Freightliner Columbia Recalls

67 recalls on file.

• Recall07V400000September 5, 2007
  STEERING:LINKAGES:TIE ROD ASSEMBLY

  ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.

  Remedy

  DEALERS WILL INSPECT FOR INSTALLATION OF THE STEERING ARMS. STEERING COMPONENTS WILL BE REPLACED ON TRUCKS THAT HAVE INCORRECTLY INSTALLED TIE ROD ARMS. THE RECALL BEGAN ON MAY 1, 2008. OWNER MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall07V357000August 13, 2007
  STEERING:COLUMN

  ON CERTAIN TRUCKS BUILT WITH A TRW GLOBAL ADJUSTABLE UPPER STEERING COLUMN, TWO UPPER TILT PLATE BOLTS MAY LOOSEN WITH USE AND FALL OUT. THESE FASTENERS HOLD THE UPPER COLUMN ASSEMBLY IN PLACE. THE STEERING COLUMN PIVOT MAY FRACTURE IF THE BOLTS ARE MISSING WHEN AN EXCESSIVE FORCE IS APPLIED TO THE STEERING WHEEL.

  Remedy

  THE TILT PLATE BOLTS WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 23, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall07V335000August 2, 2007
  FUEL SYSTEM, GASOLINE:DELIVERY

  ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

  Remedy

  DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall07V316000July 24, 2007
  SUSPENSION:REAR

  ON CERTAIN TRUCKS EQUIPPED WITH TUFTRAC REAR SUSPENSIONS, THE CENTER CASTING BRACKETS MAY BE OUT OF SPECIFICATION. AN OUT OF SQUARE CASTING MAY HAVE UNACCEPTABLE STRESS IN THE BRACKET WHEN IT IS INSTALLED AND MAY CAUSE IT TO CRACK IN SERVICE.

  Remedy

  DEALERS WILL INSPECT AND CASTINGS THAT ARE OUT OF SPECIFICATION WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 12, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall07V306000July 18, 2007
  STEERING

  FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.

  Remedy

  THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall07V302000July 16, 2007
  SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE

  CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.

  Remedy

  FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall07V289000July 3, 2007
  STEERING:COLUMN

  CERTAIN FREIGHTLINER SCHOOL BUSES AND TRUCKS MANUFACTURED FROM OCTOBER 23, 2004, TO MARCH 21, 2006. DURING THE STEERING COLUMN MANUFACTURING PROCESS TWO WELDS MAY HAVE BEEN MISSING.

  Remedy

  FREIGHTLINER WILL NOTIFY OWNERS AND INSPECT AND REPAIR THE AFFECTED VEHICLE FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall07V255000June 7, 2007
  POWER TRAIN:AXLE ASSEMBLY

  ON CERTAIN TRUCKS BUILT WITH DANA REAR AXLES, THE HOUSINGS MAY CONTAIN THINNER MATERIAL THAN WHAT IS NECESSARY FOR NORMAL VEHICLE OPERATION.

  Remedy

  DEALERS WILL INSPECT THE VEHICLE'S REAR AXLES AND, IF NECESSARY, REPLACE THE AXLE HOUSINGS. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall07V169000April 12, 2007
  SUSPENSION:FRONT:HUB

  ON CERTAIN TRUCKS BUILT WITH FRONT AXLES ASSEMBLED BY ARVINMERITOR, THE FRONT SPINDLE NUT MAY BE OVER-TIGHTENED CAUSING PRELOAD ON THE FRONT WHEEL BEARINGS WHICH COULD LEAD TO PREMATURE BEARING WEAR.

  Remedy

  DEALERS WILL INSPECT THE FRONT HUB INSTALLATION FOR CORRECT BEARING ADJUSTMENT. IF THE BEARING ADJUSTMENT IS INCORRECT, THE FRONT WHEEL BEARINGS WILL BE REPLACED. THE RECALL BEGAN ON JUNE 28, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-385-4357.

• Recall06V424000November 2, 2006
  SUSPENSION:FRONT

  ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR FRONT AXLE ASSEMBLIES, THE FRONT SPINDLE NUT MAY BE OVER-TIGHTENED CAUSING PRELOAD ON THE FRONT WHEEL BEARINGS WHICH MAY LEAD TO PREMATURE BEARING WEAR.

  Remedy

  DEALERS WILL INSPECT THE FRONT HUB INSTALLATION FOR CORRECT BEARING ADJUSTMENT. IF THE BEARING ADJUSTMENT IS INCORRECT, THE FRONT WHEEL BEARINGS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 22, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall06V387000October 11, 2006
  POWER TRAIN:DRIVELINE

  ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR RPL20 HIGH ANGLE INTERAXLE DRIVESHAFTS, AN IMPROPER SEATED OR MISSING SNAP RING CAN RESULT IN THE BEARING CUP TO SEPARATE FROM THE SLIP YOKE SUB-ASSEMBLY. THE UNIVERSAL JOINT CROSS COULD THEN CONTACT THE SLIP YOKE CASTING AND EVENTUALLY CAUSE THE EAR WORK TO FRACTURE.

  Remedy

  DEALERS WILL INSPECT THE DRIVESHAFTS AND REPLACE THEM AS NEEDED. THE RECALL BEGAN ON DECEMBER 6, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall06V205000June 12, 2006
  PARKING BRAKE:CONVENTIONAL:AIR

  CERTAIN HEAVY TRUCKS, SHUTTLE BUSES, AND SCHOOL BUSES EQUIPPED WITH BENDIX MODULATED SPRING BRAKE VALVES. A DEFECT IN THE MODULATED SPRING BRAKE VALVE CASTING MAY CAUSE AN INTERMITTENT DELAY IN THE APPLICATION OF THE PARK BRAKE.

  Remedy

  FREIGHTLINER WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE VALVES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 28, 2006 TO FREIGHTLINER, STERLING, AND FCCC OWNERS. THOMAS BUILT MAILED LETTERS TO OWNERS BEGINNING JULY 27, 2006. THIS RECALL HAS BEEN SUPERSEDED (REPLACED) BY RECALL 07V302 (FL-504).

• Recall06V190000June 5, 2006
  ELECTRICAL SYSTEM

  ON CERTAIN TRUCKS, THE PROTECTIVE COVER FOR THE CAB POWER DISTRIBUTION MODEL (PDM) MAY BE MISSING OR IMPROPERLY INSTALLED.

  Remedy

  DEALERS WILL INSTALL A NEW COVER FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall06V030000February 8, 2006
  ENGINE AND ENGINE COOLING

  ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE VARIABLE VALVE ACTUATION OIL LINE MAY WEAR AGAINST THE SHARP EDGE OF THE CYLINDER HEAD IF NOT POSITIONED CORRECTLY.

  Remedy

  CATERPILLAR, IN CONJUNCTION WITH FREIGHTLINER, WILL BE CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN FREE OF CHARGE. OWNERS MAY CALL CATERPILLAR AT 309-675-6496, OR FREIGHTLINER AT 1-800-547-0712.

• Recall05V551000December 6, 2005
  POWER TRAIN:AXLE ASSEMBLY

  ON CERTAIN TRUCKS AND MOTOR HOME CHASSIS, THE TOP FLANGE OF THE FRONT AXLE I-BEAM MAY FATIGUE AND FRACTURE.

  Remedy

  DEALERS WILL INSPECT AND REPLACE THE FRONT AXLE ASSEMBLY. THE RECALL BEGAN ON MARCH 15, 2006, FOR PHASE I. PHASE 2 WILL BEGIN DURING AUGUST 2006. THIS RECALL IS BEING CONDUCTED IN TWO PHASES. PHASE I WILL REPLACE THE COMPLETE AXLE ASSEMBLY; AND PHASE II WILL REPLACE THE AXLE BEAM AND STEERING KNUCKLES. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall05V467000October 5, 2005
  SUSPENSION:REAR:AXLE:SPINDLE

  CERTAIN 2005 THOMAS BUILT FS-65 AND C-2 SCHOOL BUSES AND 2005 FREIGHTLINER ARGOSY, COLUMBIA, CENTURY ST, AND M2 BUSINESS CLASS TRUCKS MANUFACTURED BETWEEN JUNE 4 AND JULY 8, 2005. THE SPINDLES IN THE REAR AXLE HOUSING WERE OVERHEATED DURING THE HEAT TREATMENT PROCESS. INCORRECTLY HEAT TREATED SPINDLES COULD RESULT IN A FRACTURE OF THE SPINDLE.

  Remedy

  FREIGHTLINER WILL NOTIFY ITS CUSTOMERS AND INSPECT FOR THE HEAT TREAT DATE CODE ON THE END OF THE REAR SPINDLES AND REPLACE THE AXLE HOUSING IF NECESSARY. THE RECALL IS EXPECTED TO BEGIN ON JANUARY 23, 2006. OWNERS MAY CONTACT FREIGHTLINER

• Recall05V408000September 13, 2005
  STEERING:LINKAGES

  ON CERTAIN TRUCK AND MOTOR HOME CHASSIS EQUIPPED WITH I-SHAFTS SUPPLIED BY ZF HEAVY DUTY STEERING, THERE IS A POTENTIAL FOR A FAILURE OF THE FORK/SHAFT CONNECTION.

  Remedy

  DEALERS WILL INSPECT AND ATTACH A TENSION COLLAR TO THE STEERING SHAFT TO SECURE THE CONNECTION TO THE YOKE. THE RECALL BEGAN ON NOVEMBER 16, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall05V285000June 14, 2005
  WHEELS:HUB

  ON CERTAIN TRUCKS EQUIPPED WITH 3RD GENERATION CONMET ALUMINUM WHEELS, THE DRUM MOUNTING FLANGE ON THE CONMET TRUTURN BRAKE DRUM MAY HAVE BEEN MANUFACTURED WITH A TAPER FROM THE PILOT HOLE TO THE BARREL OF THE DRUM.

  Remedy

  AFTER FURTHER INVESTIGATION AND TESTING, FREIGHTLINER HAS REVISED THE POPULATION AND THE REMEDY (DECEMBER 22, 2005). THEREFORE, THE RECALL BEGAN ON MARCH 15, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall05V185000April 27, 2005
  WHEELS

  ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH ACCURIDE ALUMINUM WHEELS, THE WHEELS WERE NOT PROPERLY PRE-STRESSED. THIS ALLOWS CRACKS TO DEVELOP OVER TIME.

  Remedy

  DEALERS WILL REPLACE THE WHEELS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

• Recall05V001000January 3, 2005
  SEATS

  ON CERTAIN TRUCKS EQUIPPED WITH SEATS BUILT BY GRA-MAG, THE SEAT PIVOT BOLTS CAN LOOSEN AND POSSIBLY FRACTURE OR DISLODGE, CAUSING THE SEAT BACK TO FAIL TO PROVIDE FULL SUPPORT TO THE DRIVER'S BACK.

  Remedy

  DEALERS WILL REPAIR THESE VEHICLES. THE RECALL BEGAN ON APRIL 20, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.