Freightliner Columbia Complaints

96 consumer complaints on file.

#10585701April 30, 2014
STRUCTURE
THE VIN LAST 6: [XXX] ; ZF MERIT OR,12 SPEED AUTOMATIC TRANSMISSION THE CENTER CARRIER BEARING WHICH SUPPORTS THE OUTPUT SHAFT AFTER THE TRANSMISSION DID NOT LAST MORE THAN 3 YEARS AND HAD EXCESSIVE PLAY. THE FIRST REPAIR INVOICE WAS ON 3/1/2012 AND THE MOST RECENT REPAIR WAS ON 4/28/2014. THE RUBBER COMPOUND USED IN THE CENTER CARRIER BEARING NEEDS TO BE REEVALUATED. ONCE THE CENTER CARRIER BEARING HAS PLAY IN THE Z DIRECTION, THERE WOULD BE EXCESSIVE VIBRATION THAT CAN FATIGUE OTHER COMPONENTS AND CAUSE FAILURE BY INITIATING A FATIGUE CRACK AND PROPAGATING DUE TO CYCLIC STRESSES. MERITOR SHOULD REEVALUATE THE RELIABILITY OF THEIR CENTER CARRIER ASSEMBLY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583077April 16, 2014
SEAT BELTS
TL* THE CONTACT OWNS A 2006 FREIGHTLINER CONVENTIONAL COLUMBIA. THE CONTACT STATED THAT WHILE TRAVELING 20 MPH IN ICY CONDITIONS, THE SEAT BELT DID NOT PROVIDE ENOUGH SLACK AND MADE IT DIFFICULT TO REACH THE TRAILER BRAKE AND CAUSED THE CONTACT TO LOSE CONTROL AND ROLLOVER. THE CONTACT SUSTAINED 3 BROKEN RIBS AND A CRACKED SHOULDER BLADE. THE TRUCK WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 8,560. UPDATED 6/10/14*CN
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10555060December 6, 2013
ENGINE
2008 CATERPILLAR ACERT C13 CRANKCASE BREATHER FILTER CLOGGED BECAUSE OF DESIGN. CAUSED TRUCK TO SHUT DOWN IN TRAFFIC CREATING A SAFETY INCIDENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10541819September 4, 2013
SERVICE BRAKES, SERVICE BRAKES, AIR
A COMMERCIAL TRUCK VEHICLE MAINTENANCE VIOLATION, WAS ISSUED DURING A ROAD SIDE INCEPTION BY A CERTIFIED DOT INSPECTOR, FOR EMERGENCY BRAKE HOSE CHAFFING. A VIOLATION OF 393.45B2. OUR INVESTIGATION PROVED BEYOND ANY QUESTIONS THAT THIS IS THE WAY FREIGHTLINERS BUILD IT'S TRUCK FOR THE PAST DECADE AND STILL DOES. WE HAVE OBTAINED EVIDENCE TO SUPPORT OUR CLAIM. THIS IS A MAJOR SAFETY RISK, AS COMPROMISING THIS HOSE RESULTED IN A LOSS OF AIR PSI NEEDED FOR SEPARATING OF THE BRAKE SHOE FROM THE DRUMS WITHOUT ANY INDICATION TO THE DRIVER. ON A SEPARATE INCIDENT WHILE DRIVING IN WINNIPEG, M.B, THE BRAKE ASSEMBLY CAUGHT FIRE!. *JB FURTHER MORE, 393.45 SPECIFICALLY INSTRUCT AN EOM HOW TO BUILD SUCH LINE AND PROHIBITED THE CHAFFING @ TIME OF MANUFACTURING . WE KNOW THAT FREIGHTLINERS ARE AWARE OF THE FACT, AND KNOWINGLY SET IT'S COSTUMER TO FAIL @ A GREAT RISK TO OTHERS THAT SHARE THE ROADS. ALL OF OUR EVIDENCE CAN BE EMAILED. ANYONE CAN WALK INTO ANY FREIGHTLINER DEALERSHIP, LIKE WE DID, LOOK ON THAT HOSE, AND FIND IT TO BE IN VIOLATION OF 393.45. WE HAVE GONE A LONG WE TO OBTAINED OUR EVIDENCE, CONTACTED FREIGHTLINER, LEO'S, MANY DOT INSPECTORS, AND THE ONES THAT TRAINED THOSE INSPECTORS. WE ARE NOW CERTAIN THAT MOST OF ALL FREIGHTLINERS TRUCKS ON THE ROAD ARE IN FACT IN VIOLATION OF 393.45, @ GREAT RISK. ALL OF OUR EVIDENCE CAN BE E-MAILED. AND WE ARE WILLING TO HELP BY ANY MEANS TO HELP EXPLAIN OR SOLVE THIS RISK. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10537529August 27, 2013
TIRES
STEER TIRE PEALED APART, 3 MONTHS OLD APPROXIMATELY 5K MILES, ON A 2006 FREIGHTLINER 3 AXLE TRACTOR. THREE OTHER TIRES ON THREE OTHER TRACTORS WITH THE SAME BRAND TIRE ALSO PEALED APART. SHOULD BE RECALLED EXTREME SAFETY HAZARD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10514193May 30, 2013
ELECTRICAL SYSTEM
THE POWER WIRE COMING FROM THE ALTERNATOR (APPROX. 4 GAUGE WIRE CABLE & ENCASED IN PROTECTIVE SLEEVE), WEARS THRU BY RUBBING ON THE WIRES SUPPORT ASSEMBLY EXPOSING THE WIRE. THE WIRE SUPPORT ASSEMBLY LOCATED ON THE TRUCKS UNDERSIDE, THERE ARE (2) TWO INDIVIDUAL WIRE SUPPORTS, BOTH OF THESE ASSEMBLIES ARE RUBBING AT BOTH LOCATIONS EXPOSING THE POWER WIRE IN TWO PLACES. CREATING THE POTENTIAL FOR A FIRE HAZARD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10463034June 25, 2012
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 FREIGHTLINER COLUMBIA. THE CONTACT STATED THAT THE VEHICLE FAILED TO STOP WHEN THE BRAKE WAS APPLIED. A LOCAL MECHANIC INSPECTED THE VEHICLE. THE MEHCANIC STATED THAT THE BRAKE VALVE FAILED AND WAS ALLOWING AIR TO ESCAPE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 106,222.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10443850January 15, 2012
SERVICE BRAKES, HYDRAULIC
THE SPRING IN THE PARKING BRAKE CHAMBER FAILED, BROKE IN 3 PLACES. THEN PUNCTURED THE DIAPHRAGM CAUSING A MAJOR AIR LEAK, THE TRUCK IS EQUIPPED WITH FOUR SPRING BRAKE CHAMBERS, 3 OUT OF THE FOUR SPRINGS WERE BROKEN, THE CHAMBER THAT THE SPRING WAS NOT BROKEN WAS INSTALLED A FEW WEEKS PRIOR TO THE INCIDENT. WHEN THE AIR PRESSURE DROPPED TO 55 LBS, THAT CHAMBER STARTED TO APPLY THE PARKING BRAKE, THE TRUCK WAS OPERATING ON AN INTERSTATE HIGHWAY, AT 65 MPH, THE DRIVER DID NOT FEEL ONE WHEEL DRAGGING AND OPERATED THE VEHICLE UNTIL THE WHEEL GOT SO HOT THE TIRE BLEW, THE DRIVER HEARD THE TIRE BLOW,AND PULLED OVER, WHEN HE GO OUT OF THE TRUCK, THE SECOND TIRE BLEW, AND THE TRUCK STARTED ON FIRE, THE TRUCK BURNED AN WAS A TOTAL LOSS.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10438089December 2, 2011
FUEL SYSTEM, GASOLINE, SUSPENSION, ELECTRONIC STABILITY CONTROL (ESC)
LOW PRESSURE, ERG VALVE, LEAKAGE, AND THE LOST OF POWER THAT THE TRUNK CANT BE CONTROLLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409966June 29, 2011
TIRES
1990 FREIGHTLINER COLUMBIA, UNIT 1 WAS TRAVELING WESTBOUND ON THE OHIO TURNPIKE IN THE RIGHT LANE WHEN THE RIGHT TIRE OF THE TRAILER SUDDENLY CAME OFF THE RIM OF THE TRAILER. UNIT 1 CAME TO FINAL REST ON THE NORTH SIDE OF THE ROAD. *BF THE DRIVER STATED EVER SINCE THE COMPANY SWITCHED TO SUPER SINGLE TIRES, EVERYONE HAD BEEN EXPERIENCING SOME TYPE OF TIRE FAILURE. THE RIM WAS DAMAGED. (OHIO TRAFFIC CRASH REPORT # 10-0336-90)*JB UPDATED 8/30/11 *CN THE CONSUMER STATED THE TIRE BLOW OUT OCCURRED ON THE TRACTOR, NOT THE TRAILER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10404851June 1, 2011
TIRES
2005 FREIGHTLINER CONVENTIONAL, UNIT 1 AND 2 WAS TRAVELING WESTBOUND ON THE OHIO TURNPIKE, WHEN UNIT 1 RIGHT SIDE TRAILER TIRE BLEW CAUSING TIRE DEBRIS TO STRIKE UNIT 2. *BF (OHIO TRAFFIC CRASH REPORT# 10-0163-89)*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10404855June 1, 2011
ELECTRICAL SYSTEM
2005 FREIGHTLINER COLUMBIA, UNIT 1 NOTICED SMOKE FROM HIS TRAILER AS HE PULLED AWAY FROM THE BOOTH AT EXIT 142. UNIT 1 PULLED TO THE BERM ON THE ON THE RAMP AND FOUND THE TRAILER WAS ON FIRE. THE TRACTOR WAS DISCONNECTED FROM THE TRAILER AND PULLED AHEAD . *BF (OHIO TRAFFIC CRASH REPORT # 10-0264-90)
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10388728March 7, 2011
TRAILER HITCHES
2001 FREIGHTLINER COLUMBIA CLASS, UNIT 1 TRAILER BECAME DISCONNECTED. UNIT 1 TRAILER STRUCK THE POWER UNIT WHILE ATTEMPTING TO STOP. UNIT 1 POWER UNIT AND TRAILER CAME TO REST IN THE RIGHT LANE. *BF UPDATED 03/21/11 *BF (OHIO TRAFFIC CRASH REPORT # 10-0047-90) *JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10353149August 30, 2010
WHEELS:LUGS/NUTS/BOLTS/STUDS
2005 FREIGHTLINER COLUMBIA , SUFFERED A MECHANICAL FAILURE WITH LEFT REAR DRIVE AXLE DUAL ASSEMBLY. *BF THE ASSEMBLY DETACHED FROM THE SEMI AND CROSSED INTO THE EASTBOUND LANES. THE BOLTS HOLDING THE TIRE ON HAD COMPLETELY SHEARED OFF. (OHO TRAFFIC CRASH REPORT # 10-0316-89) *JB UPDATED 09/13/10*BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10348226August 9, 2010
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
2008 CAT C15 ACERT ENGINE SHUTS DOWN. WE HAVE 3 OF THESE UNITS IN CLASS 8 TRUCKS ALL HAVE NUMEROUS PROBLEMS WITH THE EXHAUST TREATMENT SYSTEM ALL HAVE BEEN IN FOR REPAIR MANY TIMES. WHEN THE SYSTEM FAILS THE ENGINE DERATES POWER CAUSING A TRAFFIC PROBLEM DUE TO SLOW MOVING VEHICLE ON AN INTERSTATE HIGHWAY, SOON AFTER IT DERATES THE ENGINE WILL SHUT DOWN COMPLETELY AGAIN A SAFETY ISSUE WITH A STALLED CLASS 8 VEHICLE STOPPED ON AN INTERSTATE HIGHWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10336844June 17, 2010
FUEL SYSTEM, DIESEL, SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
TL* THE CONTACT OWNS A 2006 COLUMBIA FREIGHTLINER. THE CONTACT STATED THE PLASTIC FUEL LINE FRACTURED. THE DEALER REPLACED THE PLASTIC FUEL LINE WITH A METAL FUEL LINE BUT IT ALSO FAILED. THE SEMI WAS NOT YET TAKEN TO THE DEALER FOR THE SECOND FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 500,000 UPDATED 8/18/10 *CN THE CONSUMER STATED WHEN HE PARKED, HE NOTICED THAT ALL OF THE BRAKES WERE SMOKING. THE CONSUMER STATED THE DEALER INFORMED HIM THERE WAS A RECALL. HOWEVER, HIS TRUCK WAS NOT INCLUDED. UPDATED 08/19/10*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10327701April 27, 2010
VISIBILITY:WINDSHIELD WIPER/WASHER
TL* THE CONTACT OWNS A 2007 FREIGHTLINER COLUMBIA 120 TRUCK. THE CONTACT STATED THAT THE WATER FROM THE FRONT WINDSHIELD WIPERS WOULD OBSTRUCT HIS VIEW WHENEVER IT WAS RAINING AND WATER WAS ON THE OUTSIDE REARVIEW MIRRORS. THE VEHICLE HAD NOT BEEN DIAGNOSED AND THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 1,000,000. UPDATED 06/15/10 *BF UPDATED 07/14/10.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10320468March 17, 2010
ENGINE AND ENGINE COOLING:ENGINE
TL* THE CONTACT OWNS A 2007 FREIGHTLINER COLUMBIA. UPON ATTEMPTING TO START THE VEHICLE, THE VEHICLE WOULD NOT RESPOND. THE DEALER REPLACED THE STARTER AND POWER STEERING PUMP IN AN ATTEMPT TO CORRECT THE FAILURE. THE FAILURE PERSISTED. THE CURRENT AND FAILURE MILEAGES WERE 413,238.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10317389March 6, 2010
VISIBILITY:WINDSHIELD
WINDSHIELD IS LEAKING AFTER 2 TIMES RESEALING BY DEALER THEY REPLACED WINDSHIELD WITH NEW ONE, ALL NEW PARTS, IT IS STILL LEAKING WORST THAN BEFORE AND THEY HAVE NO ANSWER FOR IT AND THEY DON'T KNOW WHERE THE PROBLEM IS ,I KNOW MORE DRIVERS WITH SAME PROBLEM .THE LEAK IS RIGHT IN THE MIDDLE MOLDING WHERE SEPARATES TWO WINDSHIELDS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312117February 18, 2010
EQUIPMENT
2006 FREIGHTLINER COLUMBIA LEFT FRONT MUDFLAP BROKE OFF VEHICLE AND STRUCK ANOTHER VEHICLE. *KB OHIO TRAFFIC CRASH REPORT # 10-0023-90 UPDATED LETTER 04/29/10 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Freightliner Columbia