Hyundai Tucson Complaints (2022)

509 consumer complaints on file.

#11744787June 17, 2026
UNKNOWN OR OTHER
Fuel door actuator failed to unlock had to take the car into the dealership to replace a malfunctioning actuator. Left me stranded at a gas station unable to fuel the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743887June 13, 2026
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
On 3 occasions over my 18-month ownership of this certified pre-owned Hyundai 2022 Tucson, the vehicle surged suddenly forward WITH BRAKE APPLIED at creeping (parking) speeds of 3-4 mph. No warning lamps were observed. On the most recent (3rd) occasion, a crash over a sidewalk and into a storefront caused $10,000 damage. No pedestrians were harmed, no airbags deployed and neither passenger was harmed. The service department is "unable to duplicate" the surging behavior and declares the car mechanically "safe to drive."
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11743833June 12, 2026
POWER TRAIN, ENGINE, VEHICLE SPEED CONTROL
My 2022 Hyundai Tucson Experience, a sudden transmission failure at approximately 92,520 miles. The vehicle develop shifting issues and abnormal noises before losing propulsión. While driving. Hyundai diagnosed and internal Transmission failure and approved transmission replacement. I’m concerned about the sudden loss of proportion and the safety risk this creates. Hyundai proposed repair is to replace the transmission with a rebuild remanufacture transmission rather than a new transmission. I am concerned about the reliability of the repair following a complete transmission failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742609June 7, 2026
ENGINE, VEHICLE SPEED CONTROL
I am submitting this complaint regarding my 2022 Hyundai Tucson equipped with the 2.5L engine. The vehicle has experienced multiple incidents of severe engine misfiring while driving. During these events, the engine begins to shake violently, the entire vehicle vibrates, and engine power is significantly reduced. The vehicle becomes unable to accelerate normally, creating a serious safety hazard, especially when driving on highways or in traffic. The malfunction has occurred several times. Diagnostic trouble codes P0302 and P0303 have been recorded, indicating cylinder misfires. In some cases, turning the engine off and restarting it temporarily restores normal operation. On other occasions, adding fuel system cleaner appeared to temporarily improve the condition. However, the problem eventually returns. Because the condition is intermittent, the Hyundai dealership has been unable to reproduce the failure during inspection and therefore has not performed a repair under warranty. Despite multiple visits, the root cause remains unidentified. I am concerned that the sudden loss of power and severe engine vibration could result in an accident if the vehicle is unable to maintain speed or accelerate while traveling at highway speeds. This issue has significantly affected the safe operation of the vehicle. I request that this matter be investigated, as it appears to be a recurring safety-related defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742140June 4, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I was told there was a known issue with the electrical system with the front bumper harness and wiring harness need to be replaced due to water damage & Vehicle's horn keeps on going out and has to be replace
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741613June 2, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Hyundai Tucson. The contact stated that the fuel door had failed to open intermittently. The contact stated that the failure had progressively worsened, causing the contact to seek assistance to open the fuel door. The vehicle was taken to the dealer where it was being repaired. The manufacturer was not contacted. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739747May 23, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS
I have experienced the Emergency Braking System Warning and Sudden Application of my Brakes when traveling at highway speeds for what seems to be no apparent reason. I thought it had to be a glitch related to just my car; However, this has happened twice in the past month and it is an unnerving experience. As I just read about this same problem occurring in later models of my car I want to document that this same problem exists in my 2022 Hyundai Tucson.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739692May 23, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
About once a month on average my Tucson's emergency system braking comes on without an emergency. It seems to occur mostly when taking an exit on the highway, but a few times it has been completely random. All of these instances have had no other vehicles around or any roadway barriers present. When it activated, lighting comes up on my dash telling me the emergency braking is activating. Sometimes it brakes, other times it does not seem to. Mostly, it seems that if I keep pressing down on the gas pedal it just turns itself off. I've never had my car come to a complete start but I have had it hit the brakes hard a few times. I bought the vehicle brand new and have had it for 4.5 years, and it has always done this. I've had the dealership reinstall the software that controls the braking system, but it had no affect. I ask the dealer every time I go in if others are complaining about this and I am always told no. However, I saw a similar recall was just put into place for the newer years of the Tucson, and it makes me think they are told to tell people no one is complaining about this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739618May 22, 2026
POWER TRAIN, FUEL/PROPULSION SYSTEM, ENGINE
Multiple DTC codes on car at 25,120 miles,32,344, 34,324, 47,484, 51,853, 53,521, Consistent Fuel Injector failing under warranty, prior to 60,000 miles and not replaced correctly, as I have had to see dealership 4 times for ineffective fuel injector replacement and consistent problem. First DTC code reading @ 25,120 miles as stated on DTC coding Reports through Hyundai/Bluelink app. SEVERE Fuel leak into interior cabin and Fuel failure due to Powertrain/Injector Issues from 25,120 miles, and many more mileage as seen above. AUTO start does not work, Catalytic Converter is in need of replacement as codes read DTC code past readings and Engine Failure: P04567A, P030300, P022200,P012300,P210013,P042033,P042033 With FUEL INJECTOR/Powertrain Error. Caused car to engine fail in middle of driving!! *SAFETY CONCERN. I Have started multiple cases with Hyundai Motor America, and they had done nothing to report the problem or keep car for further testing and safety priority. Car is brand new, has about 66,800 miles on it now, had to replace all FUEL INJECTORS, FUEL RAIL, and now needing to replace Catalytic Converter due to Hyundai not covering issue that was consistent with Fuel Injector and initial GAS leak into Cabin. I had to visit the doctor many times due to GAS FUMES. 2025-2026-DTC codes stated under individual mechanic, and within my Hyundai Blue Link app as reading multiple DTC codes that Hyundai Refused to cover or fix initially. (Wrights Car Care, Atlanta, GA) stated that car is not safe to drive and is FIRE HAZARD (Technical Bulletin Alert) for Catalytic Converter is now pending and previously read as powertrain issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738834May 19, 2026
UNKNOWN OR OTHER, SERVICE BRAKES
Unintended acceleration, brakes unable to stop vehicle. Almost hit a car stopped at red light. I was able steer right avoiding hitting the stopped car and quickly put the car in neutral and then applied the brakes again. I was able to drive home another 10 miles. I had the car towed on 5/18/2026 to the car dealership for inspection. This put the car stopped and me and my wife at risk of injury. Car dealership has inspected the car and can not duplicate the problem. No warning lights before the event.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738744May 19, 2026
TRAILER HITCHES
The contact owns a 2022 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 25V893000(TRAILER HITCHES); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer and local dealer was not contact made aware of the issue. The contact had not experienced the failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737252May 12, 2026
ENGINE
The rocker arm of the engine has failed, causing a repair for a full engine replacement. The car has always undergone maintenance timely, and upon inspection by the dealership technician, the report state the vehicle was up to adequate level. There were no symptoms before the issue occurred, only the sudden catastrophic engine failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736567May 8, 2026
UNKNOWN OR OTHER
this recall still hasn’t been resolved. why hasn’t the manufacturer found a fix for this problem I have owned the vehicle for 4 years they should have known about this and fixed it by now. NHTSA recall number: 25V-893 Hyundai recall number: 290
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736420May 7, 2026
POWER TRAIN, UNKNOWN OR OTHER, ELECTRICAL SYSTEM
The issue involves the vehicle’s drivetrain and hybrid/electronic control system, where the car suddenly jerked forward in stop-and-go traffic on the freeway as if it had been struck from behind. Immediately following this event, the vehicle would not accelerate beyond approximately 40 mph, indicating a loss of normal power. This created a significant safety risk, as the sudden jerking could have led to a rear-end collision, and the inability to accelerate properly made it difficult to keep up with traffic on the freeway. I was barely able to safely pull off the freeway while surrounding traffic continued at higher speeds, increasing the risk to myself and other drivers. The problem appeared to resolve after turning the vehicle off and then back on; however, this raises concern about intermittent failure. The vehicle was taken to a dealership for inspection, but they were unable to reproduce or identify the issue. The vehicle remains available for inspection upon request. The vehicle has been inspected by a dealer but not by the manufacturer, police, or insurance representatives. Prior to the failure, there were no warning lights, messages, or noticeable symptoms indicating an issue. Based on similar reported experiences, this event may be consistent with a “limp mode” condition or a malfunction in the transition between the electric motor and gasoline engine, potentially involving the transmission or hybrid control system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735939May 5, 2026
ENGINE
Check engine light appeared, Car began shaking and struggling to accelerate. Independent mechanic and OReileys test stated cylinder 3 misfirw. Dealership stated GDI fuel injectors were leaking and is a known issue in several 2022 Hyundai Tuscon and needed to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734332April 28, 2026
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2022 Hyundai Tucson. The contact stated that while maneuvering into a handicap parking space, the vehicle suddenly accelerated on its own while the brake pedal was depressed. The vehicle climbed over a concrete parking bollard and struck a handicap sign, resulting in unintended acceleration. The vehicle was damaged in the undercarriage. No air bags were deployed. No injuries were reported. Property damage was a handicap sign. The vehicle was occupied by 2; the driver and passenger. A police report was filed. The vehicle was taken to the dealer, but has not been diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 26,100.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11733595April 24, 2026
UNKNOWN OR OTHER
At a slow speed the car lurched, paused, in traffic. The engine light is on. It could be dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732532April 20, 2026
ENGINE, FUEL/PROPULSION SYSTEM
1st Incident: Merging on to the freeway car started to stall but was able to safely make it off the freeway at next exit. Less than 2 miles was unable to accelerate to properly merge on freeway. A slow merge & slow driving on to a freeway is extremely dangerous. 2nd Incident: 6 months later, Nov. 2023. Driving about 65-70 MPH on the freeway with my son, the car started to stall again. I was able to safely move from the 2nd lane, to the shoulder. Waited over 2 hours in the dark for AAA to safely move us. 1st time documented issues with Hyundai dealership. Fuel injector was main issue and was replaced. No check eng light. 3rd Incident: May 2024 was driving about 75MPH in the fast lane when the car stalled. I was unable to move fully out of the lane as the car just died. I was half in the shoulder and the fast lane. I was crying with fear while I had to wait for CHP to move me. Multiple times feared other cars would hit me at 80MPH+ while I waited 30mins+ for CHP to stop traffic and move me to the shoulder. Took the car to the dealership for the second time to be "fixed" for the same issue as Nov. 2023. Fuel injector, and catalytic converter were "replaced". This now being the second time for the fuel injector issue. No check eng light. 4th Incident: April 2026 driving on a school night home from dinner with my son at about 9:45pm. It was raining and was traveling at about 55MPH on the highway. Car started to stall/ shut down again. Was able to go about15MPH to a safe spot and waited for assistance late at night. This happened on a highway where people tend to drive recklessly and try to pass other vehicles which causes a lot of head on collisions, [XXX] . Vehicle was towed to Hyundai dealership for the 3rd time & 3rd time documented for the fuel injector and 2nd for the catalytic converter. The vehicle's main purpose is to safely transport and I've had nothing but nightmares and put in extremely dangerous situations with my son. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730495April 10, 2026
FUEL/PROPULSION SYSTEM
I PURCHASED THIS 2022 TUCSON LIMITED HYUNDAI NEW. IT HAS 25,000 MILES ON IT. THE CAR CHECK ENGINE LIGHT CAME ON AND A POWER REDUCTION BEGAN ALONG WITH SHAKING OF THE CAR. I WAS ABLE TO CLEAR THE INTERSECTION SAFELY. I WAS ABLE TO TURN INTO A SAFE SPOT AND SHUT DOWN THE CAR. IT WAS TOWED TO THE DEALER WHO THEN INFORMED ME THAT IT WAS AN INJECTOR KNOW ISSUE FOR THIS YEAR AND WOULD BE COVERED UNDER THE 5 YEAR WARRANTY. HOWEVER, AS THIS IS A ENGINE/POWERTRAIN PROBLEM, IT SHOULD BE COVERED ON THE 100,000/TEN YEAR WARRANTY. A TSB (23-FL-002H-1) ALERT HAD ALREADY BEEN ISSUED, BUT NOT A RECALL. MANY OWNERS HAVE REPORTED HAVING THIS PROBLEM REPEATEDLY, AS A SAFETY ISSUE AND A KNOWN MFG DEFECT. WHEN IS THE GOVERNMENT GOING TO STEP UP AND DEMAND A REAL FIX BE DONE BEFORE SOMEONE IS KILLED? OWNER ARE CURRENT LEFT FIGHTING WITH THE DEALERS OVER THE WARRANTY LIMITS OR TAKING LEGAL ACTION. IF YOU GOOGLE THIS PROBLEM, YOU CAN FIND OUT THE NATIONAL LEVEL OF THIS PROBLEM, FROM ACCIDENTS WHICH CAUSED FIRES OR ACCIDENTS FROM POWER LOSS. MY CAR IS STILL AT THE DEALER WAITING ON PARTS. ITS TIME TO FORCE A RECALL! I WILL BE DEMANDING THAT IT IS COVERED FOR THE 10 YEAR WARRANTY PERIOD AND CONSIDERING TAKING ACTION UNDER THE LEMON LAWS. IF THE GOVERNMENT FAILS TO ACT ON THIS SOON, THAN THEY ARE JUST AS LIBEL AS THE MANUFACTURER. YOUR IMMEDIATE ATTENTION TO THIS ISSUES IS REQUESTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729463April 6, 2026
SERVICE BRAKES, FUEL/PROPULSION SYSTEM
When braking my 2022 Hyundai Tucson to come to a stop, the vehicle continues to accelerate. I have to release the brake and re-apply the brake to fix the acceleration problem. I check the internet on this problem. They internet says it is a software problem. The vehicle shows no code and the dealer says they don't have a problem. The dealer has not check for the problem since there is no code. No warning lamps or messages show up on dash. This happened 4 times in the last few months. Latest date was 4-4-2026
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Tucson