Hyundai Elantra Recalls

62 recalls on file.

• Recall08V694000December 29, 2008
  FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  HYUNDAI DE PUERTO RICO (HPR) IS RECALLING 347 MY 2008 ELANTRA VEHICLES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER, UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.

  Remedy

  DEALERS WILL REPLACE THE VEHICLE'S FUEL PUMP SUBASSEMBLY. THE RECALL BEGAN ON FEBRUARY 9, 2009. OWNERS MAY CONTACT HPR AT 1-800-981-0188.

• Recall08V533000October 14, 2008
  AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

  HYUNDAI IS RECALLING CERTAIN MY 2001-2002 ELANTRA VEHICLES. MOVEMENT OF THE SIDE IMPACT AIR BAG WIRING HARNESS MOUNTED UNDER EACH FRONT SEAT, POSSIBLY CAUSED BY CONTACT FROM MATERIALS PLACED UNDER THE SEAT, MAY RESULT IN AN ELECTRICAL RESISTANCE THAT WOULD CAUSE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) WARNING LIGHT ILLUMINATION.

  Remedy

  DEALERS WILL INSTALL NEW SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR CLIPS AND REVISED SIDE IMPACT AIR BAG WIRING HARNESS ATTACHMENTS UNDER THE DRIVER'S AND FRONT PASSENGER'S SEATS. THE RECALL IS EXPECTED TO BEGIN DURING THE FOURTH QUARTER OF 2008, AND WILL BE SENT OUT IN SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

• Recall08V532000October 14, 2008
  AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

  HYUNDAI IS RECALLING CERTAIN MY 2001 ELANTRA VEHICLES. IF A LIQUID IS SPILLED IN THE AREA OF THE CUPHOLDER ON THE CENTER CONSOLE, IT MAY SEEP THROUGH THE CONSOLE OPENING FOR THE PARKING BRAKE LEVER AND THEN DRIP ONTO THE AIR BAG CONTROL MODULE ELECTRICAL CONNECTOR. THE SPILLED LIQUID MAY CONTAMINATE THE AIR BAG CONTROL MODULE AND ITS ELECTRICAL CONNECTOR TO THE AIR BAG WIRING HARNESS AND CAUSE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) WARNING LIGHT TO ILLUMINATE.

  Remedy

  DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE VEHICLE'S AIR BAG CONTROL MODULE CONNECTOR. THE RECALL OWNER NOTIFICATION BEGAN ON NOVEMBER 30, 2008, AND LETTERS WILL BE SENT OUT IN SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

• Recall08V429000August 25, 2008
  FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  HYUNDAI IS RECALLING 65,000 MY 2008 ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES. THE FUEL PUMP MOTOR MAY NOT HAVE THE PROPER UNIFORM INTERNAL ELECTRICAL SURFACE CONTACT. THIS MAY CAUSE THE FUEL PUMP TO PRODUCE LESS PUMPING PRESSURE THAN REQUIRED TO SUPPLY THE FUEL INJECTION SYSTEM.

  Remedy

  DEALERS WILL REPLACE THE FUEL PUMP SUBASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

• Recall05V479000October 17, 2005
  AIR BAGS

  CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.

  Remedy

  DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON NOVEMBER 15, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.

• Recall05V395000September 12, 2005
  AIR BAGS

  CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.

  Remedy

  DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

• Recall05V187000April 28, 2005
  STEERING:LINKAGES:TIE ROD ASSEMBLY

  CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH THREADED PORTIONS OF THE STEERING GEARBOX ASSEMBLY'S LEFT AND RIGHT INNER BALL JOINT ASSEMBLIES THAT CONTAIN INTERNAL CRACKS IN THE MATERIAL STRUCTURE.

  Remedy

  DEALERS WILL REPLACE THE STEERING GEARBOX ASSEMBLIES ON THESE VEHICLES FREE OF CHARGE. OWNERS WERE CONTACTED BY TELEPHONE BEGINNING ON APRIL 8, 2005, AND INSTRUCTED NOT TO DRIVE THEIR VEHICLES. HYUNDAI WILL ARRANGE TO PICK UP AND RETURN THEIR VEHICLES AFTER REPAIR. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

• Recall04V370000July 30, 2004
  FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

  DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST, IT WAS DETERMINED THAT FUEL TAN DAMAGE COULD OCCUR. ON CERTAIN PASSENGER VEHICLES, A VAPOR TUBE HOSE CLAMP THAT IS LOCATED NEAR THE FUEL TANK MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE FUEL LEAKAGE.

  Remedy

  DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP EARS AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.

• Recall04V369000July 26, 2004
  FUEL SYSTEM, GASOLINE:STORAGE

  CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.

  Remedy

  DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.

• Recall04V208000May 3, 2004
  FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

  DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST ON CERTAIN PASSENGER VEHICLES, FUEL SPILLAGE OCCURRED AS A RESULT OF FUEL TANK DAMAGE CAUSED BY CONTACT BETWEEN A VAPOR TUBE HOSE CLAMP EAR AND THE FUEL TANK. THE VAPOR TUBE HOSE CLAMP EAR WAS FOUND TO BE MISPOSITIONED AND FACING TOWARD THE FUEL TANK.

  Remedy

  DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

• Recall04V178000April 9, 2004
  FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

  SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.

  Remedy

  DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

• Recall03V496000December 3, 2003
  SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

  ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.

  Remedy

  DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.

• Recall03V322000August 26, 2003
  AIR BAGS

  ON CERTAIN VEHICLES, IF THE FRONT PASSENGER SEAT IS UNOCCUPIED OR IS OCCUPIED BY SOMEONE LIGHTER THAN 56.4 POUNDS, THE PASSENGER AIR BAG IS DEACTIVATED AND WILL NOT DEPLOY IF A CRASH OCCURS. HOWEVER, THE OCCUPANT CLASSIFICATION SENSOR MAY INCORRECTLY INTERPRET THAT A SEATED ADULT IS AN INFANT SEAT AND DEACTIVATE THE PASSENGER AIR BAG IF SOMEONE HEAVIER THAN 56.4 POUNDS WHO IS SEATED WITH ONE LEG RESTING ON THE OUTBOARD OR INBOARD EDGE OF THE SEAT; WITH LEGS SPREAD; OR POSITIONED OFF-CENTER TOWARD THE CENTER CONSOLE AND WITH HIS OR HER ARM LEANING ON THE CONSOLE.

  Remedy

  THE OCCUPANT CLASSIFICATION SENSOR WILL BE REPROGRAMMED.

• Recall03V257000July 22, 2003
  SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

  ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.

  Remedy

  DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

• Recall00V332000October 17, 2000
  AIR BAGS:SIDE/WINDOW

  VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM SIDE AIR BAG SATELLITE SENSORS INSTALLED WERE IMPROPERLY MANUFACTURED, CAUSING THE AIR BAG WARNING LIGHT TO ILLUMINATE AND THE SIDE AIR BAGS TO NOT DEPLOY AS INTENDED IN THE EVENT OF A CRASH.

  Remedy

  DEALERS WILL REPLACE THE TWO SATELLITE SENSORS.

• Recall00V259001September 11, 2000
  ELECTRICAL SYSTEM:WIRING

  VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS.

  Remedy

  DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.

• Recall00V095002July 21, 2000
  FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

  VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.

  Remedy

  DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.

• Recall00V095001March 28, 2000
  FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

  VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.

  Remedy

  DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.

• Recall99V178000July 7, 1999
  POWER TRAIN:AUTOMATIC TRANSMISSION

  VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION PRESSURE CONTROL SOLENOID VALVE SEALS DO NOT REMAIN SUFFICIENTLY ELASTIC, RESULTING IN TRANSMISSION FLUID LEAKAGE. THIS LEAKAGE CAN RESULT IN REDUCED PRESSURE APPLICATION TO THE CLUTCHES, BRAKE, AND KICKDOWN SERVO, ALLOWING THEM TO SLIP.

  Remedy

  DEALERS WILL REPLACE THE PRESSURE CONTROL SOLENOID VALVE.

• Recall97V026000February 26, 1997
  VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

  THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.

  Remedy

  DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.