Ford Bronco Complaints (2022)

367 consumer complaints on file.

#11751197July 17, 2026
UNKNOWN OR OTHER
Latch for the swing gate is locked in the closed position so the swing gate will not latch closed. It swings open while driving
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751093July 17, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749734July 11, 2026
STRUCTURE:BODY
Cracks in left rear of roof theirs a recall ones that painted but not on the matt finish one. My 2022 Ford Bronco 2 door is showing the same problems as the paint ones. And Ford Dealership said they at least a dozen or more around his dealership with the same issue. And online I have been told of 100s. Have the same thing happening to their Broncos the years 2021 to 2024 even ones sit on lots for with the same problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747641July 1, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747042June 28, 2026
POWER TRAIN, ENGINE
2022 Ford Bronco 2.7L EcoBoost VIN [XXX] has experienced recurring engine oil pressure failure causing vehicle to enter limp mode limiting speed to 25mph creating an unsafe driving condition. Diagnostic trouble codes P0524 Engine Oil Pressure Too Low and P06DD Engine Oil Pressure Control Stuck Off confirmed. Two failed warranty repair attempts at Lenoir City Ford Lenoir City TN on XXX and XXX. Dealership provided loaner vehicle both times acknowledging vehicle was unsafe to drive. Ford corporate case number XXC is open. Third repair attempt scheduled XXX.” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746901June 27, 2026
FUEL/PROPULSION SYSTEM
35 miles out of [XXX] on Monday, XXX our Bronco loss fuel flow in the fast lane of [XXX] and stalled while going 70mph we were surrounded by trucks also going 70mph, unexpectedly mid morning. No warning . Almost got rear ended and had to safely drift over to reach the side of the road. Very terrifying with cars going very fast behind us. We attempted to restart the Bronco and it started a few times and sputtered out. I immediately called the closest Ford dealership Gaudin and they dispatched a tow truck. The temperature was very hot and we waited for 1.5 hrs in the desert sun. The dealer provided a rental but I was not allowed to leave NV nor go more than 50 miles, they confirmed that it was a bad fuel pump. I did not receive the car back until Friday 6/19/26. This incident occurred on my first day of VC planned in [XXX]. My whole vacation was ruined, unexpected expenses, and the stress of having to drive with a defective part when it’s fixed is a problem. We have to drive back to LA and I can’t miss work. We took the vehicle to Gaupin in LA to have it serviced before this trip even an oil change on 6/11/26. They assured us that all was well, only 2 recalls showed up- rear camera and a seat adjustment bolt . Why didn’t the dealer tell us about the fuel pump and the dangers. The vin number has a listed “1 un-repaired recall - fuel pump dated 7/2025. Manufacturer #XXX, NHTSA# 25V455. No notice has come through the mail and then it states Recall incomplete in red. If it was known that the fuel pump could fail, how are owners allowed to drive around without a complete recall, and without a fix. The dealer said they are going to announce on Jun 29. Well in our case that’s a little too late. Am I supposed to drive with a defective fuel system??? They replaced the fuel pump with another new pump that will have the same issue, not a fix. On June 19 later that evening after fueling it up, a service engine light came on with exhaust system issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746745June 26, 2026
STRUCTURE:BODY
Ford has issued a recall for 2021- Jan 2022 hard tops. Mine is a June 2022 with the same issues but not listed in the recall. This has been a known issue for the life span of the Bronco.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744590June 16, 2026
ENGINE
While driving on an interstate it was determined that the engine walls over compressed and blew out the sides of the motor of my 2022 Ford Bronco. The Bronco has 67,000 miles on it which shows a clear manufacturer defect. It is available to be inspected as well to confirm. My wife’s and unborn child’s safety was put at risk by losing acceleration and losing control of the vehicle briefly as it began to shake from the engine misfiring. This easily could have caused a serious wreck had more traffic been present at the time. The dealership has not been able to confirm this on other cars. The engine has been inspected by a Ford Dealership. There were no warning lamps or messages prior to the failure and only appeared shortly after the engine over-compressed and began to shake.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744471June 16, 2026
ENGINE, POWER TRAIN
The Incident: While operating the vehicle under high load, the driver received an explicit "Service Engine Soon" powertrain malfunction alert stating: "The powertrain control module lost communication with the vehicle active grill shutter module for a period of time." Immediately following this warning, the engine experienced a severe loss of power, followed by loud metallic banging from the engine bay. The vehicle stalled completely and lost all motive power, creating an imminent highway safety hazard.The Physical Damage: Subsequent mechanical teardown by the dealership revealed terminal block destruction, including deep vertical cylinder wall scoring, heavy unburnt liquid gasoline residue in the engine oil pan, and a blown head gasket.Relationship to Active Safety Defect: This catastrophic engine failure mirrors the progressive failure profile of NHTSA Campaign 25V455 / Ford Safety Recall 25S75 (Low-Pressure Fuel Pump Failure). In this EcoBoost architecture, the Active Grill Shutter (AGS) module shares critical voltage paths, grounding blocks, and wiring looms with the engine management and fuel delivery systems. The sudden network communication loss is diagnostic proof of a severe voltage drop or electrical short caused by the high-friction fuel pump degradation detailed in Recall 25S75. This circuit failure instantly starved the engine of fuel under turbo boost, inducing an extreme lean-out condition. The resulting pre-ignition forces violently shattered the internal piston rings (the loud banging), which then gouged the cylinder walls, wiped out compression, fouled the crankcase with fuel residue, and blew the head gasket.Request for Action: Ford's current VIN parameters for Recall 25S75 have not yet captured my specific vehicle despite it matching the exact production window, component setup, and catastrophic failure sequence. I am requesting that the NHTSA log this case as definitive evidence of consequential engine destruction originating from the 25V455 fue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744448June 16, 2026
ENGINE, POWER TRAIN
While operating the vehicle under load, the vehicle suffered a sudden and severe loss of engine performance, followed immediately by loud metallic banging from the engine bay. The vehicle lost all power and was immediately disabled (LIMP MODE), presenting an imminent highway safety hazard.The Physical Damage: Subsequent mechanical teardown revealed deep vertical cylinder wall scoring, heavy raw fuel residue in the engine oil pan, and a blown head gasket. Relationship to Active Safety Defect: This catastrophic block failure perfectly mirrors the progressive failure profile of NHTSA Campaign 25V455 / Ford Safety Recall 25S75 (Low-Pressure Fuel Pump Failure). Internal component degradation in the fuel tank delivery module dropped fuel pressure to the engine. Under turbo boost, this starvation induced an extreme, instantaneous lean-out condition. The resulting low-speed pre-ignition (LSPI) exploded and shattered the internal piston rings (the metallic banging), leading to mechanical wall gouging, unburnt fuel wash into the lower crankcase, and a secondary blown head gasket. Request for Action: Ford's current VIN parameters for Recall 25S75 have not yet captured my specific vehicle despite it matching the exact production window, component setup, and catastrophic failure sequence. I am requesting that the NHTSA log this case as clear evidence of consequential engine destruction originating from the 25V455 pump defect, and evaluate whether Ford's recall scope must be expanded to protect other consumers from highway engine failures.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744346June 15, 2026
UNKNOWN OR OTHER, POWER TRAIN
Differential carrier replacement due to metal contmination being found in differential during oil change and a transmission overhaul due to excessive wear of(clutch container, CDF bushing, forward hub and front support bushings). They also noted a sticking valve in the main control on my 2022 Ford Bronco 2.7L V6 when taken in to dealership to evaluate vehichle under warranty due to ongoing intermittent thump/clunking noise when coming to a stop and accelerating from a stop as well as when backing up from a stop and while driving as well, intermittent loud metal slapping sound at speeds over 60 mph, intermittent jerking of vehichle when cycling through gears, unexpected downshift at high speeds. After differential replacement and transmission overhaul due to excessive wear while under warranty, my vehichle continues to experience the same symptoms and problems and feel this is a safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743541June 11, 2026
STRUCTURE:BODY
The Molded-In-Color (MIC) hard top shows signs of delamination and cracking on the exterior skin of the roof panel. Models from the same production year were called under NHTSA Recall No.: 26V299. My vehicle was not included on this recall. I have attempted to have Ford inspect the issue and have refused since it is out of warranty. I am concerned that the delaminating sections will detach while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743451June 11, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742488June 6, 2026
SUSPENSION
I took my vehicle to the local Ford dealership for the remedy for recall Ford 25S01 on Feb 2, 2026. During the inspection, it was found that the part affected was damaged and the dealership sent photos to Ford. After that, I haven't received any guidance from Ford or the dealership. Since the invoice I received indicated that there was a weld crack in one of the absorbers, I assume that the recall should repair this as a safety concern, but I haven't received any proactive communication from Ford or the dealership. I have contacted the dealership twice since February but I have not received any callback. I am concerned that this is a safety issue and Ford hasn't done anything to correct this since they found out about the issue in February.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742368June 5, 2026
UNKNOWN OR OTHER
Complete clutch failure at 39,000 miles. Unable to shift or safely restart vehicle once stopped. Clutch Hydraulic line came completely apart. Ford part number MB3Z-7A512-A. Failure verified by independent SAE certified mechanic. Note: Clutch and Brakes feed from the same reservoir, so loss of clutch hydraulic fluid also impacts entire braking system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742181June 4, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741910June 3, 2026
SERVICE BRAKES
I drive a Standard ‘22 Bronco. Only E-brake works for parking brake when in parking lots and such. My Bronco rolls into oncoming traffic and pedestrians when the e-brake releases. I am former Homeland Security and this unacceptable, as this if my 10th issue with the Ford Bronco! Safety First!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741895June 3, 2026
AIR BAGS
The contact owns a 2022 Ford Bronco. A warning light restraint indicator lamp warning saying airbag system may not deploy properly, vehicle impact sensors affecting airbag, received warning indicator on the instrument panel saying vehicle should not be driven until remedied and should be taken to dealer. The vehicle was taken to the dealer where it was not diagnosed or repaired but the dealer advised does not know how to resolve the issue, The manufacturer was not notified of the issue. The approximate failure mileage was 14,440.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741818June 3, 2026
BACK OVER PREVENTION, FUEL SYSTEM, GASOLINE
The contact owns a 2022 FORD BRONCO. The contact became aware that the VIN was included in NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) through a VIN search; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact stated that the rearview and front view cameras were intermittently inoperable. The contact related the failure to NHTSA Campaign Number: 26V124000 (Back Over Prevention). The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was approximately 8,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740584May 28, 2026
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
The instrument cluster panel goes black and stays blacked out for driving from startup to shutdown. This does not occur consistently, but it occurs often and unpredictably and is occurring more and more often. Attempted to have dealership fix and they want to replace the instrument cluster panel. This is a safety issue for basic functionality of the vehicle. Ford has had this issue identified during other years of Bronco production but appears unwilling to fix it in all of them.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco