Volvo EX90 Service Bulletins
137 manufacturer communications on file.
- November 19, 2025•Document ID: 11026746Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TJ37588.1.0-2025-11-18
- Date Added:
- December 22, 2025
- Manufacturer:
- VOLVO
SummaryThis is a TJ - no attachments - If a vehicle has one or more of DTC(s) listed below set, follow the advice under "Service". - Ignore the stated DTCs; nothing needs to be done. The DTCs have no actual impact on the vehicle's functionality.
Associated Products (1)Associated Documents - November 19, 2025•Document ID: 11026744Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TJ37547.1.0-2025-11-13
- Date Added:
- December 22, 2025
- Manufacturer:
- VOLVO
SummaryThis is a TJ - text only no attachments - If a customer reports no sound during phone calls between the car and the landside while using Bluetooth or Apple CarPlay, please follow the instructions under "Service". Complaints about poor or degraded sound quality are not covered by this Technical Journal (TJ) and must be reported separately via a TIE report.
Associated Products (2)Associated Documents - November 19, 2025•Document ID: 11026742Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TJ37518.3.0-2025-11-18
- Date Added:
- December 22, 2025
- Manufacturer:
- VOLVO
SummaryThis is a TJ - no attachments If VIDA shows message "A problem was detected with PAK and its UWB antennas..." during pre-installation of software download to PAK module, or if software download to PAK module fails and gets stuck in programming session, follow advice under "Service".
Associated Products (2)Associated Documents - November 14, 2025•Document ID: 11026738Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TJ37490.2.0-2025-10-29
- Date Added:
- December 22, 2025
- Manufacturer:
- VOLVO
SummaryThis is a TJ Text only no attachments - The breakpoint for the latest (third) GHCA hardware generation is serial number S00053758, which represents the first and lowest number of the third generation. The serial number can be found on the hardware, where "S000xxxxx" is printed on the type label. For replaced GHCAs with serial numbers before S00053758, a Vehicle Report is not required for Warranty Claim acceptance if VIDA fault tracing clearly indicates that the GHCA must be replaced. For replaced GHCAs with serial numbers after S00053758, please create a Support Not Needed Vehicle Report. See the Vehicle Report section below for more information.
Associated Products (2)Associated Documents - November 14, 2025•Document ID: 11026737Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TJ37279.4.0-2025-11-06
- Date Added:
- December 22, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: In most cases the VCU does not need to be replaced. *The script in VIDA for VCU reload is now working
Associated Products (2)Associated Documents - November 1, 2025•Document ID: 11026734Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- TJ37518.2.0-2025-10-29
- Date Added:
- December 22, 2025
- Manufacturer:
- VOLVO
SummaryThis is a TJ - no attachments If VIDA shows message "A problem was detected with PAK and its UWB antennas..." during pre-installation of software download to PAK module, or if software download to PAK module fails and gets stuck in programming session, follow advice under "Service".
Associated Products (2)Associated Documents - October 31, 2025•Document ID: 11025571Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 37140
- Date Added:
- November 17, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal, Text and mp3 - Listen to the attached sound file, TJ-37140_1.mp, as an example of this noise. (The noise is heard at 5 and 26 seconds in the recording)Rumbling Noise From ERAD / TVDC. Please follow the advice under "Service"
Associated Products (2)Associated Documents - October 10, 2025•Document ID: 11025562Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 37159
- Date Added:
- November 17, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: EX90 - Dealer Demo Features Limited/Unavailable. avoid fault tracing or part replacements for known deviations . This Technical Journal describes the SW release with its intended content. Some features will not be introduced from the start of the EX90, but will be available via SW upgrade. Please see under "SERVICE" for preliminary introduction plan. *This Technical Journal will be closed 2025 week 41 if no objections. Please use Software Release Notes for content in future Software releases for EX90.
Associated Products (2)Associated Documents - September 20, 2025•Document ID: 11023540Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 37486
- Date Added:
- October 2, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Tech Journal If the vehicle triggers false alarms without a clear reason on multiple occasions, please follow advice under "service".
Associated Products (2)Associated Documents - August 28, 2025•Document ID: 11022811Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 37473
- Date Added:
- September 5, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal - EX90 - Failed Software Download Causing Invalid Certificates If a Total Upgrade, PDS, or TCAM reload fails on any ECU, the TCAM may end up with invalid certificates. To ensure proper functionality after successfully recovering the car with a new software download, follow these steps to verify certificate validity
Associated Products (2)Associated Documents - August 28, 2025•Document ID: 11022809Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 37071
- Date Added:
- September 5, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: EX90 Software download issues - If SWDL fails and HLCM is in "Not responding", it is normal. HLCM is in silent mode and therefore not listening to diagnostic commands. Continue with the next SWDL attempt without any action
Associated Products (2)Associated Documents - August 1, 2025•Document ID: 11022806Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 37275
- Date Added:
- September 5, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: EX90 GHCA Replacement: Prior Approval Needed. please create a "Prior Approval" vehicle report with "GHCA Prior Approval.
Associated Products (1)Associated Documents - July 31, 2025•Document ID: 11021939Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 37453
- Date Added:
- August 18, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: EX90 - Software download issue to HUD. Do not perform a HUD Reload.
Associated Products (2)Associated Documents - July 31, 2025•Document ID: 11021937Service Bulletin/Repair InstructionsFORWARD COLLISION AVOIDANCE: WARNINGS
- Mfr Comm. #:
- 36048
- Date Added:
- August 18, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe. The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
Associated Products (19)Associated Documents - July 23, 2025•Document ID: 11021930Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 37140
- Date Added:
- August 18, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: Rumbling Noise From ERAD / TVDC. Perform an oil change in the TVDC according to VIDA instructions.
Associated Products (1)Associated Documents - July 18, 2025•Document ID: 11021928Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 37445
- Date Added:
- August 18, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: Various Issues Due to BMS. Verify that the correct battery monitoring sensor (BMS) is fitted to both 12V batteries. Check the visible part number of the fitted RBMS (front) and BMS (rear) and compare to VIDA listing. RBMS(front) 3 Electrical System- 37 Cables and fuses- 373 Cable system Front-Battery cable Front BMS(rear) 3 Electrical System- 37 Cables and fuses- 373 Cable system Front-Battery cable Rear Replace BMS if they do not match.
Associated Products (1)Associated Documents - July 18, 2025•Document ID: 11021925Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 37342
- Date Added:
- August 18, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: iCUP IHU - Prior Approval. In most cases, the IHU does not need to be replaced
Associated Products (6)Associated Documents - July 7, 2025•Document ID: 11021919Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 37279
- Date Added:
- August 18, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: VCU Replacement. VIDA script needs to be adapted before performing VCU Reload
Associated Products (2)Associated Documents - July 3, 2025•Document ID: 11021917Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 37159
- Date Added:
- August 18, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: EX90 - Dealer Demo Features Limited/Unavailable. avoid fault tracing or part replacements for known deviations . This Technical Journal describes the SW release with its intended content.
Associated Products (2)Associated Documents - July 2, 2025•Document ID: 11021916Service Bulletin/Repair InstructionsUNKNOWN OR OTHER
- Mfr Comm. #:
- 37342
- Date Added:
- August 18, 2025
- Manufacturer:
- VOLVO
SummaryThis is a Technical Journal: iCUP IHU - Prior Approval. In most cases, the IHU does not need to be replaced
Associated Products (6)Associated Documents