Toyota Tundra Complaints (2005)

377 consumer complaints on file.

#11203504April 24, 2019
STRUCTURE:BODY
I HAVE ONLY OWNED THIS TRUCK FOR ABOUT 6 MONTHS NOW. TOOK MY TRUCK TO MY MECHANIC TO GET SOME BRAKE WORK DONE. WHEN HE PULLED THE TIRE OFF OF THE FRONT PASSENGER SIDE HE NOTICED A CRACK IN THE FRAME. SOME FURTHER INVESTIGATION REVEALED SOME VERY BAD ROT ON THE FRAME AND A HOLE ABOUT THE SIZE OF TWO FISTS THAT SOMEBODY HAD TRIED TO PATCH WITH JUST BONDO AND PAINTED BACK OVER TO HIDE IT. IT WOULD NOT HAVE BEEN VISIBLE WITHOUT PULLING THE TIRE OFF. UNSURE OF WHEN THIS ALL OCCURRED BUT APPEARS TO HAVE BEEN ROTTED OUT FOR A WHILE. I HAVE NO PICTURES TO UPLOAD AS IT IS UNSAFE TO DRIVE AND STILL AT THE GARAGE. I'M CONCERNED ABOUT THE SAFETY OF OTHERS DRIVING THESE LATER YEARS FIRST GENERATION TUNDRAS AND TOYOTAS NEGLECT AT FIXING THIS SAFETY ISSUE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11202785April 22, 2019
FUEL/PROPULSION SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL
I PURCHASED THIS VEHICLE USED APROX 10 YEARS AGO. THE ISSUE THAT I HAVE HAD LOOKED AT BY TOYOTA DEALERSHIP REMAINS UNRESOLVED. WHEN YOU TAKE YOUR FOOT OFF THE BRAKE IT IMMEDIATELY LUNGES FORWARD AND TRAVELS WITHOUT FOOT ON THE GAS UP TO SPEED OF 15 MPH ON FLAT LEVEL GROUND. IT IS DEFINITELY NOT SAFE. IT COULD CAUSE?AN ACCIDENT. MY BROTHER'S INSISTED THAT I HAVE IT LOOKED AT BY TOYOTA DEALERSHIP. I HAVE NOT HAD A SATISFACTORY ANSWER TO THIS ISSUE. AGAIN THE ANSWER REMAINS THERE HAS BEEN NO RECALL. COULD IT BE A TIMING CHAIN ISSUE?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11195586April 11, 2019
ELECTRICAL SYSTEM, SUSPENSION, UNKNOWN OR OTHER
SERVICE BULLETIN P2445 FOR SECONDARY AIR INGECTION SYSTEM THEN NOTES THE FRAME IS CORROSION AND MOUNTS ARE BRAKING OFF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11192995April 1, 2019
ENGINE
CHECK ENGINE LIGHT SECONDARY AIR INTAKE THIS WAS A RECALL IN 2007-10 YEARS BUT IS ALSO BEEN A COMMON PROBLEM IN EARLIER MODELS. THIS IS A VERY EXPENSIVE REPAIR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11190924March 22, 2019
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE AT TOYOTA OF BEDFORD (18151 ROCKSIDE RD, BEDFORD, OH 44146), THE TECHNICIAN INFORMED THE CONTACT THAT THE FRAME WAS CORRODED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11190433March 21, 2019
STRUCTURE:BODY, SERVICE BRAKES, UNKNOWN OR OTHER
MY 2005 TOYOTA TUNDRA HAS 217K MILES AND IS, MECHANICALLY, IN TERRIFIC SHAPE, EXCEPT THE FRAME HAS RUSTED OUT ON THE DRIVERS SIDE. STRUCTURALLY, IT'S STILL DRIVABLE SAFELY, BUT IT WILL NO LONGER PASS STATE INSPECTION (MAINE, USA). THOUSANDS OF OTHER TOYOTA TUNDRAS OF THE SAME STYLE AND MANUFACTURING PROCESS AND SIMILAR MODEL YEAR HAVE HAD FRAME RECALLS DONE FOR THE EXACT SAME REASON. I DO NOT FEEL IT IS FAIR TO SKIP THIS YEAR. THIS IS MY FAMILY'S ONLY SOURCE OF TRANSPORTATION RIGHT NOW, AND IT IS VITAL TO KEEP IT ON THE ROAD. PLEASE ALLOW A FRAME RECALL FOR THIS MODEL YEAR!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11176520February 12, 2019
STRUCTURE:BODY
BOUGHT THE TUNDRA IN LATE 2014 FROM TOYOTA OF KEENE IN NH. WAS TOLD FRAME WAS CHECK AND THE RUST PREVENTION SPRAY WAS APPLIED, VEHICLE FRAMED LOOKED CLEAN AND HAD NO VISIBLE RUST , THEY COULDN'T PROVIDE ME WITH ANY RECORD OF THIS . IN FEBRUARY OF 2016. I TOOK THE VEHICLE TO GRAPPONE AND HAD NOTICED SOME RUST ON THE FRAME AROUND THE GAS TANK AND UNDER THE DRIVERS SIDE. GRAPONNE TOLD ME THAT THE FRAME SERVICE WAS COMPLETED AND THEY COULDN'T ( OR WOULDN'T) BE ABLE TO HELP AND NOTED THE SPRAY WAS INTACT. AFTER THAT THE POWER STEERING ROTTED AWAY WHICH GRAPPONE TOYOTA REPLACED AND AT THAT TIME I BROUGHT THE RUST TO THERE ATTENTION AGAIN . THEY SAID IT LOOKED NORMAL AND NOT TO WORRY. AFTER THAT I KEPT MY EYE ON IT. BROUGHT IT TO GET MY ANNUAL INSPECTION. THE TECH BROUGHT ME OUT SHOWED ME THE RUST AND TOLD ME THAT I HAD 1 OR 2 YEARS LEFT BEFORE THE FRAME WOULD NEED TO REPLACED OR REPAIRED DUE TO RUST . THE TUNDRA HAS 155.XXX MILES ON IT GETS WASHED REGULARLY . CONTACTED TOYOTA USA THEY TOLD ME THEY WOULD HAVE SOMEONE CONTACT ME. TOYOTA OF KEEN CALLED ME AND TOLD BE THE TRUCK WAS OLD AND THE PERSON WHOM I SPOKE WITH TOLD ME IT WAST HIS FAULT BECAUSE HE WASN'T THERE AND THE PROBLEM AREAS I DESCRIBED TOYOTA DIDN'T PAY THE TO SPRAY PROPERLY, ( PARTS PEOPLE CANT SEE UNLESS THEY REALLY LOOK) BUT I COULD DRIVE IT IN AND THEY COULD LOOK AT IT . I CALLED TOYOTA USA AFTER RECEIVING AN EMAIL THE NEXT DAY THAT STATED I HAD THERE POSITION REGARDING MY INCIDENT AND THE REP SAID IT WASN'T TOYOTA'S PROBLEM BECAUSE THE EXTENDED SERVICE PROGRAM WAS NOT A RECALL AND EXPIRED IN 2015 I FEEL THAT IF TOYOTA KNEW THERE WAS A PROBLEM WITH THESE FRAMES THEY MIGHT INCLUDED THEM WITH ALL THE OTHER MODELS A BUT THEY DECEITFULLY COVERED UP THE PROBLEM WITH A SPRAY THAT HIDES THE PROBLEM LONG ENOUGH TO MAKE THEM "OLD " AS THEY PUT IT . MANY OTHERS WOULD AGREE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11173296January 31, 2019
AIR BAGS
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V065000 (AIR BAGS), BUT THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. THE CONTACT HEARD A LOUD NOISE COMING FROM THE VEHICLE. SUDDENLY, THE FRONT DRIVER AND PASSENGER SIDE CURTAIN AIR BAGS DEPLOYED WITH FORCE. THE CONTACT SUSTAINED A HEAD INJURY THAT REQUIRED MEDICAL ATTENTION. AN INCIDENT REPORT WAS FILED, BUT NOT A POLICE REPORT. THE DEALER (PRIORITY TOYOTA HAMPTON, 2301 W MERCURY BLVD, HAMPTON, VA 23666, (757) 838-5000) INSPECTED THE VEHICLE PER THE MANUFACTURER'S INSTRUCTION TO INVESTIGATE THE AIR BAG DEPLOYMENT. THE MANUFACTURER INVESTIGATED THE EDR BOX, BUT FOUND NO FAILURE. THE MANUFACTURER SENT A LETTER INDICATING THAT THE VEHICLE OWNER WAS AT FAULT. THE VEHICLE WAS NOT REPAIRED. THE CONTACT FELT THAT THE INVESTIGATION FAILED TO PROVIDE A CONCLUSION THAT THE RECALL REMEDY WOULD HAVE PROVIDED A PERMANENT REMEDY. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TT*JB - (RECALL RELATED INCIDENT) TS
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11172581January 28, 2019
ELECTRICAL SYSTEM, POWER TRAIN
TUNDRA HAD ELECTRICAL FAULT IN TRANSMISSION DUE TO WIRING HARNESS CORROSION. TUNDRA WILL DROP OUR OF GEAR WHILE DRIVING AND REENGAGE VIOLENTLY. TOYOTA HAS REFUSED ANY ASSISTANCE AND I AM UNABLE TO REPAIR DUE TO NATIONAL BACKLOG ON NECESSARY PARTS. MY TUNDRA WAS PART OF THE RUST RECALL A COUPLE YEARS AGO WHICH WAS NEVER PROPERLY RECTIFIED AND I BELIEVE THIS IS A CONTINUATION OF THAT PROBLEM. TRANSMISSION ISSUE SEEMS TO OCCUR MOSTLY AT SPEEDS UP TO 45 MPH.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11170912January 19, 2019
STRUCTURE:BODY
WAS PULLING LIGHT DUTY COVERED UHAUL TRAILER THAT WAS MAYBE 1/10 FULL OF HOUSEHOLD ITEMS. FRAME PULLED APART. WAS IN MY DRIVEWAY WITH SON IN LAW HELPING GUIDE BACKING UP TO GARAGE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11164849January 7, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME UNDERNEATH THE DRIVER'S SIDE BUCKLED WHEN IT WAS PLACED ON THE LIFT AT STOLTZ TOYOTA OF DUBOIS (860 BEAVER DR, DUBOIS, PA 15801, (814) 371-3333. THE DEALER STATED THAT THERE WAS A VOLUNTARY RECALL ON THE FRAME AND ADVISED THE CONTACT TO CALL THE MANUFACTURER. THE MANUFACTURER STATED THAT THE VOLUNTARY RECALL EXPIRED IN JULY OF 2015 AND THEY COULD NOT ASSIST. THE CONTACT DID NOT RECEIVE A RECALL NOTICE. THE CONTACT PURCHASED THE VEHICLE IN 2009 FROM THE ORIGINAL OWNER. THE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11145331November 5, 2018
SUSPENSION
TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING 5 MPH, THE FRONT DRIVER'S SIDE WHEEL FRACTURED AND THE LOWER BALL JOINT FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION). THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION). THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 216,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11144789November 1, 2018
STRUCTURE:BODY
FRAME IS RUSTING AND BREAKING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11143756October 29, 2018
SERVICE BRAKES
TL* THE CONTACT OWNS 2005 TOYOTA TUNDRA. THE CONTACT STATED WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO STOP THE VEHICLE AS THE BRAKE BARRIER WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT HE DRIVE UPHILL AND WHEN THE VEHICLES STARTED ROLLING BACKWARDS, HE DEPRESSED THE BRAKE PEDAL AND THE VEHICLE STOPPED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 175,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11124368September 4, 2018
STRUCTURE:BODY, SUSPENSION
MY 2005 TUNDRA IS ROTTING OUT IN THE FRAME ABOVE THE REAR LEAF SPRING FRONT CONNECTION TO THE FRAME. DEALER HAS LOOKED AT IT TWICE IN THE LAST SIX YEARS SAID NO PERFORATIONS. NOW IN 2018 THE FRAME IS ROTTING AND BUCKLED. TOYOTA CORPORATE SAYS THERE IS NOTHING THEY CAN DO BECAUSE IT OUTSIDE OF THE WINDOW OF SERVICE. SO NOW I AM STUCK WITH A TRUCK WITH JUST OVER 100K MILES, LOOKED AT BY A TOYOTA DEALER IN THE PAST AND WAS DEEMED NOT IN NEED OF A FRAME REPLACEMENT. NOW IT IS IN NEED OF A FRAME REPLACEMENT BUT TOYOTA WON'T HONOR ANY PAST RECALLS OR INSPECTIONS DONE BY A TOYOTA DEALER AND HAS LEFT IT TO ME TO DEAL WITH THE ROT. VERY DISAPPOINTED THERE IS NO HELP FOR CUSTOMERS IN THIS SITUATION FROM THE MANUFACTURER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11111844July 17, 2018
STRUCTURE:BODY
GOOD AFTERNOON, I'M WRITING TO REPORT AND REQUEST ASSISTANCE WITH CATASTROPHIC FRAME ISSUES ON MY 2005 TOYOTA TUNDRA. THERE ARE A NUMBER OF HOLES IN THE FRAME AND PLACES I BELIEVE TO BE COMPROMISED. THE TRUCK HAS 96,000 MILES. I HAVE AN OPEN INCIDENT TICKET WITH TOYOTA BUT ALSO WANTED TO REPORT THIS ISSUE HERE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11100248June 6, 2018
STRUCTURE:BODY, SUSPENSION
MY 2005 TOYOTA TUNDRA WAS RECALLED FOR RUST PROBLEMS, AND IN 2013 THE TOYOTA DEALERSHIP APPLIED A COATING TO THE FRAME WHICH THEY ADVISED WOULD REMEDY THE PROBLEM. ON 06/01/18 I NOTICED I HOWEVER HAVE HOLES IN MY FRAME NEAR WHERE THE SUSPENSION ATTACHES, AND THE FRAME IS NOT SAFE FOR OPERATION ON THE ROAD. THE DEALERSHIP SAID THEY ARE NOT LIABLE, AND I CALLED TOYOTA AND THEY SAID THEY ARE NOT LIABLE AND NO ONE WILL FIX THE ISSUE. THE DEALERSHIP HAD THE OPTION IN 2013 TO EITHER SPRAY OR REPLACE THE FRAME, THEY SPRAYED MINE BUT IT WAS NOT EFFECTIVE AND NOW I BELIEVE THE VEHICLE IS A HAZARD DUE TO HOLES IN THE FRAME. I ONLY HAVE 118,000 MILES ON THE TRUCK, AND IT HAS BEEN IN MY FAMILY SINCE BEING BRAND NEW. I BELIEVE THE FRAME IS DEFECTIVE AND TOYOTA INC. IS NOT ASSISTING ME WITH FIXING THE PROBLEM, THEY ADVISED ME I NEED TO GO TALK TO A BODY SHOP TO SEE IF THEY CAN WELD A PIECE INTO THE FRAME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11083151April 3, 2018
SERVICE BRAKES
GOT IN TRUCK, STARTED IT, BRAKE LIGHT REMAINED ON. WHILE DRIVING, BRAKES WERE SOFT. CHECKED BRAKE FLUID RESERVOIR, LOW ON FLUID. ADDED BRAKE FLUID, PUMPED BRAKES- PEDAL WENT TO THE FLOOR. FLUID UNDER RIGHT FRONT WHEEL. HAD TRUCK TAKEN TO MY MECHANIC - BRAKE LINE RUSTED OUT, ALL ALL OTHER LINES RUSTED AS WELL. RECOMMENDED ALL GET REPLACED AS A SAFETY ISSUE. NOT ONLY RUST ISSUES WITH THIS VEHICLE- WAS IN THE TOYOTA CHASSIS RECALL- CHASSIS COATED WITH RUST INHIBITOR. DIFFERENTIAL RUSTED OUT- REPLACED AT MY COST. TOYOTA TOOK NO RESPONSIBILITY. ALSO REPLACED THE HOOD RELEASE CABLE, EMERGENCY BRAKE CABLE, AS WELL AS THE TWO CABLES SUPPORTING THE TAILGATE- ALL RUSTED OUT. REAR BUMPER RUSTED OUT TOO.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11074762February 27, 2018
SERVICE BRAKES, STEERING
2005 TOYOTA TUNDRA. CONSUMER WRITES FRONT BRAKE LINE BROKE AND MAJOR RUSTING OF BRAKE LINES, AND RUSTED FRAME. * VA THE CONSUMER STATED THE POWER STEERING METAL LINES STARTED LEAKING. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11065273January 26, 2018
STRUCTURE:BODY, SERVICE BRAKES, STEERING
MAJOR RUSTING OF FRAME, RUSTED BRAKE LINES, RUSTED POWER STEERING LINES. VEHICLES IS UNSAFE DUE TO RUSTING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra