Volkswagen Jetta Complaints (2006)

580 consumer complaints on file.

#10579382April 12, 2014
AIR BAGS
TURNED THE KEY ON AND THE AIRBAG FAULT LIGHT ILLUMINATED AND STAYS ON I'VE TRIED TO RESET IT BUT IT WILL NOT RESET. I HAVE READ ON MANY FORUMS AND THIS SEEMS LIKE A VERY COMMON ISSUE. IT SHOULD BE LOOKED AT FURTHER CAUSE IT IS HAPPENING IN A LOT OF VEHICLES. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10576943April 2, 2014
POWER TRAIN
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SUDDENLY DECELERATED. THE VEHICLE WAS TOWED TO THE DEALER, WHO REPLACED THE "MECHAERON". THE MANUFACTURE WAS MADE AWARE OF THE FAILURE HOWEVER, DECLINED TO PROVIDE A REMEDY TO FIX THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 192,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574440March 24, 2014
ELECTRICAL SYSTEM
DRIVER'S REAR DOOR LOCK STOPPED RESPONDING TO THE BUTTONS ON IT, AND ON THE MAIN CONTROL, AND ON THE REMOTE. IT INTERMITTENTLY WORKED FOR A MONTH OR SO AND IS NOW DEAD. THE CAR CANNOT BE LOCKED AND THAT IS A SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574441March 24, 2014
STRUCTURE
THE HEADLINER BEGAN SEPARATING ABOVE THE REAR RIGHT PASSENGER SEAT. I LIVE ALONE AND NO ONE EVER EVEN RIDES IN THE BACK SEAT. CANNOT BE REPAIRED WITHOUT INSTALLING A WHOLE NEW HEADLINER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574443March 24, 2014
SEATS
THE LEATHER ON THE DRIVER'S SEAT STARTED SEPARATING...LOOKS LIKE LITTLE MICRO TEARS THAT CONTINUE TO WORSEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573000March 17, 2014
ENGINE
KNOCKING HEARD FROM ENGINE WHILE DRIVING ON HIGHWAY NEAR DESTINATION, APPROXIMATELY 300 MILES FROM HOME. VEHICLE ARRIVED AT DESTINATION, BUT WOULD NOT START. VEHICLE WAS TOWED TO MECHANIC. CAMSHAFT WEAR AND FOLLOWER BORE FOUND TO BE DAMAGED AND WAS REPLACED USING OEM PARTS. VEHICLE WAS USING FACTORY RECOMMENDED OIL AT REGULAR INTERVALS. CAM WEAR FOUND AGAIN ON 6/8/11, 195761 MILES. CAM SHAFT WEAR SEEN DURING TIMING BELT CHANGE. REPLACED CAM SHAFT, FOLLOWERS, AND BEARINGS. ONCE AGAIN, FACTORY RECOMMENDED OIL AND OIL CHANGE INTERVALS WERE USED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573001March 17, 2014
AIR BAGS
AIR BAG INDICATION LIGHT CAME ON WHILE DRIVING. AIR BAGS DID NOT DEPLOY. CAR WAS NOT INVOLVED IN ANY TYPE OF COLLISION AT THAT TIME. AIR BAG LIGHT HAS BEEN ON SINCE. SRS CODE NOT ABLE TO BE CLEARED FROM MEMORY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573004March 17, 2014
AIR BAGS
AIR BAG INDICATION LIGHT CAME ON WHILE DRIVING. AIR BAGS DID NOT DEPLOY. CAR WAS NOT INVOLVED IN ANY TYPE OF COLLISION AT THAT TIME. AIR BAG LIGHT HAS BEEN ON SINCE. SRS CODE NOT ABLE TO BE CLEARED FROM MEMORY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573002March 17, 2014
ENGINE
CAM WEAR FOUND ON 6/8/11, 195761 MILES. CAM SHAFT WEAR SEEN DURING TIMING BELT CHANGE. REPLACED CAM SHAFT, FOLLOWERS, AND BEARINGS. FACTORY RECOMMENDED OIL AND OIL CHANGE INTERVALS WERE USED. CAM SHAFT WAS ALSO REPLACED ON 11/03/09 AT 123086 MILES AFTER THE FOLLOWING INCIDENT: KNOCKING HEARD FROM ENGINE WHILE DRIVING ON HIGHWAY NEAR DESTINATION, APPROXIMATELY 300 MILES FROM HOME. VEHICLE ARRIVED AT DESTINATION, BUT WOULD NOT START. VEHICLE WAS TOWED TO MECHANIC. CAMSHAFT WEAR AND FOLLOWER BORE FOUND TO BE DAMAGED BEYOND REPAIR AND WAS REPLACED USING OEM PARTS. VEHICLE WAS USING FACTORY RECOMMENDED OIL AT REGULAR INTERVALS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10572728March 17, 2014
ENGINE
CAM SHAFT AND LIFTER INFERIOR QUALITY!!WHAT HAS HAPPENED ACCORDING TO OTHER OWNERS OF TDI'S THAT I HAVE TALKED TO IS THAT THE CAMSHAFT AND LIFTERS HAVE FAILED. THEY WERE BUILT INFERIOR AND BREAKDOWN. THIS CAUSES A LOT OF CONFUSION WITH MECHANICS TRYING FOR ENDLESS HOURS TO FIGURE OUT WHY ITS SMOKING. WITH A LOT OF RESEARCH I FOUND OUT THAT THE CAMSHAFT AND LIFTERS ARE INFERIOR AND BREAKDOWN. WHY DOES VOLKSWAGEN DO THAT TO PEOPLE, IT COST ME SO MANY THOUSANDS OF DOLLARS REPLACING TURBO, MASS AIR FLOW SENSOR TO REBUILDING THE ENGINE FOR GOD SAKE TO FIND THAT IT IS THE CAM AND THAT THIS IS A COMMON PROBLEM. VOLKSWAGEN SHOULD BE HELD ACCOUNTABLE FOR THIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10569191March 13, 2014
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES
DRIVER'S REAR DOOR LOCK STOPPED RESPONDING TO THE BUTTONS ON IT, AND ON THE MAIN CONTROL, AND ON THE REMOTE. IT INTERMITTENTLY WORKED UNTIL MARCH AND IS NOW DEAD. THE CAR CANNOT BE LOCKED AND THAT IS A SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10565642February 24, 2014
POWER TRAIN, ENGINE, FUEL SYSTEM, DIESEL
AT APPROX 80-90K I STARTED HEARING A CLATTERING NOISE FROM THE ENGINE AND EXTRA NOISE WHEN IDLING. ALSO, THE CAR HAS A HARD TIME SHIFTING (AUTOMATIC TRANS). AFTER TAKING THE CAR TO A MECHANIC, I WAS TOLD THAT IT'S THE DSG DMF COMING APART AND RATTLING. AFTER DOING SOME RESEARCH, I FIND IT'S A COMMON PROBLEM. IT STARTED HAPPENING SHORTLY AFTER MY CAR WENT OUT OF CPO WARRANTY, WHICH EXPIRED AT 74K. I DIDN'T REALLY PAY THAT MUCH ATTENTION TO IT UNTIL IT GOT WORSE. THIS IS A 06 TDI MKV WITH AUTO DSG, BRM ENGINE. ALSO EXPERIENCING DIFFICULTIES WITH SOOT IN FUEL FILTER, LIKELY DUE TO FAULTY SEAL IN FUEL INJECTORS UNDER CAM SHAFT. ONCE AGAIN, COMMON PROBLEM ACCORDING TO MECHANICS AND ONLINE FORUMS ON THIS MODEL. THERE'S A RECALL ON THE DMF FOR THIS MODEL IN AUSTRALIA, NEEDS TO HAVE ONE FOR US. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10564521February 15, 2014
POWER TRAIN
DUAL MASS FLYWHEEL FAILED CATASTROPHICALLY AND WITHOUT WARNING WHILE DRIVING ON THE FREEWAY. FLYWHEEL FAILURE SENT METAL SHRAPNEL INTO TRANSMISSION, CRACKING THE BELL HOUSING AND THE TRANSMISSION TO SHIFT ERRATICALLY. THE CAR WAS MECHANICALLY TOTALED AND VOLKSWAGEN OF AMERICA REFUSED TO TAKE ANY RESPONSIBILITY FOR THE PREMATURE FAILURE OF THE VEHICLE, DESPITE IT BEING A DOCUMENTED AND KNOWN ISSUE. OTHERS HAVE REPORTED THAT THIS PART WAS RECALLED IN AUSTRALIA BUT NOT THE UNITED STATES. COST OF REPAIR WAS BEYOND VALUE OF VEHICLE AND CAR WAS DEEMED A TOTAL MECHANICAL LOSS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10563513February 8, 2014
POWER TRAIN
OUR JETTA EXPERIENCED A "FALSE NEUTRAL" PROBLEM BACK IN DECEMBER, 2013. (95,000 MILES) I DID SOME RESEARCH AND FOUND THAT IT COULD BE DUE TO A LOW VOLTAGE CONDITION. I CHECKED THE ELECTRICAL SYSTEM AND FOUND THE ALTERNATOR TO BE FAULTY. I REPLACED IT AND KEPT DRIVING THE CAR. EVERYTHING SEEMED FINE UNTIL MID JANUARY, 2014 WHEN WE EXPERIENCED ANOTHER FN EVENT. WE WERE ABLE TO SWITCH THE CAR OFF AND THEN BACK ON AND THE CONDITION WENT AWAY. I CALLED OUR LOCAL VW DEALER AND SCHEDULED AN APPOINTMENT FOR A DIAGNOSTIC. THE RESULTS OF THIS TEST CAME BACK AND THEY SAID WE NEEDED A NEW MECHATRONICS UNIT (THIS CONTROLS THE TRANSMISSION) AT A COST OF $2300.00 I AM FAMILIAR WITH THESE CARS AND ALSO FAMILIAR WITH THE FACT THAT VW HAS ALREADY INVESTIGATED THIS ISSUE IN LATER YEAR CARS. THIS INVESTIGATION (NHTSA ACTION# PE09035) RESULTED IN A RECALL CAMPAIGN (NHTSA# 09V333000) WHERE VW REPLACED DEFECTIVE MECHATRONICS UNITS AND EXTENDED THE WARRANTY ON THE AFFECTED UNITS TO 10YRS/100,000 MILES. LESS THAN 24 HOURS AFTER RECEIVING THIS DIAGNOSIS, THE TRANSMISSION COMPLETELY LOCKED UP WHILE DRIVING DOWN THE ROAD, LUCKILY IT WAS AT AN INTERSECTION AND THE SPEED WAS LESS THAN 15MPH. I HAD THE CAR TOWED BACK TO THE VW DEALER, THE TRANSMISSION MUST NOW BE REPLACED ($6,000.00) I CONTENT THAT THIS IS THE SAME OR NEARLY THE SAME ISSUE ADDRESSED IN THE PREVIOUS CAMPAIGN AND THAT VW DID NOT FIND THE ROOT CAUSE OF THE MECHATRONICS AND SUBSEQUENT TRANSMISSION FAILURE. A NEW INVESTIGATION NEEDS TO BE OPENED TO ADDRESS THIS PROBLEM, IT IS A SAFETY ISSUE WHICH HAS ALREADY BEEN ADDRESSED FOR SOME OF THEIR VEHICLES. VW NEEDS TO BE MADE TO ADDRESS IT FOR ALL DSG EQUIPPED VEHICLES, ESPECIALLY ONES MANUFACTURED BEFORE THE PREVIOUSLY INVESTIGATED LOT. I CONTACTED VWOA AND EVEN THOUGH MY VEHICLE IS STILL WITHIN THE MILEAGE RANGE OF THE WARRANTY EXTENSION THEY WILL NOT OFFER ANY ASSISTANCE IN THE REPAIRS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561926January 28, 2014
AIR BAGS, ELECTRICAL SYSTEM:HORN, ELECTRICAL SYSTEM
PURCHASED THE 2006 VOLKSWAGEN JETTA IN AUGUST 2014 WITH 116,000 MILES. ONE MONTH LATER THE HORN WAS NOT WORKING. UPON DOING AN INTERNET SEARCH, DISCOVERED AN INORDINATE NUMBER OF COMPLAINTS THAT THESE HORNS BECOME INOPERABLE EVEN WITH FEWER MILES. THE PROBLEM COMES WHEN PRESSING THE HORN PAD ON THE STEERING WHEEL, IT DOES NOT MAKE CONTACT TO SOUND THE HORN. THE AIRBAG ASSEMBLY IS LOCATED HERE AS WELL SO I DON'T FEEL IT'S SAFE TO TRY TO REPLACE IT MYSELF. THE QUOTE TO HAVE THIS REPAIRED WAS $900.00. VOLKSWAGEN SHOULD ISSUE A RECALL ON THIS PART IMMEDIATELY! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561607January 27, 2014
ELECTRICAL SYSTEM, AIR BAGS, SEATS
OUR 2006 JETTA TDI HAD AN AIRBAG FAULT. WE TOOK THE VEHICLE TO A VOLKSWAGEN DEALERSHIP AND THEY TESTED THE AIR CODE AND FOUND OUT THAT THE PASSENGER OCCUPANT DETECTOR MODULE WENT BAD DUE TO A ELECTRICAL MALFUNCTION IN THE CIRCUIT. THE DEALERSHIP WAS NOT ABLE TO SAY IF THE AIRBAGS WERE GOING TO WORK ON NOT IN THE CASE OF A CRASH. VOLKSWAGEN IS REFUSING TO TAKE ANY OWNERSHIP OF KEEPING THEIR VEHICLE SAFE AND COVERING THE COST OF THE PART. I CONTACT VOLKSWAGEN USA AND THEY GAVE THE REASON THEY WILL NOT COVER THE PART BECAUSE I DID NOT HAVE AN EXTENDED WARRANTY. I FEEL THAT VOLKSWAGEN IS BEING NEGLECTFUL TO THEIR CLAIM ON PROVIDING A SAFE VEHICLE. NOW THAT THE AIRBAG SENSOR IS GOING OUT, WE ARE HAVING MORE ELECTRICAL PROBLEMS WITH HEADLIGHTS, PARKING LIGHTS, TAILLIGHTS, BRAKE LIGHTS, DAY TIME RUNNING LIGHTS, AND TURN SIGNALS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10561093January 22, 2014
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES
AFTER USING THE FOB TO LOCK THE DOORS WE NOTICED THE REAR DOORS WOULD NOT LOCK. IF THE CAR IS JUST SITTING THE REAR LOCKS WILL NOT LOCK LEAVING THE DOOR OPEN TO CHILDREN OR WOULD BE THIEVES. WE ALSO NOTICED THE REAR DOORS WOULD SHOW THEY WERE LOCKED ONCE WE WERE MOVING, BUT WERE ACTUALLY UNLOCKED ALLOWING THE REAR PASSENGER TO BE ABLE TO OPEN THE DOORS AT HIGHWAY SPEEDS. EXTREME SAFETY ISSUE! VOLKSWAGEN NEEDS TO ADDRESS THIS ISSUE ASAP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10560554January 19, 2014
ENGINE
DURING A HEAVY RAIN, AND WHILE SLOWING TO APPROACH A STOP , MULTIPLE EMERGENCY WARNING LIGHTS APPEARED IN THE DASH DISPLAY. LOW OIL PRESSURE INDICATOR ADVISED TO SHUT OFF ENGINE IMMEDIATELY, GLOW PLUG INDICATOR FLASHED, AND TACHOMETER WENT TO ZERO (EVEN THOUGH ENGINE WAS STILL RUNNING). I SHUT OFF THE ENGINE, CHECKED OIL (LEVEL WAS FINE), BUT THE ENGINE WOULD NOT START. TOWED BACK HOME, AND 30 MINUTES LATER, ENGINE STARTED. NO CHECK ENGINE LIGHT AT ANY TIME. PROBLEM RECURRED AGAIN IN HEAVY RAIN SEVERAL WEEKS LATER. EXAMINED WIRING HARNESS AND FOUND TWENTY INDIVIDUAL WEAR POINTS IN THE WIRES WHERE THE INSULATION WAS WORN ENOUGH TO EXPOSE THE COPPER STRANDS. THERE WERE NUMEROUS OTHER WEAR POINTS WITH NO COPPER VISIBLE, BUT ALL OF THE INSULATION WEAR MATCHED THE CORRUGATION OF THE RIBBING IN THE PLASTIC WIRE LOOM COVERING. CLOSER INSPECTION OF THE WEAR POINTS REVEALED THE MOST PREVALENT AND SERIOUS BARE WIRE CONDITIONS WERE IN THE AREA OF THE HARNESS SUPPORT CLAMPS. VERY CONCERNED REGARDING OTHER SIMILAR POTENTIAL WEAR PROBLEMS THAT COULD RESULT IN ENGINE FAILURE OR FIRE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10560486January 18, 2014
POWER TRAIN, VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
BEEN TO MULTIPLE DEALERSHIPS CLAIMING IN FOX VALLEY IL ROCKFORD IL GLENVIEW IL THAT EITHER MY MECHUNIT IS BAD/FAULTY OR DUAL MASS FLYWHEEL IS BAD/FAULTY. WAS DRIVING WHERE EITHER MY CAR WOULD SHIFT VERY ROUGH AS IF SOMEONE WHO IS VERY INEXPERIENCED WOULD LET GO OF THE CLUTCH LATE AND SHIFT HARD/ROUGH INTO 1-2-3 WITH CLICKING NOISES. CAR JUST RECENTLY SHIFTED FROM 2 TO NEUTRAL AND SCARED THE CRAPOUT OF ME. THE CAR HAS EXTREME VIBRATION AND UNCONTROLLED SHIFT PATTERNS. WAS TURNING ONTO MY STREET AND CAR WENT FROM 3-2 TO NEUTRAL WHILE MY CAR WAS STILL IN DRIVE AND WENT INTO A SNOW BANK ON SIDE OF ROAD. WOULD JUST LIKE TO HAVE VOLKSWAGEN CONTACT ME TO EITHER REPLACE OR FIX THIS PROBLEM. THIS IS VERY DANGEROUS OWNERS OF A 2006 VW TDI OR ANY AUTOMATIC WITH DSG MECHUNIT BEWARE AND PLEASE BE CAREFUL. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10558801January 7, 2014
ELECTRICAL SYSTEM, POWER TRAIN
TRAVELING ALONG AT 55 MPH AND THE GEAR DISPLAY STARTED FLASHING/BLINKING AS THE CAR JUST SHUT OFF. IT WOULD NOT RESTART. BATTERY IS FINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen Jetta