Volkswagen Jetta Complaints (2006)

580 consumer complaints on file.

#10204426September 28, 2007
POWER TRAIN:MANUAL TRANSMISSION, ENGINE AND ENGINE COOLING:ENGINE:DIESEL
I HAVE A 2006 VOLKSWAGEN JETTA TDI. INITIALLY I WAS SLOWING DOWN ON THE INTERSTATE, AS SOON AS I WAS GETTING READY TO STOP DUE TO CONSTRUCTION, WHEN THE SHIFTER HIT FIRST, THE CAR BUCKED, DIED AND I LOST POWER STEERING AND BRAKES. I ALSO NOTICED THAT NONE OF THE GEARS IN THE TRANSMISSION WOULD SYNC AND ALLOW ME INTO THEM. I PULLED OFF TO THE SIDE OF THE ROAD, WHEN I REALESED MY FOOT FROM THE CLUTCH, THE PEDAL DID NOT COME BACK UP. I SHUT DOWN THE CAR, CRAWLED OUT THE PASSENGER SIDE, I LOOKED UNDER THE CAR FOR LEAKS AND ANYTHING THAT MAY INDICATE A MAJOR FAILURE. WHEN I PULLED THE CLUTCH BACK UP MANUALLY, THE PEDAL WOULD NOT GO BACK DOWN BUT HALF WAY. I PUSHED HARD ENOUGH TO GET THE CLUTCH INTERLOCK SWITCH TO DISENGAGE, AND TRIED TO START THE CAR. WHEN THE STARTER ENGAGED, THE ENGINE DRAGGED WITH SOMETHING ELSE. I ABANDONED THE CAR TO GET TO A PHONE. WHEN I CALLED THE DEALER, THEY GAVE ME A PHONE NUMBER TO ROADSIDE ASSISTANCE, THEY WANTED TO CHARGE ME TO TOW THE CAR TO THE NEAREST VW CERTFIED REPAIR SHOP. EVENTUALLY I CONVINCED THEM TO TOW THE CAR, AND WHEN I MET HIM AT THE CAR, I NOTICED A LEAK OF EITHER HYDRAULIC, GEAR, OR DIESEL FLUID. WHEN I GOT ON THE INTERNET I FOUND THAT THIS IS A VERY COMMON PROBLEM DUE TO A POOR DESING IN THE FLYWHEEL. VW TENDS TO REFUSE TO REPLACE THE CLUTCH CLAIMING THAT IT WAS PREMATURE WEAR DUE TO POOR DRIVING HABITS. THE FLYWHEEL TENDS TO CRACK OR EVEN SHATTER CAUSING NOT ONLY CLUTCH ISSUES BUT ALSO TRANSMISSION AND ENGINE ISSUES. THIS ISSUE CAN LEAD TO WRECKS FIRES AND ALSO EVEN STRANDED PEOPLE THAT MAY HAVE NO WAY OF GETTING HELP. VOLKSWAGEN HAS RECALLED THE FLYWHEEL IN EUROPE BUT REFUSES TO DO SO IN AMERICA. INFORMATION ON THE ISSUE CAN BE FOUND HERE HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=137014&PAGE=1 THIS IS A 60 PAGE FORUM THAT EQUALS ABOUT 500 PAGES PRINTED OUT THIS IS SPECIFICALLY TO THIS ISSUE. THE RECALL INFO CAN BE FOUND HERE HTTP://UK-MKIVS.NET/FORUMS/2/562166/SHOWTHREAD.ASPX
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10203196September 17, 2007
VEHICLE SPEED CONTROL
I PURCHASED A 2006 JETTA TDI AND MY MILES ARE OFF....IT SEEMS AS THOUGH EVERYONE I TALK TO WITH THIS CAR HAVE THE SAME PROBLEM. I AM GOING 3-5 MILES SLOWER THEN WHAT IT IS SHOWING. I WAS THINKING OVER TIME WHEN I HAVE DRIVEN 55,000 MILES THAT I HAVE ONLY DRIVEN 50,000. I THINK THIS IS WRONG FOR A COMPANY TO DO AND VW WILL NOT DO A THING ABOUT IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10202780September 12, 2007
POWER TRAIN:CLUTCH ASSEMBLY
JUST HAD THE DUAL MASS FLYWHEEL AND CLUTCH REPLACED @ 40,000 MILES WHICH IS CRAZY. CLUTCH WAS SLIPPING AND AFTER HEARING ABOUT THE TRANSMISSIONS DESTROYED WHEN THE DMF COMES APART, I SPENT $1,400.00 CDN TO REPLACE IT. IVE DRIVEN CLUTCHES ALL MY LIFE (33 YEARS) AND NEVER HAD TO REPLACE A CLUTCH BEFORE 200,000 MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201725September 3, 2007
POWER TRAIN:CLUTCH ASSEMBLY
2006 JETTA TDI MADE IN MEXICO IN 01/06. PURCHASED 04/06. CAR WAS ALWAYS DIFFICULT TO DRIVE FROM A STANDING START. CLUTCH SEEMED TO LOCK UP PREMATURELY. MANY TIMES THIS CAUSES THE ENGINE TO STALL. AT ~25,000 MILES THE CLUTCH STARTED SLIPPING ON THE HIGHWAY. THERE IS OVERWHELMING EVIDENCE AMONG OTHER VW JETTA TDI OWNERS THAT THIS IS A SIGN OF PREMATURE DUAL MASS FLYWHEEL FAILURE. THERE ARE TWO SCENARIOS THAT MAKE THIS FAILURE A SERIOUS SAFETY RISK TO THE DRIVER AND ANY PASSENGERS: 1. SLIPPAGE OF THE CLUTCH AT HIGH SPEEDS CAUSES LOSS OF SPEED CONTROL WHILE MERGING OR PASSING. 2. LOCKING OF THE CLUTCH FROM A STANDING START CAN CAUSE THE ENGINE TO STALL POSSIBLY LEAVING THE CAR IN THE WAY OF OTHER TRAFFIC. I AM IN CONTACT WITH THE DEALER TO GET THIS FAILED DMF REPLACED BEFORE THERE ARE ANY SERIOUS INJURIES OR PROPERTY DAMAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201221August 30, 2007
POWER TRAIN:CLUTCH ASSEMBLY
THERE IS A LIST OF PROBLEMS I'VE HAD WITH THIS CAR. FIRST THE ODOMETER READS 5-7 MILES HIGHER THAN MY ACTUAL SPEED, AND THE RADIO RECEPTION AND VOLUME OSCILLATES RANDOMLY. THE ENTIRE CAR STARTS TO SHAKE THE LONGER AT A STOP; SAY IN TRAFFIC OR EVEN AT A LONG RED LIGHT. IT'S EVEN WORSE ON AN A HILL, BOTH INCLINE AND DECLINE. THE FRICTION POINT CHANGES RANDOMLY WHICH MAKES IT QUITE EASY TO STALL OUT THE CAR FROM A STARTING POSITION. WHEN ONE TURNS THE WHEEL TO GO AROUND A TURN THE FRONT OF THE CAR PRODUCES A DEEP GROANING SOUND. THE PAINT IS ALSO CHIPPING OFF RANDOMLY; AND I HAND WAX AND WASH THIS VEHICLE MYSELF; SO IT MAKES NO SENSE SINCE IT'S ONLY A YEAR OLD. THE TOP COAT IS ACTUALLY PEALING OFF ON PARTS OF THE CAR. I TOOK IT INTO THE DEALER AND THEY UPDATED THE SOFTWARE ON THE RADIO; AND I'M CURRENTLY WAITING FOR THE FLYWHEEL TO BE REPLACED, THE PART HASN'T COME IN YET.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201222August 30, 2007
POWER TRAIN:CLUTCH ASSEMBLY
HAD THE DUAL MASS FLYWHEEL COME APART. DEALER REPLACED FLYWHEEL, CLUTCH PLATE, BOLTS, A BEARING, AND A SUPPORT UNDER WARRANTY. THIS SEEMS TO BE A SYSTEMIC PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201279August 30, 2007
POWER TRAIN:CLUTCH ASSEMBLY
CLUTCH AND FLYWHEEL FAILED AT 23,740 MILES. SUDDEN FAILURE, WITHOUT WARNING. CAUSED THE CAR TO COME TO A COMPLETE STOP, PULLED THE CLUTCH PEDAL TO THE FLOOR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201288August 30, 2007
POWER TRAIN:CLUTCH ASSEMBLY
EXPERIENCED CLUTCH FAILURE IN MY 2006 VW JETTA TDI AT 23K MILES (AT LEAST 10K HIGHWAY MILES). CAR HAD A LIFETIME HISTORY OF LESS THAN SMOOTH TAKE-OFF (FROM STAND STILL TO 1ST GEAR). FIRST SIGN OF MAJOR PROBLEM WAS TOTAL CLUTCH FAILURE (PEDAL STUCK TO FLOOR, UNABLE TO SHIFT) AFTER ABOUT 30 MIN. IN STOP-AND-GO TRAFFIC ON INTERSTATE IN ROAD CONSTRUCTION ZONE. THIS IS A SAFETY ISSUE: THIS FAILURE CAUSES DRIVER TO LOSE THE ABILITY TO ACCELERATE AND HAS POTENTIAL TO CAUSE HIGH SPEED CRASH IN HEAVY TRAFFIC MERGING CONDITIONS. THIS IS ALSO A KNOWN ISSUE: ONLINE READING QUICKLY REVEALS THAT THE DUAL MASS FLYWHEEL & CLUTCH ASSEMBLY HAS BEEN PROBLEMATIC FOR SOME TIME, AND THIS PARTICULAR ISSUE IS FOUND IN THE 2005.5 & 2006 JETTA TDI. THREE EXAMPLES OF EVIDENCE FOR THIS ARE: #1. TO DATE, 46 MEMBERS OF THE ONLINE FORUM TDICLUB.COM HAVE EXPERIENCED THIS LOW MILEAGE CLUTCH AND/OR FLYWHEEL FAILURE. #2. VW HAS HAD RECALLS IN BOTH FINLAND AND AUSTRALIA FOR SAME/SIMILAR ISSUES. #3. THE PRODUCT DESCRIPTION OF SINGLE MASS FLYWHEEL & CLUTCH ADVERTISED AT DIESELGEEK.COM STATES: GETS RID OF THE FAILURE PRONE STOCK SACHS DUAL MASS FLYWHEEL. I REPEAT, THIS IS A KNOWN PROBLEM, IT SEEMS THAT VW KNOWS THAT ORIGINAL PARTS ARE DEFECTIVE OR NOT UP TO THE JOB AS THEY HAVE UPGRADED THE REPLACEMENT PARTS. BUT VW REFUSES TO PAY FOR REPAIRS, CITING OWNER ERROR AND/OR WEAR-AND-TEAR. MY REPAIR COST $1700 AND VW SHOULD REIMBURSE ME. THE REPAIRED CLUTCH IS SMOOTHER THAN IT HAS EVER BEEN, INDICATION THAT IT WAS DEFECTIVE FROM DAY ONE. FAR MORE IMPORTANT: VW SHOULD ISSUE A RECALL BEFORE SOMEONE IS HURT OR KILLED. I AM FURIOUS AT VW! THIS WAS A KNOWN PROBLEM WHEN I DROVE MY NEW CAR OFF THE LOT IN JUNE 06. AT THE VERY LEAST, I SHOULD HAVE BEEN ADVISED OF THE ISSUE AND TO BE MINDFUL OF CLUTCH OPERATION. HOW CAN VW BE SO CARELESS? WHO AT VW MADE THE DECISION TO IGNORE THIS POTENTIALLY FATAL PROBLEM? ILL CONTINUE TO SPREAD THE WORD UNTIL VW TAKES RESPONSIBILITY AND ISSUES A RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201293August 30, 2007
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
THIS HAS NOT RESULTED IN A CRASH ON MY BEHALF. WHILE DRIVING ON THE HIGHWAY WITH CRUISE CONTROL SET AT 75 MPH THE CAR WILL OCCASIONALLY (AVERAGES ONCE PER EVERY 1500 MILES) HESITATE THEN RESUME NORMAL OPERATIONS. THE DURATION OF THIS EVENT IS APPROXIMATELY 1 - 2 SECONDS. THE EFFECT OF THIS BEING THAT THE CAR SUDDENLY STARTS TO DECELERATE THEN SUDDENLY RESUME NORMAL BEHAVIOUR. THERE ARE NO INIDICATOR LIGHTS OR EVENTS LOGGED IN THE ONBOARD COMPUTER. THE VEHICLE HAS BEEN IN THE SHOP NUMEROUS TIMES WHERE THEY ARE UNABLE TO REPRODUCE THE ISSUE. I HAVE OFFERED TO DRIVE AROUND WITH A COMPUTER RUNNING VAGCOM (A VW DIAGNOSTICS APP) IF THEY WOULD PROVIDE IT IN ORDER TO CATCH THE ISSUE, YET VW AND THE LOCAL DEALERSHIP REFUSE TO DO SO. THIS INCIDENT HAS OCCURED AT LEAST 5 TIMES IN THE PREVIOUS 4 MONTHS, ONCE WHILE MY WIFE WAS DRIVING. THAT PARTICULAR INCIDENT NEARLY RESULTED IN HER RUNNING INTO THE HIGHWAY DIVIDER. THE DATE NOTED BELOW IS THE FIRST INCIDENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10201148August 29, 2007
POWER TRAIN:AUTOMATIC TRANSMISSION
DUAL MASS FLYWHEEL FAILURE IN TRANSMISSION OF 06 VW JETTA TDI. THE DMF HAS BROKEN AND IS DAMAGING THE TRANSMISION OF THE CAR. ATTEMPTING TO GET PROBLEM FIXED. *JB UPDATED 01-16-08. *KB UPDATED *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10200969August 28, 2007
VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR, EXTERIOR LIGHTING:BRAKE LIGHTS
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING 45 MPH, THE REARVIEW MIRROR OVERADJUSTED, WHICH CAUSED THE BRAKE LIGHTS TO PRODUCE A LARGE, RED GLARE ON THE REAR WINDOW. THE FAILURE CAUSED POOR VISIBILITY. THE CURRENT MILEAGE WAS 20,000 AND FAILURE MILEAGE WAS 24.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10199706August 15, 2007
POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE ATTEMPTING TO SHIFT GEARS AT 10 MPH, THE CLUTCH PEDAL DROPPED TO THE FLOOR AND THE VEHICLE WOULD NOT SHIFT. THE VEHICLE WAS PUSHED OFF THE ROAD AND TOWED. THIS IS THE SECOND TIME THAT THE CLUTCH HAS FAILED AND THE ASSEMBLY WAS REPLACED. THE CURRENT MILEAGE WAS 17,000 AND FAILURE MILEAGE WAS 1,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198758August 7, 2007
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
MY SPEEDOMETER IS READING FAST (WHEN I AM GOING 75 IT READS 80) WHEN COMPARED TO RADAR AND GPS. I TOOK MY VEHICLE IN TO MY DEALER AND THEY INFORMED ME THAT THE UNIT WAS OK, BUT THAT UP TO A 10% TOLERANCE IS ALLOWED BY FEDERAL REGULATIONS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198765August 7, 2007
VISIBILITY:WINDSHIELD WIPER/WASHER
WHILE THE CAR IS IN MOTION AND YOU ACTIVATE THE WINDSHIELD CLEANING SYSTEM, THE WIPERS WILL WIPE THREE TO FOUR TIMES AND THEN WAIT ABOUT 15 SECONDS AND THEN WIPE ONE FINAL TIME. DURING THE SUMMER MONTHS THIS IS NOT AN ISSUE AS THE SPLASH BACK IS MINIMAL. HOWEVER, DURING THE WINTER MONTHS WHERE THERE IS AN INCREASED AMOUNT OF WATER AND CHEMICALS ON THE ROAD, THE TINY AMOUNTS OF SPLASH BACK THAT GETS ONTO THE WINDSHIELD ARE SMEARED WHEN THE FINAL SWIPE OCCURS AND OBSTRUCTS YOUR VIEW. I TOOK THE VEHICLE INTO THE DEALER TO HAVE CHECKED AND STOPPED, BUT WAS TOLD IT WAS A "FEATURE" OF THE VW VEHICLES AND COULD NOT BE TURNED OFF. THIS IS A SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198790August 7, 2007
POWER TRAIN:CLUTCH ASSEMBLY
DUAL MASS FLYWHEEL LEAKING FROM CENTER HUB CLUTCH FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198480August 4, 2007
POWER TRAIN:CLUTCH ASSEMBLY
ONLY 48,000 MILES ON THE CAR AND THE CLUTCH/FLYWHEEL ARE SHOT. ACCORDING TO AN INDEPENDENT TRANS SHOP THIS IS THE SECOND TIME ITS BEEN REBUILT WITH VW PARTS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198388August 3, 2007
POWER TRAIN:CLUTCH ASSEMBLY
CLUTCH ASSEMBLY IN BOTH MY 2006 VW JETTA'S HAD TO BE REPLACED, BECAUSE OF INCORRECT ASSEMBLY AT PLANT. ONE IS RUNNING WELL, THE OTHER ONE IS STILL NOT RUNNING PROPERLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198392August 3, 2007
POWER TRAIN:CLUTCH ASSEMBLY
FLYWHEEL AND CLUTCH CATASTROPHIC FAILURE. CLUTCH PEDAL WENT COMPLETELY TO FLOOR AND ENGINE SEIZED UP. CLUTCH WOULD NOT DISENGAGE ENGINE AND WAS SEIZED UP. DRIVER WAS OPERATING VEHICLE AT LOW SPEED WHEN FAILURE OCCURRED. IF FAILURE HAD HAPPENED AT HIGHWAY SPEEDS IT LIKELY WOULD HAVE RESULTED IN HIGH-SPEED WRECK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198466August 3, 2007
POWER TRAIN:CLUTCH ASSEMBLY
FAULTY CLUTCH AND FLYWHEEL. FLYWHEEL BLEW APART AND DESTROYED CLUTCH. THE INCIDENT NEARLY CAUSED AN ACCIDENT WHICH COULD HAVE POSSIBLY KILLED MY ENTIRE FAMILY. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198215August 1, 2007
POWER TRAIN:CLUTCH ASSEMBLY
CLUTCH IN MY 2006 JETTA TDI (MANUFACTURED 02/06) WENT OUT WHILE DRIVING DOWN THE HIGHWAY AT 70 MPH. I LOST ABILITY TO SHIFT GEARS AND VEHICLE IS CURRENTLY AT THE DEALERSHIP FOR REPAIRS. DEALER SAYS THAT IT IS THE CLUTCH BUT FROM WHAT I HAVE RESEARCHED THESE CARS (MANUFACTURED BEFORE 03/06) HAVE A FAULTY DUAL MASS FLYWHEEL THAT COMES APART AND THEN TEARS UP THE CLUTCH. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volkswagen Jetta