Country Coach Magna Recalls

16 recalls on file.

• Recall08V484000September 22, 2008
  STEERING:HYDRAULIC POWER ASSIST SYSTEM

  COUNTRY COACH IS RECALLING 238 MY 2006-2008 AFFINITY AND MAGNA MOTOR HOMES. LOSS OF POWER STEERING ASSIST CAN OCCUR IN THESE MOTOR HOMES.

  Remedy

  DEALERS WILL REPLACE THE FAN DRIVE HYDRAULIC PUMP AND THE TRANSMISSION MOUNTED DRY SPLINE POWER TAKE-OFF WITH A WET SPLINE POWER TAKE-OFF AND RELOCATE THE ENGINE POWER STEERING PUMP TO THE ENGINE POWER STEERING MECHANICAL DRIVE PAD. OWNERS WILL BE NOTIFIED ABOUT THIS RECALL BEGINNING ON SEPTEMBER 28, 2008, WITH INSTRUCTIONS THAT SHOULD THEY EXPERIENCE LOSS OF POWER STEERING OR A SEVERE REDUCTION IN THE ABILITY TO STEER THE MOTOR HOME THAT THEY SHOULD IMMEDIATELY CONTACT THE COUNTRY COACH SERVICE CENTER. THE PARTS NECESSARY FOR THIS RECALL WILL NOT BE AVAILABLE UNTIL MID-NOVEMBER 2008, AT WHICH TIME THE OWNERS WILL BE NOTIFIED TO BRING IN THEIR VEHICLE FOR REPAIR. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall08V119000March 13, 2008
  EXTERIOR LIGHTING

  COUNTRY COACH IS RECALLING 1,228 MY 2004-2008 MAGNA, AFFINITY AND INTRIGUE MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUES SPECIFIED IN FMVSS NO. 108.

  Remedy

  DEALERS WILL REPLACE THE MARKER LIGHTS ON THE SIDE OF EACH MOTOR HOME AS CLOSE AS REASONABLE TO THE FRONT AND REAR CORNERS AND WIRED INTO THE PARK LIGHT SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall07V031000February 1, 2007
  EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

  CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

  Remedy

  COUNTRY COACH WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). A SECONDARY BURNER HOUSING WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2007. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COUNTRY COACH AT 1-800-452-8015.

• Recall06V329000August 31, 2006
  EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

  ON CERTAIN MOTOR HOMES, EXISTING FASTENERS USED TO SECURE THE SATELLITE DOME TO THE MOTOR HOME ROOF DO NOT PENETRATE THE ROOF SUFFICIENTLY TO PREVENT THE DOME FROM COMING OFF WHILE THE VEHICLE IS IN TRANSIT.

  Remedy

  DEALERS WILL REPLACE THE EXISTING FASTENER WITH A JACK NUT AND LONGER BOLTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 18, 2006. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall06V262000July 13, 2006
  TIRES

  COUNTRY COACH HAS REPORTED THAT THE TOYO 275/70R M102Z TIRES ON CERTAIN MOTOR HOMES ARE DEFECTIVE AND COULD FAIL UNEXPECTEDLY.

  Remedy

  DEALERS WILL REPLACE THESE TIRES WITH MICHELIN 275/70R XZA2 TIRES. THE FEDERAL TIRE LABELS WILL ALSO BE REPLACED. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall06V097000April 3, 2006
  EQUIPMENT:OTHER:LABELS

  CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE FEDERAL TIRE LABELS INCORRECTLY STATE THE COLD TIRE INFLATION PRESSURE FOR THE TOYO 12R22.5 REAR TIRES.

  Remedy

  OWNERS WILL BE PROVIDED WITH NEW FEDERAL TIRE LABELS WHICH REFLECT THE CORRECT COLD TIRE INFLATION PRESSURE FOR THE REAR TIRES. THE RECALL BEGAN ON MAY 8, 2006. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall05V373000August 29, 2005
  EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

  ON CERTAIN MOTOR HOMES, THE HYDRAULIC SLIDE ROOM HOSES COULD BLISTER AND LEAK DUE TO ENGINE HEAT.

  Remedy

  DEALERS WILL RELOCATE THE HYDRAULIC HOSES OUTSIDE OF THE ENGINE COMPARTMENT AND REPLACE ANY HOSES THAT EXHIBIT SIGNS OF BLISTERING OR LEAKAGE. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall05V209000May 9, 2005
  EQUIPMENT

  ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

  Remedy

  VEHICLE SYSTEMS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR COUNTRY COACH AT 1-800-547-8015.

• Recall04V418000August 26, 2004
  EQUIPMENT:OTHER:LABELS

  CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VHEICLES OTHER THAN PASSENGER CARS.' THE LABELS STATE INADEQUATE COLD TIRE INFLATION PRESSURE FOR THE FRONT TIRES ON THEIR FEDERAL TIRE LABELS.

  Remedy

  DEALERS WILL REPLACE FEDERAL TIRE LABELS REFLECTING THE CORRECTED COLD TIRE INFLATION PRESSURE FOR THE FRONT TIRES. THE RECALL BEGAN ON SEPTEMBER 10, 2004. OWNERS SHOULD CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall04V043000February 2, 2004
  TIRES

  CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT AXLE RATING IS INCORRECT.

  Remedy

  DEALERS WILL REPLACE BOTH FRONT TIRES AND THE FRONT AXLE WILL BE RE-RATED TO 12,000 LBS. ALL MOTOR HOMES WILL BE ISSUED NEW FEDERAL TIRE LABELS. OWNER NOTIFICATION IS EXPECTED TO BEGIN FEBRUARY 10, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-547-8015.

• Recall03V109000March 26, 2003
  EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

  ON CERTAIN MOTORHOMES EQUIPPED WITH INTERNATIONAL THERMAL RESEARCH (ITR)HURRICANE HOT WATER HEATERS, THE ELECTRONIC CONTROL BOARD MAY ADVERSELY AFFECT SAFETY FEATURES IN SOME OF THE SYSTEMS PROTECTING AGAINST OVERHEATING AND POTENTIAL FIRE SITUATION.

  Remedy

  THE DEFECTIVE ELECTRONIC CONTROL BOARD WILL BE REPLACED. IN THE MEANTIME, CUSTOMERS SHOULD TURN THE SYSTEM OFF USING THE MASTER ON/OFF SWITCH LOCATED ON THE SIDE OF THE ELECTRONIC CONTROL BOX WHICH IS ADJACENT TO THE HEATER. OWNERS WHO TAKE THEIR MOTORHOMES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ITR AT 1-800-755-1272 OR COUNTRY COACH AT 1-800-547-8015.

• Recall02V164000June 13, 2002
  EQUIPMENT:ELECTRICAL

  ON CERTAIN MOTOR HOMES EQUIPPED WITH SLIDE-OUT GENERATORS, CERTAIN GENERATOR SLIDE-OUT BALL SCREW ACTUATOR BRAKE HOLDING COMPONENTS ARE DEFECTIVE. THE BRAKE MAY NOT ALLOW THE ACTUATOR TO HOLD THE LOAD IN POSITION WITH THE POWER OFF. THE AMOUNT THE LOAD MAY MOVE CAN VARY AND IN SOME CASES THE ACTUATOR MAY NOT HOLD AT ALL. THESE ACTUATORS ARE USED TO CONTROL THE MOVEMENT OF THE SLIDE-OUT GENERATOR MOUNTED IN THE FRONT OF THE MOTOR HOMES.

  Remedy

  DEALERS WILL REPLACE THE ACTUATOR. OWNER NOTIFICATION BEGAN JUNE 19, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall01V322003November 26, 2001
  VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

  VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.

  Remedy

  DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall01V354000November 15, 2001
  SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

  VEHICLE DESCRIPTION: MOTOR HOMES. MISALIGNMENT OF THE MOTOR HOMES' FRONT BRAKE HOSES DURING SHARP TURNING MOVEMENTS CAN WEAKEN THE HOSES THROUGH RUBBING AND/OR CHAFFING ON THE STEERING TIRES OR COMPONENTS OF THE FRAME. A SUDDEN LOSS OF BRAKING ON A STEERING WHEEL COULD OCCUR IF THE HOSE RUPTURES, CAUSING THE MOTOR HOME TO PULL SHARPLY TO ONE SIDE.

  Remedy

  DEALERS WILL REPLACE AND RE-ROUTE THE FRONT BRAKE HOSES. OWNER NOTIFICATION BEGAN NOVEMBER 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall01V284000September 6, 2001
  EQUIPMENT:OTHER:LABELS

  CERTAIN MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE MOTOR HOMES WERE ERRONEOUSLY ASSIGNED INADEQUATE TIRE INFLATION PRESSURES AND INADEQUATE AXLE WEIGHT RATINGS ON THE FRONT AND/OR REAR AXLES AS A RESULT OF MATHEMATICAL MISCALCULATIONS. THESE MOTOR HOMES HAVE TIRE WEIGHT RATINGS THAT ARE LESS THAN THE FRONT OR REAR AXLE WEIGHT RATINGS (FRONT AXLE WEIGHT RATING:FAWR AND REAR AXLE WEIGHT RATINGS:RAWR) AND IN SOME INSTANCES HAVE INADEQUATE FAWR AND/OR RAWR.

  Remedy

  DEALERS WILL REMOVE THE FRONT AND/OR REAR TIRES AND REPLACED. FEDERAL TIRE LABELS WILL ALSO BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

• Recall99V014003October 27, 1999
  SUSPENSION:FRONT:WHEEL BEARING

  VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH 16,000 LB., 18,000 LB., OR 20,000 LB. HEAVY DUTY STEERING AXLES. THE INNER WHEEL BEARING CONE FOR THE STEERING AXLE WHEEL HUB ASSEMBLY DOES NOT PROPERLY FIT ONTO THE NAVISTAR STEERING AXLE SPINDLE ASSEMBLY. IMPROPER FIT OF THE BEARING TO THE SPINDLE INCREASES THE STRESS LEVELS TO THE STEERING AXLE SPINDLE WHICH COULD CAUSE SPINDLE FAILURE.

  Remedy

  DEALERS WILL REMOVE THE LEFT AND RIGHT HUB/DRUM ASSEMBLIES FROM THE STEERING AXLES AND REPLACE THE INNER WHEEL BEARING CONES AND CUPS.