Ford F-350 Complaints (2007)

61 consumer complaints on file.

#11678553August 5, 2025
TIRES:TREAD/BELT
GT Radial Adventuro AT3, 275/70R-18 Load Range E The tire exploded at 65mph while pulling a trailer. I still have what is left of it. The debris flying off the vehicle into traffic and the need to pull completely off the road. The sharp reduction of speed in traffic on a 4 lane divided highway. The tire has not been inspected by any official or company. I had purchased hazard insurance from Walmart when I bought the tires. They refused to honor the coverage due to the tire having no tread. The 2nd tire, purchased at the same time, was on the drivers side, but they refused to consider the tread remaining on that tire as an example of the blowouts previous tread. I have an active TPMS (tire pressure monitoring system) on the truck and no alarms went off prior to the explosion. It did alarm after the explosion. It is also mounted, where I as the driver, can monitor it. The blowout severely damaged my truck. My insurance indicates they will cover the cost of repairs after my deductible, but not replacement of the tires. My 2 million miles operating my own semi causes me to believe the tire was manufactured in a defective manner. I have never seen, or recall a non-retread tire shedding ALL of it's tread. Recaps generally will. I have contacted Walmart Corporate and Giti Tire. Neither has responded. Lucky only my truck was damaged and the highway scattered with debris for other travelers to encounter!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11612469September 4, 2024
ENGINE, FUEL/PROPULSION SYSTEM
Engine is the 2.7 Ecoboost and is becoming louder and louder with many ticks and sounds whether you are driving or idling the vehicle at a stop light. Every morning the engine ticks and revs very high and emits huge billowing white smoke from the exhaust whether it’s warm or cold outside. Believe the engine is needing to be replaced in the upcoming recall from ford for the exact engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11523994May 26, 2023
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
Diesel Fuel leaking into the coolant
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11473720July 13, 2022
SUSPENSION
Ford death wobble. Truck shakes violent and almost loses control driving at 60 miles per hour.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467253June 3, 2022
SUSPENSION, STEERING, UNKNOWN OR OTHER
This truck has the problem known as the “death wobble.” I bought the vehicle from Johnson City Ford in Johnson City Tennessee after they said they had inspected it and everything was fine on the truck. It was used so I bought the extended warranty. The truck started shaking so violently I couldn’t drive it. I took it back to this Ford place. They replaced the universal joint under my warranty. I left didn’t get it home and it started again shaking. I took it back to them and they confirmed the death wobble and said there were no recalls and they want 3600 dollars to fix the problem. I called Ford corporate and they said there were no recalls or programs to help with this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426850July 28, 2021
TIRES:TREAD/BELT
The contact owns a 2007 Ford F-350 equipped with Nitto tires, Tire Line: Dura Grappler, Tire Size: 275/65/18, DOT number: EAW2215. The contact stated that while driving the vehicle there was an abnormal sound coming from the rear of the vehicle. Upon inspection it was discovered that the driver’s side rear tire had experienced tread separation. The cause of the failure was not determined. The local dealer was notified of the failure and informed the contact that the tires were not included in NHTSA campaign number: 14T014000 (Tires) due to the manufacturing date of the tire. The contact indicated that the tire had experienced the same failure listed in the recall. The manufacture was not yet notified. The failure mileage was 30,000. Consumer stated thread separation happened with the second tire 2 weeks later. Manufacture was notified and all 4 tires have now been replaced prematurely.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11404669March 24, 2021
POWER TRAIN, WHEELS
TL* THE CONTACT OWNS A 2007 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE REAR WHEEL LOCKED UP WITHOUT WARNING. DUE TO THE FAILURE, THE CONTACT TEMPORARILY LOSS CONTROL OF THE VEHICLE BEFORE THE VEHICLE INDEPENDENTLY RETURNED TO NORMAL OPERATION. THE CONTACT HAD TAKEN THE VEHICLE TO FORD OF BRANFORD (301 E. MAIN ST, BRANFORD, CT 06405) ON THREE SEPARATE OCCASIONS HOWEVER, THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11365421October 20, 2020
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
SINCE I BOUGHT THIS 2007 FORD F 350 I'VE HAD NOTHING BUT PROBLEMS FUEL PUMP INJECTORS EGR COOLER FUEL FILTERS BRAKES THE TRUCK HAS BEEN IN TH E SHOP THREE TIMES SINCE I'VE HAD IT NOW I'M PRAYING DONT ANYTHING ELSE GO WRONG WHAT A WASTE.;
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11230126July 8, 2019
TIRES
TL* THE CONTACT OWNS A 2007 FORD F-350 SD EQUIPPED WITH BF GOODRICH ALL TERRAIN T/A TIRES, SIZE: LT275/70R18 LRE (NA). WHILE DRIVING 70 MPH, THE REAR DRIVER'S SIDE TIRE EXPLODED WITHOUT WARNING. THE FAILURE DAMAGED THE REAR DRIVER'S SIDE RIM, SUSPENSION, AND FENDER. THE CONTACT MANAGED TO PLACE A SPARE TIRE ON THE VEHICLE AND DRIVE HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE AND TIRE FAILURE MILEAGE WAS 27,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11143726October 29, 2018
ELECTRICAL SYSTEM
VEHICLE STARTED RUNNING VERY ROUGH WHEN GOING DOWN THE ROAD, AND HARD TO START. FOUND THE FICM WIRING HARNESS SMOKING AND CHAFED THROUGH WHERE IT HAD RUBBED ON ENGINE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11092264May 7, 2018
SUSPENSION
TL* THE CONTACT OWNS A 2007 FORD F-350. THE CONTACT RECEIVED FIELD ACTION NOTICE NUMBER: 09L02 FROM THE MANUFACTURER. WHILE DRIVING 40 MPH ON BUMPY TERRAIN, THE VEHICLE SHOOK. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED A LOCAL DEALER (BOB THOMAS FORD INC, 2215 DIXWELL AVE, HAMDEN, CT 06514, (203) 281-7500) AND WAS INFORMED THAT THERE WOULD BE A DIAGNOSTIC FEE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED DUE TO THE DIAGNOSTIC FEE. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE LOCAL DEALER, AND THAT THERE WOULD BE A CHARGE FOR VEHICLE INSPECTIONS. THE FAILURE MILEAGE WAS APPROXIMATELY 7,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11035129October 20, 2017
ENGINE
6.0 LITER DIESEL ENGINE NEEDS OIL COOLER & EGR COOLER REPLACED EVERY 100,000 MILES ACCORDING TO FORD MECHANICS. MY ENGINE HAD THIS PROBLEM AT 98,000 MILES. THE COOLER IS UNDERNEATH THE INTAKE MANIFOLD MAKING REPAIRS VERY EXPENSIVE. THE MECHANICS TELL ME TO WATCH FOR SMOKE, LESS POWER, ETC. AND TO PULL OFF THE SIDE OF THE ROAD AND CALL A TOW TRUCK WHEN I EXPERIENCE THOSE PROBLEMS OR I COULD DESTROY THE ENGINE. THEY SAID MY ENGINE OIL IS RUNNING MUCH HOTTER THAN MY ENGINE COOLANT WHICH COULD CAUSE OIL SEALS TO BEGIN LEAKING. THERE IS NO WAY TO VERIFY THIS PROBLEM. I DON'T HAVE A OIL TEMPERATURE GAUGE IN MY TRUCK JUST A OIL PRESSURE GAUGE. FORD NEEDS TO STOP SELLING THIS ENGINE OR REPAIR THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11016131August 18, 2017
POWER TRAIN, STEERING, SUSPENSION
WHEN GAINING SPEED ON HIGHWAY VEHICLE SHAKES TO THE POINT OF INSTABILITY - AFRAID TO DRIVE STOCK TIRES NOT THE PROBLEM HAVE CHECKED THE ALIGNMENT -TWICE CANNOT LOCATE ISSUE NO RECALL ISSUED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10873035June 7, 2016
SUSPENSION, WHEELS, STEERING
THERE IS AN ISSUE THAT IS KNOWN TO THE FORD MOTOR COMPANY INVOLVING THIS TYPE OF VEHICLE WHICH IS SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS. I HAVE RECEIVED AT LEAST TWO LETTERS FROM FORD CONCERNING THIS ISSUE. THE ONE I HAVE BEFORE ME IS LISTED AS LITERATURE PROGRAM 09L02. IT STATES THAT FORD AND NHTSA ARE STUDYING THE ISSUE. UNFORTUNATELY THAT DOES LITTLE GOOD FOR ME AS MY VEHICLE IS BASICALLY AN ACCIDENT WAITING TO HAPPEN. THE SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS RENDER THE VEHICLE UNSAFE TO DRIVE AS THEY (THE SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS) HAPPEN WITH NO PROVOCATION AT TIMES AND THE VIBRATIONS BECOME SO VIOLENT THAT KEEPING CONTROL OF THE STEERING WHEEL IS EXTREMELY DIFFICULT, ADDITIONALLY CONTROLLING THE VEHICLE IS IMPOSSIBLE. I HAVE HAD THE SEVERE STEERING WHEEL AND FRONT WHEEL VIBRATIONS OCCUR AT SPEEDS FROM @20MPH TO 55MPH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10840411March 7, 2016
TIRES, TIRES:TREAD/BELT
MICHELIN TIRES DRY ROTTING AND CRACKING 4 YEARS OLD, SIMILAR TIRES RELLED BY MICHELIN BUT NOT MINE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10819569January 11, 2016
STEERING
WAS DRIVING 60MPH ON INTERSTATE WHEN I HAD A DIP IN THE ROAD AND THE TRUCK WOBBLED AND SHIMMIED SO I HAD TO REDUCE SPEED TO GET IT BACK UNDER CONTROL. TIRE PRESSER WAS CORRECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10818907January 8, 2016
SERVICE BRAKES, SUSPENSION
TL* THE CONTACT OWNS A 2007 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 55 MPH OVER A BUMP, THE FRONT END OF THE VEHICLE AND STEERING WHEEL BEGAN TO VIBRATE VIOLENTLY. THE FAILURE OCCURRED WHEN DRIVING 55 MPH OR GREATER OVER AN UNEVEN ROAD SURFACE OR BUMP. THE CONTACT REPAIRED THE VEHICLE HIMSELF. THE FRONT SHOCKS, ROTORS, AND BRAKES WERE REPLACED. IN ADDITION, THE FRONT WHEEL BEARINGS WERE REPLACED WITH FOUR NEW TIRES INSTALLED ON THE VEHICLE. THE FAILURE PERSISTED AFTER THE REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10682044February 9, 2015
TIRES
WE WERE DRIVING ON THE FREEWAY, AND JUST STARTED CLIMBING THROUGH THE MOUNTAINS, WITH OUR F350 TOWING OUR TRAILER. WE NOTICED A STRANGE SOUND FROM THE TIRES AND DECIDED TO PULL OVER AT THE NEXT EXIT TO CHECK IT OUT. BEFORE REACHING THE EXIT, THE DRIVERS SIDE REAR TIRE BLEW. WE HAD BF GOODRICH ALL TERRAIN TIRES ON OUR TRUCK THAT HAD 18,000 MILES ON THEM AND THE TREAD COMPLETELY SEPARATED AND DAMAGED OUR TRUCK BED WHICH CAUSED $10,000 WORTH OF DAMAGE. WE WERE FORTUNATE THAT MY HUSBAND WAS TRAINED WHAT TO DO IN SUCH SITUATIONS WHICH PREVENTED US HAVING AN ACCIDENT AS WE COULD HAVE LOST CONTROL OF THE TRAILER VERY EASILY. FORTUNATELY, THE TRUCK WAS STILL DRIVE-ABLE AFTER TAKING OFF A SUPPORT BRACKET AND PUTTING THE SPARE TIRE ON. AFTER GETTING TO A CITY WITH A TIRE STORE, WE ENDED UP PURCHASING 2 NEW TIRES SO THAT THE REAR AXLE HAD A MATCHED SET. WE PURCHASED THE SAME TYPE OF TIRE AS WE PREVIOUSLY HAD AS WE NEVER HAD A PROBLEM BEFORE AND THOUGHT IT WAS JUST A FLUKE. BUT AFTER READING REVIEWS AFTER BEING AT HOME, I'M WISHING WE LOOKED INTO OTHER OPTIONS. UNFORTUNATELY, WHEN YOU ARE ON A TRIP, IT ISN'T THE BEST TIME TO RESEARCH TIRES. WE HAD THE TIRE SUBMITTED TO MICHELIN, BUT THEY ARE SAYING IT WASN'T A DEFECTIVE TIRE. GLAD WE HAVE INSURANCE TO FIX OUR TRUCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10670084January 5, 2015
STEERING, SUSPENSION
EXTREME DEATH WOBBLE!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10608629July 7, 2014
TIRES, TIRES:TREAD/BELT
FEDERAL COURAGIA M/T LT265/70R17E TIRES PURCHASED JAN2013. TWO TIRES HAD BELT SEPARATE IN MAY2014. THE FIRST TWO TIRES WERE REPLACED BY MY LOCAL TIRE SHOP. ANOTHER TIRE SUFFERED COMPLETE TREAD SEPARATION ON JUNE2014. THE LOCAL TIRE SHOP ASSURED ME THAT THEY WILL ALSO REPLACE THE TIRE THAT CAME APART AND ASKED ME TO PROVIDE BODY ESTIMATES TO REPAIR THE DAMAGE CAUSED BY THE TIRE SO THEY CAN SUBMIT THEM TO TIRE DISTRIBUTOR. THE TIRES HAVE APPROX. 15,000 MILES ON THEM. THESE TIRES ARE INSTALLED ON A 2007 FORD F-350 4X4 WITH A 5.4L GAS ENGINE. THE TIRES ARE PEELING OFF AS IF THEY WERE RECAPPED TIRES BUT THEY ARE NOT RECAPS. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-350