GMC · Model Report
Showing safety data for the 2003 model year only.
General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.
General Motors (GM) is recalling certain model year 2003-2004 Chevrolet Express and GMC Savana vehicles, equipped with a left side cargo door, and originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Water and road contaminants may become trapped in the protective conduit that covers the fuel filler pipe and may cause the pipe to corrode.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
TL* THE CONTACT OWNS A 2003 GMC SAVANA. WHILE OPERATING THE VEHICLE, THE STEERING WHEEL AND BRAKE PEDAL MALFUNCTIONED AND DID NOT PROPERLY OPERATE. WHILE DEPRESSING THE BRAKE PEDAL, THE STEERING WHEEL WOULD JERK AND THE BRAKE PEDAL WAS HARD TO DEPRESS, WHICH AFFECTED THE VEHICLE STOPPING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE HYDRO PUMP WAS FAULTY. THE PUMP WAS REPLACED, BUT THE FAILURES CONTINUED. THE CONTACT INDICATED THAT THE HYDRO PUMP HAD BEEN REPLACED THREE TIMES WITHIN THE PAST EIGHT MONTHS. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 100,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2003 GMC SAVANA 1500. THE CONTACT STATED THAT THERE WAS A ODOR OF FUEL INSIDE THE VEHICLE. UPON INSPECTION, IT WAS DISCOVERED THAT FUEL WAS LEAKING FROM THE VEHICLE DUE TO CORROSION OF FUEL FILLER NECK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000. UPDATED 01/27/16*LJ
No injuries · No fire · No crash
GAS TANK LEAKS WHEN FULL. THE SEAM WHERE THE FILLER NECK MEETS THE TANK'S NIPPLE IS CRACKED. GM DOES NOT MANUFACTURE A REPLACEMENT TANK, NO USED TANKS AVAILABLE. I'M FORCED TO DRIVE A VAN THAT LEAKS FUEL IF FULL, OR HITS A BUMP IN THE ROAD. HELP! *TR
No injuries · No fire · No crash
AIR BAGS DID NOT DEPLOY HIGH IMPACT ACCIDENT 55 TO 65 MPH HIT CONCRETE WALL BOUGHT VAN NEW 2003 SAVANNA 1500. *TR
TL* THE CONTACT OWNS A 2003 GMC SAVANA. THE CONTACT STATED WHILE DRIVING 30 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. ALSO, THE CONTACT SMELLED FUEL INSIDE THE VEHICLE AND FUEL LEAKED OUT OF THE FUEL TANK WHILE THE VEHICLE WAS PARKED ON A HILL. THE CONTACT RECEIVED A RECALL NOTICE FOR CAMPAIGN NUMBER 06E043000 (FUEL SYSTEM, GASOLINE) AND TOOK THE VEHICLE TO THE DEALER. THE DEALER DID NOT HONOR THE RECALL AND WOULD NOT INSPECT THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO ANOTHER DEALER. THE DEALER STATED THERE WAS NO CORROSION ON THE FUEL FILLER PIPE BUT THE FUEL TANK HAD CORROSION AND NEEDED TO BE REPLACED, MAKING THE VEHICLE UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 159,000. THE VIN WAS NOT AVAILABLE.
No injuries · No fire · No crash