Ford C-Max Complaints

510 consumer complaints on file.

#11057801January 1, 2018
FUEL/PROPULSION SYSTEM
ON 12/20/2017 AT ABOUT 8:30 PM ON ROUTE 139 (HIGHWAY) EAST BOUND, AFTER STOPPING FOR A RED LIGHT, I TRIED TO ACCELERATE BUT THE VEHICLE PROPULSION SHUT OFF. NO WARNING LIGHTS OR ENGINE LIGHT CAME ON. I HAD TO PLACE GEAR IN PARK, AND RESTART VEHICLE. THIS HAPPENED AGAIN ON 12TH STREET IN JERSEY CITY, NJ BEFORE I WAS ABLE TO PARK LESS THAN A MILE AWAY. IN THE MORNING I WAS ATTEMPTING TO BRING IT TO WAYNE FORD AT 444 ROUTE 46, WAYNE , NJ 07470, WHEN THE VEHICLE SHUT OFF IN THE MIDDLE OF A INTERSECTION. ON ROUTE 1(HIGHWAY) IN JERSEY CITY, NJ. AGAIN I HAD TO PLACE VEHICLE IN PARK AND RESTART VEHICLE. THIS OCCURRED MULTIPLY TIMES BEFORE I FINALLY ARRIVED AT THE DEALERSHIP, FORTUNATELY THE VEHICLE ONLY STOPPED AGAIN ON LOCAL ROADS ANS NOT ON THE HIGHWAY OF ROUTE 46 OR ROUTE 3 WHICH I HAD TO USE TO GET TO THIS LOCATION.. I EXPLAINED TO THE REPAIR PERSON MY VEHICLE SHUT DOWN WHILE IN MOTION AS I PRESSED ON THE ACCELERATOR, ONCE WHILE TURNING, ALWAYS WHEN IN MOTION. ALSO ASKED THAT ALL RECALL ITEMS OF THIS VEHICLE BE CORRECTED AT THIS TIME TOO. AS OF THIS DATE 1/01/2018 WAYNE FORD HAS YET TO TELL ME WHAT THE PROBLEM IS OR WHEN MY VEHICLE WILL BE REPAIRED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11056667December 26, 2017
POWER TRAIN
TRANSMISSION WENT OUT 2200 MILES AWAY FROM HOME TWICE ABOUT ONE YEAR APART. BOTH TIMES THE TRANSMISSION BEGAN TO MAKE TERRIBLE NOISE BOTH IDLING AND ON THE ROAD. THE TWO DEALERS, ONE IN NASHUA, NEW HAMPSHIRE AND TNE OTHER IN GREENVILLE, SOUTH CAROLINA, CHECKED THE TRANSMISSION OIL FOR METAL PARTICLES WHICH WERE FOUND IN ABUNDANCE BOTH TIMES. I LOOKED AT THE OPENED TRANSMISSION WHERE I OBSERVED THE VERY LARGE ROLLER BEARINGS AND RACE FULL OF PITS AND GULLS OBVIOUSLY FROM POOR QUALITY METAL PARTS SINCE THE TRANSMISSION IS SEALED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11056726December 26, 2017
POWER TRAIN
TRANSMISSION WENT OUT 2200 MILES AWAY FROM HOME TWICE ABOUT ONE YEAR APART. BOTH TIMES THE TRANSMISSION BEGAN TO MAKE TERRIBLE NOISE BOTH IDLING AND ON THE ROAD. THE TWO DEALERS, ONE IN NASHUA, NEW HAMPSHIRE AND TNE OTHER IN GREENVILLE, SOUTH CAROLINA, CHECKED THE TRANSMISSION OIL FOR METAL PARTICLES WHICH WERE FOUND IN ABUNDANCE BOTH TIMES. I LOOKED AT THE OPENED TRANSMISSION WHERE I OBSERVED THE VERY LARGE ROLLER BEARINGS AND RACE FULL OF PITS AND GULLS OBVIOUSLY FROM POOR QUALITY METAL PARTS SINCE THE TRANSMISSION IS SEALED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11055439December 19, 2017
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2014 FORD C-MAX. THE CONTACT STATED THAT THE PLUG TO CHARGE THE VEHICLE WAS MELTING AND CAUSED THE POWER OUTLET IN THE HOUSE TO MELT. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO CHARGE AND WAS UNABLE TO OPERATE AT TIMES. THE CONTACT CALLED SARAHSOTA FORD AT 888-349-4989 AND INFORMED THE CONTACT THAT IT WAS DUE TO USER ERROR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11055308December 18, 2017
POWER TRAIN
TL* THE CONTACT OWNS A 2013 FORD C-MAX. WHILE DRIVING 10 MPH, THE TRANSMISSION MADE AN ABNORMAL GRINDING NOISE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OPENED CASE NUMBER: CAS-13704524-H7N0D5. NO FURTHER ASSISTANCE WAS OFFERED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11053411December 8, 2017
STEERING
WHEN I STARTED MY CAR TO RETURN HOME FROM WORK, THE "STEERING WARNING" LIGHT CAME ON. I PUT THE CAR IN REVERSE AND WHEN I TRIED TO BACK OUT, I REALIZED THAT MY WHEEL WAS NEXT TO IMPOSSIBLE TO TURN. I TURNED THE CAR OFF AND RESTARTED IT WITH THE SAME RESPONSE. I CALLED FOR A TOW TO A DEALERSHIP AND AFTER THEY HAD THE CAR OVERNIGHT AND INTO THE NEXT AFTERNOON, WAS TOLD IT WOULD COST $1,400 TO REPLACE THE STEERING PUMP AND TO BALANCE AND REALIGN MY TIRES. THE REPAIR IS NOT UNDER WARRANTY AS IT IS 4 YEARS OLD AND HAS JUST OVER 52,000 MILES. THERE WAS NO INDICATION MY STEERING WAS ABOUT TO GO. MY CAR IS REGULARLY SERVICED AND MADE NO NOISES OR HAD ANY TROUBLES PRIOR TO THIS INSTANT FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11051670December 1, 2017
STEERING
UNABLE TO DRIVE CARE DUE TO SUDDEN LOSS OF POWER STEERING (HAPPENED WHEN PARKED FOR JUST A FEW MINUTES -- WENT IN BUILDING TO PICK UP SON FROM DAYCARE, CAME OUT AND NO POWER STEERING WHEN I RESTARTED CAR). THIS HAS APPARENTLY BEEN A PROBLEM ON OTHER FORD MODELS OF THE SAME YEAR AND THERE ARE RECALLS FOR THOSE, BUT NOT FOR THE C-MAX. UNSURE IF THIS COULD HAPPEN WHILE DRIVING, BUT IT COULD BE CATASTROPHIC IF IT DID. CAR HAS 52000 MILES AND HAS BEEN DEALER MAINTAINED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11048413November 25, 2017
ELECTRICAL SYSTEM
CMAX MELTING PLUG THE 120 VOLT, 12 AMP CHARGE CORD THAT CAME WITH MY CAR IS OVERHEATING CREATING A FIRE HAZARD. THE END OF THE CORD THAT PLUGS INTO THE WALL HAS MELTED AND LEFT BURN MARKS ON THREE DIFFERENT ELECTRICAL OUTLETS IN MY GARAGE WHERE I PLUG THE CAR IN TO CHARGE. I PUT IN A DEDICATED 20 AMP LINE AND PLUG DUE TO THIS PROBLEM IN AUGUST. THE PLUG STILL BURNED AND MELTED. I HAVE PHOTOS OF THE OUTLET AND PLUG. I MADE FORD AWARE OF THE PROBLEM AND ADVISED VIA. FORD EV HELP LINE CASE # CAS-13607255. I AM TAKING THE CAR AND CHARGER INTO FORD ON MONDAY COMING 11/27/17. THIS PROBLEM WITH THE CORD HAS BEEN GOING ON SINCE 2013. I THOUGHT IT WAS MY PLUG. IT IS NOT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11047477November 20, 2017
ELECTRICAL SYSTEM
CAR WILL NOT START AFTER BEING PARKED. AUTOMATIC DOOR OPENER DOES NOT WORK TO OPEN CAR. ONLY VALET KEY WILL OPEN CAR. ALL ELECTRICAL SYSTEMS ARE DEAD, THIS HAS HAPPENED MORE THAN 10 TIMES SINCE I PURCHASED THE CAR IN 2014. SUPPOSEDLY THIS PROBLEM HAS BEEN REPAIRED BY THE DEALERSHIP EACH TIME BY REPLACING THE BATTERY, REPLACING RELAY SYSTEMS, ETC. BUT IT CONTINUES TO RECUR. THERE IS NO PATTERN TO ITS OCCURRENCE BUT IS WELL KNOWN TO FMC.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11051973November 10, 2017
UNKNOWN OR OTHER
THE PARK ASSIST FAILED WHEN THE AUTOMATED SYSTEM WAS PARKING MY VEHICLE IN A PARALLEL PARKING SPACE. THE PARK ASSIST SYSTEM APPEARED TO BE FUNCTIONING PROPERLY UNTIL DURING THE VEHICLE'S IT'S INITIAL BACKUP MANEUVER WHEN IT BACKED MY VEHICLE INTO A PARKED PICKUP TRUCK IN THE ADJACENT PARKING STALL WITHOUT WARNING. FORTUNATELY DAMAGE WAS LIMITED TO PAINT DAMAGE ON MY VEHICLE'S BUMPER WITH DO DAMAGE TO THE VEHICLE IN THE ADJACENT PARKING STALL. THE LOCAL FORD DEALERSHIP HERE IN BRANDON FLORIDA HAS TESTED THE SYSTEM AND REPORTED THAT THE SYSTEM IS FUNCTIONING PROPERLY,THUS DENYING ANY RESPONSIBILITY. I HAVE REPORTED THIS TO FORD MOTOR COMPANY ON 11/09/2017 (CAS-13504308) AND AWAITING A RESPONSE FROM THEM.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11043928November 6, 2017
STEERING
43,500 MILES THE POWER STEERING HAS FAILED; IT BEGAN A FEW THOUSAND MILES AGO, WHERE IT WOULD INTERMITTENTLY NOT WORK AFTER STARTING THE CAR, BUT THEN WITHIN A FEW MINUTES IT WOULD BEGIN WORKING. NOW IT HAPPENS MORE FREQUENTLY FOR LONGER. DEALER SERVICE HAS REVIEWED AND HAS DETERMINED THE (EST.) $2000 PARTS NEED REPLACING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11039187October 24, 2017
POWER TRAIN
TL* THE CONTACT OWNS A 2013 FORD C-MAX. THE CONTACT HEARD AN ABNORMAL GRINDING NOISE IN THE GEARS OF THE VEHICLE. THE CONTACT INFORMED SONORA FORD (13254 MONO WAY, SONORA, CA 95370; 209-532-5593), BUT THE CAUSE OF THE FAILURE COULD NOT BE IDENTIFIED. THE CONTACT WAS INFORMED THAT THERE WAS NO FAILURE. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SHOULDER OF THE BRIDGE. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT IT FAILED TO START. THE VEHICLE WAS TOWED TO VERACOM FORD (790 SAN MATEO DRIVE, SAN MATEO, CA 94401; 650-340-7199) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 13370483. THE CONTACT WAS ADVISED TO FILE A COMPLAINT WITH NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11034471October 19, 2017
STEERING
FOR THE PAST COUPLE MONTHS THE STEERING SOUNDED LIKE IT NEEDED LUBRICATION, BUT I COULDN'T FIND ANY LUBRICATION POINTS EVERYTHING IS SEALED, THEN THE OTHER DAY WHILE MY WIFE WAS DRIVING THE STEERING WENT OUT AND A WARNING MESSAGE APPEARED SERVICE POWER STEERING ASSIST NOW AND THE STEERING WHEEL LOCKED UP ( IT WOULD ONLY GO STRAIGHT NOT RIGHT OR LEFT) LUCKILY SHE WAS GOING INTO A TURN WITH A TURN OUT NEXT TO IT SO SHE COULD GET IT STOPPED. SHE RE STARTED THE CAR AND HAD MANUAL STEERING AND GOT THE CAR HOME. LATER I STARTED IT GOT THAT MESSAGE AND AN ADVANCE TRAC WARNING AND COULDN'T TURN THE STEERING WHEEL AFTER MOVING FORWARD AND BACKWARD A FEW TIMES AND RESTARTING THE CAR SEVERAL TIMES I WAS ABLE TO DRIVE IT TO MY MECHANIC WHO EXPERIENCED THE SAME PROBLEMS AND SUGGESTED WE TAKE IT TO A FORD DEALERSHIP. SO WE LOADED IT ON A CAR DOLLY AND TOWED IT 60 MILES TO THE NEAREST DEALERSHIP AND RECOMMENDED A $2400. REPAIR REPLACING THE POWER STEERING ASSEMBLY THE CAR HAS AROUND 75000 MILES ON IT AND IS ONLY 4 YEARS OLD. I HAVE READ ONLINE THAT FORD HAS HAD RECALLS FOR THE POWER STEERING ASSEMBLY FOR 2013 CAR BUT NOT THE C-MAX. PLEASE HELP BEFORE SOMEONE DIES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11033441October 15, 2017
VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
RECEIVED A LETTER FROM FORD ALTHOUGH FORD IS NOT CALLING THIS A RECALL I BELIEVE IT IS PRETTY SERIOUS. THIS IF FOR THE CUSTOMER SATISFACTION PROGRAM;17B28 FORD IS SAYING THE ELECTRONIC THROTTLE BODY MAY DEVELOP CONTAMINATION AND MAY RESULT IN THE VEHCILE ENTERING A PROTECTIVE LOW-SPEED MODE WHICH CAN BE DANGEROUS IF THIS HAPPENS ON THE HIGHWAY. I CALLED MY LOCAL DEALER AND THEY ARE SAYING THAT THE THE NEXT APPOINTMENT FOR THIS FIX IS NOT UNTIL AUGUST 2018! I THINK THIS IS A PRETTY SERIOUS PROBLEM THAT FORD SHOULD FIX RIGHT AWAY. I HAVE NOT HAD ANY ISSUES HOWEVER I HAVE READ FROM SOME PEOPLE THAT THIS HAS HAPPEN ON THEIR VEHICLE IN WHICH THEIR CAR DROPPED TO 5MPH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11032161October 7, 2017
ELECTRONIC STABILITY CONTROL (ESC), ELECTRICAL SYSTEM, POWER TRAIN
WRENCH LIGHT CAME ON MEANING CONTACT DEALER ASAP ABOUT POWERTRAIN ISSUE. I HAD NOTICED A FEW DAYS EARLIER IT SEEMED TO NOT BE SWITCHING BETWEEN ELECTRIC AND ENGINE AS WELL OR SMOOTHLY WHEN DRIVING. WHEN STATIONARY, THE DISPLAY SCREEN FOR RADIO WOULD NOT COME ON WHEN GETTING INTO THE CAR. INSTEAD IT GIVES MESSAGE "TURNING OFF TO CONSERVE BATTERY." CAR HAS BEEN WELL MAINTAINED AND IS AT 78000 MILES. TOOK TO DEALER. CANNOT FIND ISSUE. CODES IT IS THROWING ARE FOR BATTERY BUT THEY BOTH TEST GOOD. THEY RESET CODES AND WE WENT TO PICK IT UP. NOW KEY FOBS WON'T WORK UNLESS THE CAR IS TURNED ON. ALARM BUTTON ON THE FOB MAKES THE CAR SOUND LIKE A FLUTTERING NOISE, BUT NO REAL ALARM. THE DEALER IS GOING TO KEEP IT MORE AND CHECK IT OUT MORE. STILL HAS THE MESSAGE ABOUT CONSERVING BATTERY ON THE SCREEN. THEY HADN'T FOUND WHAT CAUSED THE BATTERY CODES AND NOW MORE THINGS AREN'T WORKING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11031986October 6, 2017
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
VEHICLE IS NOT HOLDING EV NOW/LATER MODES CAUSING UNEXPECTED BATTERY USAGE AND FUEL CONSUMPTION. AN EXAMPLE IS TRAVELING HIGHWAY SPEEDS (70-75 MPH); VEHICLE WILL UNEXPECTEDLY SWITCH INTO AUTO MODE AND REVERT FROM GAS/HYBRID PERFORMANCE TO ELECTRIC/BATTERY ONLY PERFORMANCE WHICH IS REDUCED POWER AND RESPONSE AGAIN AT HIGHWAY SPEEDS. THIS IS NOT ALWAYS THE CASE AS I HAVE FOUND THIS TO HAPPEN BEFORE I ENTER THE HIGHWAY AND CAN ADJUST MY DRIVE ACCORDINGLY. ADDITIONALLY, THIS HAPPENS IN EV NOW MODE WHICH HOLDS THE ELECTRIC ENGINE TO PREVENT GAS USE AT ALL BUT THE SYSTEM WILL INADVERTENTLY SWITCH TO THE AUTO MODE. CONDITION IS EXTREMELY SPORADIC AND DIFFICULT TO REPLICATE MOST TIMES WILL HAPPEN WITHOUT THROWING A CHECK ENGINE LIGHT CODE. FORTUNATELY I DO HAVE A FEW INSTANCES WHERE A CODE WAS THROWN AND I WAS ABLE TO HAVE THE DEALER TAKE A LOOK AND MAKE SOME WARRANTY REPAIRS NONE OF WHICH HAVE RESOLVED THE ISSUE AS IT STILL COMES BACK IN THE SAME RANDOM FORM. ATTACHED ARE THE SEVERAL DEALER VISITS TO ADDRESS THE CONCERN AND AFTER SEVERAL VISITS, THE TRANSMISSION PUMP MODULE SEEMS TO BE A REPEAT ISSUE. UNFORTUNATELY NOT SURE IF THIS IS THE CAUSE OF THE MODES NOT HOLDING AS IT SHOULD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11031781October 4, 2017
ELECTRICAL SYSTEM
THE CAR WENT INTO "LIMP" MODE WHILE GOING 70 MPH. TOOK THE CAR IN AND WE WERE TOLD IT HAD A RECALL ON THE ELECTRONIC THROTTLE BODY. WE NEVER RECEIVED A RECALL NOTICE AND IT ISN'T LISTED ON THE NHTSA SITE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11024878September 21, 2017
UNKNOWN OR OTHER
UPON BRAKING, THE CAR HAS LURCHED FORWARD ON SEVERAL OCCASIONS, ALMOST REAR ENDING OTHER CARS, HAPPENS IN ALL KINDS OF WEATHER, ROAD SURFACES, INTERMITTENT BUT HAPPENS PROBABLY AT LEAST 3 TIMES PER WEEK. ALSO, WHEN STOPPED AND ACCELERATING, THE CAR HAS A HESITATION ISSUE LIKE NO FUEL GETS TO IT FOR A MOMENT AND THAT HAS HAPPENED 3 TIMES IN THE LAST WEEK AS WELL AS SEVERAL MONTHS AGO
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11024493September 19, 2017
ENGINE AND ENGINE COOLING, POWER TRAIN
DRIVING MY 2015 FORD C-MAX AND ALL OF A SUDDEN I LOSE POWER. I PRESS THE GAS AND NOTHING. I WAS DRIVING THROUGH A INTERSECTION AND HAD TO COAST TO THE SIDE OF THE RODE. BIG RED TRIANGLE SHOW UP SAYING "STOP SAFELY NOW". CAR HAS BEEN AT THE DEALER FOR 4 DAYS, THEY ARE TRYING TO FIND THE PROBLEM. I HAVE READ ONLINE ABOUT THIS PROBLEM WITH MULTIPLE FORD VEHICLES AND A RECALL WAS CALLED FOR THE FOCUS. I GUESS FORD IS TO BIG TO GO AFTER AND THE NTSB DRAGS THERE FEET LIKE NO OTHER. CALL FOR A RECALL ON ALL VEHICLES THAT "STOP SAFELY NOW'. WILL YOU WAIT UNTIL PEOPLE DIE TO DO SOMETHING!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11020018August 28, 2017
STRUCTURE:BODY
WHILE DRIVING, VEHICLE DOORS AND WINDOW AREAS CREAK AS IF THE FRAME/STRUCTURE IS COMPROMISED OR FLEXING UNUSUALLY. MAY BE SIMPLY POOR QUALITY CONSTRUCTION OR POOR LATCHING MECHANISMS, BUT SEEMS UNUSUAL FOR A NEW VEHICLE. CAR PURCHASED NEW AND HAS HAPPENED SINCE NEW; CAR NOW HAS 3,028 MILES ON IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford C-Max