Hyundai Sonata Recalls

73 recalls on file.

• Recall04V178000April 9, 2004
  FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

  SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.

  Remedy

  DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

• Recall03V097000March 17, 2003
  TIRES:TEMPORARY/EMERGENCY SPARE TIRE

  ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A TRACTION CONTROL SYSTEM (TCS), IF THE T125/70D-15 COMPACT SPARE TIRE IS INSTALLED ON A FRONT WHEEL POSITION, THE TCS MAY INADVERTENTLY ACTIVATE BEGINNING AT SPEEDS OF 20 MPH.

  Remedy

  DEALERS WILL REPLACE THE SPARE TIRE WITH A NEW LARGER DIAMETER T125/80R-15 COMPACT SPARE TIRE AND A NEW TIRE PRESSURE LABEL WILL BE INSTALLED ON THE DRIVER'S DOOR TO PROVIDE INFORMATION APPLICABLE TO THE T125/80R-15 COMPACT SPARE TIRE. VEHICLES PRODUCED FROM NOVEMBER 15, 2002 THROUGH DECEMBER 16 2002, ALREADY CONTAIN T125/80R-15 COMPACT SPARE TIRES, WILL ONLY REQUIRE NEW TIRE PRESSURE LABELS. OWNER NOTIFICATION BEGAN JUNE 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

• Recall02V145000May 24, 2002
  AIR BAGS:SIDE/WINDOW

  ON CERTAIN PASSENGER VEHICLES, THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) SIDE IMPACT AIR BAG SATELLITE SENSORS MAY BE TOO SENSITIVE TO SOME LATERAL ACCELERATIONS THAT ARE NOT CAUSED BY SIDE IMPACTS TO THE VEHICLE, SUCH AS FORCEFULLY SLAMMING A DOOR CLOSED.

  Remedy

  DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG SATELLITE SENSORS. OWNER NOTIFICATION BEGAN JULY 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

• Recall02V105000April 9, 2002
  AIR BAGS:SIDE/WINDOW

  ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE SIDE IMPACT AIR BAGS AND COULD PREVENT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR.

  Remedy

  DEALERS WILL MORE SECURELY FASTEN THE SIDE IMPACT AIR BAG WIRING HARNESSES AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION BEGAN MAY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

• Recall01V347000November 6, 2001
  AIR BAGS

  VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT COULD ILLUMINATE DUE TO MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR THAT MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE DRIVER AND/OR PASSENGER SEAT-MOUNTED SIDE IMPACT AIR BAG(S).

  Remedy

  DEALERS WILL MORE SECURELY FASTEN THE FRONT SEAT SIDE IMPACT AIR BAG WIRING HARNESS AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION WILL OCCUR IN SIX MAILINGS ON MAY 27, JUNE 3, JUNE 10, JUNE 17, JUNE 24, AND JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

• Recall00V314001October 2, 2000
  FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

  VEHICLE DESCRIPTION: ACCENT GT MODEL VEHICLES EQUIPPED WITH DOHC ENGINES MANUFACTURED FROM DECEMBER 19, 1996 THROUGH JUNE 30, 1997; 1998 ACCENT MODEL VEHICLES MANUFACTURED FROM MAY 6, 1997 THROUGH JUNE 25, 1998; 1997 SONATA VEHICLES MANUFACTURED FROM AUGUST 1, 1996 THROUGH JULY 9, 1997 AND 1998 SONATA VEHICLES PRODUCED FROM JULY 9, 1997 THROUGH APRIL 24, 1998. THE EVAPORATIVE EMISSION CONTROL SYSTEMS MAY APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. MINOR FUEL TANK DISTORTION COULD RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER COULD NOTICE A GASOLINE ODOR.

  Remedy

  DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF IT IS CRACKED, A NEW FUEL TANK WILL BE INSTALLED. A NEW FUEL FILLER CAP THAT DECREASES THE AMOUNT OF VACUUM INSIDE THE FUEL TANK WILL ALSO BE INSTALLED. NOTE: THE 1997-1998 SONATA FUEL TANKS HAVE ALSO EXPERIENCED CRACKING. HOWEVER, AT THIS TIME, THE CAUSE FOR THE CRACKING HAS NOT BEEN IDENTIFIED. THIS PORTION OF THE CAMPAIGN WILL BEGIN AFTER HYUNDAI HAS DETERMINED THE CAUSE AND CORRECTIVE PROCEDURE.

• Recall00V259001September 11, 2000
  ELECTRICAL SYSTEM:WIRING

  VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS.

  Remedy

  DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.

• Recall97V026000February 26, 1997
  VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

  THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.

  Remedy

  DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.

• Recall95V163000August 23, 1995
  SUSPENSION:REAR:SHOCK ABSORBER

  ONE OR BOTH OF THE REAR SUSPENSION LOWER SPRING SEATS ARE NOT SECURELY ATTACHED TO THE SHOCK ABSORBER AND CAN SLIDE LOWER ONTO THE SHOCK ABSORBER THAN INTENDED. THE REAR SPRING WOULD NO LONGER FUNCTION TO SUPPORT THE VEHICLE BODY AT ITS NORMAL HEIGHT.

  Remedy

  DEALERS WILL INSPECT THE VEHICLE TO DETERMINE WHETHER THE REAR SHOCK ABSORBERS ARE FROM THE SUSPECT PRODUCTION. IF THE SHOCK ABSORBERS ARE FROM THE SUSPECT PRODUCTION, THE SHOCK ABSORBER/SPRING SEAT ASSEMBLIES WILL BE REPLACED.

• Recall94V166000September 1, 1994
  EQUIPMENT:OTHER:LABELS

  THE TIRE INFLATION PRESSURE LABEL AFFIXED TO THE LEFT REAR DOOR STATES THAT THE VEHICLE CAPACITY IS "1,100 POUNDS". THIS INFORMATION IS INCORRECT. THE CORRECT VEHICLE CAPACITY WEIGHT IS 860 POUNDS. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."

  Remedy

  HYUNDAI WILL PROVIDE OWNERS WITH A NEW LABEL SHOWING THE CORRECT VEHICLE CAPACITY WEIGHT WITH INSTRUCTIONS FOR APPLICATION.

• Recall93V196000November 29, 1993
  SEAT BELTS

  THE MOTORIZED SHOULDER BELT CAN TRAVEL SLOWLY OR CHATTER IN THE TRACK AND MAY EVENTUALLY STOP TRACKING AND BECOME INOPERATIVE.

  Remedy

  DEALERS WILL LUBRICATE THE TRACK ASSEMBLY AND, IF ANY SYSTEMS ARE FOUND INOPERATIVE, THE SYSTEM WILL BE REPAIRED OR REPLACED, AS REQUIRED.

• Recall90V037000February 21, 1990
  ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

  THE SPRING CLAMP TANGS ON THE COOLANT BYPASS HOSE MAY CONTACT AND POSSIBLY DAMAGE THE ENGINE FUEL SUPPLY HOSE.

  Remedy

  ROTATE SPRING CLAMP TO PREVENT CONTACT WITH FUEL HOSE; REPLACE DAMAGED HOSES.

• Recall90V038000February 21, 1990
  LATCHES/LOCKS/LINKAGES:HOOD:LATCH

  INSUFFICIENT CLEARANCE COULD CAUSE THE SAFETY CATCH ON THE SECONDARY HOOD LATCH STRIKER TO BIND.

  Remedy

  REPLACE HOOD LATCH STRIKER ASSEMBLY.