Ford F-250 Complaints (2003)

294 consumer complaints on file.

#10341298July 3, 2010
ENGINE AND ENGINE COOLING
WHILE DRIVING DOWN THE ROAD, A SPARK PLUG BLEW OUT OF THE ENGINE ON MY 2003 V10 TRITON F250 TRUCK. IT HAS 86,000 MI. AND STILL HAS THE FACTORY SPARK PLUGS IN IT AT THE FACTORY TORQUE SETTINGS. THE SPARK PLUG EXPLODED OUT OF THE ENGINE AND COULD HAVE POTENTIALLY CAUGHT THE ENGINE ON FIRE (I READ IN SOME CASES WHERE IT DID CATCH THE ENGINE ON FIRE WITH THE SAME INCIDENT). IT CAUSED SOME INTERNAL DAMAGE WHEN BLOWING OUT OF THE ENGINE, BUT THE PLUG WAS NO WHERE TO BE FOUND. I HAVE NOTICED THAT FORD HAS A PROBLEM, WITH THIS PARTICULAR VEHICLE AND OTHERS, WITH THE SPARK PLUGS EJECTING OUT OF THE HEAD, BUT HAS DONE NOTHING TO FIX THE PROBLEM WITH THEIR ENGINEERING DEFECT. I NOTICED THAT THE HEAD ONLY HAS THREE THREADS HOLDING THE SPARK PLUG IN PLACE AND THAT IS NOT ENOUGH TO HOLD ONE IN PLACE WITH AN ALUMINUM HEAD. THE POTENTIAL SAFETY HAZARD WITH THIS PROBLEM IS HIGH AND VERY SEVERE. I FEEL LIKE I NEED TO REPLACE ALL THREADS AND SPARK PLUGS BEFORE THIS INCIDENT HAPPENS AGAIN AND AGAIN. IF ONE SPARK BLEW OUT THAN IT IS JUST A MATTER OF TIME BEFORE ANOTHER ONE BLOWS OUT POTENTIALLY CATCHING FIRE AND/OR CAUSING INJURY OR DEATH. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10333847May 29, 2010
SUSPENSION:FRONT
I OWN A 2003 F-250 SUPERDUTY EXTENDED CAB TWO WHEEL DRIVE FORD PICK-UP, THE FRONT END WILL SHAKE VIOLENTLY AT AROUND 55 MILES AN HOUR WHEN YOU HIT A BUMP IN THE ROAD OR EVEN MAKING A SLIGHT RIGHT HAND CURVING TURN ON THE HIGHWAY. IT IS SO BAD THAT I HAVE TO PULL OF THE HIGHWAY TO KEEP CONTROL OF THE TRUCK. I REPLACED THE SHOCKS WITH MONROE GAS MAGNUM SHOCKS , NO CHANGE FOR THE BETTER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10331931May 24, 2010
STEERING
THE FRONT END VIBRATES AND OSCILLATES WHEN I HIT A BUMP OR ROUGH ROAD CONDITIONS DRIVING BETWEEN 30 AND 50 MPH. THERE IS MORE SLACK IN THE STEERING, AND I HAVE TO SPEED UP ABOVE 50 MPH OR SLOW DOWN BELOW 30 MPH OR JERK THE WHEEL FROM SIDE TO SIDE IN ORDER TO STOP THE SHAKING. THIS OCCURS EVERY TIME WE DRIVE THE TRUCK. THE TIRES HAVE BEEN CHECKED, AND FROM RESEARCHING, IT APPEARS THAT THERE IS A FAULTY STEERING BOX, BUT FORD REFUSES TO ACKNOWLEDGE THE DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10330804May 17, 2010
ENGINE AND ENGINE COOLING
MY 2003 FORD F 250 SHOT A SPARK PLUG OUT - MECHANIC LOOKED INSIDE AND SAID ALL THE THREADS HAD BEEN RIPPED OUT AND HAS HAD THIS ISSUE WITH SEVERAL OTHER FORD PICKUPS IN RECENT MONTHS. OBVIOUSLY A PROBLEM AS THIS IS A SMALL TOWN AND NOT THAT MANY FORD PICKUPS AROUND. 2 OPTIONS TO FIX REPLACE THE HEADS OR RETAP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328142April 29, 2010
SERVICE BRAKES, HYDRAULIC
I OWN A 2003 FORD F250 7.3 LITER DIESEL PICKUP. ON INSPECTION, REQUIRED BY PA LAW FOR SAFETY REASONS, IT FAILED BECAUSE OF ROTOR RUST. I THEN HAD TO REPLACE ALL FOUR BRAKES AND ROTORS AT A CONSIDERABLE COST TO ME. . THE TRUCK HAD 33,309 MILES ON IT AND WAS STORED AND USED SIMILAR TO THREE OTHER OLDER VEHICLES I OWNED THE SAME THING OCCURRED ON THIS TRUCK AT 19,750 MILES WHEN IT WAS 3 YEARS OLD. THE EARLIER RUST ISSUE WAS COVERED UNDER WARRANTY. RUSTING BRAKE PADS ARE UNACCEPTABLE IN TODAY'S WORLD. I HAVE NEVER HAD THIS TYPE OF PROBLEM IN THE PAST AND SUSPECT FORD IS USING SUB STANDARD STEEL. OTHER PARTS ON THIS TRUCK HAVE RUSTED OUT AND I WILL ENTER SEPARATE REPORTS ON THOSE PROBLEMS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328147April 29, 2010
ENGINE AND ENGINE COOLING
I JUST ENTERED A SAFETY COMPLAINT REGARDING BRAKE ROTORS RUSTING (( 10328142 ) ON MY 2003 FORD F250 7.3 L DIESEL. THIS COMPLAINT REGARDS RUSTING OUT RADIATOR HOSE BRACKETS. ON JULY 6 TH 2007 A RADIATOR HOSE CLAMP RUSTED OUT , AND I RAPIDLY LOST COOLING, WHILE ON INTERSTATE 68 IN MD TRAVELING AT 65 MPH TOWING A TRAVEL TRAILER. I MANAGED TO STOP THE VEHICLE AND TRAILER SAFELY BUT HAD TO BE TOWED TO A DEALER FOR REPAIRS. THIS WAS ON A 4 YEAR OLD TRUCK.( JUST RECENTLY IN CONJUNCTION WITH THE ROTOR PROBLEM A WIRING CLAMP RUSTED OUT UNDER THE BODY LEAVING LOOSE DANGLING WIRES. AT THE TIME I THOUGHT IT WAS A SINGLE RUSTING ISSUE. NOW THAT I AM EXPERIENCING MULTIPLE FAILURES I KNOW THE PROBLEMS ARE MORE EXTENSIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10325701April 14, 2010
TIRES, TIRES:TREAD/BELT
WE WERE RETURNING HOME AND PULLING OUR RV WHEN THE RIGHT REAR TIRE SHED ALL THE SURFACE COVER BUT DID NOT LOSE IT'S AIR AND ALMOST CAUSED US TO CRASH. THE TIRE IS A UNIROYAL LT 265-75-R16 MADE BY MICHLIN. I NOW HAVE 2500.00 IN TRUCK DAMAGES AND NO RECOURSE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10324160April 7, 2010
VEHICLE SPEED CONTROL
CRUISE CONTROL DOES NOT WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10321859March 24, 2010
ENGINE AND ENGINE COOLING:ENGINE
I WAS DRIVING MY 2003 FORD F-250 WHEN A SPARK PLUG BLEW OUT OF THE CYLINDER HEAD BREAKING THE COIL, AND CAUSING THE TRUCK TO RUN ON 7 CYLINDERS. MY TRUCK HAS ONLY 72340 MILES ON IT AND THOSE ARE THE ORIGINAL SPARK PLUGS FROM THE FACTORY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10317529March 7, 2010
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
THIS THE SECOND TIME MY 2003 FORD F-250 V/10 HAS EJECTED A SPARK-PLUG. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10295283December 10, 2009
POWER TRAIN:DRIVELINE
2003 FORD F250 FRONT AUTO LOCKING HUBS NOT WORKING (FAIL TO UNLOCK OR LOCK) CAUSING CV JOINTS TO FAIL FOR THE SECOND TIME!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10289524October 23, 2009
TIRES, STEERING
TL* THE CONTACT OWNS A 2003 FORD 250 WITH GENERAL GRABBER AT2 TIRES; SIZE 235/85/16. WHILE DRIVING APPROXIMATELY 65 MPH THE VEHICLE BEGAN TO DRIFT ACROSS THE ROADWAY. HE THEN DRIVER REDUCED THE VEHICLES SPEED TO 50 MPH. AFTER TWO NEW TIRES WERE MOUNTED ON THE VEHICLE THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TIRES AT THIS TIME HAVE NOT BEEN DETERMINED AS THE CAUSE OF FAILURE. THE STEERING ASSEMBLY WAS REPAIRED, BUT THE FAILURE CONTINUED. THE FAILURE MILEAGE WAS 131,681. THE CURRENT MILEAGE WAS 132,000. UPDATED 12/08/09. *LJ UPDATED 12/10/09
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10282815September 3, 2009
POWER TRAIN:DRIVELINE, ENGINE AND ENGINE COOLING
I HAVE A 2003 FORD F250 WITH 73K MILES ON IT, AND I TOO AM ANOTHER VICTIM OF A SPARK PLUG BLOWING OUT OF MY 4TH CYLINDER ON THE PASSENGER SIDE OF MY TRUCK. WHY IS FORD NOT DOING ANYTHING ABOUT THIS. AS MUCH AS WE PAY FOR THESE CARS AND TRUCKS, YOU WOULD THINK THEY WOULD MAKE THINGS RIGHT. NO WONDER U.S. AUTO MAKERS ARE FAILING. JUST MORE CORPORATE GREED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10281653August 25, 2009
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
TL*THE CONTACT OWNS A 2003 FORD F-250HD. THE CONTACT STATED THAT WHILE DRIVING AT ANY GIVEN SPEED THE VEHICLE WOULD JERK. THE VEHICLE WAS TAKEN TO A DEALER AND INSPECTED WHERE IT WAS DETERMINED THAT THE FAILURE OCCURRED FROM THE INJECTOR WIRE HARNESS. THE VEHICLE WAS REPAIRED AT A COST OF $100.00. FOUR YEARS LATER THE CONTACT NOTICED A ANTIFREEZE SMELL IN THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER AND INSPECTED WHERE IT WAS DETERMINED THAT THE OIL COOLER HAD FAILED. THE VEHICLE WAS REPAIRED AT A COST OF $844.00. THREE MONTHS LATER THE CONTACT ATTEMPTED TO START THE VEHICLE AND THE VEHICLE WOULD NOT START. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO A DEALER FOR FURTHER INSPECTION. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED TO TAKE THE VEHICLE TO A DEALER FOR FURTHER INSPECTION. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE IS 76,286. BL THE DEALER DETERMINED THE HIGH PRESSURE OIL PUMP AND INJECTOR FAILED. THE ANTI-LOCK BRAKES WERE INOPERATIVE AS WELL. UPDATED 10/07/09.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10279670August 7, 2009
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, ELECTRICAL SYSTEM:WIRING
TL*THE CONTACT OWNS A 2003 FORD F250 SUPER DUTY. WHILE DRIVING 15 MPH, THE CHECK ENGINE LIGHT ILLUMINATED IN THE VEHICLE. SHORTLY AFTER, HE NOTICED THAT THE VEHICLE BARELY ACCELERATED WHILE PULLING OUT OF A PARKING SPACE. THE VEHICLE WOULD ALSO STALL AT LOW SPEEDS. ONCE HE RESTARTED THE ENGINE, THE VEHICLE WOULD OPERATE NORMALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THEY WOULD DIAGNOSE THE FAILURE. THE DEALER STATED THAT THE VEHICLE NEEDED A NEW INJECTION CONTROL PRESSURE SENSOR MODULE (ICP) INSTALLED IN THE VEHICLE. THROUGH RESEARCH, HE FOUND NHTSA CAMPAIGN ID NUMBER 05V270000, NHTSA ACTION NUMBER EA05003 (ELECTRICAL SYSTEM:WIRING). IN 2004, A 2004 ENGINE WAS PLACED IN THE VEHICLE. HE BELIEVES THAT THE VEHICLE WAS EXPERIENCING THE SAME DEFECT BECAUSE IT HAD A 2004 ENGINE. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 61,000. UPDATED 08/31/09 *BF UPDATED 09/03/09.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10278823July 30, 2009
ENGINE AND ENGINE COOLING:ENGINE
TRAVELING AT 52MPH SPARK PLUG BLEW OUT. 2003 FORD F250 5.4L. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10276347July 10, 2009
FUEL SYSTEM, DIESEL
I HAVE A 2003 FORD F250 W 7.3 DIESEL. LAST YEAR IT BROKE DOWN,JUST QUIT, FINALLY STARTED, NEED A NEW IN TANK PUMP, WAS TOLD BY FORD DEALER IT HAD ?!@#$% IN THE TANK, SPENT $1000. 2 WEEKS AGO IT START MESSING UP AGAIN. FORD SAID IT NEEDED A NEW COMPUTER,3 DAYS AFTER REPAIRED IT STARTED BUCKING AGAIN.FORD COULD NOT FIND ANYTHING. AFTER MAKING SEVERAL INQUIRES, I FIND FORD HAS A SERIOUS PROBLEM WITH THE COATING COMING OFF INSIDE THE FUEL TANK AND WREAKING PUMPS, FILTERS INJECTORS ETC. ALSO THEY ARE REFUSING TO DO ANYTHING. SINCE THIS CAN BE VERY DANGEROUS, QUITTING AT ANY TIME, I HOPE NHTSA WILL MAKE FORD FIX THIS PROBLEM OR ADVISE WHERE TO JOIN A CLASS ACTION SUIT, SINCE IM TIRED OG SPENDING MONEY AND NOT ABLE TO FINALLY FIX THIS PROBLEM AND DEPEND ON MY TRUCK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10272710June 2, 2009
ENGINE AND ENGINE COOLING:ENGINE
I HAVE A 2003 FORD F250 WITH THE 5.4L ENGINE WITH ABOUT 80,000 MILES. I PURCHASED THE TRUCK NEW. THE NUMBER 3 OEM SPARK PLUG BACKED OUT AND BLEW OUT OF THE HEAD. I CONTACTED FORD, THEY RECOMMENDED I COVER ALL EXPENSES AND HAVE IT TOWED AND REPAIRED AT FORD DEALERSHIP. I PAID A LOCAL MECHANIC TO REPAIR IT. HE IS UNSURE WHAT WILL HAPPEN IN THE FUTURE. HE SAID IT COULD BE DANGEROUS AND MIGHT CAUSE A FIRE IF IT HAPPENS AGAIN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10267896May 6, 2009
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2003 FORD F250 SUPER DUTY. WHILE DRIVING 70 MPH, THE VEHICLE SHUT OFF. THE CONTACT LOST CONTROL OF THE POWER STEERING AND BRAKES. THE FAILURE OCCURS AT LEAST FORTY TIMES PER WEEK. THE CONTACT STATED THAT HE MUST TURN OFF THE VEHICLE AND GIVE IT TIME TO RESTART. HE IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR INSPECTION. THE MANUFACTURER IS AWARE OF THE FAILURE, BUT WILL NOT PROVIDE COMPENSATION SINCE THERE ARE NO RECALLS FOR THE ISSUE. THE FAILURE MILEAGE WAS 130,000 AND CURRENT MILEAGE WAS 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10267369April 30, 2009
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
TL*THE CONTACT OWNS A 2003 FORD F250 SUPER DUTY. WHILE DRIVING 65 MPH, THE VEHICLE SUDDENLY STALLED AND SHUT OFF. THE VEHICLE WAS UNABLE TO BE RESTARTED AND WAS TOWED TO THE CONTACT'S RESIDENCE. A FEW DAYS LATER, THE VEHICLE STILL FAILED TO START AFTER A FEW ATTEMPTS. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT A NEW FUEL INJECTION CONTROL MODULE WAS NEEDED. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE IS CURRENTLY BEING REPAIRED AT THE CONTACT'S EXPENSE, BUT HE BELIEVES THAT IT SHOULD HAVE BEEN INCLUDED IN THE RECALL. THE CURRENT AND FAILURE MILEAGES WERE 58,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250