vehicle was taken to the dealer pending an inspection. The vehicle remained at the dealer unrepaired. The contact stated that recently the low oil warning light was illuminated, and the fuel level was low; however, the oil level and fuel level were not low. The ABS, traction control, steering, and tire pressure warning lights were illuminated. In addition, the brake warning light failed to function as intended. The contact replaced the brake lights however, the failure persisted. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 20V750000 (Engine); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 168,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700481November 20, 2025
ENGINE
Engine burning oil and the recall had to do with the engine burning oil and could cause engine fire while driving. It was under the recall list but the dealership said the time frame for the warranty expired it has been inspected by a auto shop and the said it needs a engine because the engine burned oil really fast and there where no warning
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698243November 7, 2025
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
I own a 2015 Kia Forte (VIN: [XXX] ) that experienced complete engine failure. The vehicle had been running normally until it began stalling and sputtering while driving. Shortly after, the engine would only run for 1–2 seconds before shutting off entirely. This exact issue mirrors those documented in previous recalls and class-action lawsuits involving Kia's 2011–2015 models with 2.0L and 2.4L engines. However, despite having the same failure and engine type, my VIN was excluded from the existing recall/warranty extension campaigns. Kia confirmed this is a known issue, but will not cover repairs. This failure occurred at approx. 180,000 miles. Engine failure without warning is a serious safety risk and financial burden. I am filing this complaint so NHTSA can review this issue and evaluate whether additional VINs — like mine — should be included in a broader investigation or recall. A case has been opened with Kia (Case #XXX), and full diagnostic documentation from a certified mechanic is available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693740October 16, 2025
ENGINE
Vehicle started making a ticking noise under the hood. I immediately had it towed to a mechanics shop in town. They performed an inspection and said the ticking noise is from a Rod Bearing # 3 has come loose and the whole engine must be replaced. The car has only 108,000 miles. There were no check engine lights that came on either. I called Kia to see about getting a replacement engine from them and they informed me they no longer make that engine for that car anymore which is the 1.6 Liter Turbo Charged GDI 4 Cylinder Engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689697September 25, 2025
SERVICE BRAKES
I was driving today and upon braking trying to come to a four way stop, the brake pedal went to the floor with no stopping. My vehicle went through the 4 way stop endangering me and my passengers. The piston blew out where all fluid leaked over the place. This is dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686444September 10, 2025
ENGINE
Rod knock in engine, catastrophic failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679307August 8, 2025
ENGINE
Oil leak with no warning signal what so ever . My car can completely run out of oil and the light won't turn in at all.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679060August 7, 2025
ENGINE
Took care to kis for a recall picked it up and got down the street and it died on me brought it back to Kia and was told it was okay just the oil filter took Kia home and changed oil and filter and car kept going dead would restart but the die again after driving for a little bit. The car kept going dead in middle of road interstate turning into lane across from on going traffic very unsafe. Took care back to Kia the scanned it and checked recall they did and said it was ok took car home again and same problem it now has a loud knock or chattering sound while driving.and it's still going dead. Took care back to Kia again and now they say there is internal engine failure and that I don't have the extended warranty because my mileage is just over the limit for regular warranty. And they will not offer goodwill either because the Internal engine failure. My car drove just fine no problems until I took it to them for the recall and now they say they can't help with nothing. With being disabled and a student I worked really hard to get this car and I need it to get to appointments school and therapy. This has taken away my transportation my happiness and my hard work And effort. It takes a lot to accomplish things being disabled and this makes it even harder. I want to give up most days being able to get to school gave me a purpose and I felt like I belonged. I feel it is only far to have another opinion and to have goodwill being the issue occured after the recall took place. Please help me get my car back and running I've given life and my education my all and my best with what circumstances I have to go through to make it through a day and not having the one things that I earned and worked so hard for taken away from me is really defeating and hard.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Forte