Dodge Ram Complaints (2012)

1,397 consumer complaints on file.

#11706707December 23, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2012 Ram 1500. The contact stated that upon inspection, the fuel tank strap was corroded. No warning light was illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired because there was no related recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 18V160000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706813December 23, 2025
POWER TRAIN
Engine ticking noise, poorly made bolts on exhaust manifold were used. Bolts loosen or Break off and manifold warps or cracks. Cause exhaust leak into cabin. Truck can be inspected if needed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699801November 17, 2025
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
The contact owns a 2012 Ram 1500. The contact stated that while driving at undisclosed speeds, there was an abnormally loud howling and winding sound coming from the vehicle. There were no warning lights illuminated. The sound had progressed over time. The vehicle was taken to the local dealer, where it was diagnosed, and determined that the rear axle pin was faulty and might have caused the wheels to lock up. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697955November 6, 2025
FUEL/PROPULSION SYSTEM
Our 2012 RAM 2500 truck with 135k miles, had it's fuel tank fail. The dealership in Oak Ridge, TN tested the vehicle and found that the gas tank tubes were broken causing us to not be able to fill the tank. The dealership recommended "NEED TO REPLACE GAS TANK". Mopar aka Stellantis does not make the fuel tank anymore, the "replacement" fuel tank does not work (completely wrong configuration), there is not an aftermarket tank. We have a Million Mile bumper to bumper warranty with MOPAR. "Customer Care" does not care.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696795October 31, 2025
ENGINE, ELECTRICAL SYSTEM
The contact owns a 2012 Dodge Ram 1500. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The contact was able to coast to the side of the road. No warning lights were illuminated. After several attempts, the vehicle restarted. The contact stated that the failure persisted. The contact stated that on a separate occasion, while starting the vehicle, after releasing the key fob, the vehicle stalled. The contact taped the key to the side of the vehicle to start. The contact stated that once the key fob was taped, the windows failed to roll up, the indicators failed to function as intended, the heater and A/C failed to operate as needed, and the hazard lights were inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The approximate failure mileage was 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694960October 22, 2025
FUEL/PROPULSION SYSTEM
While driving my Ram truck at approximately 55 MPH, the front gas tank strap failed, causing the front portion of the fuel tank to drop below the vehicle’s body. Upon inspection, I found that the strap securing the tank had detached from its connection point on the frame. The failed part is available for inspection upon request. This incident presented a serious safety hazard to myself and others on the road, as the entire fuel tank could have separated from the vehicle, creating a significant risk of fire or collision. The issue was reported to a local dealership, which advised me to contact Dodge. Dodge acknowledged the issue but stated there is no warranty coverage or recall, and that any repair would be at my expense. No formal inspection has been performed other than my own, and I have implemented a temporary repair to secure the tank. There were no warning lights or prior symptoms before the failure. The only indication was a loud clunking noise followed by the sound of the strap repeatedly striking the drivetrain.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693828October 16, 2025
POWER TRAIN
Differential making scraping sound, points to the pinion gear having a problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693696October 15, 2025
FUEL/PROPULSION SYSTEM
I noticed while looking underneath my vehicle the front fuel tank strap was no longer attached. Further inspection show the frame had rusted enough that the fuel tank strap is no longer attachable. I noticed a recall (U04 / NHTSA 18V-160) was available however my VIN shows no record of this recall being available. So no dealer will assist me with it although my vehicle meets all of the prerequisites the recall states. Currently undriveable due to safety concerns.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689380September 24, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2012 Dodge Ram 1500. The contact stated that while driving at an undisclosed speed, there was an abnormally loud sound coming from the vehicle, followed by the sound of metal striking the vehicle. Upon inspection, the contact discovered that the fuel tank strap had detached from the vehicle due to extensive corrosion. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 210,000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688894September 22, 2025
AIR BAGS, ENGINE, FUEL/PROPULSION SYSTEM
This truck has had to have several high temp burnoffs because of failures in the EGR and Carbon build up. The recent recall for Rams does not cover the 2012, and began at 2013, however, we are experiencing the same exact issues with the same type of system. In addition, we have had repeated airbag issues due to the positioning of the cockspring and wiring getting choked out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687970September 17, 2025
WHEELS
Drivers side rear wheel broke loose from hub and bounced into the opposing lane of traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11685276September 5, 2025
FUEL/PROPULSION SYSTEM
Front gas tank strap pulled out from (rusted)-frame. Dropping front of (full) gas tank inches from road. I’m told there was an extended warranty for the issue. That I never received notice of. It has since expired. I found recall - U04/NHTSA 18V-160 That I’m also told doesn’t apply to my vehicle. Odd that the extended warranty would have. But the recall doesn’t?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11677703August 1, 2025
ENGINE
The vehicle finally became inoperable at 119,000 miles due to lifter failure. Lifter issues started when the vehicle had about 106,000 miles on it. There were multiple misfire and gas mileage became worse. There was a loud ticking noise coming from the engine as well. Vehicle has been well maintained and only 1 owner, purchased new. With the lifter failure, this caused damage to the camshaft and which led to an excess amount of metal shavings to be spread throughout the engine. The vehicle ultimately had to get a engine replacement because of the excess metal shavings in the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676775July 28, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2012 Ram 1500. The contact stated that while his son was driving approximately 50 MPH, there was an abnormal thud coming from the vehicle. The contact stated that his son was unaware of a warning light being illuminated and continued driving to his destination. The contact was informed that the vehicle muffler might have fallen off the vehicle. The contact drove to his son's workplace and inspected underneath the vehicle and became aware that the right front strap of the fuel tank had detached from the body of the vehicle and was touching the ground. The fuel tank was no longer properly secured to the vehicle. The contact drove the vehicle back to the residence. The contact called a dealer and was informed that there had been a manufacturer program to cover the repair of the fuel tank straps due to rust however, the vehicle was not covered under the program. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674243July 17, 2025
SERVICE BRAKES
The brake line broke on my Dodge truck and all the brake fluid leaked out. Fortunately this didn't happen while driving on the highway. I discovered no brakes when I got in the vehicle to leave. I have a long driveway. As I was driving the slight grade down to the main road, I hit the brakes and they went to the floor. I was able to turn around in my yard before all the brake fluid was gone and get the truck back to my barn. I got under the truck and took a picture. I discovered that the brakes had rusted and leaked out the fluid. No one has inspected it or confirmed it. The truck is not safe to drive and sitting in my barn
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668209June 20, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2012 Ram 1500. The contact stated that while driving at an undisclosed speed, the contact noticed an extremely loud knocking sound coming from the vehicle. The vehicle was driven to the residence. The vehicle was taken to an independent mechanic, where it was diagnosed with a front detached fuel tank strap and a rear fractured fuel tank strap. The contact was advised that the fuel tank straps needed to be replaced. The vehicle was not repaired. The contact was advised to contact the dealer for assistance. The vehicle was taken to the dealer where it was diagnosed with a front detached fuel tank strap and a rear fractured fuel tank strap. The contact was advised that the fuel tank straps needed to be replaced. The vehicle was being repaired. The contact referenced NHTSA Campaign Number: 18V160000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666195June 10, 2025
FUEL/PROPULSION SYSTEM
While driving down the highway I hit a bump then got a severe grinding noise in my 2012 Ram 1500. I pulled over and found the front gas tank strap had pulled out of the welded frame bracket for the fuel tank strap. The strap was not broken, the front fuel tank frame bracket had rusted out. The front fuel tank bracket which is welded to the frame needs to be repaired so the fuel tank strap will be held securely. The grinding I heard was the front fuel tank strap that had become detached was rubbing on the driveshaft.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663405May 28, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, ENGINE
Unknown this truck was not involved in an accident however it came close with steering /brakes the Engine Faulty Wiring Harness caused major issues it wasn’t until recently I saw a video of how to fix the problem you can view these videos online I will say Dodge is Responsible they did have buybacks this too I had No Knowledge of no recalls either however I recently address it to the dealership who sold me this truck the Service Manager told me it’s my issue not theirs they took care of it years ago this is the reason I am sending my complaint I was informed your department will look into this matter to get a resolution on this serious matter thank you. I have some photos the video would not download you can see it if you put 2012 Dodge Ram Engine Faulty Wire issues . Yes I spent $3000 for a mechanic to wire it this should had been fix by Dodge Chrysler not me and it still needs to be fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661342May 15, 2025
ENGINE
The engine has lifters ticking when cold and a loss of power during operation. The engine hesitates during driving at different times and runs rough. There is no warning before this happens and no warning lights/sensors activated. The truck only has 76k miles on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660592May 13, 2025
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, AIR BAGS
The contact owns a 2012 Ram 1500. The contact stated that the check engine, air bag, and the fuel pump relay failure warning lights were illuminated. The contact stated that the exterior lights failed to operate as needed, and the vehicle occasionally failed to start. Additionally, the contact stated that the vehicle stalled while driving. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the TIPM was faulty and needed to be replaced. The local dealer was not contacted. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Dodge Ram