Volvo S80 Complaints (2000)

318 consumer complaints on file.

#10203386September 18, 2007
TIRES:SIDEWALL
225/50R-17 94V PROXES TPT ALL SEASON BLACKWALL HAD A SIDEWALL FAILURE WHILE TRAVELING STRAIGHT ON A HIGHWAY AT 70 MPH, OUTSIDE TEMP WAS 84 DEGREES F. TIRE CORE REMAINED INTACT LEAVING 1 OR 2 INCHES OF EACH SIDEWALL GLUED TO RIM. TIRE HAD 22K MILES ON IT. AIR PRESSURE SHOULD HAVE BEEN OKAY SINCE IT WAS CHECKED A FEW WEEKS EARLIER. OPPOSING TIRE WAS AT 33 WHEN CHECKED COLD THE NEXT DAY. DOOR PANEL INDICATES 29-39 IS OKAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201848September 4, 2007
SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING 5 MPH, THE LEFT BALL JOINT ASSEMBLY DETACHED AND CAUSED THE FRONT AXLE TO FAIL. THE CONTACT STATED THAT THE LEFT FRONT WHEEL COLLAPSED. THE VEHICLE WAS TOWED TO THE LOCAL MECHANIC AND WAS SOLD TO HIM. THE CURRENT AND FAILURE MILEAGES WERE 73,000. UPDATED 09/18/07. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10200049August 19, 2007
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
A HISSING SOUND COMING FROM THE BRAKE PEDAL AREA BEGAN OCCURING AND I TOOK TO THE CAR TO THE DEALER AND WAS INFORMED THAT IT WAS A DEFECTIVE "BRAKE BOOSTER" AND THAT IT IS A VERY DANGEROUS SITUATION THAT IF NOT CORRECTED COULD LEAD TO TOTAL BRAKE FAILURE. THE CAR IS USED TWICE A WEEK AND THE BRAKE BOOSTER HAS NOT BEEN REPLACED AND IS AVAILABLE FOR INSPECTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10193589June 18, 2007
ELECTRICAL SYSTEM:WIRING
TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING 35 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDERNEATH THE HOOD OF THE VEHICLE. THE VEHICLE BURST INTO FLAMES. THE INSURANCE AGENCY AND VOLVO INVESTIGATORS DETERMINED THAT THE CAUSE OF FAILURE WAS DUE TO A SHORT IN THE WIRE HARNESS. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGES WERE 40,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10191053May 17, 2007
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING 35 MPH, ALL OF THE DASHBOARD WARNING LIGHTS ILLUMINATED AND THE ENGINE COMPLETELY FAILED. THE CONTACT WAS ABLE TO PULL TO THE SIDE OF THE ROAD. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE DEALER. THE DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED AND THAT THE CAUSE OF FAILURE WAS A FAILED TIMING BELT TENSIONER. THE CURRENT AND FAILURE MILEAGES WERE 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10189845May 5, 2007
VEHICLE SPEED CONTROL:LINKAGES, ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, SUSPENSION:FRONT:SHOCK ABSORBER
TREBOL MOTORS DISTRIBUTORS CORP. PO BOX 11204, FDEZ. JUNCOS STA. SAN JUAN, P.R. 00910-2304 PHONE # 787-793-2828 FAX 787-793-2978 YEAR 2000 S80 GENTLEMEN: ACCORDING TO NORTH AMERICA VOLVO I HAVE AT LIST THREE RECALLS ON MY UNIT. THE SAME ARE UNDER THE NUMBERS: 1- RECALL ID # 06V441000 VEHICLE SPEED CONTROL DATED NOV. 15, 2006 MODEL AFFECTED 2000 VOLVO S80 2- RECALL ID # 04V451000- ENGINE AND ENGINE COOLING:COOLING SYSTEM FAN 3- RECALL ID # 00V238000-SUSPENSION FRONT CONTROL ARM: UPPER BALL JOINT , DATED AUG. 24, 2000. THOSE RECALLS ARE APPLICABLE TO MY CAR AS TELEPHONE CALL FROM VOLVO NORTH AMERICA. TWO OF THEM, THE FIRST TWO, OCCURRED TO MY VEHICLE, AND I PAID YOU FOR LABOR AND PARTS. 2- INVOICES: 1- # 04937 DATED 09/05/06 THROTTLE HOUSING 8644347 TOTAL COST PAID $ 815.74. PAID 09-15-2006 2- # 02481 DATED 06/18/04 ELECTRICAL FAN 30636445 TOTAL COST PAID $ 498.02 PAID 06-17-2004 THE THIRD RECALL I DO NOT FIND INVOICES FOR, BUT MAY BE INVOICES: THAT PART PROBABLY DAMAGE THE SHOCK ABSORBERS WHICH WERE CHANGE ON 09/05/2006 INVOICE 04937 , IN WHICH I PAID FOR PARTS 8667253 , 8646713 THE AMOUNT OF $ 566.98, PAID ON 09/16/2006. I CALL SEVERAL TIMES TO YOUR SERVICE DEPARTMENT BUT THE MANAGER OF SERVICE NEVER EVER RETURN MY CALLS. I EXPECT YOUR REACTION SOON. YOUR PROMT ATTENTION WILL BE APPRECIATED. PLEASE ACKNOWLEDGE RECEIPT. I AUTHORIZE MY FATHER JOSE D. SANTIAGO TO VISIT AND MAKE ALL EFFORTS WITH TREBOL MOTORS TO TAKE WHATEVER ACTIONS MAY BE NEEDED TO GET REIMBURSEMENT OF PAYMENTS MADE UP TO NOW.I ALSO AUTHORIZE HIM TO SIGN ALL DOCUMENTS, DELIVER COPIES, AND HANDLE NOTIFICATIONS TO TREBOL MOTOR & /OR VOLVO.ALSO TO TAKE CAR FOR SERVICE COVERED BY ANY RECALLS NOT YET REPAIR. JOSE D. SANTIAGO DATED MAY 4, 2007 *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10187440April 10, 2007
STEERING:COLUMN, AIR BAGS:FRONTAL
TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING AT 7 MPH THE STEERING WHEEL LOCKED. THE VEHICLE CRASHED INTO A TREE AND ROLLED OVER. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE ROAD CONDITIONS WERE CLEAR. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WERE 111,000. *AK
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10186587March 30, 2007
TIRES:SIDEWALL, TIRES
WE WANT TO FILE A COMPLAINT TO A TIRE MANUFACTURER, MICHELIN. WE HAVE BOUGHT 4 PIECE OF MICHELIN TIRES ON 11/24/2006 FROM ITS A TIRE DEALER, COSTCO WHOLESALE CLUB TIER CENTER, LOCATED AT 50 OVERLOOK BLVD, NANUET, NY 10954, TEL. (845) 425-0316 AND THE 4 PIECE TIERS WERE INSTALLED THERE. THE TIRE MODEL IS MICHELIN PILOT SPORT A/S 225/50R17 ULTRA HIGH PERFORMANCE PRICE AT $207.99 PER TIER (CURRENT PRICE) AFTER 4 MONTHS, ON 3/28/07, WE ACCIDENTALLY FOUND ONE TIRE LOCATED AT FRONT PASSENGER SIDE HAD BLISTER (A BUBBLE) IN THE SIDEWALL, WHEN WE CHECKED THE TIRE AIR PRESSURE. SEE THE PICTURE AS FOLLOWS: WE ARE GLAD TO FIND THIS DEFECTIVE TIER PRIOR TO GETTING A CAR ACCIDENT. BECAUSE WE REALIZED THAT THE DEFECTIVE CONDITION MIGHT RESULT IN A RAPID LOSS AIR PRESSURE, WHICH COULD LEAD TO A LOSS CONTROL AND A VEHICLE CRASH. WE COULD LIKE TO HAVE EITHER AN INSPECTOR OF THE HIGHWAY TRAFFIC SAFETY ADMINISTRATION OFFICE OR A THIRD PARTY INSPECTOR TO INSPECT THIS DEFECTIVE TIER TO GET SOME INFORMATION TO PROTECT PEOPLE FROM POTENTIAL CAR CRASH AND LOST LIVES. PLEASE CONTACT ME FOR ANY ADDITIONAL INFORMATION. I APPRECIATE YOUR CONSIDERATION AND LOOKING FORWARD TO HEAR YOU SOON. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10185087March 14, 2007
SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
TL* - THE CONTACT OWNS A 2000 VOLVO S80. THE CONTACT STATED THAT THERE WAS SAFETY RECALL 00V238000 THAT DID NOT APPLY TO THIS VEHICLE DUE TO THE VIN. THE CONTACT STATED THAT THE PROBLEMS HE HAD CURRENTLY WITH THIS VEHICLE WAS DIRECTLY RELATED TO THE SAFETY RECALL. THERE WAS FRONT SUSPENSION NOISE PRIOR TO TAKING THE VEHICLE THROUGH INSPECTION, AND THE RESPONSE TIME WHEN MAKING A TURN WAS NOT AS TIGHT AS IT ONCE WAS. THE TIE RODS HAD AN EXCESSIVE AMOUNT OF PLAY IN THEM, AND HE BELIEVED THAT IT WAS DIRECTLY RELATED TO THE PROBLEM WITH THE BALL JOINTS. THE CURRENT AND FAILURE SPEED WERE BOTH 92,000 MILES.*AK UPDATE 05/04/07*TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10183051February 20, 2007
VEHICLE SPEED CONTROL
TL*- THE CONTACT STATED THAT THE 2000 VOLVO S80 HAD REPAIRS DONE ON 11/10/05 FOR THE ELECTRONIC THROTTLE MODULE. HE ORIGINALLY HAD THE REPAIR COMPLETED ON 11/10/05. THE CONTACT STATED THAT THE RECALL WAS REPAIRED AGAIN ON 02/09/07, AND HE STILL HASDTHE SAME PROBLEMS WITH THE VEHICLE. THE DEALERSHIP INFORMED HIM THAT HE WOULD HAVE TO BE FULLY RESPONSIBLE FOR THE COST OF THE REPAIRS HIMSELF. THE CONTACT WILL BE FILLING A COMPLAINT WITH THE MANUFACTURER ON 2/20/07, AND WILL BE SENDING IN INFORMATION NEEDED FOR REIMBURSEMENT FOR THE 1ST REPAIR. THE FAILURE MILEAGE WAS 7800, AND THE CURRENT MILEAGE WAS 101000.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10179282January 21, 2007
FUEL SYSTEM, GASOLINE:DELIVERY
MY 2000 VOLVO S80 T6 ETM THEY SAID THEY WOULD NOT FIX IT UNLESS I BOUGHT A CEM THEY SAID CAR WOULDN'T WORK WITHOUT IT. SO THEY FIXED IT TO A TUNE OF $900.00 FOR CEM SO I CHARGED IT BACK ON MY CREDIT CARD BECAUSE IT'S ALL COVERED ON ETM UPDATE. IN THE MORNING THE CAR STILL REVS MORE I WANT VOLVO TO BUY THIS CAR BACK FROM ME BECAUSE NO ONE INFORMED ME OF THIS PROBLEMS. THEY WOULDN'T GIVE ME OLD CEM I ASKED. *NM
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10177094December 27, 2006
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS, SEAT BELTS: REAR/OTHER:BUCKLE ASSEMBLY, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL* - THE CONTACT WAS REAR ENDED BY A TRUCK WHILE DRIVING 5 MPH. THE CONTACT STATES THAT IT WAS WINDY AND THAT THERE WERE LIGHT FLURRIES AT THE TIME. THE REAR BACK BUMPER WAS STRUCK AT AN ANGLE ON THE DRIVERS SIDE OF THE VEHICLE. THE CONTACT HAS HAD THE REAR BUMPER REPLACED, AND NOW THE VEHICLE'S LEFT REAR DOOR IS NOT LOCKING AND THE SEAT BELTS NOT LATCHING. THE CONTACT STATED THAT DOOR LOCKS WILL NOT UNLOCK OR LOCK FROM THE MAIN PANEL AND THAT SHE HAS TO LOCK HER CAR MANUALLY. THE CONTACT STATES THAT NOTHING WAS WRONG WITH THE DOORS, THE LOCKING MECHANISMS OR, SEAT BELTS BEFORE THE ACCIDENT. THE CONTACT WOULD LIKE TO KNOW IF THE SEAT BELTS AND THE LOCKING MECHANISM ARE MALFUNCTIONING BECAUSE OF THE ACCIDENT.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10175749December 11, 2006
VEHICLE SPEED CONTROL
APPROXIMATELY 6 MONTHS AGO VEHICLE BEGAN ERRATIC THROTTLE WHILE ON SPEED CONTROL (SURGING). DEALER SERVICED VEHICLE WITH SOFTWARE UPDATE AND TEMPORARILY RESOLVED PROBLEM. PROBLEM HAS RETURNED AS WELL A SPONTANEOUS STALLING, AND VERY ERRATIC VARIANCE IN THROTTLE PEDAL POSITION AND ACCELERATION. STALLING HAS OCCURRED WITH THROTTLE PEDAL RELEASE ENTERING TURN LANE - NO POWER STEERING NOR BRAKE BOOST. DEALER HAS SERVICED VEHICLE - CLEANED SENSORS RELATED TO THROTTLE POSITION MODULE - WITH NO IMPROVEMENT. WIFE IS REFUSING TO DRIVE VEHICLE SHE NOW REFERS TO AS SCARY. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10174627November 28, 2006
LATCHES/LOCKS/LINKAGES:DOORS:LATCH, VEHICLE SPEED CONTROL, VISIBILITY, ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN, STEERING:HYDRAULIC POWER ASSIST SYSTEM, ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
1. FOLLOWING DOWNLOAD OF RECALL SOFTWARE PERFORMANCE HAS BEEN VASTLY REDUCED AND NOW ONLY ACHIEVES 8.2 MPG. 2. THE ABS CONTROL MODULE FUNCTIONS INTERMITTENTLY AND USUALLY IN THE FAILURE MODE. ABS BRAKES DO NOT FUNCTION PROPERLY-REPLACEMENT $950 3. WHILE BACKING (COLD ENGINE), BRAKES FAIL TO STOP THE CAR FOR SEVERAL SECONDS (FEET). 4. THE VEHICLE STALLS MOSTLY ON TURNS BUT ON STRAIGHT AWAY. A. CAR NOW SHUTS OFF APPROX 6-8 TIMES WHILE DRIVING, DANGEROUS WHILE DRIVING AT INTERSTATE/HIGHWAY SPEEDS. IT "SURGES" FORWARD AND THE LIGHTS (DASH AND HEADLIGHTS) FADE - VEHICLE STALLS WITH NO POWER STEERING OR POWER BRAKES. 5. CRUISE CONTROL FAILS ?? UP HILLS/DOWN HILLS SHUTS DOWN. NOW IS INOPERABLE. 6. THE ELECTRONIC DOOR LOCKS MALFUNCTION INTERMITTENTLY. 7. FOLLOWING ERROR CODES DISPLAY AND TOTAL MILEAGE, TRIP 1 & 2 MILEAGE DISPLAYS DEFAULT TO ?? --------?? AND MILEAGE DOES NOT LOG ON THE ODOMETER: A.BRAKE FAILURE STOP ASAP B.COOLANT LEVEL LOW STOP ASAP C.ABS FAILURE / SERVICE REQUIRED D.STC SERVICE REQUIRED E.POWER STEERING FAILURE - SERVICE REQUIRED F.EMISSION SYSTEM SERVICE REQUIRED G.STOP SAFELY AND RESTART ENGINE H.ALARM SYSTEM SERVICE REQUIRED I.ALARM TRIGGERED J.EMISSION SYSTEM SERVICE REQUIRED K.NO OIL PRESSURE STOP ASAP L.CHECK ENGINE. *NM THE BALL JOINT, DRIVER SIDE WINDOW MOTOR, SUNROOF SWITCH WERE REPLACED. NUMEROUS BULB REPLACEMENTS AND REPLACEMENT OF MASS FLOW SENSOR. THE COOLING FAN MALFUNCTIONED. THE ABS CONTROL MODULE WOULD FUNCTION INTERMITTENTLY WHICH WOULD CAUSE THE ABS TO NOT FUNCTION. THE POWER STEERING FAILED. THE VEHICLE WILL COMPLETELY SHUT OFF WHILE DRIVING. THE CRUISE CONTROL WAS INCONSISTENT, THE VEHICLE WOULD LOOSE POWER WITH THE CRUISE ACTIVATED. THE ELECTRONIC DOORS MALFUNCTIONED, THE FOB DOES NOT ALWAYS OPEN THE DOOR AND AT TIMES WHEN CLOSING THE DRIVER SIDE DOOR. UPDATED 12/15/06. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10173590November 15, 2006
VEHICLE SPEED CONTROL, POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM), ELECTRICAL SYSTEM
ERRATIC THROTTLE POST 10 MINUTES OF DRIVE, MUCH ACCELERATION, NOT ENOUGH ACCELERATION, HESITATION, BACKFIRES LEAN. GETS STUCK 2ND GEAR. CEL ON. "TRANSMISSION SERVICE URGENT" WARNING MESSAGE DISPLAYED. CRUISE CONTROL IS LOST AND CANNOT BE TURNED BACK ON. OBDII PCODES STORED 10-29-2006 10:21:18.464 READ STORED DTC: P0756 DTC: P1171 DTC: P1181 DTC: P1618 10-29-2006 10:21:18.474 READ STORED DTC: P1184 10-29-2006 10:21:18.474 READ STORED DTC: P1174 THE FIRST CODE ALWAYS DISPLAYED WHEN THE FAULT OCCURS. SUBSEQUENT CONTINUED DRIVING RESULTS IN THE SECOND CODE PENDING OR PERMANENT. THE REMAINING CODES WILL BE ADDED IN PAIRS. FIRST DEALER REPORTS I HAVE 18 CODES BUT FACTORY VADIS INDICATES CAN ONLY STORE 15 CODES MAXIMUM. REQUESTED ADDITIONAL $300 TO ADJUST FUEL TRIMS, CHECK EXHAUST AND INTAKE LEAKS, CHECK O2 SENSORS, WORK DECLINED. SECOND DEALER REPORTS NEEDS COMPLETE TRANSMISSION. NO ATTEMPT TO SOLVE COMPLAINTS BY DEALER, CONTACTED VOLVO CUSTOMER SERVICE AND THEY DECLINED TO DISCUSS PROBLEMS, THEY DECLINED ANY FURTHER INVOLVEMENT. CAR HAD SALVAGE TITLE 2+ YEARS AGO FROM MINOR ACCIDENT WHICH PREMATURELY DEPLOYED AIR BAGS, REPAIRED AND RETURNED TO SERVICE. I AM RETIRED ASE MASTER MECHANIC, SERVICE MANAGER, AND SAE MEMBER, THIS IS NOT A TRANSMISSION ISSUE BUT CAUSED BY THE ERRATIC ACTIONS OF THE THROTTLE BODY SYSTEM AND MODULE. TRANSMISSION PASSES ALL CONVENTIONAL TESTS. RESULTS STUCK IN GEAR CAN BE CORRECTED BY CYCLING THE IGNITION SWITCH OFF AND BACK ON. THIS CAN BE DONE BY PULLING TO THE SIDE OF THE ROAD AND STOPPING TO CYCLE THE KEY OR TRAFFIC PERMITTING PLACING IN NEUTRAL AND RESTARTING AND THEN BACK TO DRIVE. NO OBSERVED FAILURES ABOVE 65 MPH. TSB SEND WRONG SIGNALS TO "NETWORK" ARE TRANSLATED AS INSTRUCTIONS RESULTING IN POOR FUEL CONSUMPTION, HIGH EMISSIONS, ABNORMAL WEAR AND TEAR ON TRANSMISSION, IGNITION SWITCH, STARTER, AND RELATED COMPONENTS FOR NORMAL OPERATION, PLUS A DANGEROUS DRIVING CONDITION. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10172342November 1, 2006
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING:ENGINE, SUSPENSION:FRONT
IN EARLY JUL 05, I EXPERIENCED ELECTRONIC THROTTLE SYSTEM (ETS) PROBLEMS WITH MY 2000 VOLVO S80. PARTICULARLY CONCERNING TO ME FROM A SAFETY STANDPOINT WAS THAT SEVERAL TIMES, INCLUDING WHEN I WAS IN HIGHWAY DRIVING SITUATIONS, THE CAR ON ITS OWN SUDDENLY ACCELERATED AND DECELERATED, HESITATED ON ACCELERATION OR WOULD NOT ACCELERATE, AND DISPLAYED ENGINE STALL SYMPTOMS. THE COMPUTER INDICATED DEGRADED ENGINE PERFORMANCE (LIMP MODE). I LINED UP A SERVICE APPOINTMENT WITH LOVERING VOLVO OF MEREDITH. AFTER LOVERING'S FIRST ATTEMPT AT REPAIRS, THE CAR WAS STILL NOT OPERATING NORMALLY AND I TOOK IT BACK TO THE DEALER A SECOND TIME. I PAID A TOTAL OF $2,074.42 FOR REPAIRS, $1,741.44 THE FIRST TIME AND $332.98 DURING THE SECOND VISIT. IN ACCORDANCE WITH A JUNE 2006 VOLVO LETTER, I TOOK MY S80 BACK TO LOVERING FOR INSPECTION AND ETS SOFTWARE UPGRADE. I SUBMITTED TO VOLVO A CLAIM FOR REIMBURSEMENT FOR ETS REPAIRS. THE ADVERTISING CHECKING BUREAU (ACB), WHICH ADMINISTERS THE ETS WARRANTY REBATE PROGRAM ON BEHALF OF VOLVO, SENT ME A CHECK FOR $747.93 FOR THE ETS REPAIRS. ACB SAID IT WAS AUTHORIZED TO REIMBURSE ME ONLY THE $587.93 COST OF ELECTRONIC THROTTLE BODY, ELECTRONIC THROTTLE MODULE RELOAD, AND GASKET, AND ASSOCIATED $160.00 LABOR COST. ACB ADVISED ME TO CONTACT THE VOLVO CUSTOMER CARE CENTER. A VOLVO CUSTOMER CARE REPRESENTATIVE CONFIRMED THAT ACB HAD DONE AS INSTRUCTED AND SUGGESTED THAT I TAKE UP THE MATTER OF THE REMAINING REPAIR COSTS WITH LOVERING. THE LOVERING INVOICES, DATED JULY 26, 2005 AND AUGUST 8, 2005, INDICATE THAT A $295.65 PORTION OF THE INITIAL $1,741.44 REPAIR BILL HAD TO DO WITH TOTALLY UNRELATED STEERING/SUSPENSION AND ENGINE MOUNT REPAIRS. STILL QUESTIONABLE IN MY MIND ARE THE OXYGEN SENSOR REPAIRS WHICH ADDED UP TO $897.86 AND THE SUBSEQUENT MASS AIR FLOW SENSOR REPAIRS WHICH CAME TO $332.98. I SUSPECT THE PROBLEMS ARE ALL ETS-RELATED AND I AM CURRENTLY PURSUING THE MATTER WITH THE DEALERSHIP. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10170597October 12, 2006
SUSPENSION:FRONT, EQUIPMENT:ELECTRICAL
PURCHASED A 2000 VOLVO S80 IN MARCH OF 2006, EXPERIENCE POWER LOSS WITH THING SUCH AS SUNROOF AND WINDOWS, TERRIBLE GLARE FROM FRONT WINDSHIELD IMPAIRS VISION, SUSPENSION- BALL JOINTS, AXLES, RODS, STRUT BUSHINGS, STRUTS, BRAKE CALIPERS, CV BOOTS/JOINTS, CONTROL ARM, AND TIRES HAVE BEEN REPLACED ... STILL HEAR NOISE., ENGINE SURGES AT LOW SPEEDS AND WHEN CAR IS STOPPED- ENGINE TORQUE MOUNT REPLACED, BRAKE PEDAL HAS TO BE PRESSED COMPLETELY BEFORE CAR STOPS-DESPITE BRAKE BOOSTER, AND MASTER CYLINDER BEING REPLACED. ABS MODULE WAS REPLACED. CAR DRAGS (HAS A DELAY) WHEN ACCELERATING. RECEIVED UPDATES AND RECALLS PERFORMED. FIXED ALMOST EVERYTHING CAR SURGED FORWARD INTO A TRAILER HOOK ON THE BACK OF A PARKED CAR-COSMETIC DAMAGE VERY EXPENSIVE. HAVE BEEN HOPING THAT THE REPAIRS WILL COME TO AN END...FIRST CAR EVER PURCHASED AND HAVE ALMOST SPENT 1/2 OF ITS BLUE BOOK VALUE IN REPAIRS. SEEKING EXPLANATIONS, REIMBURSEMENTS, AND NATIONAL AWARENESS. LOVE THE APPEARANCE, WISH IT WASN'T SO MANY DEFECTS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10170372October 10, 2006
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
IN JULY I WAS TRAVELING IN TRAFFIC AT IDLE SPEED WHEN MY CAR STARTED TO SURGE THEN STALLED. I WAS ABLE TO RESTART IT, HOWEVER I HAD TO KEEP ONE FOOT ON THE GAS AND THE OTHER ON THE BRAKE TO KEEP IT RUNNING. I WAS ABLE TO LIMP IT HOME USING THIS METHOD TO KEEP THE RPMS UP. WHEN THE CODES WERE READ IT SAID THE 4 OXYGEN SENSORS WERE OUT OF RANGE. I TUNED UP THE CAR, CLEANED THE THROTTLE BODY AND OXYGEN SENSORS AND RESET THE CODES. (65,000 MILES) AFTER THIS THE CAR SEEMED ALRIGHT UNTIL AROUND 79,000 MILES. MY WIFE AND I WERE ON RTE. 1A ON THE MAINE COAST IN TRAFFIC . WHILE GOING AROUND A SHARP CURVE THE CAR STALLED. I LOST CONTROL OF MY STEERING AND BRAKES AND THE CAR NEARLY WENT OVER THE CLIFF INTO THE OCEAN. I WAS ABLE TO GET IT UNDER CONTROL AND THE CAR RESTARTED WITH THE IDLE SURGING. I LIMPED THE CAR HOME USING THE GAS AND BRAKE METHOD. AT INTERSECTIONS IF I LET THE CAR IDLE THE CAR WOULD SURGE FORWARD THEN STALL. MY MECHANIC READ THE CODES AND TOLD ME THE MAP SENSOR AND O2 SENSORS WERE BAD AND REPLACED THEM. THIS SEEMED TO WORK FOR A WHILE, HOWEVER THE CAR REVERTED BACK TO THE SAME PROBLEMS. I FINALLY CALLED GALLO VOLVO WHO HAD SERVICED MY CAR UNDER WARRANTY UNTIL 60,000 MILES AND THE SERVICE MANAGER TOLD ME THAT THIS WAS A KNOWN PROBLEM COVERED UNDER A HIDDEN RECALL. ONCE A CUSTOMER COMPLAINED THEY COULD FIX IT. I BROUGHT MY CAR TO THEM AND THEY REPROGRAMMED THE COMPUTER TO "REPAIR" THE PROBLEM. MY CAR NO LONGER STALLS, HOWEVER IT SURGES AND HESITATES UPON ACCELERATION NEARLY CAUSING PEOPLE TO HIT ME IN TRAFFIC. I AM STILL TRYING TO RESOLVE THIS PROBLEM AFTER OVER $1800 DOLLARS IN EXPENSES, MULTIPLE NEAR ACCIDENTS AND NUMEROUS HOURS OF MY TIME. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10170237October 8, 2006
EXTERIOR LIGHTING:HEADLIGHTS, ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
MY 2000 VOLVO S80 BEGAN GIVING ME ERROR MESSAGES OF SEVERAL KINDS, ONE OF WHICH TELLS ME "DIPPED BEAM BULB FAILURE." WHEN THAT HAPPENS, THE LOW BEAM HEADLIGHTS DO NOT WORK (THEY COME ON WHEN I START THE CAR AS RUNNING LIGHTS). AFTER BUYING NEW BULBS TO PUT IN, I FOUND THAT THE OLD BULBS WERE NOT BURNED OUT AND THAT THE PROBLEM OCCURRED AT RANDOM. THE BIG PROBLEM WAS DRIVING HOME WITH THE BRIGHT LIGHTS ONLY - WHICH THOUGH SEEMED DIFFERENTLY, ARE NOT TOO AWFULLY BRIGHT - ONLY A FEW PEOPLE FLASHED ME. I THEN HAD OTHER CODES COMING UP AND HAD TO REPLACE THE "ABS CONTROLLER" TO THE TUNE OF $1000; AND, GUESS WHAT? THE DIPPED BEAM BULB FAILURE MESSAGE STILL OCCURS OFF AND ON (SPENDING THE $1000 DID CURE THE OTHER, MULTIPLE MESSAGES)*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10169409September 27, 2006
POWER TRAIN:AXLE HUBS
SINCE BUYING MY 2000 VOLVO S80 T6 IN 2001 I'VE BEEN PUZZLED BY AN OCCASIONAL NOISE COMING FROM THE FRONT OF THE CAR AND WOULD MENTION IT TO THE PAT PATTERSON VOLVO, MEMPHIS, TN SERVICE WRITER. HE WOULD PASS MY COMMENTS ON TO THE MECHANICS BUT NOTHING WAS EVER FOUND. ON SATURDAY 8/5/2006 I MADE A TRIP IN THE MOUNTAINS OF CENTRAL ARKANSAS DURING WHICH I DROVE ON A ROUGH, GRAVEL ROAD. AFTER A LITTLE OVER A MILE I HEARD A NOISE SOMETHING LIKE THAT CAUSED WHEN THERE IS A FLAT TIRE. I WAS FORTUNATE IN FINDING A MECHANIC TO LOOK AT THE CAR. HE WAS ABLE TO GET ME ON MY WAY AND I THUS WAS NOT STRANDED ON A WEEKEND A HUNDRED MILES FROM HOME. MYSTERY OF THE LONG TIME NOISE SOLVED! THE PROBLEM WAS A BOLT LOOSE ON THE RIGHT FRONT HUB. THE MECHANIC STATED THE BOLT HAD BEEN LOOSE FOR A LONG TIME AND THEORIZED THAT DRIVING ON THE ROUGH ROAD HAD CAUSED IT TO FINALLY COME ALL THE WAY OUT. THE REASON THE BOLT CAME LOOSE, HE SAID, WAS THAT LOCK-TIGHT WASN'T APPLIED BY THE FACTORY. THE LOCAL MECHANIC REMOVED THE BOLT ON SATURDAY BUT DIDN'T HAVE A REPLACEMENT SO I TOOK IT BACK TO PAT PATTERSON VOLVO (PPV) YESTERDAY. THE LACK OF LOCK-TIGHT HAVING BEEN USED BY THE FACTORY WAS CONFIRMED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S80