Hyundai Santa Fe Sport Complaints

1,199 consumer complaints on file.

#11728573April 1, 2026
STRUCTURE:BODY, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The passenger-side doors do not latch properly and may open after closing. This creates a safety risk while driving. The issue occurs continually and has worsened over time. Vehicle has approximately 106,265 miles. this causes the auto door locks no to work.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728648April 1, 2026
ELECTRICAL SYSTEM, ENGINE, SERVICE BRAKES
I was told by a mechanic that something electrical is wrong with the vehicle it causes the engine to misfire. Different issue than before.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728658April 1, 2026
ENGINE
The contact owns a 2018 Hyundai Santa Fe Sport. The contact stated that while driving 30 MPH and attempting to accelerate, the vehicle hesitated, with the check engine warning light illuminated. The vehicle was driven back to the residence. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 141,654.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728667April 1, 2026
ENGINE
I own a 2018 Honda Santa Fe it is using oil so fast. I know that there is other people complaining about the oil consumption so my engine just blew up because I had it changed on March 13 brand new oil change and on Monday night the engine blew up.. The people who changed my oil said that there have been a complaint that they have been using so much oil and I have talked to Hyundai about this and they refuse to do anything Now I have a Hyundai Santa Fe that is no good to me because I personally can’t afford a new engine/motor
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11728684April 1, 2026
ENGINE, SERVICE BRAKES
After having the ABS recall fixed a while back all of the lights came back on about a week ago. There has been a loss of oil meaning i have been adding oil in between oil changes at least once a week, there has been smoke coming from under the hood and if you run the heat or air you have to have circulate cabin air button pushed or it pulls the smell inside the car and it is overwhelming. The smoking has been going on for about at least a month now.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727970March 30, 2026
VEHICLE SPEED CONTROL
Abs, traction control lights, emergency braking lights on .. tire sensors are bad. Causing intermittent issue with the lights. For 3 years I've been trying to get my ABS/traction control fixed at Hyundai, that dealership refused to acknowledge there was an issue. I had a code from a car place since I live over an hour away and they said they couldn't use it since it wasn't from them. I have an extended warranty there. Went to another dealership and was immediately told it was the tire sensors. That he used to work at the other dealership and they saw it all the time. I now see Palisades have a tire sensor issue. Heck I've been dealing with this for years, and apparently so are many other Hyundai owners, according to this Hyundai employee. Now they're trying to overcharge me and saying my warranty will only cover a quarter of what they want. My deductible is only 100 if I don't get the work done at the original place, the one that said there isn't a problem. I've had it with Hyundai. They are unsafe and don't care about customer service.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727837March 29, 2026
ENGINE, FUEL/PROPULSION SYSTEM
I bought a 2018 Hyundai Santa Fe from a dealership in May of 2023. Ever since then I have paid around $8,000 in repairs for this car. These repairs have been so expensive and time consuming that last year I wasn’t able to drive it for 6 months because it was in the shop for most of the year. I had to fix the Fuel pump, the Battery, timing chain valve TWICE, O2 sensor , Catalytic Converter, Engine valve, cylinder 1 & 3 and NOW I have to fix cylinder 2 & 4 & that cost again around $2,000 to fix. I am constantly stressed out, crying and becoming broke because I have to keep on repairing this car. I use up all of my tows every year because my car always shuts off on me while I am driving. I am at the point where I want a refund on the car and I want to get rid of this vehicle. I do not feel safe driving on the highway or driving with my two kids and I am currently pregnant again and this car isn’t safe for a family. I am constantly feeling broken down and worthless because I can’t even keep this car a float.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726301March 23, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM, ENGINE
I was driving on March 20, 2026 at about 12:00 PM when I suddenly noticed smoke, a strong gasoline smell, an oil smell, and a burning odor coming from the vehicle. I pulled over immediately because I believed the vehicle was unsafe and at risk of fire. The vehicle had to be towed. An independent repair shop later found a fuel leak at the high-pressure fuel line / fuel pump area, a loose ground wire on the right-hand side of the engine, a valve cover gasket leak, and engine timing chain noise. I was informed that gasoline had sprayed throughout the engine bay. This created an immediate fire hazard even though no actual fire occurred. This problem was especially concerning because the vehicle had been inspected and serviced by an authorized Hyundai dealer in December 2025, less than about 3,000 miles earlier. The loose engine ground wire and fuel leak raise serious concerns about vehicle safety and the adequacy of the prior inspection. I contacted Hyundai the same day and reported this as a fire-risk safety issue, but I did not receive timely assistance. Because immediate dealer service was not available, I had to authorize emergency repairs at a local shop for safety reasons. No warning lights were noted before the incident. The failure was confirmed by the repair shop.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11726332March 23, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Enterprise car sales sold me this vehicle when it had 3 open recalls on it. The vehicle itself was a problem from the beginning. When I took it in for it's first oil change the mechanic told me it had no oil in it. He said they sold me a car that is notorious for consuming oil and or seizing or blowing up. I had the engine replaced on this car already and I just took it in for it's first oil change and it was already consuming oil. I want a new car but enterprise is telling me this is my problem
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726371March 23, 2026
POWER TRAIN, ENGINE, FUEL/PROPULSION SYSTEM
While driving the vehicle at approximately at 55 MPH on a the 826, the engine suffered a sudden and catastrophic mechanical failure without warning. The vehicle lost all motive power in active traffic, creating an immediate safety hazard and nearly resulting in a rear-end collision. Upon inspection, it was determined that the engine assembly, which is a replacement unit provided by Hyundai under the Theta II Settlement, with less than 12,000 miles, suffered an internal breach. This breach allowed coolant to contaminate the lubrication system sort of a milky oil, which led to a connecting rod bearing seizure. Despite this being a repeat failure of a safety-recall component and the vehicle being covered under the Theta II Settlement Lifetime Warranty, Hyundai Motor America has denied the repair claim. I am reporting this as a safety defect because the sudden engine stall resulted in a loss of power-assisted steering and braking while the vehicle was in motion.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726456March 23, 2026
SERVICE BRAKES, AIR BAGS
The contact owned a 2018 Hyundai Santa Fe. The contact’s son stated that while driving at 45 MPH, the brake pedal depressed with no warning light illuminated. The contact’s son stated that the ABS braking system failed, and the brake pedal did not function when attempting to stop the vehicle. As a result of the failure, the contact’s son collided with the highway pavement. No injuries were sustained, and no medical attention was required. The contact’s son also stated that the air bags did not deploy during the crash. A police report was filed. The vehicle was towed and was deemed a total loss by AAA due to severe front-end damage. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11725641March 19, 2026
ENGINE
I drove 2.5 hours north to a Marine brother's father's funeral, who unexpectedly passed. I started my drive home and made it to Yorktown in about 15 minutes, and the engine light came on, started flashing, and went into limp mode. I pulled over on I-69 to shut it off, pulled the dipstick, and the oil level was full. I pushed the Bluelink button on my rearview mirror, and HMA sent a tow truck to tow the vehicle to a local dealership about 10-12 minutes away. The dealership did not inspect the vehicle until the following Monday, since it was Friday, three weeks ago. The dealership found DTC codes for misfires in cylinders 1 and 2, multiple-cylinder misfire, and too-high pressure in all four cylinders. The vehicle has had the knock sensor replaced, a KSDS ECM update, and a series of gaskets replaced. It has been burning oil since 69,362 miles and is now not operational, 2.5 hours from home. HMA has declined to replace the engine on a vehicle involved in a class action settlement due to problems with several completed replacements. The dealership has followed the manufacturer's process, and, due to the engine not producing a code it had at 87,986, but now not capable due to piston damage, cylinder scouring, and spark plug damage, the manufacturer has declined a goodwill replacement. The engine failure did put others in harm's way, as it did me when having to pull off the busy interstate to inspect the obvious failure. I have been driving a rental since this situation occurred, have a vehicle that is not operational, and a manufacturer that is not assuming responsibility for the catastrophic failure. I have read numerous forums across several platforms about the Theta 2 engines. The vehicle has been serviced as needed, including multiple requests to fix or repair the engine noises it produced, when the oil level became low, and oil had to be added.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725196March 18, 2026
SERVICE BRAKES, HYDRAULIC
The contact owned a 2018 Hyundai Santa Fe Sport. The contact stated that while driving 5 MPH, while depressing the brake pedal, the vehicle failed to respond. No warning lights illuminated. The contact pulls over to the right side of the road, exits the vehicle, and notices flames coming from the engine, and smoke starts coming inside the vehicle. The contact mentioned that a bystander gave him a fire extinguisher to extinguish the fire, the flames stopped, then a couple of seconds later, the failure persisted. No injuries were sustained. No medical attention was required. A police report was filed. The fire department extinguished the fire. The vehicle was destroyed. The vehicle was towed to J&J Towing. The vehicle was not repaired. The contact was relating to the failure of the NHTSA Campaign Number: 22V810000(SERVICE BRAKES, HYDRAULIC). The manufacturer was not notified of the failure. The failure mileage was 170,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11725311March 18, 2026
ENGINE
I am reporting a serious safety concern involving a 2018 Hyundai Santa Fe Sport with approximately 132K miles. While driving at highway speed, the vehicle suddenly lost power/velocity and the engine light flashed. This created an immediate safety hazard, as maintaining speed is critical in highway traffic. Within seconds, the vehicle regained power and the warning light turned off, giving the impression that the issue had resolved. Shortly afterward, while exiting the highway, the vehicle began shaking and felt as though it would stall but was able to drive home less than one mile. A mechanic retrieved misfire codes for cylinders 2 and 4. Further inspection revealed internal engine damage in cylinder 4 requiring major rebuild. A full deconstruction revealed that one of the valves in cylinder 4 had partially broken. This failure occurred with little to no warning and involved a sudden loss of power at highway speed, which could have resulted in a serious accident. The vehicle’s warning systems did not provide adequate or persistent alerts prior to significant engine failure. Over the last 6 months it began consuming oil frequently requiring weekly checks, however no warning systems or errors to indicate an underlining concern. Based on research, similar Hyundai vehicles have documented issues involving excessive oil consumption and internal engine damage without sufficient warning. This raises concerns about a potential safety defect affecting engine performance and failure detection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725066March 17, 2026
ENGINE, VEHICLE SPEED CONTROL, FUEL/PROPULSION SYSTEM
Circuit board inside the fuse box stopped working and there was no speed indicator, no cruise control, no odometer registering while driving. Also the mechanical fuel pump started leaking fuel at 148,000 miles and now at 156,000 miles it is burning through oil and no oil light came on and the engine went into limp mode and is also now going through coolant too.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724727March 16, 2026
FUEL/PROPULSION SYSTEM, ENGINE
While traveling at approximately 80 mph on the highway, my vehicle suddenly lost all response to the accelerator pedal. Despite continued pressure on the gas, the vehicle rapidly decelerated to approximately 40 mph on its own. There were no warning lights, unusual noises, or physical indicators of a problem before, during, or after the event. I was able to safely navigate the vehicle off the highway. The vehicle appeared to operate normally afterward. The following day, I brought the vehicle to a mechanic who was unable to replicate the issue and found no stored fault codes. No repairs were made. Given the known concerns surrounding the Theta II engine in this model year, I am submitting this incident for documentation purposes and to contribute to any ongoing or future investigation into sudden acceleration loss in 2013 Hyundai Santa Fe vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724297March 14, 2026
TIRES:TREAD/BELT
At 4 AM on March 10,2026, I received a recall for the tires (Recall ID:26T009). I took it to the Hyundai dealership to get it serviced. The Director Mr. [XXX] , informed me that the only recall they have for me is a software recall. In addition, the do not fix any tire recalls I would have to reach out to the manufacturer such as Kumho tires co. When the service tech [XXX] looked at the tires, he informed me that there is Bridgestone tires on the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723852March 12, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while the vehicle was parked and running, there was an abnormal fuel odor inside the vehicle. The contact exited the vehicle and inspected it. The hood was opened, and the engine cover was removed, and there was condensation dripping from the fuel pump. The contact’s brother inspected the vehicle and became aware of the strong fuel odor and the condensation dripping from the high-pressure fuel pump. The vehicle was then taken to a dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723924March 12, 2026
STRUCTURE:BODY
Day 1 – Feb 11 at 4pm incident occurred my daughter was driving the vehicle on [XXX] , she was in the far right hand lane preparing to take an upcoming exit. Suddenly and unexpectedly the hood opened obstructing her view of the roadway and smashed the front windshield. Because she was in the right hand lane she was able to pull the vehicle to to the shoulder of the road immediately. No other vehicles were involved because of both her location (right hand lane) and ability to access the shoulder immediately. She could have been killed! The problem has not been confirmed Hyundai has informed me it will take 5/6 weeks to determine if an inspection is warranted. -Thursday February 19 We got the vehicle to the closest Hyundai dealer Metro West in Framingham Massachusetts on Thursday February 19 - I explained to the service representative the history (recall and repair in 2017) and a request to investigate recurrence of the recall defect as well as to prepare an estimate for repair. I never received a phone back so I called them on Wednesday February 27 and was informed that the vehicle estimate and inspection was in progress. At that point I contacted Hyundai corporate offices and was given a case number. On March 3, I called again and completed the preliminary investigation report - i was informed they would get back to me in approximately 48 hours. - On 3/9/26 after a phone conversation I was emailed a request to inspect my vehicle authorization form and another form (11 questions that had been answer numerous time by phone already) both were completed and submitted the following day 3/10/26. Dealership now threatening storage fees - Because the vehicle experienced failure of a component that was previously repaired under a federal safety recall, I am formally requesting that Hyundai preserve all evidence relating to the hood latch assembly and related components for purposes of regulatory review and potential insurance subrogation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722393March 6, 2026
UNKNOWN OR OTHER, ENGINE
Engine-Excessive oil consumption. Other-backup camera does not work and hasn’t for some time is 2028 sant fe sport included in recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe Sport