CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
The contact owned a 1997 BMW Z3 Roadster. The contact stated that while driving at approximately 40 MPH, there was a multi-car rear-end accident involving two other vehicles after she fell asleep at the wheel and rear-ended the vehicle in front of her. The contact stated that no other passengers were in her vehicle; however, only the driver's side air bag had failed to deploy. The contact required hospitalization and was in a coma. A police report was filed. The vehicle was towed to a tow yard and later auctioned. The manufacturer was made aware of the failure and confirmed the VIN was not included in an air bag recall. The approximate failure mileage was 199,000. The VIN was not available.
VEHICLE JERKS, SHUTTERS AND PULLS TO THE RIGHT. REAR SUB FRAME AND DIFFERENTIAL BUSHING FAILURE.
No injuries · No fire · No crash
THE SEAT TRACKS OF BOTH THE DRIVER AND PASSENGER SIDE OF THE VEHICLE ALLOWED THE SEATS TO MOVE AT LEAST 10MM FORWARD AND REARWARD UNDER BRAKING AND ACCELERATION. THIS MOVEMENT CAUSES A PARTIAL LOSS OF CONTROL OF THE VEHICLE. *TR
No injuries · No fire · No crash
UPON STARTING THE CAR THE AIR BAG LIGHT CAME ON AND STAYED ON. THIS IS THE THIRD TIME THIS HAS HAPPENED. THE FIRST TWO TIME IT COST APPROXIMATELY $350 TO REPAIR. FOR THIS TO HAPPEN A THIRD TIME IS INDICATIVE OF A DESIGN FAULT.
No injuries · No fire · No crash
I TURNED THE KEY TO START THE VEHICLE. IT STARTED NORMALLY. I PUT THE CAR IN NEUTRAL (5 SPEED TRANS.) TO ALLOW IT TO WARM-UP FOR ABOUT 2 MINUTES WHILE I CHECKED MY VOICE MAIL ON MY PHONE. AS I PUT THE CAR IN GEAR AND LOOKED OUT THE WINDSHIELD TO PULL OUT OF MY PARKING SPACE, I SAW DENSE WHITE SMOKE ROLLING OUT FROM UNDER THE HOOD ON THE DRIVER'S SIDE. I LOOKED AT THE DASH FOR ANY WARNING OR INDICATOR LIGHTS; THERE WERE NONE. I IMMEDIATELY TURNED THE CAR OFF, POPPED THE HOOD, AND GOT OUT OF THE CAR. I WANTED TO WAIT UNTIL THE SMOKE WAS NO LONGER ROLLING OUT BEFORE ACTUALLY OPENING THE HOOD, AS I WAS AFRAID OF INTRODUCING A RUSH OF AIR IF SOMETHING WAS ON FIRE. AS THE SMOKE RAPIDLY INCREASED AND PROGRESSED TO BLACK SMOKE, I CALLED MY FACILITY SECURITY FROM AN EMERGENCY CALL BOX WHILE ALSO CALLING 911 FROM MY CELL PHONE. DURING THE 911 CALL, FLAMES BECAME VISIBLE FROM UNDER THE HOOD. FOUR FIRE ENGINES ARRIVED TO PUT OUT THE FIRE. ALL FOUR LEVELS OF MY FACILITIES PARKING DECK WERE FILLED WITH TOXIC SMOKE WHICH WAS EVACUATED BY THE FIRE DEPARTMENT. THE CAR WAS A TOTAL LOSS. THE FIRE DEPT. TOLD ME THAT NIGHT THAT THE CAR WAS TOO BADLY BURNED TO DETERMINE THE CAUSE. THEY SUPPOSED IT WAS ELECTRICAL. AFTER INSPECTING THE CAR, THE INSURANCE INVESTIGATOR DID NOT BELIEVE THE FIRE TO BE FROM ELECTRICAL ORIGIN, BUT INSTEAD FUEL / ENGINE RELATED. THE CAR HAD BEEN MAINTAINED ON A REGULAR BASIS. NO SERVICE HAD BEEN RECENTLY PERFORMED. I HAD NOT BEEN EXPERIENCING ANY ISSUES WITH THE CAR'S PERFORMANCE.