Ford Explorer Complaints (1992)

633 consumer complaints on file.

#10702264March 27, 2015
FUEL SYSTEM, GASOLINE, POWER TRAIN, ENGINE
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. WHILE REVERSING, THE VEHICLE LOST POWER. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 444,980. UPDATED 5/18/15*CN THE REPAIR SHOP REPLACED THE FUEL VAPOR CANISTER. ALSO, THE VEHICLE WOULD NOT GO IN REVERSE. UPDATED 06/02/15*JB
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10548921October 22, 2013
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
MY CAR CAUGHT FIRE AT PARKING LOT WHEN I TRIED STARTING IT UP AFTER MY GIRLS AND I GOT BACK IN CAR AFTER BEING AT MALL FOR ABOUT 2 HOURS FLAMES COMING OUT FROM BOTTOM AND TOP OF ENGINE AND FRONT DASH. THANK GOD WE GOT OUT IN TIME. MY CARS ELECTRICAL WIRES FOR EVERYTHING IS MELTED AND IM UNSURE HOW MUCH MORE IS DAMAGED SINCE IM NOT A MECHANIC. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10498360February 16, 2013
SEAT BELTS
DRIVER'S SIDE SEAT BELT LATCH (FEMALE PIECE) DISENGAGED WHILE DRIVING. LATCH WILL NO LONGER STAY ENGAGED WITH THE MALE PART OF THE SEAT BELT IN A RELIABLE MANNER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468013July 27, 2012
ENGINE
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT HE ATTEMPTED TO STOP THE VEHICLE, BUT THE VEHICLE CONTINUED TO ACCELERATE. THE CONTACT SLAMMED THE GEAR INTO PARK AND TURNED THE ENGINE OFF. UPON RESTART, THE VEHICLE FUNCTIONED AS NORMAL. THE CONTACT STATED THAT HE INSPECTED THE VEHICLE AND NOTICED THAT THERE WAS A PIECE OF PLASTIC IN THE HOSE THAT RAN FROM AIR FILTER TO THE AIR INTAKE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 102,000. UPDATED 08/28/12*LJ THE CONSUMER STATED THAT IT IS ALSO IMPORTANT TO NOTE THAT THE RUBBER RING UNDER THE C-CLAMP- THAT THE PLASTIC HOSE IS ATTACHED TO THE AIR-INTAKE WITH WAS THE REASON FOR THE MALFUNCTION. THE RUBBER CORRODED TO THE POINT THAT A PIECE OF IT BROKE OFF AND WAS SUCKED INTO THE ENGINE. THE ENTIRE HOSE HAD TO BE REPLACED BECAUSE THAT PART ISN'T SOLD SEPARATELY. UPDATED 09/05/2012 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10456084April 23, 2012
WHEELS, TIRES:TEMPORARY/EMERGENCY SPARE TIRE
I WAS TRAVELING DOWN HIGHWAY AND THE SPARE TIRE CABLE BROKE AND THE WHEEL FELL OUT AND GOT JAMMED UNDER THE EXPLORER. LUCKILY I SOME HOW WAS ABLE TO GET PULLED OVER BEFORE THEIR WAS AN ACCIDENT. AFTER THAT HAD HAPPEN I FOUND OUT THAT THEY HAD A RECALL ON THE CABLES DUE TO THEM BREAKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10456111April 23, 2012
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THERE WERE NUMEROUS CRACKS NEAR THE REAR WINDSHIELD, NEXT TO THE MANUFACTURING EMBLEM.THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10446007January 31, 2012
SERVICE BRAKES, HYDRAULIC, ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKES AT LOW SPEEDS, SHE NOTICED A GRINDING NOISE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HER THAT THE FRONT DRIVER AND PASSENGER SIDE BRAKES AND ROTORS NEEDED TO BE REPLACED. IN ADDITION, WHEN TURNING THE HEATER ON SHE COULD SMELL ANTI-FREEZE AND ALSO NOTICED A LEAK. THE INDEPENDENT MECHANIC ADVISED HER THAT THE HEATER COIL AS WELL AS THE BRAKE LINES NEEDED TO BE REPLACED DUE TO SEVERE RUSTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN CONTACTED. THE FAILURE AND THE CURRENT MILEAGES WERE UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415214July 26, 2011
SEAT BELTS
DRIVER'S SEAT BELT SOCKET NO LONGER LATCHES. FORD DEALER ADVISES REPLACEMENT IS DISCONTINUED. AFTER MARKET ALTERNATIVES NOT AVAILABLE. WITH "CLICKET OR TICKET" PROGRAMS IN PLACE VEHICLE BECOMES INOPERATIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10331433May 20, 2010
SERVICE BRAKES, HYDRAULIC:POWER ASSIST
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THE BRAKE PEDAL WOULD FEEL SPONGY WHEN DEPRESSED AND WOULD INCREASE STOPPING DISTANCE. THE VEHICLE PREVIOUSLY RECEIVED REPAIRS UNDER NHTSA RECALL CAMPAIGN ID NUMBER 96V024001 (SERVICE BRAKES, HYDRAULIC: POWER ASSIST: HYDRAULIC). THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED THAT THERE WAS A MISSING STUD AND NUT FROM THE MASTER CYLINDER. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS ALREADY REPAIRED UNDER THE RECALL CAMPAIGN AND WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 220,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10282669September 2, 2009
STEERING, SUSPENSION:FRONT
TL*THE CONTACT OWNS A 1992 FORD EXPLORER XLT. THE CONTACT STATES WHILE DRIVING APPROXIMATELY 55 MPH ON NORMAL ROAD CONDITIONS. THERE WAS A LOUD SQUEALING NOISE COMING FROM THE FRONT END OF THE VEHICLE . THERE WAS ALSO EXCESSIVE VIBRATION. THE DRIVER CONTINUED OPERATION WITH CAUTION. WHENEVER THE SPEED RATE WAS REDUCED THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10268682May 13, 2009
ELECTRICAL SYSTEM
WENT TO FORD DEALER 3 MONTHS AGO ABOUT CHECK ENGINE LIGHT SAID OXYGEN SENSOR OR COLD WEATHER IT BE FINE ON MY WAY HOME SUNDAY IT HAD A BAD MISS THEN FIRE SHOT THROUGH MY FLOOR BOARD AND DASH ALL MY DOORS INSTANTLY LOCKED I BARELY MADE IT OUT OF MY VEHICLE IF WIFE AND CHILDREN HAD BEEN IN PROB WOULDN'T BE HERE AT THE SECOND I MADE IT OUT OF MY CAR I TURNED AND WATCHED THE STEERING WHEEL HIT THE SEAT I OWN I 1992 FORD EXPLORER I CAN BE REACHED I HAVE CONTACTED AN ATTORNEY LOCALLY. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10229659June 2, 2008
STRUCTURE
TL*THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT THE RIGHT HYDRAULIC LIFT BRACKET DETACHED FROM THE VEHICLE. AS A RESULT, THE LIFT GATE FELL ON THE CONTACTS HEAD. THE CONTACT SUSTAINED BRUISES TO THE BACK OF THE HEAD. THERE IS A RECALL FOR THE STRUCTURE: BODY: HATCHBACK/LIFTGATE: SUPPORT DEVICE (NHTSA CAMPAIGN ID #95I007000) HOWEVER, THE DEALER STATED THAT HIS VIN WAS NOT INCLUDED. THE CONTACT FELT THAT HIS VEHICLE SHOULD HAVE BEEN INCLUDED. THE FAILURE MILEAGE WAS 250,000 AND CURRENT MILEAGE WAS 255,000.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10215889January 24, 2008
STEERING: STEERING WHEEL/HANDLE BAR
A BLACK TAR-LIKE SUBSTANCE IS LEAKING OUT OF THE STEERING WHEEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10215892January 24, 2008
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
DRIVING DOWN THE ROAD, SMOKE STARTED POURING FROM THE AIR VENTS. COULD FIND NO SOURCE FOR THE SMOKE. AFTERWARDS, ONLY FAN SPEED THAT WORKS IS HIGH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10215895January 24, 2008
VISIBILITY:REAR WINDOW WIPER/WASHER
STARTED UP VEHICLE IN MORNING, REAR WIPER CAME ON AUTOMATICALLY AND COULD NOT SHUT IT OFF. HAD TO REMOVE WIPER AS IT COULD NOT BE STOPPED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10213906January 2, 2008
ENGINE AND ENGINE COOLING, POWER TRAIN:AUTOMATIC TRANSMISSION
1992 FORD EXPLORER REPLACEMENT TRANSMISSION NEEDED. CONSUMER STATES THAT THE VEHICLE NEEDS A NEW TRANSMISSION AND OIL LEAK FIXED. SHE DOES NOT HAVE THE MONEY AND THE REPAIRS WILL COST AROUND $1500.00. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201550August 28, 2007
TIRES
FIRESTONE TIRE RECALL/ REPLACEMENT FOR FORD EXPLORER CUSTOMER STATES THAT FIRESTONE REFUSED TO PROVIDE WARRANTY SERVICE**CC THE CONSUMER STATED HAD A PROBLEM WITH A TIRE RECALL ISSUED FOR HIS SPECIFIC VEHICLE. THE CONSUMER STATED TOOK THE VEHICLE IN FOR SERVICE ON THE RECALL BUT NOTICED THE DEALER INSTALLED PASSENGER CAR TIRES ON HIS TRUCK. THE CONSUMER STATED THAT THE PASSENGER TIRES WERE .75 INCHES SMALLER, THE CONSUMER STATED THE DEALER INFORMED HIM WHEN PERFORMING THE RECALL HE COULD USE ANY TIRE SIZE HE WANTED TO AND IT DIDNT HAVE TO BE COMPARABLE TO THE OLD TIRES. THE CONSUMER FURTHER STATED WHILE THIS IS A SPARE TIRE HE FEELS VERY UNSAFE IF SOMETHING SHOULD HAPPEN TO HIS TIRES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188572April 23, 2007
VEHICLE SPEED CONTROL:CRUISE CONTROL
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. WHILE AT A STOP SIGN SMOKE ASCENDED FROM UNDERNEATH THE HOOD, AND CONTACT COULD SMELL SOMETHING BURNING. AFTER ALL PASSENGERS EXITED THE VEHICLE FLAMES IGNITED FROM THE HOOD. THERE WERE NO INJURIES. THE FIRE DEPARTMENT PUNCTURED THE HOOD DUE TO THE FLAMES. HOWEVER, THEY OPENED THE HOOD AND EXTINGUISHED THE FIRE. THERE WERE NO WARNING INDICATOR LIGHTS PRESENT PRIOR TO THE FAILURE. ON APRIL 16, 2007 THE OIL WAS CHANGED AND THE FLUIDS WERE AT NORMAL LEVELS. THE FIRE DEPARTMENT DIAGNOSED THE FAILURE AS THE CRUISE CONTROL, AND STATED THAT THIS WAS A KNOWN OCCURRENCE FOR FORD VEHICLES. THE CURRENT AND FAILURE MILEAGES WERE 111,130.*AK
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10187579April 11, 2007
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
TL*THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE BEGAN PRODUCING A KNOCKING NOISE. THERE WERE NO WARNING INDICATORS. THE DEALER DIAGNOSED THE VEHICLE AS NEEDING A NEW TIMING CHAIN, BUT THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 103,000.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10181725February 5, 2007
POWER TRAIN:AUTOMATIC TRANSMISSION
TL* - THE CONTACT PURCHASED A 1992 FORD EXPLORER IN 1999 AND HAD TRANSMISSION PROBLEMS ON 2002, 2003, 2006. THE TRANSMISSION WAS REPLACED TWICE, BUT THE VEHICLEINOPERABLE. THERE WERE NO RECALLS ON THIS VEHICLE REGARDING TRANSMISSION FAILURES. WWW.CARCOMPLAINTS.COM HAD A DEFECT INVESTIGATION NUMBER: EA93004 UNDER LEMON LAWS REGARDING THIS VEHICLE. THE CONTACT WANTED TO FILE A COMPLAINT WITH FORD REGARDING THIS PROBLEM. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Explorer