BMW 428i Service Bulletins
457 manufacturer communications on file.
- October 1, 2017•Document ID: 10142923Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B110317
- Date Added:
- July 16, 2018
- Manufacturer:
- BMW
SummaryN20 AND N26 ENGINE TIMING CHAIN AND OIL PUMP DRIVE CHAIN: LIMITED WARRANTY EXTENSION TO 7 YEARS/70,000 MILES
Associated Products (12)Associated Documents - September 1, 2017•Document ID: 10146769Service Bulletin/Repair InstructionsAIR BAGS
- Mfr Comm. #:
- B650414
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"AIRBAG WARNING LIGHT: ACSM FC 930A60 OR 930A1C SEAT OCCUPANCY DETECTION. According to the customer, the airbag warning light was on, but it may not be on when the vehicle arrives in the workshop. 1. ACSM fault code ""930A60 - Seat occupancy detection, front passenger; malfunction"" is stored. The fault may or may not currently be present. Or 2. ACSM fault code ""930A1C - Front passenger seat occupancy detection transmitting fault (moisture)"" is stored. The fault may or may not currently be present. The front passenger seat occupancy mat consists of a seat occupancy mat with a capacitive sensor system. This means a front passenger is detected by measuring the resistance of the human body. The fault is set when moisture is detected on the mat itself."
Associated Products (154)Associated Documents - September 1, 2017•Document ID: 10146765Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B613617
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"BATTERY DISCHARGE CCM (CHECK CONTROL MESSAGE) DISPLAYED: COMFORT ACCESS DISABLED. One or more of the following conditions are present: * CCM ""Battery. Discharge in standstill."", or similar, is displayed. * Comfort Access and contactless tailgate opening are not working. * Vehicle can still be unlocked with radio remote control (ID transmitter). Fault conditions are cleared upon engine restart. FEM (Front Electronics Module) software error Unauthorized (radio remote control out of range) access to vehicle has been attempted at least seven times with Comfort Access or Smart Opener (contactless tailgate opening) when the vehicle was locked. As a result of these unauthorized access attempts, the following conditions were set: * CCM ""Battery. Discharge in standstill."", or similar, is displayed * Terminal 30F (switched battery terminal when fault occurs) was deactivated, preventing Comfort Access and contactless tailgate opening."
Associated Products (60)Associated Documents - September 1, 2017•Document ID: 10146763Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B610315
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryVARIOUS CCM (CHECK CONTROL MESSAGES) CAUSED BY SHORTED K-CAN. The customer states that one or more of the following CCM are displayed: * 627 - Steering behavior: Drive moderately * 070 - Steering: Drive moderately * 765 - Rear-end collision restricted * 850 - Pedestrian warning restricted * 236 - Driving stabilization: Drive moderately * 299 - SOS call system failure * 042 - Brake system: Drive moderately After performing a vehicle test, one or more of the following fault codes are stored: * ACSM (Advanced Safety Crash Module) - C9549A Message faulty (seat memory), ACSM receiver, driver's seat module transmitter * FEM (Front Electronics Module) - D91DE0 No message, receiver FEM, transmitter TMSL * FEM - D91EE5 No message, receiver FEM, passenger seat module transmitter * ACSM - C9540C Message missing, receiver ACSM, transmitter FEM * TMSL (Front Light Electronics Left) - D95402 Message missing, receiver TMSL, transmitter FEM * KOMBI - E11454 No message, receiver KOMBI, transmitter REM * FEM - D91DE6 No message, receiver FEM, transmitter TMSL * TMSR (Front Light Electronics Right) - D99401 Message missing, receiver TMSR, transmitter FEM * TMSR - D99402 Message missing, receiver TMSR, transmitter FEM * FEM - 8041BA AHL system faulty * FEM - D916C3 No message, receiver FEM, transmitter TCB * ZBE (Controller) - E2D403 No message, receiver CON, transmitter FEM-ZGM * TRSVC (Control unit for rear view camera and Side View) - CA9428 Message incorrect, receiver TRSVC, transmitter PDC-REM * TMSL - D95401 Message missing, receiver TMSR, transmitter FEM * HU-H (Headunit High) - S0397 MOST configuration was not stored * TCB (Telematics Control Box) - E1445F KCAN2 or KCAN4: Line fault/electrical fault * FEM - 8041B6 LWR faulty * REM (Rear Electronics Module) - E58468 Body CAN2; communication fault * TRSVC- CA9427 Message incorrect, receiver all around vision camera, transmitter PDC/REM FEM - D91CEC Message missing, receiver FEM, transmitter REM * Shorted K-CAN wiring under drive
Associated Products (48)Associated Documents - September 1, 2017•Document ID: 10146762Service Bulletin/Repair InstructionsLATCHES/LOCKS/LINKAGES:TAILGATE:LATCH
- Mfr Comm. #:
- B514616
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryCREAKING NOISE FROM TAILGATE LOCK.. During opening and closing of the tailgate, a creaking noise can be heard from the tailgate lock. Excess friction caused by dust/dirt entry into the tailgate lock and on the striker.
Associated Products (19)Associated Documents - August 1, 2017•Document ID: 10146684Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B621017
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryERRONEOUS SERVICE INCLUSIVE CBS DISPLAY. After pre-delivery check or after instrument cluster exchange, BMW Service Inclusive is displayed although the vehicle does not feature the optional Service Inclusive coverage. Instrument Cluster display error
Associated Products (71)Associated Documents - June 1, 2017•Document ID: 10215017Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SIB612817
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummarySME FAULT CODE 21F04B - One or several of the following check control messages (CCM) may be displayed: Engine fault! Power loss" Powertrain malfunction, Hybrid system malfunctioning.
Associated Products (1)Associated Documents - June 1, 2017•Document ID: 10214956Service Bulletin/Repair InstructionsBACK OVER PREVENTION
- Mfr Comm. #:
- SIB511016
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummaryGroaning noise from doors. This service information bulletin replaces SI B51 10 16 Dated March 2016.
Associated Products (1)Associated Documents - June 1, 2017•Document ID: 10214955Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- SIB340717
- Date Added:
- July 5, 2022
- Manufacturer:
- BMW
SummaryVisual Inspection of brake discs/Rotors for new c ar deliveries
Associated Products (1)Associated Documents - June 1, 2017•Document ID: 10146719Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B840214
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryConnectedDrive/BMW Assist System Diagnosis Information This Service Information bulletin replaces SI B84 02 14 dated July 2014 What's New: Model - Removed models which no longer support BMW Assist functionality and added new models. Procedure - Add step requesting print out of ConnectedDrive Service Cockpit page Information - Add SI for ConnectedDrive Service Cockpit; updated the hyperlinks and email address for CD support team; deleted scenario for old CDMA unit which are no longer supported. ConnectedDrive/BMW Assist features are partially or completely inoperative. This Service Information bulletin is being published because vehicles are down for an extended period of time when researching system failures with ConnectedDrive or BMW Assist. This Service Information bulletin will assist you both in identifying the issue and providing technical support. CAUSE Not enough information is available for BMW NA engineers to assist the technician in diagnosing the root cause.
Associated Products (253)Associated Documents - June 1, 2017•Document ID: 10146718Service Bulletin/Repair InstructionsEQUIPMENT:APPLIANCE:AIR CONDITIONER
- Mfr Comm. #:
- B640613
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryA/C Cooling: Intermittent Reduction of Air Flow What is new The date in repair procedure and warranty section has been changed for vehicles produced to September 30, 2013 and from October 1, 2013.. Customer may complain of reduced air flow when the air conditioning system is operated for an extended time, usually longer than 30 minutes. INFORMATION Possibility of reproducing this situation is improved by the following conditions: High outside ambient temperature High humidity Note: It is very difficult to duplicate this issue. The fault may be reproduced under the following conditions: Air-conditioning system switched on Driving Experience switch NOT set to Eco Pro Slower fan speeds Temperature setting below 68F (20C) Trip duration at least 30 minutes Outside temperature above 68F (20C) NOTE: After parking the vehicle or switching off the air-conditioning system for at least 20 minutes, the symptom disappears (ice melts off evaporator and puddles under the car from the A/C drains). Evaporator starts to freeze up due to the position of the evaporator temperature sensor.
Associated Products (57)Associated Documents - May 1, 2017•Document ID: 10149254Service Bulletin/Repair InstructionsSTEERING: STEERING WHEEL/HANDLE BAR; ELECTRICAL SYSTEM
- Mfr Comm. #:
- B612417
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
Summary"?STEERING WHEEL BUTTONS DO NOT FUNCTION RELIABLY. ? Sporadic or continuous malfunction of multifunction steering wheel buttons ? CC Message ""Cruise control without function"" displayed ? Sporadic or continuous malfunction of shift paddles Frictional corrosion on connector line (wiring harness) between switch cluster and steering wheel"
Associated Products (49)Associated Documents - May 1, 2017•Document ID: 10149240Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR
- Mfr Comm. #:
- B410316
- Date Added:
- November 26, 2018
- Manufacturer:
- BMW
SummaryEDGE CORROSION IN THE INNER DOOR JAMB AREA. Corrosion on inner door panels at the following holes and cavity openings: ? Door brake (1). ? Door wiring harness pass-thru (2).
Associated Products (55)Associated Documents - May 1, 2017•Document ID: 10136745Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B840214
- Date Added:
- May 14, 2018
- Manufacturer:
- BMW
SummaryConnectedDrive/BMW Assist System Diagnosis Information
Associated Products (242)Associated Documents - April 1, 2017•Document ID: 10146658Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B840311
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"?Telematics Device Spares Replacement Part Activation via DCSnet for BMW Assist What's New: ? Model: All models added along with 6AC option code ? Situation: All information added ? Information: Deleted CDMA related information and added activation of Wi-Fi control unit ? Procedure: Added "Note" regarding ConnectedDrive support hotline information . A replacement telematics control unit must only be activated for vehicles with an active BMW Assist subscription. Note: 2G CDMA and 2G GSM telematics control units cannot be activated because they are no longer supported and the supporting network(s) have been decommissioned. INFORMATION The following changes have taken place: All Telematics control unit replacements must be activated by Part managers via the DCSnet application. New steps included in the procedure for activating Telematics control unit replacements for vehicles equipped with Wi-Fi Hotspot (6WD)."
Associated Products (244)Associated Documents - April 1, 2017•Document ID: 10146657Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B650717
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"LIST OF AVAILABLE FM RADIO STATIONS TEMPORARILY NOT AVAILABLE. INFORMATION As of 11/2015, all Entry-NAV/Media head units supplied in new vehicles were upgraded for improved noise characteristics and quality. As a part of this upgrade, the hardware updating the sender lists was changed from an "update after every diversity reception interruption or maximum of four minutes" configuration to "regular interval updates (every four minutes) without regard to diversity reception status" configuration. This may cause a delay of up to four minutes for updates to the sender list when leaving areas of poor reception. The last received transmitter, before the entrance into underground car parking or a tunnel, is still received and will show station identification. This fixed interval update does not apply to Traffic Message Channel updates which remain active. This new equipment operation pattern may be noticed by the customer after replacement of their Head unit. All replacement Head units delivered since 01/2016 have the upgraded design. An immediate solution would be for the customer to select one of their stored favorite stations via the menu or favorites buttons. PARTS INFORMATION Parts exchange or a software update are not effective or approved for this situation. WARRANTY INFORMATION Not applicable."
Associated Products (104)Associated Documents - April 1, 2017•Document ID: 10146655Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B620517
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary?INSTRUMENT CLUSTER DISPLAYS MIXED UNITS. When the displayed unit of measurement is changed from miles to Kilometers everything except the cruise control or limit set speed is displayed in Kilometers; the set speed is still shown in miles in the Instrument Cluster (Kombi) display. KOMBI software.
Associated Products (45)Associated Documents - April 1, 2017•Document ID: 10146653Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B620117
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryTIME DISPLAY (CLOCK) ERROR IN INSTRUMENT CLUSTER. The clock on the basic instrument cluster (KOMBI) gradually loses time even after being reset. Power supply fluctuations cause the time to reset.
Associated Products (57)Associated Documents - April 1, 2017•Document ID: 10146643Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B540217
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummarySERVICE ACTION: IMPLAUSIBLE SENSOR SIGNALS IN CONVERTIBLE ROOF SYSTEM. Signals from sensors in luggage compartment are being misinterpreted by the convertible top control module (CVM). This may lead to failure of the system to detect obstructions and cause damage to the hydraulics. Software error in the CVM.
Associated Products (8)Associated Documents - April 1, 2017•Document ID: 10146641Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B511817
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryEXTERIOR BMW ROUNDEL EMBLEMS SEPARATE AND FALL OFF. The exterior BMW Roundel Emblem (front and/or rear) separates from the mounting base and falls off. Delamination of the Roundel Emblem.
Associated Products (53)Associated Documents