Chevrolet · Model Report
Showing safety data for the 1988 model year only.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
DRIVERS SEAT AND/OR SHOULDER BELT LOCKING MECHANISM MAY NOT OPERATE.
BRIDGESTONE TIRE RUPTURE: PLY SEPARATION, ON FREEWAY, NO WARNING, AT 35000 MILES WITH LOTS OF TREADLIFE REMAINING. I CAN PROVIDE PHOTOS OF DAMAGED TIRE ON REQUEST. ALL PLIES OF TIRE COMPLETELY SEPARATED, THEY WERE NEVER BONDED TOGETHER PROPERLY. TIRE IS BRIDGESTONE M773 SWP II, SIZE 235-85-16.
No injuries · No fire · No crash
IT WAS NOTICED THAT THE P/S GEARBOX WAS SEPARATING FROM ITS MOUNT ON THE VEHICLE FRAME AS THE STEERING WHEEL WAS MOVED. THE STEERING BECAME LOOSER. IT WAS DISCOVERED THAT THE U-CHANNEL FRAME WAS CRACKED OUT IN THE AREAS OF 3 OF THE 4 POWER STEERING GEARBOX MOUNTS. THESE CRACKS HAD TO BE WELDED. A YEAR AN A HALF LATER A CHECK OF THE WELDS WAS MADE FROM UNDERNEATH THE VEHICLE AND A NEW CRACK WAS FOUND. THERE WAS NO COMMERCIALLY AVAILABLE DOUBLER/STIFFENER REPAIR PLATE AVAILABLE FOR THIS PARTICULAR MODEL. THE FRAME SHOULD NOT CRACK UNDER NORMAL USE. *TR
No injuries · No fire · No crash
I PURCHASED FOUR PREMIUM BRIDGESTONE TIRES ($168 EACH). TWO OF THESE HAVE NOW FAILED PREMATURELY DUE TO CATASTROPHIC TREAD SEPARATION. THE FIRST WAS AT 29,000 MILES, THE SECOND AT 32,000 MILES. BOTH STILL HAD PLENTY OF TREAD DEPTH REMAINING. I BELIEVE THAT MY SAFETY IS AT RISK WITH THE TWO REMAINING TIRES. THESE TIRES WERE NEVER DRIVEN OFF-ROAD, AND WERE WELL CARED FOR PRIOR TO SUDDEN FAILURE. THE TIRE MODEL WAS BRIDGESTONE R273SWP. *TR
No injuries · No fire · No crash
PURCHASED FOUR BRIDGESTONE R273 SWP PREMIUM TIRES IN 2001 ($168 EACH) FROM BRIDGESTONE DEALER. VEHICLE IS 1988 CHEVROLET SUBURBAN, USED FOR ON-ROAD USE ONLY. VEHICLE IS GARAGED DAILY, ONLY DRIVEN ~5000 MILES PER YEAR. TIRE SIZE IS 235-85R16E. TOTAL MILEAGE ON TIRES IS 29,000 MILES. ESTIMATED REMAINING TREAD LIFE 50% (9/32"). LEFT REAR TIRE SUDDENLY HAD TREAD SEPARATION WHILE DRIVING ON FREEWAY. TIRE DID NOT LOSE AIR, BUT TREAD SEPARATED FROM CASING AND STEEL BELTS WERE VISIBLE FOR APPROX 6-8" IN AREA OF SEPARATION. THERE WAS NO PUNCTURE OR ANY OTHER VISIBLE EVIDENCE FOR CAUSE OF FAILURE. DEALER REPLACED TIRE FOR FREE, ONLY CHARGING FOR BALANCE/ETC. HOWEVER, I'M CONCERNED ABOUT THE OTHER THREE TIRES. HAS THERE BEEN ANY HISTORY OF FAILURES/RECALLS ON THIS TIRE? SHOULD I INSIST THAT BRIDGESTONE REPLACE THE REMAINING THREE TIRES FOR FREE? *TR
No injuries · No fire · No crash
DT*: THE CONTACT STATED WHILE SITTING IN THE VEHICLE THE DRIVER'S SEAT BOLT FRACTURED CAUSING THE SEAT TO FALL BACKWARD. AN INDEPENDENT REPAIR SHOP REPLACED THE BOLT.
No injuries · No fire · No crash