Chevrolet HHR Complaints (2006)

1,006 consumer complaints on file.

#10362263October 25, 2010
AIR BAGS
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE AIR BAG LIGHT WAS CONSTANTLY LIT ON THE INSTRUMENT PANEL. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 54,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10358019September 28, 2010
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER SIDE PLASTIC DOOR HANDLE BROKE OFF NOVEMBER 2008. THE HANDLE WAS REPLACED AT THAT TIME BUT IT BROKE OFF AGAIN TWO WEEKS LATER. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD LOOK INTO IT. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 30,194.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10357865September 27, 2010
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER SIDE INTERIOR DOOR HANDLE WAS INOPERABLE. WHEN ATTEMPTING TO EXIT THE VEHICLE AND ENGAGING THE DOOR HANDLE, THE DOOR WOULD NOT OPEN. THE VEHICLE WAS INSPECTED AT AN AUTHORIZED DEALER BUT NOT REPAIRED. THE MANUFACTURER ADVISED THE CONTACT THAT THE TECHNICIAN DID NOT LOCATE A MANUFACTURING DEFECT THEREFORE THEY WOULD NOT ASSIST WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 30,600. UPDATED 12/22/10 *BF UPDATED 12/29/10*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10357681September 26, 2010
STRUCTURE, LATCHES/LOCKS/LINKAGES
WHILE OPENING THE LEFT FRONT DOOR FROM THE INSIDE THE PLASTIC CHROME DOOR HANDLE BROKE OFF IN MY HAND MAKING IT IMPOSSIBLE TO OPEN THE DOOR FROM THE INSIDE. THIS WILL IMPAIR THE ABILITY OF THE OCCUPANTS TO EXIT THE VEHICLE IN THE EVENT OF AN EMERGENCY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10353864September 4, 2010
ELECTRICAL SYSTEM, STEERING, TRACTION CONTROL SYSTEM
TURNED ON THE IGNITION AND THE DASHBOARD GAUGES ALL WENT OUT. PULLED THE FUSE AND REINSERTED IT - PROBLEM CORRECTED. T/C INDICATOR ON INSTRUMENT PANEL CAME ON AND THE TRANSMISSION WAS UPSHIFTING HARD. AGAIN, I REMOVED AND REINSTALLED THE FUSES AND THE PROBLEM WENT AWAY. POWER STEERING WARNING WAS DISPLAYED ON THE DASH AND THE POWER STEERING WAS DISABLED. I REMOVED AND REINSTALLED THE FUSE ASSOCIATED WITH THE POWER STEERING AND THE PROBLEM WENT AWAY. I DID NOTICE THAT MOST OF THE FUSES WERE MILDLY OXIDIZED ON ONE LEG OF EACH FUSE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10353871September 4, 2010
STEERING
2006 CHEVY HHR LT, WHILE DRIVING AT A POSTED SPEED OF 45MPH, DAUGHTER LOST POWER STEERING SENDING HER INTO THE CURB ALMOST HITTING ANOTHER CAR THEN INTO THE CURB AGAIN. SHE WAS TERRIFIED BY THIS INCIDENT. MY HUSBAND WENT TO PICK HER UP AND HE DROVE THE VEHICLE BACK TO OUR HOUSE, AND WHILE ON THE HIGHWAY AT 65MPH, AGAIN THE POWER STEERING FAILED, AND HE ALMOST CRASHED INTO THE WALL BUT WAS ABLE TO BRING THE VEHICLE TO A STOP WITHIN INCHES OF CRASHING. THE POWER STEERING LIGHT HAS NOW COME ON SEVERAL TIMES, AND THE STEERING HAS GONE OUT WHILE DRIVING THREE TIMES THUS FAR. IN ADDITION THE GEAR SHIFT HAS BECOME A PROBLEM AGAIN WHERE IT LOCKS, AND I HAVE ALREADY HAD THIS REPLACED 3 TIMES, EACH TIME LASTING ABOUT A YEAR BEFORE THE PROBLEM REOCCURS. I HAVE READ THAT SEVERAL OTHER 2006 MODELS HAVE BEEN EXPERIENCING THE SAME POWER STEERING PROBLEM, SEVERAL OF THEM RESULTING IN ACCIDENTS. ARE THEY WAITING FOR SOMEONE TO BE KILLED BEFORE EXPANDING THE RECALL TO INCLUDE THE STEERING ON THE 2006 CHEVY HHR? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351905August 26, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
2006 CHEVY HHR. GEAR SHIFT CONTROL PIN FALLS OUT OF PLASTIC RETAINMENT PIECE RESULTING IN GEAR SHIFT BUTTON STICKING IN THE INWARD POSITION AND THE KEY REMAINING LOCKED IN STEERING COLUMN. DUE TO A DEFECT IN MANUFACTURING, THE PLASTIC CRACKS AROUND THE PIN RETAINMENT HOLE. THE CONTROL PIN THEN BECOMES LOOSE, THUS RESULTING IN THE CONTROL PIN EITHER MOVING OUT OF IT'S INTENDED POSITION AND JAMMING THE GEAR SELECTOR, OR FALLING OUT COMPLETELY AND ALLOWING THE GEAR SELECTOR TO MOVE IN ANY GEAR AT ANY TIME, WEATHER THE CAR IS RUNNING OR SHUT OFF. ONCE CONTROL PIN MOVES OUT OF POSITION OR FALLS OUT, THE MICRO SWITCH CANNOT BE ACTIVATED TO RELEASE THE KEY FROM THE IGNITION, THUS RESULTING IN A DEAD BATTERY VERY DANGEROUS. THE DEALERSHIPS ARE AWARE OF THIS PROBLEM BUT INSIST THERE IS NO T.S.B. OR RECALL. THEY COULD EASILY REPLACE THE PLASTIC RETAINMENT PART WITH THE NEWER VERSION USED IN LATER MODELS, BUT CLAIM THEY CAN'T GET IT. THERE REMEDY IS TO REPLACE THE ENTIRE SHIFTER ASSEMBLY AT A COST OF $150.00 PLUS LABOR. THE NEWER RETAINMENT PART CAN'T COST MORE THAN 15 DOLLARS,(NARROW PIECE OF PLASTIC ~ THE SIZE OF A PENCIL WITH A SMALL HOLE IN IT). THIS PART GOES FROM THE TOP OF THE SHIFTER TO THE BOTTOM OF THE GEAR SELECTOR AND HOLDS THE CONTROL PIN IN POSITION, WHICH IN TURN, ACTIVATES THE MICRO SWITCH TO RELEASE THE KEYS. WITH THE AMOUNT OF OCCURRENCES LISTED ONLINE SINCE 2006. THIS, WITHOUT A DOUBT, SHOULD BE A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351579August 24, 2010
LATCHES/LOCKS/LINKAGES, STRUCTURE:BODY:DOOR
CHEVY HHR 2006 DRIVERS SIDE INTERIOR DOOR HANDLE BROKE OFF IN HAND DURING NORMAL USE. MADE OF CHEAP PLASTIC. AUTO MAKER STATES THAT THE ONLY WAY TO REPAIR IS TO COMPLETELY REMOVE THE DOOR AND PAY. ALL OF THIS FOR A PIECE OF PLASTIC WHICH SHOULD COST PENNIES TO REPLACE? I SUFFER FROM NECK PAIN AND HAVE TROUBLE ROLLING THE WINDOW DOWN TO REACH OUT AND OPEN THE DOOR. THEY HAVE TO FIX THIS AT THEIR COST. THIS IS OBVIOUSLY NO FAULT OF THE OWNERS AND ONLY DUE TO FAULTY (PLASTIC) EQUIPMENT THEY ARE USING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351224August 23, 2010
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WATER WOULD ENTER THE VEHICLE BEHIND THE GLOVE COMPARTMENT EVERY TIME IT WOULD RAIN AND THE PASSENGER SIDE FLOORBOARD WOULD BECOME SATURATED. THE DEALER ADVISED THAT THE SEAL OF THE FRAME BEHIND THE GLOVE COMPARTMENT WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE POTENTIAL DEVELOPMENT OF MOLD AND FUNGUS IF THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 18,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351270August 23, 2010
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY. THERE WAS A STRONG BURNING ODOR AND THE CONTACT DISCOVERED THAT THERE WAS A HOLE IN THE ENGINE OIL PAN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND HE CONTACTED THE MANUFACTURER. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 50,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10350754August 20, 2010
STEERING:ELECTRIC POWER ASSIST SYSTEM
ELECTRIC POWER STEERING FAILURE: THIS IS A KNOWN ISSUE BY GENERAL MOTORS AND THEY HAVE RECALLED CHEVROLET COBALT AND MALIBU, ALONG WITH PONTIAC G5. THE SAME PART IS USED IN THE CHEVROLET HHR, WHICH SHARES THE SAME PLATFORM AND MANY COMMON PARTS WITH THE COBALT AND G5. I HAVE HAD SEVERAL INSTANCES OF POWER STEERING FAILURE THAT NEARLY RESULTED IN ACCIDENTS. I FEEL ENDANGERED AND GENERAL MOTORS DOES NOT CARE. THEY NEED TO RECALL THIS. I HAVE SEARCHED AND FOUND MANY MANY INCIDENTS OF THIS OCCURRING ON THE WEB. THEY KNOW ABOUT THIS AND REFUSE TO ACKNOWLEDGE THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10350910August 19, 2010
SUSPENSION
2006 CHEVROLET HHR LS. CONSUMER STATES THAT VEHICLE HAS WORN STRUTS WHICH NEEDED TO REPLACED AFTER ONLY 33,000 MILES AND DEALER HAS BEEN UNABLE AND UNWILLING TO ASSIST WITH DEFECT *TGW
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10350203August 18, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
I HAVE HAD MY 2006 HHR IN DEALERSHIP 3 TIMES FOR A HARD SHIFTING TRANSMISSION. THEY REBUILT THE TRANSMISSION AND I AM HAVING THE SAME PROBLEM AGAIN. I TOOK IT BACK THEY DROVE IT AND IT WAS FINE. THIS HARD SHIFTING HAPPENS MAYBE 25PER CENT OF THE TIME BUT WHEN IT DOES IT SHIFTS VERY HARD AND CONTINUES. I AM AFRAID IT WILL PUT ME DOWN WHAT CAN I DO? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10350431August 18, 2010
STRUCTURE
I OWN A 2006 CHEVROLET HHR, TODAY WHEN I PARKED MY CAR THE DRIVERS INSIDE DOOR HANDLE BROKE AND I COULDN'T OPEN MY DOOR. I HAVE FOUND MANY COMPLAINTS ONLINE ABOUT THIS PROBLEM AND HAVE SEARCHED FOR REPLACEMENT PARTS. NONE TO BE FOUND. THE ONLY SOLUTION IS TO REPLACE THE ENTIRE DOOR PANEL AT A HEFTY PRICE. MY CONCERN TO THIS MATTER IS THE FACT IF YOU GET IN AN ACCIDENT OR THERE IS A FIRE AND THE DOOR HANDLE BREAKS YOU CAN'T GET OUT OF THE CAR. THEREFORE I FEEL STRONGLY THIS IS A DEFECT ON THE PART OF GM SINCE THE HANDLE IS MADE OUT OF PLASTIC AND CAN'T TAKE THE STRESS OF CONTINUOUS OPENING. APPARENTLY THEY HAVE NOT RESPONDED TO MANY COMPLAINTS ABOUT THIS AND I FIND IT NECESSARY TO REPORT THIS MATTER. THIS COULD BE A MAJOR PROBLEM IF SOMEONE IS TRAPPED IN THE CAR AND CAN'T GET OUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10349922August 17, 2010
STEERING
WHILE DRIVING ON THE HIGHWAY AT 65-70 MPH MY POWER STEERING SHUT OFF. THE DASH BOARD DINGED 3 TIMES, GOT A MESSAGE ABOUT THE POWER STEERING AND THE NEEDLES ON THE MPH AND RPMS WERE ALL OVER THE PLACE. THE SHIFTER IS ON THE FLOOR AND WILL MAKE A CLICKING NOISE LIKE IT'S TRYING TO FIND A GEAR OR SOMETHING. THAT HAPPENED ON 7/31/10 AND HAS HAPPENED 4 TIMES SINCE. THIS SITUATION CAN HAPPEN AT SPEEDS. CAR WILL ALSO BUCK/JERK HARD WHEN TRYING TO ACCELERATE WHEN THIS HAPPENS. I HAVE GIVEN UP DRIVING THE CAR AS ITS NOT SAFE. I HAVEN'T GOTTEN IT FIXED YET SINCE I WOULD LIKE TO SEE THIS PROBLEM RECALLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10348649August 11, 2010
ELECTRICAL SYSTEM, POWER TRAIN:AUTOMATIC TRANSMISSION
2006 HHR WITH AUTOMATIC TRANSMISSION. REPAIR LIGHT LIT WITH CODES INDICATING INTERNAL TRANSMISSION PROBLEMS AND BAD CONNECTIONS IN ELECTRICAL SYSTEM. SEVERAL TRIPS TO MECHANIC LOCALIZED PROBLEM TO CONNECTOR PLUG ON TRANSMISSION. HARNESS WIRE IS TOO SHORT AND DRIVETRAIN FLEX CAUSES STRAIN ON PLUG RESULTING IN FAILURE OF CONNECTOR PINS IN PLUG. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10348646August 11, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
2006 CHEVY HHR LT WITH AUTOMATIC TRANSMISSION. METAL PIN MECHANISM LOCATED IN LOWER SHIFTER HANDLE WHICH ACTIVATES TRANSMISSION INTERLOCK SLIDES OUT OF SHIFTER UNIT DUE TO EXCESSIVE WEAR ON THE PLASTIC CARRIER BRACKET. SHIFTER HANDLE IS THEN ABLE TO BE PULLED OUT OF PARK WHEN KEY IS IN "OFF" OR "LOCK" POSITION AND KEY CANNOT BE REMOVED FROM IGNITION WITHOUT DISASSEMBLING THE CONSOLE TO ACTIVATE THE MICROSWITCH INTERLOCK. ANECDOTAL EVIDENCE INDICATES THIS PROBLEM OCCURS ACROSS HHR AND COBALT PLATFORMS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10348074August 8, 2010
STRUCTURE, LATCHES/LOCKS/LINKAGES
MY HHR DRIVER'S INTERIOR HANDLE BROKE OFF A FEW WEEKS AGO. I FEEL THAT GM NEEDS TO RECALL 2006 HHR CARS AND REPLACE THE DOOR HANDLE. I DO NOT HAVE $400.00 TO GIVE THE DEALERSHIP. A MONTH AGO I JUST PAID FOR KEY IGNITION SWITCH TO BE FIXED FOR $400.00. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10347275August 4, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
THE BUTTON ON THE SHIFT LEVER ON THE AUTOMATIC TRANSMISSION OF MY 2006 CHEVY HHR STICKS IN THE IN POSITION ALLOWING THE TRANSMISSION TO BE SHIFTED INTO ANY GEAR INCLUDING PARK AND REVERSE AS I AM DRIVING. THIS PROBLEM IS INTERMITTENT BUT RECURS FROM TIME TO TIME, VERY UNPREDICTABLE. AT THIS TIME I HAVE NOT FIXED IT BECAUSE I WAS DEBATING TRADING THE CAR IN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10347270August 4, 2010
ENGINE AND ENGINE COOLING
MY '06 CHEVY HHR WAS RUNNING FINE FOR 4 YEARS AND THEN 3 WEEKS AGO THE ENGINE LIGHT CAME ON AND MY CAR STOPPED AND STARTED COASTING WHILE I WAS IN THE MIDDLE OF DRIVING IT. AFTER THAT INCIDENT, IT HAPPENED INTERMITTENTLY EVERY OTHER DAY AND NOW WE CAN'T DRIVE IT A FEW MILES WITHOUT IT SHUTTING DOWN SEVERAL TIMES. IT ALWAYS STARTS RIGHT BACK UP BUT IT IS EXTREMELY DANGEROUS B/C IT HAPPENED WHILE MY HUSBAND IS DRIVING ON THE FREEWAY. WE ARE AT THE POINT WHERE WE DON'T DRIVE IT OUTSIDE OF THE NEIGHBORHOOD AND WE'RE GOING TO SEE ABOUT GETTING A NEW VEHICLE. I SAW ONLINE WHERE PEOPLE WERE HAVING THE SAME PROBLEM. I AM GOING TO THE DEALER NEXT WEEK TO HAVE IT CHECKED BY THEM BUT I DON'T THINK I SHOULD HAVE TO PAY FOR THIS IF IT IS A DEFECT IN THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet HHR