Ford Edge Complaints (2016)

926 consumer complaints on file.

#11708769January 5, 2026
SERVICE BRAKES, HYDRAULIC, LATCHES/LOCKS/LINKAGES:HOOD:LATCH
The contact owns a 2016 Ford Edge. The contact stated that while driving at 15 MPH in the rain, the brake pedal was applied however, there was a delay in responding, and crashed into a Subaru Forester. There was an abnormal squeaking and squealing sound detected. The vehicle was drivable. While approaching a stoplight, there was an abnormal squealing noise, and there was an increase in stopping distance. There were no warning lights illuminated. The contact sustained a sprained neck, and medical attention was provided. There was no reported fire or air bag deployment. A police report was filed. The vehicle was taken to a brake center where it was determined there was an ABS failure related to NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic) however the parts were not available. The hood was unable to be opened. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 111,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11707464December 29, 2025
ENGINE
The contact owned a 2016 Ford Edge. The contact stated that while driving at 70 MPH, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that cylinder #3 needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately two weeks later. The vehicle was taken back to the independent mechanic, where it was diagnosed that all three cylinders needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately a week later. The contact stated that while driving at approximately 70 MPH, there was an abnormal sound coming from the engine compartment. The vehicle was taken to the residence. The vehicle was taken to two independent mechanics, where it was diagnosed that an unknown hose had leaked fluid into the engine, and the engine needed to be replaced. The vehicle was not repaired. The vehicle was then taken to a dealer, where the same assessment was made. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 58,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707150December 26, 2025
STRUCTURE:BODY
- door hinge failure - hinge assembly intact but the weld area failed and tore the base from the door structure - door wont close or open properly - not as of yet no warning lamps just a non functional door. the failure is identical to the linked complaint [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706481December 22, 2025
BACK OVER PREVENTION, SERVICE BRAKES, HYDRAULIC
The contact owns a 2016 Ford Edge. The contact received notifications of NHTSA Campaign Numbers: 25V544000 (Service Brakes, Hydraulic) and 25V572000 (Back Over Prevention); however, parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was shifted into reverse(R), the rear-view camera intermittently displayed a blank or distorted image. The dealer was contacted but offered no assistance. The manufacturer was made aware of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703923December 9, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2016 Ford Edge. The contact stated that while driving approximately 45 MPH, the contact depressed the brake pedal, and the brake pedal felt spongy and depressed to the floorboard. There was no warning light illuminated. The contact was able to stop and exit the vehicle. The contact then observed a puddle of fluid by the passenger’s side rear wheel well. The vehicle was towed to a local dealer, where the vehicle was diagnosed and determined that the passenger’s side rear flexible brake line had ruptured. The dealer replaced the brake line, and the vehicle was repaired. The manufacturer was not informed of the failure. The contact recently received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); and related the failure to the recall. The failure mileage was 117,490.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703694December 8, 2025
VISIBILITY/WIPER, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Manufacturer has failed or is unable to remedy this safety recall for my vehicle in a timely manner: Sep 08,2025 Manufacturer Recall Number 25S89 NHTSA Recall Number 25V572 Recall Status Recall Incomplete, remedy not yet available
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702621December 3, 2025
ENGINE
Complaint Description: My 2016 Ford Edge 2.0L EcoBoost is experiencing a catastrophic engine failure due to "coolant intrusion" into the engine cylinders, a known manufacturing defect associated with the open-deck engine block design in this model year (referenced in Ford TSB 19-2346). The Failure: While driving at highway speeds (65+ MPH) on California freeways, the vehicle intermittently and suddenly enters "limp mode," drastically reducing power and acceleration without warning. This makes it impossible to merge safely or keep up with traffic, creating a life-threatening safety hazard for myself and other motorists. History & Diagnosis: The issue began in early 2025 with a Check Engine Light, which was initially misdiagnosed by a mechanic as a non-critical boost leak. The condition worsened significantly in Q4 2025, leading to dangerous stalls in power. A new independent inspection confirmed the root cause is not a boost leak, but internal coolant leakage into the engine block cylinders. This defect has caused permanent engine damage requiring a full engine replacement. The failure mode is identical to thousands of other complaints regarding the 2.0L EcoBoost engine, yet no safety recall exists to address the sudden loss of motive power.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702260December 1, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2016 Ford Edge. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic). The contact called a local dealer and was informed that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701468November 25, 2025
SERVICE BRAKES
The manufacturer has failed or is unable to remedy this safety recall for my vehicle in a timely manner: Aug 25,2025 Manufacturer Recall Number25S87 NHTSA Recall Number25V544 Recall StatusRecall Incomplete, remedy not yet available
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700637November 20, 2025
BACK OVER PREVENTION, SERVICE BRAKES, HYDRAULIC
The contact owns a 2016 Ford Edge. The contact received notifications of NHTSA Campaign Numbers: 25V544000 (Service Brakes, Hydraulic) and 25V572000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while depressing the brake pedal, the braking distance was extended before the vehicle came to a stop. The brake light was illuminated. While in reverse, the back-over prevention camera displayed a black screen. The dealer was contacted. The manufacturer was made aware of the failures. The failure mileage was approximately 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700049November 18, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2016 Ford Edge. The contact stated that while driving at 40 MPH, the engine warning light illuminated. The driver became aware that the coolant level was low. While driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to an independent mechanic who confirmed that the failure was due to a misfire in cylinders #2 and #3. The contact stated that the spark plugs were replaced, and coolant was added, but the failure reoccurred. The contact stated that coolant was leaking into the engine. The mechanic informed the contact that the engine needed to be replaced. The contact called an unknown local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and confirmed there was no recall coverage for the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699808November 17, 2025
SERVICE BRAKES
My brake pressure dropped rapidly and the ABS and brake system warnings lit up. I added brake fluid and it leaked out from the rear passenger side brake line. Took car to dealer and they confirmed a recall on the brake lines and replaced the lines. I was responsible for the repair cost and the dealer was not able to process reimbursement until unknown date of Ford completing recall instructions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699367November 14, 2025
BACK OVER PREVENTION, SERVICE BRAKES, HYDRAULIC, EQUIPMENT:ELECTRICAL:INFOTAINMENT
See attached document for complaint. I am writing to file a formal complaint regarding the handling of safety recalls 25V572 and 25V544 on my vehicle, and to urgently request your assistance in having all repairs authorized at a local Ford dealership, due to the profound unprofessionalism and neglect I have experienced from the selling dealership, Pure Honda Ferndale. My vehicle is a 2016 Ford Edge Sport with approximately 101,003 miles. I purchased it from Pure Honda Ferndale just prior to being notified of these active recalls, after which the vehicle was understandably grounded. The core of my issue lies with the conduct of the dealership's management. Before the recall notice and the vehicle being pulled from sale, I was in direct communication with the General Manager, Mr. Sheldon Taylor. He personally assured me that he would resolve several preexisting issues, including arranging for a vehicle exchange or repairs. These issues include the dealership selling me defective and outdated tires and a rim package that no local tire shop will service, as well as a noticeable and hazardous defect in the SYNC system where the screen experiences complete blackouts, particularly when using the navigation and radio. However, once the reca ll was enforced, Mr. Taylor ceased all communication and delegated my case to a sales representative, who has since also ignored my repeated calls and the recall notices I have provided. I have been left with a vehicle I cannot safely drive due to the open recalls and an infotainment system that fails unpredictably, creating significant distraction and safety risk. The dealership that sold me this problematic vehicle now refuses to take responsibility for its prior promises. Given the complete breakdown in communication and the lack of professional accountability from Pure Honda Ferndale, I do not trust them to manage my vehicle's critical safety repairs or address this additional SYNC system defect. Therefore, I respectfully request that the NHTSA assist me in obtaining permission t
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698712November 11, 2025
VISIBILITY/WIPER
The rear window spontaneously shattered/exploded. The rear defrosted was on as well as the rear wiper. It was 30 degrees outside.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697146November 3, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2016 Ford Edge. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the vehicle failed to stop immediately. The contact stated that the brake pedal needed to be depressed extremely hard. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, parts for the recall repair were not yet available. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696985November 2, 2025
ELECTRICAL SYSTEM, STEERING, EXTERIOR LIGHTING
My vehicle previously had recall work, including power steering, but now I’m experiencing: * ‘Steering Assist Required’ warning, and the electric power steering is intermittently failing * Traction control and hill assist turned off * Headlights (and other lights) staying on even when the car is off * The vehicle pulls sharply to the left when braking * Despite multiple alignments and suspension/tie rod replacements, my new tires are wearing out rapidly
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696903November 1, 2025
ENGINE
My 2016 Ford with only 56,210 miles has developed a critical engine failure. The engine block due to a manufactuing design flaw has caused the coolant to leak into one of the cylinders. Dealership informed me I need a new motor at the cost of $7300.00. Ford will not stand behind the repair due to the age of my vehicle. It's in excellent condition other than the defective engine block.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696817October 31, 2025
ENGINE
I’ve had my car nine years. No problems with the body there’s no rust on it at all, and I love my ford. Just as I hit 100,000 miles the warning light came on the car. Come to find out it is a head gasket leak and is required to have a whole new engine. Yes the warranty is over as the car has been paid for and the warranty is expired. My complaint is that Ford knows this is an issue which I know for a fact that they know this. I cannot afford $7100 for a new engine when I just want to keep my car. I can’t even afford another car not even a beater for $1000. I’m complaining that ford knows this is a known issue, but because I am out of warranty, they will not help me. I’ve had ford’s most of my life and never had an issue like this. Very disappointing that a big company like this has a known issue but will not help repair it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696629October 30, 2025
BACK OVER PREVENTION
The contact owns a 2016 Ford Edge. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that the rearview camera was inoperable while reversing. The vehicle was taken to the dealer, where the contact was informed that a fee would be charged for the repair, but there was no guarantee that the repair would correct the failure. The vehicle was then taken to an independent mechanic, where the rearview camera was replaced with an aftermarket part; however, the contact stated that the rearview camera was not operating as needed. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696137October 28, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2016 Ford Edge. The contact stated that while driving at various speeds, the brake pedal was depressed and almost went to the floorboard. The contact stated that the brake warning light was illuminated. The contact stated that brake fluid was dripping from the rear of the vehicle. Additionally, the contact stated that the parking brake was engaging independently. The contact had received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic). The contact had taken the vehicle to a local dealer and was informed that the part was not yet available and that another letter would be sent when the part was available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 195,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Edge