Ford Expedition Complaints (2018)

383 consumer complaints on file.

#11729374April 6, 2026
ENGINE, POWER TRAIN
Vehicle experienced catastrophic timing system failure causing engine to jump time and stall at idle, creating a safety hazard due to risk of sudden loss of power. This is a repeat issue originally documented under warranty (2020) and again during recall/service program 21N03 (2021), where repair was declined as “not severe enough.” Recall 24E13 (software update intended to prevent timing chain failure) was completed in 2025, but failed to prevent this exact condition. Vehicle is now inoperable and unsafe. This raises concerns about the effectiveness of the recall remedy and prior service handling. We've also submitted a case to Ford: CXH07545978W9W1D2
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726870March 24, 2026
POWER TRAIN, VEHICLE SPEED CONTROL
"Verified internal hydraulic cross leak due to CDF drum bushing movement. Transmission has delayed engagement in 4th, 5th, and 6th gears. This is a known manufacturing defect in the 10R80 transmission."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726084March 21, 2026
POWER TRAIN
The CDF drum is starting to fail and it will shift from a low gear to a high gear at certain speeds. It’s definitely not safe and is extremely expensive to repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726007March 21, 2026
ENGINE
I am writing to express concern regarding a significant engine issue with my 2018 Ford Expedition. At approximately 122,000 miles, the vehicle developed a cylinder 4 misfire accompanied by low compression, indicating an internal engine failure. This type of issue seems premature for a well-maintained vehicle and has resulted in major repair considerations, including potential engine replacement. Given Ford’s reputation for durability and reliability, I find this failure both unexpected and concerning. I have kept up with regular maintenance and did not anticipate facing a major engine issue at this mileage. I am requesting that Ford review this situation and consider a recall. I have seen and heard of a lot of folks having this same issue at such an early mileage
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725633March 19, 2026
ELECTRICAL SYSTEM
My 2018 Ford Expedition had an open recall for back up screens not working at all. I have a 2018 Ford Expedition Limited, purchased new for $72,000 in April 2018. The issues that have been repaired are endless however this one is a HUGE safety issue. It is a known issue and my VIN is not included in the recall. I called dealership and they will do a $285 “free” software fix as they did to the VIN included in recall: this is a known 2018 Ford Expedition recall and my VIN is not included but has the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724708March 16, 2026
AIR BAGS
The contact owns a 2018 Ford Expedition. The contact stated that while driving at 45 MPH, another vehicle drove through a stop sign, causing the contact to T-bone the other vehicle, causing damage to the front end of the vehicle. The contact stated that no air bags did not deploy in his vehicle. The contact stated that he sustained whiplash to the neck and upper back. No medical attention was required. The contact mentioned the vehicle was towed to a collision center. The contact stated that a police report was filed. The manufacturer was notified of the failure, and they informed him to take the vehicle to the dealership. The approximate failure mileage was 88,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11721616March 3, 2026
POWER TRAIN
While driving at approximately 55 mph, the vehicle intermittently loses throttle response. Pressing the accelerator results in no increase in RPM or vehicle speed, even when the pedal is fully depressed. After 3–5 seconds, power suddenly returns. The issue consistently occurs after the vehicle has been driven for about 20 minutes and is at normal operating temperature. During some events, a “Powertrain Malfunction / Reduced Power” warning with a wrench indicator appears. The vehicle is equipped with the 10R80 10-speed automatic transmission. The failure occurs during steady highway cruising and creates a serious safety concern, as the vehicle will not accelerate when needed for merging or passing. A buzzing noise is heard during the loss of power, and engine RPM remains steady with no response to throttle input. This intermittent loss of power at highway speeds presents a significant safety risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719657February 21, 2026
EXTERIOR LIGHTING
Front passenger DRL fail in lower 2/3 of LED strip. Im afraid other cars won't see me as well. No warnings on the inside dash display. A car flagged me down to tell me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718934February 18, 2026
POWER TRAIN
The vehicle often feels like it is slipping when it is changing gears at lower speeds. When trying to accelerate quickly getting on the highway, it fails to increase speed. The gas pedal is pressed and the engine revs and it does not increase speed. This has happened more than once and has caused me to nearly be in accidents because I cannot enter the highway as I should. I took it to a dealer initially in 2023 and they repaired the transmission cooler. Was told it was operating as designed after that. Then in 2024 I took it in for the same issue and was told I needed an engine replacement. I paid for an entire engine replacement and was told the issue was fixed. I am now having the same issue and will be taking it back for a 3rd time. My local shop (not the dealer) told me it is the timing belt which is part of the engine. I feel unsafe in my vehicle and do not feel my $16,000 repair fixed the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715730February 5, 2026
ENGINE
My cam phasers failed. I had a 6 year, 72k mile warranty. All maintenance was done at the dealership at the correct time. The parts failed at 7 years, 75,600 miles. Had to replace the engine. Dealer wanted to charge me $19000. Found a local shop to do it with new Ford engine for $14000. The cam phasers are a known issue. There are hundreds of vehicles out there that have had the same problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709452January 7, 2026
POWER TRAIN
At approximately 100,500 miles, my 2018 Ford Expedition XLT 3.5L EcoBoost developed loud rattling noises consistent with cam phaser failure. Zeigler Ford confirmed the failed cam phasers on October 20, 2025. These phasers were previously replaced on the vehicle at 51,000 miles on February 10, 2022, at Al Piemonte Ford under the Customer Satisfaction Program 21N03. They used the old phasers HL3Z-6C525-CD which are known to be defective rather than the new updated phasers ML3Z-6C525. Cam phaser failure can cause engine misfires, loss of power, and potential engine damage, creating a serious safety risk, especially at highway speeds. This issue has been reported by multiple Ford Expedition owners, indicating it is not isolated. I request that NHTSA investigate whether this defect warrants a recall or expanded coverage for vehicles like mine that exceed CSP mileage limits. My vehicle has been properly maintained, and the failure is due to a known defect in the 3.5L EcoBoost cam.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708735January 5, 2026
SUSPENSION
While driving on to a rough area such as a bridge crossing the vehicle exhibited excessive bouncing and caused the direction of travel toward the next lane. Repairs to the front struts were made at the dealership where the vehicle was originally purchased. The repair part was described as JL1Z 18124 E Shock Absorber Asy. The service advisor said struts are described this way due to the way it is listed in the parts catalog. Since this repair the vehicle has increasingly repeated the same bouncing and driveability to the extent that another service call is required.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708963January 5, 2026
EXTERIOR LIGHTING
Passenger side DRL (daytime running light) has dimmed and turned purple. Upon further research, this is happening to thousands of Ford Expeditions specifically on the passenger side. The only repair is to replace entire housing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707777December 30, 2025
POWER TRAIN
When attempting to pass a slow moving vehicle on a 2 lane highway when driving up a hill the transmission failed to properly shift instead making a loud clunking and grinding sound before eventually managing to shift into a gear. This failure to shift properly meant that the vehicle was unexpectedly without power when trying to change lanes leading to a dangerous situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707796December 30, 2025
EXTERIOR LIGHTING
DRL failure is widespread across ford vehicles and should be addressed by the manufacturer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705393December 16, 2025
POWER TRAIN, ENGINE
The contact owns a 2018 Ford Expedition. The contact stated that while driving over 40 MPH, the vehicle stalled on two occasions. The contact stated that while driving a roundabout, the vehicle lost motive power. The accelerator pedal was depressed, but the vehicle jerked and was sluggish, and there was no area to pull over to. Upon parking the vehicle, the power train warning light was illuminated. The contact called an independent mechanic who was unable to service the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that the vehicle was jerking due to the CS drum and transmission failure. The vehicle was not repaired. The dealer was not contacted regarding the latest symptoms that the vehicle had displayed. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705181December 15, 2025
POWER TRAIN
My vehicle has started to have problems shifting in some gears(3rd & 7th). I have been doing research, and this seems to be a recurring problem for vehicles with the 10r80 transmission. Where this has caused a big safety risk, is that a few times, the vehicle wouldn't move when pushing on the gas after having the foot on the brake after I had already left and been driving it for 5-10 minutes. This has put me at risk of getting hit by oncoming cars since I couldn't get the vehicle to go as it should to cross a road or intersection. My vehicle shows no dashboard warnings that anything is wrong. I have had all regular maintenance done, don't use the vehicle for towing, and I only have 70k miles on the car. Over the years I have had it where it just feels like the vehicle won't shift, but it has gone away pretty quickly. It's only been since this summer that it is now a persistent issue. I have brought it up over the years to the ford service department, and nothing was shared with me that there was an issue with the vehicle transmission. It is now that it's been consistent(only when the transmission is cold) that this happens on every drive. All Ford wants to do is charge me to rebuild the transmission conveniently now that I am out of warranty!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703347December 5, 2025
UNKNOWN OR OTHER
The chrome trim on the upper center console of my 2018 Ford Expedition Platinum Max has begun peeling and lifting, creating a razor-sharp exposed metal edge in the front passenger compartment. The sharp metal edge is located where the driver and front passenger/children rest their arms and where the console storage is opened and accessed during normal use. The edge is sharp enough to cause deep lacerations with normal contact. This defect has already resulted in multiple significant cuts to occupants, producing wounds that bled for several hours and required medical care to control bleeding. The center console cannot be used safely without risk of injury, and occupants cannot reasonably avoid contact with the affected area. A vehicle interior surface should never create the risk of open wounds to occupants during ordinary operation. Manufacturer Response Ford Motor Company, Ford Customer Care, and Ford Protect have been notified of the safety risk. Despite documented injury, the dealership and Ford warranty administrators have refused to repair the component, stating that the part is categorized as “cosmetic” in their parts system. Because of this internal categorization, they declined to submit or review the issue as a safety-related failure, and no remedy has been offered. Reason for Filing The failure of interior trim material to maintain structural integrity has resulted in dangerous exposed sharp metal, causing real injury and presenting a continuing safety hazard to vehicle occupants. Manufacturer refusal to take corrective action after injury demonstrates the need for federal safety review.
Crash:
No
Fire:
No
Injuries:
5
Deaths:
0
#11702098November 30, 2025
ELECTRICAL SYSTEM
I own a 2018 Ford Expedition, and the factory-installed backup camera has progressively failed. Initially, the camera display was intermittent—sometimes showing the rear view and other times freezing or going black. The issue has now worsened to the point that the camera no longer turns on at all when the vehicle is placed in reverse. This failure presents a significant safety hazard, as the rearview camera is critical for detecting pedestrians, obstacles, and other vehicles—especially in a large SUV with limited rear visibility. The loss of this feature increases the risk of an accident while reversing. Additionally, this defect renders the vehicle non-compliant with Federal Motor Vehicle Safety Standard (FMVSS) No. 111, which requires all vehicles manufactured after May 2018 to have a functioning rear visibility system. Because the Expedition was sold with this federally mandated safety equipment, the complete failure of the camera should be considered a safety defect. I am requesting that NHTSA investigate this issue, as it appears to be a widespread problem among Ford vehicles of this model year, and urge Ford to provide a corrective action or repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697836November 6, 2025
POWER TRAIN
I was driving down the road at 45 MPH, I pushed the accelerator then my vehicle shifted out of drive to neutral, the RPM increased, the car speed decelerated, then the vehicle put itself back in gear severely downshifted so much that my car lost 20 MPH then the engine returned to normal after a violent shake and loud grinding noise. The car could have caused an accident had there been anyone behind me. Luckily there were no other cars around me. I had the vehicle towed to the dealer. They are unable to duplicate the issue I stated but did indicate a skip in cylinders when they hooked it up. I had the transmission overhauled at 53K when it was not shifting properly. I asked Ford to replace the transmission however they elected to overhaul it. From time to time the transmission would shift odd but nothing of over concern. The incident on Nov 3 was very unusual and safety of travel for me. The vehicle had done something similar earlier that morning but that time it was from a stop and no speed so not nearly as violent as the one later that evening. The vehicle is currently sitting at a dealer needing a transmission replaced, however the vehicle is 500 miles over the 75K ESP. Ford is refusing to discuss the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition