Hyundai Tucson Service Bulletins

564 manufacturer communications on file.

September 15, 2017•Document ID: 10118674
Service Bulletin/Repair Instructions
SUSPENSION
Mfr Comm. #:
5NP-K9M7J-10
Date Added:
October 12, 2017
Manufacturer:
HYUNDAI
Summary
Due to parts communization, the rear trailing arms on (TL) Tucsons produced after July 26, 2016 have been revised. This change also affects service parts. Therefore, anytime a rear trailing arm is replaced on (TL) Tucsons produced on or before July 26, 2016 it is necessary to replace both sides. Refer to the repair procedure located in the applicable Service Shop Manual: Suspension System - Rear Suspension System- Trailing Arm - Repair Procedures.
Associated Products (1)
2016 Hyundai Tucson
Associated Documents
- Download MC-10118674-0001.pdf↗
September 6, 2017•Document ID: 10118676
Service Bulletin/Repair Instructions
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT:ELECTRICAL
Mfr Comm. #:
5NP-Y8D3S-10
Date Added:
October 12, 2017
Manufacturer:
HYUNDAI
Summary
On certain 2016 - 2017 MY Tucson (TL), intermittently there is no sound from the audio system. This is caused by the instrument cluster not sending the proper CAN signals to the amplifier. This bulletin describes the procedure to reprogram the instrument cluster to correct the signal transmission timing.
Associated Products (2)
2017 Hyundai Tucson 2016 Hyundai Tucson
Associated Documents
- Download MC-10118676-0001.pdf↗
August 9, 2017•Document ID: 10117374
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Mfr Comm. #:
5NP-E2C3Q-09
Date Added:
September 14, 2017
Manufacturer:
HYUNDAI
Summary
This bulletin provides information on how to return a Hyundai HEV/PHEV/EV/Fuel Cell Lithium Battery for proper disposal and safe environmental recycling using Hyundai?s authorized vendor Kinsbursky Brothers Inc. (KBI).
Associated Products (12)
2018 Hyundai Ioniq 2017 Hyundai Ioniq 2017 Hyundai Sonata 2017 Hyundai Tucson 2016 Hyundai Sonata 2016 Hyundai Tucson 2015 Hyundai Sonata 2015 Hyundai Tucson 2014 Hyundai Sonata 2013 Hyundai Sonata 2012 Hyundai Sonata 2011 Hyundai Sonata
Associated Documents
- Download MC-10117374-0001.pdf↗
August 3, 2017•Document ID: 10117373
Service Bulletin/Repair Instructions
EQUIPMENT:ELECTRICAL
Mfr Comm. #:
5NP-V3F8T-09
Date Added:
September 14, 2017
Manufacturer:
HYUNDAI
Summary
If you are servicing a vehicle with the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. ? Diagnostic trouble codes: ? P0705 - Range switch sensor circuit ? P0706 - Range switch range/performance ? P0707 - Range switch - open circuit ? P0708 - Range switch - short circuit or multiple inputs ? Symptoms: ? Malfunction Indicator Light (MIL) illuminated ? 4th gear fail-safe ? No gear indication in cluster ? Intermittent no engine crank/no start in ?P? or ?N? with or without MIL or DTC.
Associated Products (56)
2018 Hyundai Elantra 2018 Hyundai Elantra GT 2018 Hyundai Santa Fe Sport 2018 Hyundai Sonata 2017 Hyundai Accent 2017 Hyundai Azera 2017 Hyundai Elantra 2017 Hyundai Santa Fe Sport 2017 Hyundai Sonata 2017 Hyundai Tucson 2016 Hyundai Accent 2016 Hyundai Azera 2016 Hyundai Elantra 2016 Hyundai Santa Fe 2016 Hyundai Santa Fe Sport 2016 Hyundai Sonata 2016 Hyundai Tucson 2015 Hyundai Accent 2015 Hyundai Azera 2015 Hyundai Elantra+ 36 more
Associated Documents
- Download MC-10117373-0001.pdf↗
March 16, 2017•Document ID: 10110927
Service Bulletin/Repair Instructions
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES; ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Mfr Comm. #:
5NP-B6N5A-04
Date Added:
August 10, 2017
Manufacturer:
HYUNDAI
Summary
This bulletin provides the procedure to update both the ECM (Engine Control Module) and the TCM (Transmission Control Module) on some 2016 and 2017 Hyundai Tucsons equipped with a 7-speed EcoShift® Dual Clutch Transmission (DCT). The update will address: ? A slight hesitation at low speeds that can be experienced in certain driving conditions. This update improves the low speed engine and transmission response. ? Malfunction indicator light illuminated with DTC P0128 - Coolant Thermostat - Coolant Temp Below Thermostat Regulating Temperature.
Associated Products (2)
2017 Hyundai Tucson 2016 Hyundai Tucson
Associated Documents
- Download MC-10110927-0001.pdf↗
February 13, 2017•Document ID: 10110913
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM; ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
Mfr Comm. #:
5NP-M4L8P-03
Date Added:
August 10, 2017
Manufacturer:
HYUNDAI
Summary
This bulletin describes the service procedure to inspect the lot number of the electronic stability control (ESC) module of certain Santa Fe (NC) and Tucson (TL) vehicles. Parts from the affected LOT number may have damaged bolts which hold the ECU to the solenoid block. Vehicles with affected LOT number ESC modules must be inspected for damaged bolts. If the bolts are intact, they must be replaced. If the bolts are damaged, the HECU assembly must be replaced.
Associated Products (2)
2017 Hyundai Santa Fe 2017 Hyundai Tucson
Associated Documents
- Download MC-10110913-0001.pdf↗
February 3, 2017•Document ID: 10110915
Service Bulletin/Repair Instructions
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Mfr Comm. #:
5NP-H6A7M-03
Date Added:
August 10, 2017
Manufacturer:
HYUNDAI
Summary
In some areas, a vehicle's underbody may exhibit corrosion due to road salt usage. As a precautionary measure, cavity wax coating is applied to the internal surfaces of underbody components, and an undercoating spray is applied to the bottom exterior surfaces of specified underbody components. This bulletin describes the procedure to perform this preventative service on certain Tucson (JM) vehicles.
Associated Products (5)
2009 Hyundai Tucson 2008 Hyundai Tucson 2007 Hyundai Tucson 2006 Hyundai Tucson 2005 Hyundai Tucson
Associated Documents
- Download MC-10110915-0001.pdf↗
January 25, 2017•Document ID: 10117918
Service Bulletin/Repair Instructions
ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
Mfr Comm. #:
5NPL5W5G02
Date Added:
September 22, 2017
Manufacturer:
HYUNDAI
Summary
This bulletin describes the service procedure to inspect the lot number of the electronic stability control (ESC) module of certain Santa Fe (NC) and Tucson (TL) vehicles. Parts from the affected LOT number may have damaged bolts which hold the ECU to the solenoid block. Vehicles with affected LOT number ESC modules must be inspected for damaged bolts. If the bolts are intact, they must be replaced. If the bolts are damaged, the HECU assembly must be replaced.
Associated Products (2)
2017 Hyundai Santa Fe 2017 Hyundai Tucson
Associated Documents
- Download MC-10117918-0001.pdf↗
December 22, 2016•Document ID: 10089504
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:WIRING; TRAILER HITCHES
Mfr Comm. #:
5NP-D8L3J-01
Date Added:
January 25, 2017
Manufacturer:
HYUNDAI
Summary
THE 2017 SANTA FE (NC) AND 2016 2017 TUCSON (TL) ARE AVAILABLE WITH A GENUINE HYUNDAI TRAILER HITCH AND WIRING HARNESS. ON CERTAIN UNITS, WHEN THE TRAILERS LIGHTING WIRING HARNESS IS CONNECTED TO THE VEHICLE, THE TOW HITCH MODULE MAY MALFUNCTION RESULTING IN CONTINUOUS ILLUMINATION OF THE TRAILERS BRAKE AND/OR TURN SIGNAL BULB(S). THIS CONDITION AFFECTS ONLY THE TRAILERS LIGHTING; NOT THE VEHICLES. IF A VEHICLE EQUIPPED WITH THE GENUINE HYUNDAI ACCESSORY TOW PACKAGE IS DRIVEN WITH A TRAILER, IT IS POSSIBLE THAT THE TRAILER LIGHTS WOULD BE UNABLE TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARDS. A FAILURE TO NOTIFY OTHER VEHICLES OF THE DRIVERS INTENT COULD POTENTIALLY INCREASE THE RISK OF A CRASH.
Associated Products (4)
2017 Hyundai Santa Fe 2017 Hyundai Tucson 2016 Hyundai Santa Fe 2016 Hyundai Tucson
Associated Documents
- Download MC-10089504-0001.pdf↗
December 1, 2016•Document ID: 10089516
Service Bulletin/Repair Instructions
EQUIPMENT:APPLIANCE:AIR CONDITIONER
Mfr Comm. #:
5NP-J3J3D-01
Date Added:
January 25, 2017
Manufacturer:
HYUNDAI
Summary
HYUNDAI MOTOR AMERICA IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE HVAC INTAKE ACTUATOR ON CERTAIN 2015 MODEL YEAR TUCSON VEHICLES. SERVICE CAMPAIGN T1I PROVIDES A PROCEDURE TO REPLACE THE INTAKE ACTUATOR.
Associated Products (1)
2015 Hyundai Tucson
Associated Documents
- Download MC-10089516-0001.pdf↗
December 1, 2016•Document ID: 10089408
Service Bulletin/Repair Instructions
ELECTRONIC STABILITY CONTROL (ESC)
Mfr Comm. #:
5NP-U3K4E-01
Date Added:
January 24, 2017
Manufacturer:
HYUNDAI
Summary
"THIS BULLETIN DESCRIBES THE PRELIMINARY PROCEDURE TO INSPECT THE LOT NUMBER OF THE ELECTRONIC STABILITY CONTROL (ESC) MODULE OF SOME SANTA FE (NC) AND TUCSON (TL) VEHICLES. PARTS FROM THE AFFECTED LOT NUMBER MAY HAVE DAMAGED BOLTS WHICH HOLD THE ECU TO THE SOLENOID BLOCK. VEHICLES WITH AFFECTED LOT NUMBER ESC MODULES SHOULD BE HELD (NOT RETAILED) UNTIL A FINAL SERVICE PROCEDURE IS PROVIDED ON A FUTURE TSB."
Associated Products (2)
2017 Hyundai Santa Fe 2017 Hyundai Tucson
Associated Documents
- Download MC-10089408-0001.pdf↗
December 1, 2016•Document ID: 10089405
Service Bulletin/Repair Instructions
EQUIPMENT:APPLIANCE:AIR CONDITIONER
Mfr Comm. #:
5NP-S6P6C-01
Date Added:
January 24, 2017
Manufacturer:
HYUNDAI
Summary
ON SOME TUCSON (LM) VEHICLES, THE INTAKE ACTUATOR OF THE HVAC SYSTEM MAY EXHIBIT AN ABNORMAL NOISE DURING OPERATION.
Associated Products (1)
2015 Hyundai Tucson
Associated Documents
- Download MC-10089405-0001.pdf↗
November 14, 2016•Document ID: 10119107
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE
Mfr Comm. #:
5NP-X7Y4J-12
Date Added:
October 15, 2017
Manufacturer:
HYUNDAI
Summary
This bulletin provides the procedure to update both the ECM (Engine Control Module) and the TCM (Transmission Control Module) on some 2016 and 2017 Hyundai Tucsons equipped with a 7-speed EcoShift® Dual Clutch Transmission (DCT). The update will address: ? A slight hesitation at low speeds that can be experienced in certain driving conditions. This update improves the low speed engine and transmission response. ? Malfunction indicator light illuminated with DTC P0128 - Coolant Thermostat - Coolant Temp Below Thermostat Regulating Temperature.
Associated Products (2)
2017 Hyundai Tucson 2016 Hyundai Tucson
Associated Documents
- Download MC-10119107-0001.pdf↗
November 14, 2016•Document ID: 10119093
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE
Mfr Comm. #:
5NP-R6T4X-12
Date Added:
October 15, 2017
Manufacturer:
HYUNDAI
Summary
Hyundai Motor America conducted Recall 149 to update the DCT Control Logic on certain 2016 Model Year Tucson 1.6L vehicles. Recall 149 (16-01-038-01) provides an updated procedure to update the TCU and ECM software. Hyundai Motor America is conducting a revision to Recall to update both the TCU and ECM.
Associated Products (1)
2016 Hyundai Tucson
Associated Documents
- Download MC-10119093-0001.pdf↗
November 14, 2016•Document ID: 10119090
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION
Mfr Comm. #:
5NP-P9A3V-12
Date Added:
October 15, 2017
Manufacturer:
HYUNDAI
Summary
Eco, Sport, and Limited trim 2016 Hyundai Tucsons are equipped with a 7-speed EcoShift® Dual Clutch Transmission (DCT). In specific operating conditions, the transmission clutch application logic can result in a delayed engagement when accelerating from a stop. If the accelerator pedal is steadily depressed for approximately 1.5 to 2 seconds, the vehicle will begin to accelerate and normal driving is resumed. However, if the accelerator pedal is repeatedly cycled, the vehicle will not accelerate. The inability to move the vehicle in traffic may increase the risk of a crash. Also accompanying with the software are updates for the following: ? A slight hesitation at low speeds that can be experienced in certain driving conditions. This update improves the low speed engine and transmission response. ? Malfunction indicator light illuminated with DTC P0128 - Coolant Thermostat - Coolant Temp Below Thermostat Regulating Temperature.
Associated Products (1)
2016 Hyundai Tucson
Associated Documents
- Download MC-10119090-0001.pdf↗
November 14, 2016•Document ID: 10119089
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE
Mfr Comm. #:
5NP-P8N9N-12
Date Added:
October 15, 2017
Manufacturer:
HYUNDAI
Summary
Hyundai Motor America is conducting a Service Campaign to update both the ECM (Engine Control Module) and the TCM (Transmission Control Module) on certain 2016-17MY Model Year Tucson equipped with DCT. Service Campaign T1B provides a procedure to update the ECM and TCM.
Associated Products (2)
2017 Hyundai Tucson 2016 Hyundai Tucson
Associated Documents
- Download MC-10119089-0001.pdf↗
November 14, 2016•Document ID: 10119088
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN
Mfr Comm. #:
5NP-P5H8L-12
Date Added:
October 15, 2017
Manufacturer:
HYUNDAI
Summary
This bulletin provides the procedure to update the TCM (Transmission Control Module) on some 2017 Hyundai Tucsons equipped with a 7-speed EcoShift® Dual Clutch Transmission (DCT). The update will address: ? A slight hesitation at low speeds that can be experienced in certain driving conditions. This update improves the low speed engine and transmission response.
Associated Products (1)
2017 Hyundai Tucson
Associated Documents
- Download MC-10119088-0001.pdf↗
November 14, 2016•Document ID: 10119084
Service Bulletin/Repair Instructions
ELECTRICAL SYSTEM:SOFTWARE
Mfr Comm. #:
5NP-K7T6F-12
Date Added:
October 15, 2017
Manufacturer:
HYUNDAI
Summary
Hyundai Motor America is conducting a Service Campaign to update the TCM (Transmission Control Module) on certain 2017 Model Year Tucson equipped with DCT. Service Campaign T1C provides a procedure to update the TCM.
Associated Products (1)
2017 Hyundai Tucson
Associated Documents
- Download MC-10119084-0001.pdf↗
November 1, 2016•Document ID: 10119075
Service Bulletin/Repair Instructions
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Mfr Comm. #:
5NP-H2S7R-12
Date Added:
October 15, 2017
Manufacturer:
HYUNDAI
Summary
In some areas, a vehicle?s underbody may exhibit corrosion due to road salt usage. As a precautionary measure, cavity wax coating is applied to the internal surfaces of underbody components, and an undercoating spray is applied to the bottom exterior surfaces of specified underbody components. This bulletin describes the procedure to perform this preventative service on certain Tucson (LM) vehicles.
Associated Products (3)
2012 Hyundai Tucson 2011 Hyundai Tucson 2010 Hyundai Tucson
Associated Documents
- Download MC-10119075-0001.pdf↗
October 12, 2016•Document ID: 10089603
Service Bulletin/Repair Instructions
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH; ENGINE
Mfr Comm. #:
5NP-U4R7N-11
Date Added:
January 26, 2017
Manufacturer:
HYUNDAI
Summary
"SOME TUCSON (LM) AND SANTA FE SPORT (AN) MAY EXPERIENCE A ROUGH IDLE IN DRIVE AFTER DECELERATING TO A STOP WHEN NEUTRAL CONTROL IS ENABLED. THIS BULLETIN PROVIDES A DIAGNOSIS AND REPAIR PROCEDURE FOR THIS CONDITION."
Associated Products (7)
2015 Hyundai Tucson 2014 Hyundai Tucson 2013 Hyundai Santa Fe 2013 Hyundai Tucson 2012 Hyundai Tucson 2011 Hyundai Tucson 2010 Hyundai Tucson
Associated Documents
- Download MC-10089603-0001.pdf↗

← Back to Hyundai Tucson