Chevrolet · Model Report
Showing safety data for the 2004 model year only.
General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.
General Motors (GM) is recalling certain model year 2003-2004 Chevrolet Express and GMC Savana vehicles, equipped with a left side cargo door, and originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Water and road contaminants may become trapped in the protective conduit that covers the fuel filler pipe and may cause the pipe to corrode.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
NHTSA Campaign Number: 12V388000. I have this problem. A leaking fuel line due to corrosion. I drive in the Cascade MT's of Washington state. my line now leaks excessively on fill up.
No injuries · No fire · No crash
This vehicle was sold for use over US highways, as "repairable condition". After going to a mechanic shop, I was advised, because of sever rust the rear leaf spring hangers were completely rusted thru, the rear axle assembly could come off or the frame could break in half, by just going over say, a railroad crossing. The mechanic said they would not repair this vehicle for use to drive on roads. I am requesting a local representative to help evaluate if this vehicle is safe to travel on Oklahoma roads.
No injuries · No fire · No crash
MY 2004 CUTAWAY CHEVY SOLD AS A 2005 FOUR WINDS HAS THE EXACT PROBLEM FOR THIS RECALL. RECALL NUMBER 12V388000 RECALL DATE 08/08/2012 COMPONENT FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP SUMMARY GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2003-2004 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES, EQUIPPED WITH A LEFT SIDE CARGO DOOR, AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. WATER AND ROAD CONTAMINANTS MAY BECOME TRAPPED IN THE PROTECTIVE CONDUIT THAT COVERS THE FUEL FILLER PIPE AND MAY CAUSE THE PIPE TO CORRODE. CONSEQUENCE SIGNIFICANT CORROSION MAY ALLOW FUEL TO LEAK DURING REFUELING, AND IN THE PRESENCE OF AN IGNITION SOURCE; THERE IS AN INCREASED RISK OF FIRE. WHAT OWNERS SHOULD DO GM WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEW FUEL FILLER NECK, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 1, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546 AND GMC AT 1-866-996-9463. THE EXPRESS 1500 I OWN IS CURRENTLY EXHIBITING THIS EXACT ISSUE, AND ALTHOUGH SOLD IN CA IN 2005, BASE VAN WAS MANUFACTURED IN INDIANA MODIFIED BY THOR MOTORHOMES. THIS STATE IS LISTED IN THE RECALL ABOVE. I'M AFRAID TO DRIVE IT, CAN'T AFFORD TO FIX THE ISSUE BEING DISABLED VET ON SMALL SSDI INCOME. IVE THE FEELING IT'S THE SAME MODEL RECALLED, BUT OF COURSE CHEVY WILL NOT REPAIR IT BECAUSE IT IS NOT SPECIFICALLY ON RECALL LIST LIKE THE LEFT SIDE CARGO DOOR MODELS THAT ARE BEING REPAIRED BY THE CHEVROLET GM DEALERS? PLEASE HELP
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS STATIONARY, FUEL SPILLED ONTO THE GROUND. IT WAS DIAGNOSED THAT THE FILLER NECK WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 148,000. UPDATED 04/11/2017*JS
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS PARKED THE REAR DRIVER'S SIDE WINDOW FELL OUT OF PLACE. THE CONTACT STATED THAT ALL THE WINDOWS ON THE VEHICLE WERE LOOSE. THERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 33,000. UPDATED 01/31/17*LJ CONSUMER STATED DRIVERS SIDE REAR SEAT LOWER WINDOW BROKE. GLUE CAME OFF MANUFACTURED WINDOW MADE BY C.R. LAURENCE CO, INC. WINDOW WAS REPLACED 11/08/16. UPDATED 6/22/18*JB
No injuries · No fire · No crash