Ford Edge Complaints (2016)

926 consumer complaints on file.

#11535471July 31, 2023
ENGINE
The contact owns a 2016 Ford Edge. The contact stated while driving 55 MPH, the vehicle overheated. Additionally, the contact stated that the temperature gauge was reading hot. The vehicle was veered to the side of the road until the vehicle cooled down, and the vehicle was restarted. The vehicle was taken to an independent mechanic and was diagnosed and determined that the head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 133,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11535481July 31, 2023
ENGINE AND ENGINE COOLING
The contact's daughter owns a 2016 Ford Edge. The contact stated that while driving at various speeds, the engine overheated with the check engine warning light illuminated. Upon inspection, the contact discovered that the coolant reservoir was empty. The vehicle was taken to the dealer where the vehicle was diagnosed with a blown head gasket. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 129,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534911July 27, 2023
ENGINE, POWER TRAIN
Coolant is leaking into the engine causing check engine light showing misfiring in #3, loss of coolant, heater to not warm up. It is available for inspection currently until we are able to replace the long block of the engine. Ford has an ongoing law suit over this Ecoboost engine coolant issue of which they are doing nothing to help repair the issue. The local Ford Dealership has confirmed the leak. It has not been inspected by police or insurance. We have been told not to drive the car due to chance of it catching fire or ruining the engine if coolant runs out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534402July 25, 2023
ENGINE, STRUCTURE
The contact owns a 2016 Ford Edge. The contact stated that the vehicle was shaking and vibrating abnormally while being started. Additionally, while driving at various speeds, the vehicle suddenly started to shake and vibrate and while accelerating from a stop. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that that the failure was due to a cracked flex plate and that the flex plate needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed of an Extended Coverage for the failure, but the vehicle had exceeded the mileage. The failure mileage was 155,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534213July 24, 2023
SEAT BELTS
I have a 2016 Ford Edge. Bought my car 2018. I Have never used the back seat driver side seat belt only a few times. When I switched my daughter out of her car seat(who was born the year I got my car) I had no need for the seat belt. Until now when I switched her to her booster seat. Now the seat belt lap strap is locked and not able to come out. There for I can't use that seat at all. And have to put her in the middle. My son is too tall to sit in the middle seat. But too young to sit in the front. I took my car into the dealership and called a different dealership and they said the seat belt may be an aftermarket. They had never seen one that has the airbags in them. So we need to order you just a normal seat belt, and it's on back order. So now I have to wait [XXX] only knows how long. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11533644July 21, 2023
ENGINE
The contact owns a 2016 Ford Edge. The contact stated while driving 55 MPH, the check engine warning light illuminated. The contact called and made the local dealer aware of the failure. The vehicle was not repaired. The contact took the vehicle to an independent mechanic and was informed that there was coolant leaking into cylinder #3 and the long block needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 101,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11532955July 18, 2023
ENGINE
The contact owns a 2016 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle shuddered, and the check engine warning light illuminated. Additionally, there was white smoke coming from the exhaust tip. The contact attempted to restart the vehicle and the vehicle failed to start. The contact stated that the engine had overheated. The vehicle was taken to the dealer, who informed the contact that there was coolant leaking into the cylinder and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was unknown. The contact stated that no assistance has been offered and no repairs have been made yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11532689July 17, 2023
EXTERIOR LIGHTING:TAIL LIGHTS
The contact owns a 2015 Ford Edge. The contact stated that upon visual inspection, he observed condensation build-up within both the driver's and passenger's side taillights that could severely reduce night-time visibility. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11532693July 17, 2023
ENGINE
This happened in late June when I started my car it had white smoke coming out of the exhaust which cleared and no warning light on. I drove it to work and back and we checked coolant, and it was low so added and the next time I drove it, the check engine light went on! I called the Ford Dealership near me which is about an hour away and made an appointment to take on July 14th. The diagnosis was coolant leaking into my second cylinder and the block where head sits is worn down. I need a new long block, engine! $6000 was the quote!!!! My car is a 2016 Ford Edge with 75725 miles on it! I called Ford Customer Service and this car is not eligible for Financial Assistance and I have not heard from the Corporate Office! I have seen complaints of exactly the same thing and some people are getting Ford to help with the bill and not sure how they decipher what vehicle does or does not qualify! I am working on this issue and will not settle for nothing! I have never experienced anything like this, this is terrible! Who can afford this at this time in our lives and why???? It is a Ford issue not the consumer!!!! They have known about this for quite some time and the block on my car being worn is a manufacturing defect, it happened in the casting of the block, that car should have never left the plant with the correct inspection, where were the inspectors on this?? Ford used to give their dealerships a budget to help out issues like this for their customers but that has ended so nothing the dealership can do but fix your car and you pay the bill and good luck after that! As a Ford customer I have been taken advantage of, my safety was put in jeopardy and there is no loyalty at all to the customer!!! Not good for them! This car should have a recall on it and they should foot my bill and every other person who has experienced this and there are a lot of us!!!!! Ford should take responsibility for their poor actions!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11532652July 17, 2023
ENGINE, ENGINE AND ENGINE COOLING
The contact owns a 2016 Ford Edge. The contact stated that the check engine warning light was illuminated. The contact used a DTC reader and determined that the cause of the failure was a defective crank shaft, cam shaft, and oxygen sensors. Despite the repairs made to vehicle, the check engine light remained. The vehicle was taken to an independent mechanic where he was informed that coolant had leaked into cylinder #1. The contact was advised to stop driving the vehicle and contacted the dealer. The contact was informed that the vehicle was not under recall and a diagnostic test was performed. The dealer confirmed the failure and informed the contact that the engine block needed to be repaired. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11532526July 16, 2023
WHEELS
Dealer’s (San Tan Ford, Gilbert, AZ) service department indicates I need to replace all lug nuts ..all found swollen creating a safety hazard. Cost of replacement is $164.98 plus taxes and labor charges.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531893July 12, 2023
ENGINE
Engine overheating due to coolant leaking due to head gasket failure. Ford has technical service bulletin #19-2208 that recommends replacing long block. Milage at 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531928July 12, 2023
ENGINE
Noticed engine misfire. Brought to local ford dealership. After diagnosis noticed coolant intrusion into cylinders. Ford recommended complete engine replacement
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530488July 5, 2023
ENGINE
The contact owns a 2016 Ford Edge. The contact stated while the vehicle was idling, he heard an abnormal sound coming from the engine. The contact stated no warning light was illuminated. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 129,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530522July 5, 2023
ENGINE
The vehicle started to make a low rattling noise that grew louder each time the vehicle was idling. We now believe the flexplate is cracked. Ford has sent out a letter stating they are aware the flexplate may crack but they are not willing to cover repairs on the vehicle after a certain time period, which has already passed. They state in the letter to not bring vehicles in unless they are making a rattling noise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530008July 2, 2023
ENGINE
Car has a little over 100,000 miles 2017 Ford edge. Engine light came on, took to a Ford dealership where we were informed that coolant was leaking into the cylinders and would need to replace the whole engine. From researching this issue I have discovered that this seems to be a big problem with not just my car but others as well and ones with less miles and yet Ford will not pay for replacement or issue a recall on this issue. The car is sitting at the dealership now as we think about what should be done next.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530022July 2, 2023
ENGINE
In 2016, I purchased a new Ford Edge. In June 2023, I'm informed by Ford Certified Personnel that the engine has a "Coolant Inclusion" issue requiring replacement with a new engine. This problem caused by a design flaw in the engine that Ford was aware of in 2009 and continued to install without repair or recall. Research information shows it can cause overheating and possible vehicle fire. My service records can be verified with Brinson Ford, Athens TX. [XXX], Service Advisor. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529618June 29, 2023
ENGINE
The contact owns a 2016 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that while accelerating while making a left or right turn, the brake pedal was depressed, and the contact heard liquid rotating coming from the hood of the vehicle. Additionally, the contact stated that while shifted into reverse(R), the vehicle started to shudder. The vehicle was taken to the dealer where it was diagnosed that coolant had leaked into cylinder #2. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided information for TSB Number: 22-2133 to repair the vehicle. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 67,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529560June 29, 2023
ENGINE
Rough idling on start up and engine light came on. After taking car to a local repair shop, mechanic noticed that vehicle was consuming coolant and the engine was cracked. They advised taking it to dealer. Ford dealer confirmed diagnosis. Vehicle had 93304 miles on it and Ford has a Technical service bulletin out on it. Was originally quoted $6,000 to replace engine. After a lot of negotiating with Ford Customer Satisfaction Program, we paid $1,685 to replace engine. Ford has known about this issue for quite a while and in my opinion, should have issued a recall. There have been reports from others that the engine has caught fire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11528531June 23, 2023
ENGINE
Coolant leak to inside the piston engine
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Edge