Hyundai Kona Complaints

964 consumer complaints on file.

#11737318May 12, 2026
ENGINE, VEHICLE SPEED CONTROL
The vehicle all shut off as I slowed down for a stop sign. Put in Park turn the key off restarted it got to the next stop sign same thing. Also the red light same had to shut it off put it in put in Park shut off and then restart and step on the gas so I can get through before a car hit me. Happened several times till I finally got the car home done it started knocking loudly and shut off just as I got into my driveway. Check the oil. The oil is fine. Occasionally the oil light would come on if you put in Dr.. It is knocking really loud. The engine light keeps flashing constantly. I called Brown Dobb Hyundai in Easton Pennsylvania. They told me this recall has nothing to do with my car because of the VIN number. But everything that is happening to it is is under recall 187. But because of the VIN number they are insisting it’s not my car. What can I do before I get in an accident? I don’t have any other cars to rely on. I have a son with Autism and I am a single mother. What else can I do? I had this car not even three months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737100May 11, 2026
ENGINE
Engine light comes on starts flashing as well as the oil light occasionally. If you slow down or have to stop it completely shuts down you have to put in park and restart the car to get anywhere and start stopping in front in the middle of traffic. So if you slow down to go up a hill or anything, it just stops completely. Also making a clicking or grinding sound not sure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736844May 10, 2026
ELECTRICAL SYSTEM
Coke spill in cup holders caused a leak to the wiring harness below the center console. It drained the battery, shut down all of the buttons on the steering wheel and shut the infotainment system down. It finally died and had to be towed to Vann York Hyundai in Highpoint NC. They told me that because it was cased by an outside influence it's not covered by the warranty and estimated $800 labor for repair. The leak is a defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736065May 6, 2026
ENGINE
Engine blew a head gasket so had to have the engine rebuilt @ a cost of $13,000. Car only had 22,500 miles on it. I think that should instigate a recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736103May 6, 2026
ENGINE AND ENGINE COOLING, ENGINE
The contact owns a 2018 Hyundai Koa. The contact stated that while the daughter was driving the vehicle began to sputter and jerk before stalling. During the failure the oil warning light flashed off and on. The vehicle was towed to the local dealer who diagnosed that the engine had failed due to carbon buildup. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 21V301000(ENGINE) The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736013May 6, 2026
ELECTRICAL SYSTEM
The vehicle experienced a total electrical failure while driving. Dealer diagnosed the issue as a loose fuse box connector/power distribution connector. The vehicle and repaired component should be available for inspection through the Hyundai dealer service department. The vehicle suddenly lost all power while being driven on a public roadway. The engine shut off, dashboard went dark, and power steering assistance was lost, creating a risk of collision and leaving the vehicle disabled in traffic. A Hyundai dealer diagnosed and confirmed that a loose fuse box connector caused the loss of power. The vehicle was inspected by an authorized Hyundai dealer service department. No police or insurance inspection was performed. No warning lights, messages, or symptoms appeared prior to the failure. The vehicle lost power suddenly without warning while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735187May 1, 2026
ENGINE, POWER TRAIN
The vehicle suddenly stalled while driving on the highway at normal speed without warning. The engine lost power completely, creating a dangerous situation and a risk of collision with surrounding traffic. The vehicle had to be towed to a repair shop, where the issue was diagnosed as engine failure. There were no warning lights or prior symptoms before the incident. This appears to be a serious safety-related defect. I am aware that similar engine issues have been reported in Hyundai vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735057May 1, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
The automatic emergency braking system brakes way too hard causing the car to stop too fast and risks causing a rear end collision. This is not fixed by adjusting settings. It is a common complaint and the system needs to be calibrated to brake more smoothly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734040April 27, 2026
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2025 Hyundai Kona. The contact stated that while driving, she observed a loud explosion emanating from the roof of the vehicle. The contact slammed on her brakes and then steered the vehicle to the side of the road, where she observed crackling glass noises also emanating from the sunroof. The contact then exited the vehicle to inspect, where she observed the sunroof had a frisbee-sized hole in the middle. There was no impact on the sunroof. The contact called the police, but there was no police report taken. The contact stated that her ears began ringing, and medical attention was needed. The vehicle was taken to a dealer, where it was diagnosed that there was no natural cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 5,798.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11733958April 27, 2026
SERVICE BRAKES, UNKNOWN OR OTHER
On April 20, 2026 I was pulling into a parking space. I began to break but something went terribly wrong. My car accelerated on it's own, went over the curb and crashed into a building. Three air bags deployed: two on the drivers side of the car (front and side air bag) and one in the back seat behind the driver (the side air bag). I had a [XXX] in the back seat behind the passenger side of the car in a car seat. I was told at the time of the incident that there was not structural damage to the building that was hit. I have asked my insurance company to inspect the car for any malfunctions but they won't. They deem it totaled and say I am at fault because it's my responsibility to control my car. The police arrived but they did not inspect the car either. I have contacted the dealership (Parkway Hyundai), but they are of no help either. There were not warning lamps, messages or other symptoms of the problem prior to the failure. However, I did notice recently that when I put my foot on the break to start the car that sometimes the break was very stiff and other times it was not. I thought it strange but thought it was just the way my car was. My insurance is Progressive. Claim # XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11733726April 25, 2026
SERVICE BRAKES, VEHICLE SPEED CONTROL
I stopped my car foot on brake put it in park and it accelerated on its own and forced me to crash into a concrete wall still not wanting to stop
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11733599April 24, 2026
ENGINE, POWER TRAIN
The vehicle burns oil faster and the vehicle began to stall at highway speeds. Upon further research, a campaign recall for the same vehicle is open but only for specific VIN. Although this vehicle was not part of the recall campaign 21V301000 the vehicle shows issues aligned with the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733095April 22, 2026
ENGINE, UNKNOWN OR OTHER
I purchased a 2021 Hyundai Kona in 2023. I own it outright. 2 weeks later my engine seized on the CA 118 in the middle lane & I lost steering & power. I don’t know how I made it to the side w cars doing 80. I was shaking. The dealer refurbished my engine no cost , it was due to the oil consumption problem & the piston ring issues many cars in ‘20 & ‘21 had. I had a Hyundai rep call & offer me $400 to sign off on any future engine issues w this car, & I knew this car was likely to have many other future problems after that offer. I did not accept offer. The transmission is also very jerky on surface streets. Well 2 yrs later, the engine started to seize up again today as I was on my way to a dentist appt. I don’t feel safe in this car. I am a 58 y/o woman w fibromyalgia & the stress of the power just shutting down when I’m driving makes my disease flair up terribly. I’ve had many cars & this is the only 1 I’m truly scared to drive alone in , after being stuck on a mountainside road, w no power, no steering, no one w me. I avoid driving at times, because the PTSD from the first incident is always w me . I love to drive - I had a motor home I drove across this country 6 times. I really want to sell this car, but I don’t want some other person to be in danger either. If I knew Hyundais in certain yrs had these issues, I certainly never would have purchased that particular year/model. That should be disclosed w the cars stats if it is known & actually in several class action suits. No advanced warning came on to alert me either - the engine just seized on a mountainside freeway as I was doing 68 mph. I feel lucky to be here after that.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731892April 17, 2026
ENGINE
On February 27, 2026, my 2020 Hyundai Kona (Recall 203) suffered a catastrophic engine stall while driving, requiring an emergency tow. The dealership (Rosen Hyundai) and Hyundai Motor America are refusing to perform the Safety Recall 203 remedy unless I first pay $4,715.26 for a timing repair. I was also required to pay $453.05 for wiring repairs just to "enable" the recall test, yet the recall remains unaddressed because of a financial paywall. I am reporting an obstruction of a federal safety recall by the manufacturer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731676April 16, 2026
ENGINE
Last week just driving to school, my engine started to knock. So the next day we take it to a local mechanic shop and it exploded while they were test driving it and they diagnosed it with rod bearing failure. So I contact Hyundai and get it towed to the Hyundai dealership for them to inspect it and eventually do an engine swap, but after it got dropped off I was told it’d be $360 to get it diagnosed and filed and they said that I have no warranty. I explained to the rep that the class action lawsuit regarding the Theta 2 GDI engines extends the warranty to 15 years/150,000 miles for all subsequent owners especially since I’ve had the KSDS installed. They’re refusing to cover damages even though my car was affected by a manufacturing issue on their end and was part of major recall campaigns. My car failed at 94,000 miles while up to date on services and the representative was recommending I ask Hyundai for “good-will funding” but I don’t need their “good will” I need them to make the situation right and cover all my expenses related to my blown engine
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731640April 16, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
On two separate occasions while in drive and accelerating, the car display indicated an “engine has been turned off, move to park” error. The car automatically went into neutral and I lost all control of acceleration until I came to a full stop, put it in park, and turned off the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731257April 14, 2026
ENGINE
The check engine light came on while driving. Vehicle was assessed by mechanic with strange diagnostic code; full oil and filter change done. Check engine light still on and engine stalled while driving on freeway. Took to dealer and was advised the car requires CVVTS (which is essentially a new engine), serpentine belt and spark plugs (approx $3600). There is a known engine defect with the 2018 Hyundai but they refuse to do as a recall and refuse discounted repair on a vehicle that 8 years old with 92,000 miles. This vehicle is owned by my young adult child and I believe it is undriveable since stalling at full speed is quite dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730758April 13, 2026
ENGINE
In January 2026, my engine light illuminated and the vehicle lost power. The dealership found a sudden loss of compression across all four cylinders, requiring a total engine replacement. This occurred without warning, only two months after a routine oil change at the same facility where no issues were reported. Despite opening a case with Hyundai corporate, there has been no progress. My research indicates that while NHTSA Recall 21V301 (Safety Recall 203) specifies 2019–2021 models, the 2022 model shares the same engine design and identical reports of stalling and compression loss. My vehicle has been at the dealership for three months with no resolution. The dealership says they are running tests requested by tech line without providing documentation of the tests or the results. Although, the initial test performed indicated that it was a compression ring issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730654April 12, 2026
ELECTRICAL SYSTEM, VISIBILITY/WIPER, EXTERIOR LIGHTING
- While driving, everything electrical turned off (engine stayed on) for approximately 3 seconds including headlights, navigation, dashboard containing speed, music, etc. - This occurrence happened during the daytime, so there was no danger; however this has also happened to me at night a year ago, causing me to lose all vision at 40 MPH which was a major safety risk. - This problem has occurred with others [XXX] ) and Hyundai has not acknowledged it or been able to reproduce it, simply returning the vehicle to people who bring it in. - My vehicle has not been inspected, as from others' experiences it sounds like this issue does not register as an error code and would be a waste of time with no action from Hyundai. - There are no other issues with my vehicle in terms of warning lights or messages. I have frequent oil changes and have only driven this car 6,000 miles. It was bought brand new in 2024. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730363April 10, 2026
POWER TRAIN
The contact owns a 2020 Hyundai Kona. The contact stated that during a regular maintenance visit, the contact was informed that there was a leak coming from the front axle transfer case, which was initially unrepaired. The vehicle was subsequently taken to a dealer in Colorado, where the seal was replaced. However, while an oil change service was being performed later, it was discovered that the failure recurred because the previous repair was performed incorrectly. The first failure was for an inoperable seal, and the second failure was due to an improper repair. The third inspection confirmed that the seal had not been installed correctly during the prior service. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 146,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Kona