Volvo XC90 Complaints (2019)

42 consumer complaints on file.

#11767107September 26, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Coming from a cold start in hybrid or pure mode the ERAD disengages causing the vehicle to slow down, hesitate and buck until the gas engine can engage to recover acceleration.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758396August 21, 2026
SERVICE BRAKES
COMPONENT & AVAILABILITY: The primary brake booster assembly and vacuum pump failed twice. The vehicle remains fully assembled and grounded at Volvo Cars White Plains, available for immediate inspection upon request. SAFETY RISK: Both incidents involved primary braking system failure while traveling downhill. During the second failure on August 4, 2026, the vehicle completely overshot a residential intersection, crossed a perpendicular road, and overran the pavement, coming to a stop at the edge of the opposite traffic lane directly where a sharp hill forms and drops off. DEALER CONFIRMATION: The failure was diagnosed and confirmed by the authorized dealer service center (Volvo Cars White Plains) following flatbed towing on both June 5, 2026, and August 4, 2026. After the second failure, the service supervisor explicitly stated that because the identical system failure recurred, they would need corporate approval for a secondary repair. INSPECTION STATUS: The vehicle components were inspected and diagnosed by the manufacturer-certified dealership network. No independent third-party teardown has been authorized to preserve component evidence. WARNING SYMPTOMS & PRIOR INCIDENTS: The primary failure initially occurred on June 5, 2026, while driving downhill, requiring full-force manual pedal pressure to stop. Following a dealer replacement of both components under a single repair cost, the identical mechanical failure recurred three weeks later on August 4, 2026. Crucially, prior to both the first and second incidents, there were absolutely no warning lamps, dashboard messages, or symptoms of any kind before the component malfunction occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757166August 15, 2026
STRUCTURE:BODY
The exterior chrome trim on the door handle has severely delaminated and flaked. The peeling metallic coating has separated from the plastic handle structure, creating a razor-sharp edge. This component is located on a primary vehicle entry point, creating an immediate laceration hazard to anyone attempting to open the door. The flaking metal shards are sharp enough to cut fingers or hands during normal vehicle operation, posing a particular safety risk to children or anyone unfamiliar with the vehicle's defect. This is a known manufacturing material failure affecting 2019 Volvo models.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757167August 15, 2026
STRUCTURE:BODY
The exterior chrome trim on the door handle has severely delaminated and flaked. The peeling metallic coating has separated from the plastic handle structure, creating a razor-sharp edge. This component is located on a primary vehicle entry point, creating an immediate laceration hazard to anyone attempting to open the door. The flaking metal shards are sharp enough to cut fingers or hands during normal vehicle operation, posing a particular safety risk to children or anyone unfamiliar with the vehicle's defect. This is a known manufacturing material failure affecting 2019 Volvo models.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749584July 10, 2026
VISIBILITY, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
The contact owns a 2019 Volvo XC90. The contact stated that while driving at various speeds and or while the vehicle was parked, the A/C unit became inoperable, and the defogger failed to clear the front windshield. The contact stated that the A/C was shifted to the MAX setting to operate as needed to defrost the windshield with an abnormal odor blowing through the vents. The vehicle was taken a dealer where it was diagnosed and determined that the front evaporator core needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 114,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743566June 11, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Volvo XC90. The contact stated that while driving at various highway speeds, the vehicle suddenly entered LIMP mode and decelerated before stalling. The failure had occurred on two separate occasions. On one occasion, the vehicle did not restart and was towed to the dealer. During the second occurrence, the vehicle was restarted moments later and was driven to the residence. The vehicle was later towed to the local dealer, where the contact was informed that diagnostic trouble codes for fuel delivery system malfunction and low fuel pressure were retrieved; however, the exact cause of the failure was not determined, and the vehicle was not repaired. The contact stated that the fuel tank was half-full during the failures. The manufacturer was notified of the failure. The failure mileage was 79,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741732June 3, 2026
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:CONDENSOR/EVAPORATOR
The front and rear evaporator core of my 2019 Volvo XC90 has failed and I no longer have air conditioning. This issue was diagnosed by a dealer. The evaporator core failure is a massive, widely documented issue specifically targeting the 2016–2020 Volvo SPA-platform models. According to my research, Volvo sold approx. 370,000 vehicles in the US during this period. At roughly $5,000 per vehicle, the owners are being asked to spend over a billion dollars on this known, product defect. Volvo is fully aware of this defect, yet they refuse to cover the full cost of the repair. They issued an official Technical Journal (TJ 35912.1.0) admitting that the system over-cools, causing the evaporator to freeze, expand, and crack. When technicians perform this repair, Volvo explicitly mandates installing a retroactive "jumper cable" resistor harness (Part No. 32241228) to prevent the replacement core from cracking again. The question for you is this: Is this a vehicle safety concern. We might consider why one would need air conditioning in the first place. Is it only for comfort or could it sufficiently cool air to help venerable people form having health issues (e.g., elderly, those with asthma). A recent Lancet study, for example, showed heat related deaths in Europe rising to 63,000 per year. This may be extreme, but if one lives in a southern state where temperatures climb to 100s or even a northern state where this routinely occurs in July and August, lack of A/C could be a serious health and safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740350May 27, 2026
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
The contact owns 2019 Volvo XC90. The contact stated while parked and occupied in the vehicle or while driving various speeds, the contact noticed when attempting to turn the air conditioner on she noticed that the a/c unit was not working as intended in the vehicle. The contact mention she can hear a clicking noise coming from the air conditioner. An independent mechanic and A dealer was contacted. The vehicle was taken to a dealer where they recharged the vehicle and no diagnoses, the vehicle was then taken to an independent mechanic where it was diagnosed that the rear air conditioner vapor needed to be replaced, the vehicle was then taken back to the dealer where they informed her the rear and front vapor needed to be replaced .The vehicle was not repaired. The contact mention these failures have occurred on several different occasions. The manufacturer was notified of the failure, and they offered her one thousand dollars out of the seven thousand. The failure mileage was approximately 35,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738272May 16, 2026
UNKNOWN OR OTHER
The exterior paint on my 2019 Volvo XC90 has experienced significant premature peeling and delamination on the front bumper and surrounding body panels. This is not the result of collision, misuse, or environmental damage the vehicle has been properly maintained and garaged. The paint failure appears to be a factory defect related to improper adhesion, primer application, or a substandard clear coat process during manufacture. The affected components are available for inspection upon request. Safety concern: Peeling and delaminating paint can obscure visibility of underlying corrosion, accelerate rust formation on structural body components, and create road debris hazards if large sections separate at highway speeds — posing risk to following vehicles. The concern was submitted to Volvo Cars USA Customer Care and assigned a formal case number. After requesting photographs and inquiring about paint protection documentation, Volvo denied any financial assistance without conducting a physical inspection, technical review, or providing a written basis for denial. No dealer inspection was performed, and no independent technical evaluation was offered or facilitated by Volvo. There were no warning lamps or electronic symptoms prior to the paint failure. The defect became visually apparent gradually and has progressively worsened. No prior accidents, repaints, or aftermarket modifications have been made to this vehicle. It is my belief that this paint defect may be a systemic manufacturing issue affecting multiple 2019 XC90 vehicles, and that Volvo Cars USA is aware of or should be aware of this condition. I am requesting that NHTSA investigate whether a defect trend exists across this model year and whether a safety recall or technical service bulletin is warranted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736779May 9, 2026
SUSPENSION, ELECTRICAL SYSTEM
The suspension module failed due to water accumulation on floorboards. Suspect other electronics may be at risk. Water ingress cause by a combination of what dealer said was a worn out sunroof gasket and two of four drains that became plugged. Further examination from dealer found the plugged drains were crimped from when the vehicle was manufactured. The dealer blamed the excessive water ingress was further allowed by a failed sunroof seal. The vehicle has always been serviced by the dealer and problem areas like that were either not inspected or not reported. The seal appears as good as the day we purchased vehicle from dealer. It seems it needs a more expert eye to detect how it fails. The result was standing water in the floor boards and body cavities, which then caused the suspension module to fail. The entire interior had to be disassembled to verify there was no further electrical damage. The dashboard and other interior pieces needed to be removed to replace or correct the drains. This appears to be a common problem with this model although no service advisories seem to have been issued. Total estimated damage is about $5200. Vehicle has only 60K miles. Volvo has rejected responsibility for the compromised drain and failed sunroof seal. Service documentation attached, not including the estimated $1700 to remove dash for repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730933April 13, 2026
ENGINE
The contact owns a 2019 Volvo XC90. The contact stated that while driving at various speeds, the vehicle lurched forward while switching back and forth between electric and gasoline mode. The vehicle was taken to the dealer, where an unknown repair was performed; however, the failure recurred while driving three years later. Additionally, the turtle warning light was illuminated with the message "Engine System Reduced Performance". The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719068February 19, 2026
ENGINE AND ENGINE COOLING
The contact owned a 2019 Volvo XC90. The contact stated that while driving approximately 50-52 MPH, there smoke coming from the front passenger’s side wheel well of the vehicle. The contact stated that an off-duty Police Officer witnessed the failure and activated the Emergency Lights, allowing the contact to safely pull off the highway The contact immediately pulled over and stopped the vehicle. The grandson seated in the front passenger’s seat immediately exited the vehicle and the contact was able to unbuckle and removed the [XXX] from the second-row middle seat. The contact stated that moments later there were explosions, and there was black smoke and flames engulfing the vehicle. The vehicle was destroyed. There were no injuries sustained; however, all three occupants of the vehicle experienced emotional trauma from the vehicle catching on fire. Medical attention was not needed. A Police Report was filed at the scene and the vehicle was towed away. The contact stated that the car seat in the rear of the vehicle was destroyed. The vehicle was examined by an Insurance Adjuster, and it was determined that the fire had started in the engine compartment. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 61,511. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
Yes
Injuries:
3
Deaths:
0
#11712444January 21, 2026
UNKNOWN OR OTHER
I am writing to formally a repeated mechanical failure involving the HVAC evaporator systems in two Volvo vehicles that I purchased within a few months of each other. The vehicles involved are: • 2019 Volvo XC90 T6 Momentum VIN: [XXX] Purchased: November 2024 • 2020 Volvo XC60 T5 Momentum Purchased: January 2025 Within a six months apart, both vehicles suffered complete air conditioning system failure due to large evaporator leaks. In total, three evaporators have now been confirmed as leaking across these two vehicles. The 2020 XC60 experienced evaporator failure in May 2025 and required full evaporator replacement under its CPO warranty. The 2019 XC90 subsequently developed the same issue. After multiple independent inspections and a full diagnostic performed by Volvo, they have confirmed that both the front and rear evaporators were leaking. The total repair estimate exceeds seven thousand dollars. Despite the statistical improbability of two vehicles purchased months apart suffering identical HVAC system failures within months of ownership, Volvo Cars North America denied my goodwill assistance request. The denial was based solely on the fact that a prior owner of the XC90 had previously received an unrelated goodwill repair. I was not informed of this at the time of purchase and had no connection to that prior claim. I then filed a complaint with the BBB against Volvo Cars North America. Volvo did not respond at all. The BBB has now formally closed the case and recorded that Volvo failed to respond to the complaint. I have acted in good faith at every step. I paid for diagnostics. I provided complete documentation. I pursued proper escalation channels. I sought resolution through the BBB. Volvo has remained silent. This is not an isolated service matter. It reflects a potential systemic defect affecting multiple Volvo platforms and model years. The repeated evaporator failures raise serious concerns as far us intaking large freon amounts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708339January 2, 2026
ELECTRICAL SYSTEM, ENGINE, STEERING
Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about a year or two ago and two back to back a few weeks ago. The first time I was stopped at a drive through but in “drive” with my foot on the brake. All of the sudden the car completely turns off. Screens black, engine off. Completely black car no inside lights on. Within a couple of seconds, I hear the engine reengage and the car “starts” as normal like when you turn the switch. All of the lights and screens turn on and apple car play reconnects. The most recent two incidents were the same day and in drive having stopped at stoplights. The car goes “dead” then restarts all in drive with my foot on the brake. No warnings come up after the incident either. This time my husband and children were with me and can confirm it happened. I did not get these incidents checked out since the car was instantly back to normal with no warning messages. Very unnerving though and feels like the car is being remotely restarted somehow. The first time I just brushed it off, now I am concerned about this happening while in motion.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704235December 10, 2025
POWER TRAIN, ENGINE, ELECTRICAL SYSTEM
Upon driving a symbol with a turtle and engine cation sign flashed upon the dash displaying and reading reduced power train mode as this is being shown on dash the passenger next to me smelt smoke as we next seen smoke coming from the air conditioning system we immediately pulled over to the safest spot out of the ongoing traffic as smoke continued to worsen now under the hood when flames engulfed the engine and spread to rest of car.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11701504November 25, 2025
ENGINE
My engine caught on fire. Unknown cause at this time.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11690299September 29, 2025
UNKNOWN OR OTHER
Rear evaporator coil (Failure) The rear evaporator coil failed on my Volvo XC90 purchased new at the dealership in 2019. This car only had 27,000 miles on it when the evaporator coil went bad. Refrigerant smells entered the cabin when AC was on while my 2 year old daughter was in the back. Having refrigerant leaking into the cabin is not great for health, especially that of a toddler. Additionally this could have caused an inability to defrost windows creating a safety hazard. All refrigerant leaked out leading to a condition where I had to drive in 90 - 100 degree temperatures with my daughter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689054September 22, 2025
SERVICE BRAKES
While driving, the brakes completely failed without any warning. There were no signs, alerts, or symptoms prior to the failure. The braking ability was suddenly and entirely lost, creating an extremely dangerous situation. Upon inspection, it was determined that the brake booster had failed. This component failure directly caused the complete loss of braking power. Because this occurred without warning or prior indication and such an unexpected failure not only poses a significant safety risk to the driver and passengers but endangers everyone on the road, and it represents a severe safety hazard. A sudden brake booster failure can easily lead to loss of vehicle control, accidents, injury, or even fatalities. Immediate action is required to address this serious issue that threatens public safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663618May 29, 2025
UNKNOWN OR OTHER, ENGINE
Vehicle started experiencing stalling and when trying to accelerate it would not pick up on speed, I have been quoted by Volvo that the supercharger is bad on a car that is only 6 years old. That repair for this is $2,000 as the engine valve also has to get cleaned out. The vehicle started having issue with AC after 2 years and now the front evaporator has gone bad and with summer Time is when I realized of this defect. $5,000 repair for the evaporator.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661570May 16, 2025
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
After a software update the backup camera’s field of view is super focused on the tailgate, license plate, and the immediate ground below. This is a safety concern as there have been a few near misses at parking lot speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC90