Jeep Wrangler Complaints (2005)

650 consumer complaints on file.

#10201164August 29, 2007
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
IN AUG OF 2005 AT 10,000 MILES I NOTICED A SHUDDER IN THE FRONT END WHEN STOPPING PROCEEDED TO THE DEALERSHIP AND THEY SAID MY ROTORS NEEDED RESURFACING WHICH THEY DID FOR FREE IT WAS COVERED UNDER WARRANTY . WITHIN A YEAR IT BEGAN AGAIN SUMMER OF 2006 WITH 35,000 MILES TOTAL ON THE VEHICLE THE ROTORS AND PADS HAD TO BE REPLACED AS THE SHUDDER WHEN STOPPING OVER 45 MPH BEGAN AGAIN MY ROTORS WERE WARPED OF COURSE THE WARRANTY IS NO LONGER AVAILABLE AFTER 12,000 MILES. NOW ONCE AGAIN AUGUST 2007 I JUST HAD THE ROTORS AND PADS REPLACED AGAIN AT 60,000 MILES . *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10200395August 21, 2007
ELECTRICAL SYSTEM:WIRING, EXTERIOR LIGHTING, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
WIRING OVERHEATING AND MELTING BLOWER MOTOR FAN SWITCH AT 36,500 MILES. WIRING OVERHEATING AND MELTING MULTIFUNCTION SWITCH FOR TURN SIGNALS, HEADLAMPS, HAZARDS, ETC... AT 37,800 MILES. UNKNOWN CAUSE FOR EITHER FAILURE. REPLACED BLOWER MOTOR CONTROL SWITCH ASSEMBLY AFTER FAILURE MYSELF AS IT WAS ONLY $25 USD AND 10 MINUTES TIME. NOW THE MULTIFUNCTION SWITCH IS DOING THE SAME - MELTING AND CAUSING HEADLAMPS TO FAIL. IS THERE A VOLTAGE CONTROL PROBLEM WITH THE ELECTRICAL SYSTEMS TO CAUSE THESE FAILURES? WILL THE REPLACED PARTS FAIL AGAIN? WILL A FIRE RESULT THE NEXT TIME? *TR UPDATED 02-01-08 *BF UPDATED 02/01/08 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10199656August 15, 2007
STEERING
STEERING FEELS LOOSE AND WOBBLY WHEN GOING ABOVE 45 MPH. TAKING IT IN TO GET LOOKED AT NEXT WEEK - CLOSET APPT. I CAN GET - I WILL NOT DRIVE THIS ANYWHERE. OTHER PROBLEMS TOO AND THERE IS ONLY 18K MILES ON IT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10199494August 14, 2007
SUSPENSION
2005 JEEP RUBICON UNLIMITED HAS UNCONTROLLABLE VIGOROUS FRONT END SHAKING. VEHICLE BEGINS TO SHAKE AFTER HITTING ROAD PATCHES, SEAMS, AND ANY OTHER TYPE OF BUMP AT SPEEDS OF 30 + MPH. SHAKE IS SO VIOLENT THAT VEHICLE MUST BE STOPPED TO RESUME REGULAR DRIVING. VERY DANGEROUS CONDITIONS IN HEAVY TRAFFIC AND UNSAFE FOR PASSENGERS AND OTHER MOTORISTS DEALER IS GOING TO REPLACE CAMBER BOLTS AND STEERING DAMPENER BUT PARTS ARE ON NATIONAL BACKORDER WITH AN INDEFINITE TIME FOR REPAIR. FIRST INCIDENT WAS IN JUNE AND IT HAS HAPPENED SEVERAL TIMES SINCE THEN. IT IS DRIVEN ON AN AS NEEDED BASIS ONLY, DUE TO THE "DEATH WOBBLE". *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10197594July 26, 2007
POWER TRAIN:MANUAL TRANSMISSION
TL*THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE DRIVING 10 MPH, THE TRANSMISSION SLAMMED OUT OF GEAR. THE CONTACT HEARD A RATTLING SOUND COMING FROM THE TRANSMISSION WHEN THE FAILURE OCCURRED. HE STATED THAT THE OTHER GEARS OPERATE NORMALLY. THE DEALER REPLACED THE THROW OUT BEARING, HOWEVER, THE FAILURE STILL PERSISTS. THE CURRENT MILEAGE WAS 34,461 AND FAILURE MILEAGE WAS 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10193120June 13, 2007
SUSPENSION:FRONT
SINCE I HAVE OWNED THE 2005 JEEP WRANGLER 2 DOOR I HAVE COMPLAINED ABOUT VIBRATION WHEN I HIT A BUMP AT ABOUT 30-35 MPH THAT S TARTS SHAKING THE VEHICLE SO VIOLENTLY I HAVE TO SLOW DOWN TO BELOW 5 MPH. THE JEEP JERKS ALL OF THE ROAD OUT OF CONTROL UNTIL I SLOW DOWN. THE DEALER HAS REPLACED SEVERAL PARTS ON THE SUSPENSION. THE DEALER IS KINGS JEEP 513-774-5333. I HAVE ALSO SEEN ON WEB AT THIS ADDRESS HTTP://WWW.YOUTUBE.COM/WATCH?V=VQVKG2LP4R4 . THIS PROBLEM MAY LEAD TO LOSS OF CONTROL AND OR A DEATH. JEEP NEEDS TO ADDRESS THIS AS IT APPEARS TO BE AN ISSUE WITH OTHER JEEPS TOO.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10191349May 21, 2007
SUSPENSION:FRONT, STEERING
I HAD THE FIRST EXPERIENCE WITH THE FRONT END SHIMMYING WHEN I HAD APPROXIMATELY 15,000 MILES ON THE JEEP. IT HAPPENED AFTER CROSSING A SEAM IN THE PAVEMENT ON THE HIGHWAY AT 70 MPH. IT HAPPENED SEVERAL TIMES SINCE THEN WHEN HITTING ANY SMALL BUMP IN THE ROAD. I TOOK THE JEEP TO THE DEALER, AND THEY REPLACED THE STEERING STABILIZER WITH A HEAVY DUTY MODEL BUT IT MADE NO DIFFERENCE. I STILL HAD THE PROBLEM. I COULD NOT LET MY WIFE OR CHILDREN DRIVE THIS VEHICLE BECAUSE IT COULD EASILY SEND YOU EITHER OFF THE ROAD OR INTO ONCOMING TRAFFIC WHEN THE SHIMMY OCCURS. YOU HAVE TO COME TO ALMOST A COMPLETE STOP BEFORE IT WILL STOP SHAKING AND DRIVE NORMAL AGAIN. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189690May 3, 2007
AIR BAGS:FRONTAL
I HIT A TREE HEAD ON AND THE AIR BAG DID NOT DEPLOY. THIS RESULTED IN INJURIES TO MY FACE AND CHEST. THE FORCE WAS SUFFICIENT ENOUGH THAT THE STEERING WHEEL WAS BENT AND THE STEERING COLUMN IS BEING REPLACED. THE VEHICLE IS CURRENTLY UNDER REPAIR AT JAKE TOMLINSON & CO, 13810 LINCOLN WAY, AUBURN, CA 530-885-0183. *JB
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10188463April 20, 2007
STEERING:LINKAGES
2005 JEEP WRANGLER WITH 9,600 MILES. EXPERIENCED "DEATH WOBBLE" AT 40 MPH. DEALER SAID IT NEEDED NEW AFTER MARKET STEERING DAMPNER..THIS DOES NOT SOLVE THE PROBLEM OF DEATH WOBBLE.. DEALER AVOIDS THIS PROBLEM AREA.. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188209April 18, 2007
SUSPENSION, STEERING
TL*THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE ENGAGES IN A "DEATH WOBBLE" (UNCONTROLLABLE SHAKING) CAUSED BY STEERING SUSPENSION FAILURE. THE DEALER REPLACED THE STEERING DIMPLER, BUT THE PROBLEM STILL EXISTS. THE CURRENT AND FAILURE MILEAGES WERE 9,617. THE VIN IS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10187722April 12, 2007
POWER TRAIN:AUTOMATIC TRANSMISSION
UNINTENDED ACCELERATION / ENGINE FLARE. CAN BE ANTICIPATED AND VEHICLE MOVEMENT PREVENTED IN 2 WHEEL DRIVE, HIGH RANGE BUT WILL OVERPOWER BRAKES WHEN IN 4 WHEEL DRIVE , LOW RANGE. OCCURRENCE NOT CONSISTENT OR REPEATABLE ON DEMAND BUT IS FREQUENT. CAN OCCUR WITH APPLICATION (OR RELEASE) OF POWER BRAKE, TURNING OF STEERING WHEEL (POWER STEERING) OR AIR CONDITION CYCLING. WHEN THIS HAPPENS IN TECHNICAL TRAIL MANEUVERS (OFF ROAD CONDITIONS IN TREACHEROUS TERRAIN) OR IN CLOSE PROXIMITY TO TREES, LARGE ROCKS, ABRUPT DROP-OFFS ALONG ROAD, THE RESULTS ARE POTENTIALLY DEADLY. NO CORRECTIVE ACTION CAN BE TAKEN BY ANY, NON FACTORY REPRESENTATIVE AS THIS IS A PROGRAMMING ISSUE WITH THE VEHICLE COMPUTER. THIS VEHICLE IS NOT UNIQUE. THE "DEALER" IS UNABLE TO REPRODUCE THE SYMPTOM. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10181916February 7, 2007
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
BLOWER CONTROLS/RESISTOR PACK SHORT OUT, FAIL AND CAUSE WIRING HARNESS TO MELT FOR THE HVAC BLOWER AND BLOWER CONTROLS. BLOWER WIRING HARNESS APPEARS TO PULL THE FULL CURRENT OF THE BLOWER MOTOR THROUGH THE WHOLE SWITCH CONTROLS WIRING HARNESS, THIS CAUSES AN OVERLOAD CONDITION AND OVERHEATS THE WIRING OF THE CONTROL SYSTEM, CAUSING SEVERE MELTING OF THE PLASTIC COMPONENTS AND POSES A SEVERE FIRE RISK. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10175346December 6, 2006
VISIBILITY
REAR PLASTIC WINDOW CRACKED IN COLD WEATHER. TOLD BY DEALER THAT THIS IS A COMMON PROBLEM AND PLASTIC WINDOWS CANNOT BE TOUCHED IN COLD WEATHER. NOTHING IN THE OWNER'S MANUAL STATES THIS POLICY. DEALER ADVISED NOT TO REMOVE SNOW/ICE, BRUSH WINDOW, TOUCH WINDOW, OR CONTACT WINDOW WITH WATER IN COLD WEATHER. DEALER EMPLOYEE STATED THAT THEY WILL NOT TOUCH A PLASTIC WINDOW UNLESS THEY WARM THE PLASTIC UP FIRST. JEEP WILL NOT REPLACE UNDER WARRANTY, STATING ENVIRONMENTAL FACTORS. POSSIBLE SAFETY HAZARD IN NOT BEING ABLE TO WASH VEHICLE IN COLD WEATHER OR REMOVE SNOW/ICE. THIS LEAVES NO VISIBILITY OUT OF REAR WINDOW. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10174358November 26, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
THERE WAS AN UNCONTROLLABLE SHAKING DURING BRAKING MAINLY AT HIGH SPEEDS OF >45 MPH AND SMALL SHAKING AT <45MPH. I KNEW IT WAS THE ROTORS BEING WARPED. THE SHAKING STARTED WHEN THERE WAS ~10000 MILES ON THE VEHICLE. I TOOK THE VEHICLE INTO THE SERVICE PLACE AT SUBURBAN CHRYSLER JEEP AND THEY CONFIRMED THE ISSUE WITH THE ROTORS BEING OUT OF ROUND. ALTHOUGH THE MILAGE OF MY VEHICLE WHEN IT WAS FIXED WAS ~18000 MILES THEY STILL MACHINED THE ROTORS FREE OF CHARGE. THIS SOLVED THE PROBLEM. I NOW HAVE 24000 MILES ON THE VEHICLE AND THE PROBLEM IS NON EXISTENT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10173158November 10, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
MY 2005 JEEP WRANGLER PURCHASED FROM MOOTHART JEEP WAS EXPERIENCING AN UNCONTROLLABLE SHAKING AT SPEEDS BETWEEN 30-40 MPH. I HAD TO PULL OFF THE FREEWAY TO GET IT CHECKED OUT. MECHANIC TOLD ME IT WAS A PROBLEM WITH THE ROTORS. WHEN I CALLED THE DEALER TO EXPLAIN THE PROBLEM, THEY DISMISSED THE ROTORS AS THE CAUSE AND BLAMED MY ALL-TERRAIN TIRES (WITHOUT EVEN LOOKING AT THE CAR) AND STATED THAT MY WARRANTY WOULD NOT COVER IT BECAUSE OF THESE NEW TIRES. CAR WAS TOWED TO THE DEALERSHIP ANYWAY AND THEY BLAMED STABILIZER. THEY CLAIMED TO HAVE REPLACED THE STABILIZER UNDER WARRANTY (OUT OF COURTESY). WHEN I PICKED UP THE CAR AND TRIED TO DRIVE IT HOME, THE CAR WAS SHAKING WORSE THAN WHEN IT CAME IN ON THE TOW TRUCK. I CALLED THE SERVICE MANAGER WHO TOLD ME THAT THE TIRES WERE TOO HEAVY FOR THE CAR. I INQUIRED ABOUT WHY A 4-WHEEL DRIVE OFF-VEHICLE CAR WOULD NOT BE ABLE TO HANDLE ALL-TERRAIN TIRES. HE HAD NO LOGICAL ANSWER FOR ME. I BROUGHT THE CAR TO MY MECHANIC (WHO SPECIALIZES IN TIRES) TO CHECK THE TIRES AND ANYTHING THAT COULD BE CAUSING THIS. THEY ULTIMATELY FIXED THE DEFECTIVE ROTOR, AND THE CARS RUNS FINE. HE TOLD ME THAT THE TIRES WERE FINE; IT WAS A PROBLEM WITH THE ROTORS. DURING THIS PROCESS, I CONTACTED DAIMLER CHRYSLER ABOUT THIS ISSUE AND THEY TOLD ME ALL SERVICE PROBLEMS ARE THE RESPONSIBILITY OF THE SERVICE MANAGER AT THAT PARTICULAR DEALERSHIP. I INFORMED THEM THAT I HAD ALREADY SPOKE TO HIM AND HE REFUSED TO ATTRIBUTE THE PROBLEM TO ANYTHING ELSE BUT THE TIRES. THEY GAVE ME INFORMATION REGARDING THE LEMON LAWS IN CALIFORNIA. THE CAR HAD ONLY 9,303 MILES WHEN THIS PROBLEM OCCURRED AND ONLY 1.5 YEARS OLD. THE VEHICLE CAME WITH A 7-YEAR WARRANTY, BUT THEY REFUSED TO LOOK AT THE ROTORS ON THE CAR. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10172402November 1, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
MY 2005 JEEP WRANGLER UNLIMITED BEGAN HAVING AN INTERMITTENT SQUEAK THIS SUMMER. AT THE END OF OCTOBER THE DEALER INFORMED ME THAT THE VEHICLE NEEDS THE BRAKE PADS AND ROTORS REPLACED AND THAT THIS ITEM WAS NOT COVERED UNDER WARRANTY. THE VEHICLE HAS ONLY 26,000 MILES AND I HAVE NEVER HAD TO REPLACE BRAKE PADS THIS EARLY IN OTHER VEHICLES I HAVE OWNED. I CALLED THE CHRYSLER CUSTOMER CARE LINE AND WAS TOLD THAT THEY COULD DO NOTHING ABOUT THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168749September 20, 2006
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
NOTICED A BURNING SMELL AND THOUGHT IT WAS ONE OF FOUR TRUCKS AHEAD OF ME. PULLED OFF ONTO MY EXIT AND CONTINUED TO NOTICE THE SMELL. SMOKE BEGAN POURING FROM THE DASH. I HAD SEEN THE SERVICE DEPARTMENT THE SAME MORNING AND INFORMED THEM MY BLOWER MOTOR HAD BEEN WORKING INTERMITTENTLY. THEY VERIFIED THE PROBLEM AND ORDERED A NEW MOTOR. UPON INSPECTION OF MY VEHICLE I NOTICE THAT THE AREA AROUND THE BLOWER MOTOR IS EXTREMELY HOT. BLOWER MOTOR HAS THE FOLLOWING: LABEL 1 VALEO:KJLHD 929520G REV A -- PASS 11-18-4 10:10:50 LABEL 2 BOSCH MADE IN MEXICO DPL 653 12V 9 000 025 075 19 904 929431H CW 49104 1. *NM
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10164624August 6, 2006
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
2005 RUBICON-2480 MILES. ENGINE INDICATOR LIGHT HAS COME ON FOR THE 8TH TIME. DEALER CHECKED WITH DIGITAL READER WHICH IDENTIFIES "SMALL EVAPORATIVE LEAK". FIRST TIME, TIGHTENED GAS CAP, BUT DEALER HAD TURNED OFF THE INDICATOR LIGHT WITH THE READER. THIRD OCCURRENCE DEALER SCHEDULED CHECK OF EXHAUST AND CLEAN AIR SYSTEM, ALL TESTED FINE. LAST 4 TIMES I DISCONNECTED BATTERY UNTIL LIGHT RESET. DEALER HAS CHANGED HANDS, AND JUST SCHEDULED FOR ANOTHER CHECK, MENTIONED REPLACING GAS CAP. THIS APPEARS TO BE A NUISANCE ISSUE RATHER THAN A SERIOUS DEFECT. I WISH THEY COULD FIX IT ONCE AND FOR ALL. I AM NOT SURE HOW THIS NEW DEALER WILL SUPPORT THE WARRANTY ISSUES. FORMERLY THEY WERE GREAT. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10163887July 29, 2006
STEERING, SUSPENSION
UNCONTROLLABLE HANDLING ( IN THE FRONT END) WHEN GOING AN EXCESS SPEED OF 45 MILES OR MORE AND HIT ANY KIND /SIZE BUMP IN ROAD. FOUND OUT IT WAS THE STABILIZER BAR. WHEN I FIRST TOOK MY CAR IN (MONTHS AGO) THEY TOLD ME ( CHRYSLER) IT WAS MY ROTORS. DIDN'T UNDERSTAND HOW MY ROTORS COULD DO THAT SINCE I WASN'T BRAKING AT THE TIME THE SHAKING WAS HAPPENING. I ENDED UP TAKING IT TO A MECHANIC AND THEY FIGURED OUT WHAT IT WAS. THE GUYS AT CHRYSLER HAVE A NICKNAME FOR IT; "SUDDEN DEATH". NOT ONCE DID I GET A RECALL LETTER ABOUT THIS PROBLEM. THEY MUST OF BEEN WORRIED ABOUT IT BECAUSE IT ONLY TOOK THEM ABOUT 2 HOURS TO FIX IT. THEY WENT AND BOUGHT AN AFTER MARKET STABILIZER BAR. I HAVE HAD OIL CHANGES FROM THE SAME PLACE THAT HAVE TAKEN LONGER. I HAD THE CAR FOR ABOUT A YEAR WHEN I FIRST NOTICED THE SHAKING BUT I HEARD ABOUT OTHER WRANGLERS HAVING THE SAME PROBLEM. SOMEONE NEEDS TO LET OTHER JEEP OWNERS ABOUT THIS PROBLEM . IT'S VERY DANGEROUS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10163310July 24, 2006
TIRES
DT*: THE CONTACT STATED THAT WHILE TRAVELING 67 MPH ON THE HIGHWAY A BUMPY VIBRATION WAS OBSERVED COMING FROM THE DRIVER SIDE TIRES. WHILE ATTEMPTING TO APPLY THE BRAKES, THE TIRE MALFUNCTIONED CAUSING THE VEHICLE TO SPIN OUT OF CONTROL AND CRASHING INTO A GUARD RAIL IN THE EMERGENCY LANE. SEVERE INJURIES WERE INCURRED TO THE DRIVER AND MINOR INJURIES TO THE PASSENGER. THERE WAS DAMAGE TO THE BODY OF THE VEHICLE. THE SIDEWALL OF DRIVER'S REAR TIRES WERE COMPLETELY DAMAGED. THE DAMAGED TIRE WERE REMOVED AND REPLACED WITH THE SPARE. A POLICE REPORT WAS FILED. THE OFFICER ADVISED THE VEHICLE WAS SAFE TO DRIVE. THE VEHICLE WAS TAKEN TO THE DEALERS WHO DETERMINED THAT THE CAUSE OF INCIDENT WAS DUE TO IMPROPER TIRE INFLATION. THE CONTACT EXPRESSED THAT THE TIRE FAILURE MAY BE DUE TO A MANUFACTURER DEFECT. THE HYDRAULIC VALVE FOR THE BRAKE SYSTEM WAS REPAIRED. THE MANUFACTURER DETERMINED THAT AN INSPECTOR WOULD BE SENT TO EXAMINE THE VEHICLE. HOWEVER, THE INSPECTOR REFUSED TO PROVIDED REPORTS OF THE EXAMINATION.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0

← Back to Jeep Wrangler