Volkswagen Passat Complaints (2001)

432 consumer complaints on file.

#11745122June 18, 2026
SERVICE BRAKES
My fuses keep blowing, this is leading to replacing the Brake switch which I believe was recalled. If it was replaced,it's not working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422304June 25, 2021
AIR BAGS
The driver's side airbag of my 2001 VW Passat spontaneously deployed while I drove on Hwy 494 in Woodbury MN. Sometime within 24 hours before the airbag deployed, the airbag fault light turned on in the car's dashboard display. Within 15 minutes before the incident, the car's automatic locking locks unlocked twice while I was driving the car. After the second time, I tried to lock the car doors by pressing the lock button on the driver's door console but the doors would not locked. At that time I noticed that the two interior lights in the back seat area were turned on. All the doors of the car were properly shut. When the airbags deployed I was driving on the smooth 1 year old concrete section of Hwy 494. I did not hit anything on the highway. After the deployment, I parked on the shoulder, shut off the engine and opened the passenger door to air out the car. After about 5 minutes, I got back in the car and drove home. The automatic locks worked again. The interior lights automatically turned off. The drive home was uneventful.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11389398January 22, 2021
ENGINE, FUEL/PROPULSION SYSTEM
TOOK CAR TO VW DEALER TO HAVE TIMING BELT REPLACED AND WAS NOTIFIED THAT THERE WERE SEVERAL OPEN RECALLS AND THEY OFFERED TO TAKE CARE OF THEM FREE OF CHARGE. HOWEVER, THEY WERE UNABLE TO PERFORM RECALL #08V156. MANUFACTURER #26E5. THEY INSTALLED THE HEAT SHIELD BUT COULD NOT PERFORM SOFTWARE UPGRADE. I NEVER RECEIVED ANY RECALL NOTICES IN THE MAIL. NOW VW WANTS TO BUY THE CAR BACK BECAUSE THEY CAN'T FIX IT. IT'S A 2001 VW PASSAT WITH 25K MILES IN SHOWROOM SHAPE. WAS NEVER DRIVEN IN SNOW AND GARAGED IT'S ENTIRE LIFE. THEY OFFERED ME $1500 OUT OF WHICH I OWE $1300 FOR THE TIMING BELT. THEY SAID IT MAY NEED A ECU BUT THEY ARE NO LONGER AVAILABLE FROM VW BUT REFUSE TO INSTALL A USED ONE. THE CAR HAS BEEN AT THE VW DEALER SINCE 12/28/2020. I WAS UNDER THE IMPRESSION THAT RECALLS NEVER EXPIRE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11120015August 15, 2018
SERVICE BRAKES, VEHICLE SPEED CONTROL
ABS LIGHT ON AND BREAK LIGHT FLASHING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11054149December 12, 2017
FUEL/PROPULSION SYSTEM
STARTED SMELLING GAS AND MILEAGE STARTED DROPPI G BAD AROUND THE END OF NOVEMBER. WE SEE THAT THERE HAS BEEN RECALLS ON THE GAS TANK AND FUEL LINES FOR 01 VOLKSWAGEN PASSATS BUT UNFORTUNATELY NOT FOR THIS VIN # WHICH HAPPENS TO BE MY SONS CAR. NOW ITS AT THE SHOP BECAUSE ITS GAS MILEAGE WENT WAY DOWN AND AND SMELLS LIKE GAS AND HE WAS TOLD THAT HE WAS DRIVING A BOMB BASICALLY. IT COULD BE AROUND $1000 TO FIX IT. NONE OF US HAVE THAT KIND OF $ AND HES STILL HAS $800 LEFT OWEING ON IT. HELP
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11046400November 15, 2017
ENGINE
FAULTY CAM CHAIN TENSIONER FAILED AND CAUSED SEVERE ENGINE DAMAGE TO VALVES, PISTONS, CAMSHAFT, CAM TIMING CHAIN. I WAS STATIONARY WAITING AT A RED LIGHT WHEN I HEARD A SUDDEN LOUD GRINDING NOISE FROM INSIDE THE ENGINE COMPARTMENT, THE ENGINE BEGAN TO SHAKE AND SPUTTER. THE CAR LOST MOST OF ITS POWER AND I WAS BARELY ABLE TO MAKE IT THROUGH THE INTERSECTION WHEN THE LIGHT TURNED GREEN. UPON INSPECTION IT WAS CLEAR TO SEE THAT THE CAM CHAIN TENSIONER HAD SELF DESTRUCTED AND CAUSED THE ENGINE TO FAIL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11012185August 1, 2017
FUEL/PROPULSION SYSTEM
MY 2001 VOLKSWAGEN PASSAT HAS HAD AN R5 RECALL FOR FUEL LINES, FUEL TANK, AND A HEAT SHIELD. THE HARD (LOW PRESSURE FUEL RETURN?) LINE, THE MIDDLE ONE OF THE MOUNTING BRACKET ATOP THE FIREWALL, HAS FAILED CATASTROPHICALLY. IT NOW SPRAYS GASOLINE DIRECTLY DOWN ONTO THE CATALYTIC CONVERTER HEAT SHIELD. THIS IS THE SAME FAILURE IN THE SAME EXACT POINT THAT MANY OTHER OWNERS HAVE HAD. THIS PART IS DANGEROUS AND COULD HAVE KILLED ME AND DESTROYED MY CAR. VOLKSWAGEN REFUSED TO FIX IT. I'VE BEEN IN CONTACT WITH VW CUSTOMER CARE AND MY LOCAL DEALER, BOTH TOLD ME THAT ONCE THE RECALL IS CLOSED ON MY VEHICLE THAT THERE IS NOTHING THEY'LL DO. THEY WANTED ME TO TOW MY CAR TO THE DEALERSHIP AND PAY $135 FOR A DIAGNOSTIC UNTIL I SHOWED THEM A VIDEO OF THE FUEL LINE UNDER PRESSURE SPRAYING EVERYWHERE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10955699February 20, 2017
AIR BAGS
MY CAR IS A 2001 MODEL, AND I'D LIKE TO KNOW IF IT HAS TAKATA AIRBAGS IN IT, EVEN IF IT ISN'T COVERED BY THE RECALL. DEALER DOESN'T KNOW IF THE AIRBAGS ARE TAKATA OR NOT. CAN YOU GIVE ME THIS INFORMATION?? I HOPE SO, OTHERWISE I DON'T KNOW HOW TO FIND OUT. THANKS [XXX] *DL INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10908805September 22, 2016
SERVICE BRAKES
ABS CONTROL MODULE FAULT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10865850May 19, 2016
POWER TRAIN
AS MY SON GOT ON THE HIGHWAY THE TRANSMISSION FELT LIKE IT WAS SLIPPING AND JERKING TO THEN CATCH BACK UP TO THE ORIGINAL SPEED I WAS GOING. WHEN HE PUT HIS FOOT ON THE GAS PEDAL THE CAR WOULD STRUGGLE TO GO, 5 SECONDS LATER IT WOULD GET UP TO SPEED BUT THEN SLOW BACK DOWN. AT A STOPLIGHT THE CAR WOULD SHAKE ROUGHLY AND IDLE REALLY HIGH, THEN HE SAW THE FRONT OF THE HOOD START TO SMOKE AND I REALIZED THERE WAS A PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10806596November 24, 2015
STRUCTURE:BODY, FUEL/PROPULSION SYSTEM
VWOFA HAVE NOT TAKEN STEPS NECESSARY TO FACILITATE THIS FIRE HAZARD RECALL!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10717045May 18, 2015
POWER TRAIN
TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE TRANSMISSION WOULD SLIP AND THEN THE VEHICLE STALLED. THE ENGINE CONTINUED TO RUN, BUT THE VEHICLE WOULD NOT MOVE. THE VEHICLE WAS TAKEN TO A DEALER AND IT WAS DETERMINED THAT THE TEETH ON THE GEARS OF THE TRANSMISSION HAD FRACTURED AND THE ENTIRE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 160,000. UPDATED 8/19/15*CN THE CONSUMER STATED THERE WAS A RECALL FOR THE SAME MAKE, MODEL, AND YEAR BUT, THE CONSUMER'S VIN WAS NOT INCLUDED. UPDATED 9/30/2015*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10658597November 17, 2014
ELECTRICAL SYSTEM, AIR BAGS, ENGINE
SO I GOT REAR ENDED AT THE OTHER PARTY'S FAULT AT HIGH SPEED WHILE I WAS AT A STOP SIGN AND THEY NEGLECTED TO STOP PUSHING ME INTO AN INTERSECTION FULL OF TRAFFIC...NO AIRBAGS DEPLOYED..AND SINCE MY HEATER DOESN'T WORK BUT PASSENGER SEAT HEAT BURNED MY 12 YEAR OLD DAUGHTERS BUTT...ANYONE HELP? I JUST WANT HEAT FOR MY BABIES..BELOW ZERO HERE :( THANK YOU!! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10611366July 17, 2014
ELECTRICAL SYSTEM, SERVICE BRAKES
I WAS DRIVING ON I-95 AT APPROX. 78 MPH WHEN THE CAR SUDDENLY SAYS STOP! BRAKE FAILURE! SEE VOLKSWAGEN SERVICE. IN MY RESEARCH ON THE ISSUE, I'VE FOUND THIS HAPPENS ON ALMOST ALL 1998-2001 VW PASSATS AND AUDI A-4S. THIS NEEDS TO BE ADDRESSED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10593014May 21, 2014
STRUCTURE:BODY, ELECTRICAL SYSTEM
ROLLED INTO VEHICLE IN FRONT. NO DAMAGE TO EITHER VEHICLE. CAR BURST IN TO FLAMES. TOTAL LOSS. *TR
Crash:
Yes
Fire:
Yes
Injuries:
0
Deaths:
0
#10564966February 19, 2014
ENGINE
I WAS DRIVING AND I PULLED INTO MY PARKING LOT AND MY ENGINE CAUGHT ON FIRE. I PUT IT OUT WITH SNOW THANK GOD OR IT WOULD HAVE BEEN A LOT WORSE. I ALWAYS HAVE COOLANT AND OIL AND I CHECKED IT A LOT CAUSE OF THE FREEZING WEATHER WE HAVE HAD RECENTLY HAD -30 FOR QUITE AWHILE. I CALLED VW CUSTOMER CARE AND THEY WERE VERY WORRIED ABOUT MY SAFETY AT 1ST THEN THEY HAD A PRODUCT SOMETHING GUY CALL ME AFTER SEE THE PICTURE I SENT THEM. I UNDERSTAND THEY HAVE PEOPLE ALWAYS LOOKING FOR A QUICK ESCAPE GOAT BUT THIS WAS A FIRE IT COULD HAVE BEEN SO MUCH WORSE IF THERE WAS NOT SNOW NEAR BY. I WANT MY CAR FIXED BUT I AM MORE WORRIED ABOUT THE NEXT PERSON THIS COULD HAPPEN TOO. I SHOULD TELL YOU AFTER ASK HIM IF HE JUST WANTED TO FIND THE REASON BEHIND IT HE SAID NO. PERSONALLY A CAR FIRE IS NOT A NORMAL THING. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10560737January 21, 2014
FUEL SYSTEM, GASOLINE
I NOTICE THAT FUEL IS LEAKING FROM MY VW PASSAT 2001'S FUEL TANK. I FILL OUT THIS COMPLAINT IN ORDER TO SEEK A HELP FROM AUTHORITIES ON THESE MATTERS AND ALSO KNOWING IF MY ISSUES CAN BE HANDLED BY VOLKSWAGEN AMERICA. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10548346October 18, 2013
SERVICE BRAKES, ELECTRICAL SYSTEM
ABS MODULE IS OUT, CAN'T GET EMISSIONS PASSED UNLESS I PAY OVER 600 DOLLARS. ALSO I DON'T HAVE ABS, CAN'T SEE IF MY CHECK ENGINE LIGHT MEANS ANYTHING BECAUSE I'M TOLD IT ALL GETS RE ROUTED THOROUGH THE ABS MODULE AND CAN'T GET PAST THAT PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10522521June 30, 2013
POWER TRAIN
2001 VW PASSAT STICKING GAS PEDAL COMMENTS: THIS HAS HAPPENED TO ME RECENTLY 2 TIMES....GAS PEDAL STUCK TO FLOOR, REDLINE, ALMOST CRASHED. RESEARCHING I FOUND IT TO BE A COMMON PROBLEM. VW SHOULD BE HELD ACCOUNTABLE... THIS IS A DANGEROUS SITUATION! SHOULD I STOP DRIVING IT??? MORE ACCOUNTS AT: HTTP://WWW.PASSATWORLD.COM/FORUMS/42-VOLKSWAGEN-PASSAT-B5-DISCUSSION/236513-ANYONE-ELSE'S-GAS-PEDAL-GET-STUCK.HTML. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10512737May 19, 2013
FUEL/PROPULSION SYSTEM, FUEL SYSTEM, GASOLINE
2001 PASSAT 1.8T MANUAL TRANSMISSION DEVELOPED FUEL LEAK ON THE FIREWALL ATTACHMENT AREA, ON THE MIDDLE LINE DIRECTLY OVER CATALYTIC CONVERTER; CAR COMPARTMENT SMELLED HEAVILY OF GASOLINE. STOPPING CAR AND INSPECTING THE FUEL LINE SHOWED THE CRACK. THIS IS A VERY SERIOUS ISSUE AND WAS VERY LUCKY IN THIS CASE NOT TO HAVE CAR ON FIRE. PLEASE INVESTIGATE THIS AS THERE SEEMS TO BE RELATED RECALLS FROM VW ON THIS ISSUE. I'M SCARED TO HAVE KIDS ON BOARD THE PASSAT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen Passat