Toyota Tundra Complaints (2002)

482 consumer complaints on file.

#10126586June 26, 2005
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
I OWN A 2002 TOYATA TUNDRA. I, LIKE MANY, AS I AM NOW FINDING OUT, AM PLAGED BY THE SAME BRAKING PROBLEMS THAT SO MANY ARE EXPERIENCING. BEFORE THE 36,000 MI WARRANTY WENT OUT I TOOK THE RRUCK TO MY DEALER AND THEY SAID THAT THERE WAS A SERVICE BULLETIN ON THE BRAKES. THEY REPLACED ROTORS, AND CALIPERS. AFTER A WHILE THE SAME VIBRATING CAME BACK AGAIN. I TOOK IT BACK AGAIN AND THEY TURNED THE ROTORS AND SAID THAT FIXED THE PROBLEM. SINCE THE WARRANTY HAS RUN OUT , I HAVE REPLACED THE ROTORS TWICE AND NEW PADS EVERY TIME. I LOVE MY TRUCK BUT THERE IS NO DOBT THAT THEY HAVE A PROBLEM. I JUST NEED A SOLUTION, ALONG WITH SO MANY OTHER TUNDRA OWNERS!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10126061June 21, 2005
EXTERIOR LIGHTING:BRAKE LIGHTS
STOP LAMP SOCKET FAILURE. AT 1ST THE BULB WOULD STAY IN THE SOCKET AND WOULD ONLY FALL OUT EVERY SIX MONTHS OR SO. IN THE LAST 1/2 YEAR THE BULB WOULD FALL OUT AT LEAST ONCE A MONTH. MOST OF THE TIME THE BULB WOULD FALL OUT AND END UP LAYING IN THE LENSE CASING AND COULD BE PLUGGED BACK IN AND STILL WORK. THIS IS A REOCCURING PROBLEM IN THE TOYOTA TUNDRA. THEY HAD A RECALL FOR THE 2002 MODEL TUNDRA FOR THE EXACT SAME PROBLEM. THAT RECALL # WAS SSC-Y01. I WENT TO THE DEALER AND THE PLUG WAS TOTALLY CUT OFF AND REPLACED. THE REPAIR WAS COVERED UNDER EXTENDED WARRENTY BUT WITH A $50 DEDUCTABLE THAT I HAD TO PAY. MY SERVICE MAN DID NOT KNOW ANYTHING ABOUT THE 2000 RECALL, BUT ANOTHER SERVICE MAN INDICATED TO ME THAT IS WAS A PROBLEM IN PREVIOUS YEARS AND GAVE THE 2000 RECALL INFORMATION ABOVE. I CALLED TOYOTA AND THEY WOULD NOT DO ANYTHING. THE EXACT WORDING FOR 2000 SSC-Y01 TUNDRA STOP LAMP RECALL SAID THE FOLLOWING " THE PLASTIC BULB SOCKET IN CERTAIN REAR COMBINATION LAMP (INCLUDES STOP LAMP) MAY NOT HAVE BEEN MOLDED PROPERLY IN CERTAIN 2000 MODEL YEAR TUNDR'S. THIS COULD CAUSE A REDUCTION OF BULB RETENSION FORCE IN USE. IN THE WORST CASE, THE BULB COULD FALL OUT OF THE SOCKET RESULTING IN AN INOPERATIVE STOP LAMP." THIS IS EXACTULLY WHAT OCCURRED WITH MY STOP LIGHT BULB. WHAT THEY DO NOT INDICATE IS THE WOREST THING COULD HAPPEN WOULD SOMEONE COULD REAR END YOU SINCE THE LIGHTS ARE NOT WORKING WHICH COULD BE FATAL. YOU MAKE THE CALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10122596May 31, 2005
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
1.EXCESSIVE BREAK VIBRATION DURING STOPING. THOUGHT TO AT FIRST RELATED TO TIRE BALANCE. 2.FRONT BRAKE ROTORS WARPED FROM HEAT BUILDUP AND IMPROPER VENTILATION. 3.CONTACTED LOCAL TOYOTA SERVICE DEPARTMENT. ADVISED OF (TOYOTA TSB #BR004-02 BRAKE UPGRADE) AUTHORIZING REPLACEMENT OF: DUST SHIELDS, FRONT ROTORS, CALIPERS,PADS,REAR DRUMS,AND PADS. TOYOTA REFUSES TO REPAIR WITH MILEAGE BEING 41,000 AS TRUCK IS NOT IN WARRENTY. TOYOTA WOULD LIKE TO REPAIR FOR $1803.25. TOYOTA WOULD NOT COMMENT ON WHY I WAS NOT ADVISED OF THIS PROBLEM BEFORE WARRENTY EXPIRED. AS OF NOW, HAVE CONTACTED TOYOTA SOUTHEAST AND ISSUE NOT RESOLVED. TUNDRA WILL NOW HAVE TO BE REPAIRED OUT- O-F POCKET, AS BREAK FAILURE IS IMMINENT, AND SAFETY IS COMPROMISED. INDEPENDENT MECHANIC SUGGEST REPLACING ROTORS WITH PERFORMACE COOLING DISC AND CERAMIC PADS TO MINIMIZE WARPING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10122064May 24, 2005
SERVICE BRAKES, AIR:DISC:ROTOR
MY 2002 TOYOTA TUNDRA HAS VIBRATION IN THE BRAKE SYSTEM. TOYOTA TRIED TO SAY IT WAS NORMAL WEAR AFTER 50K MILES TO HAVE WARPED ROTORS. NEVER HAPPEN ON ANY OTHER VEHICLE I HAD. I SPENT $400 ON THERE 60K MILE INSPECTION (WHEN TRUCK HAD ONLY 52K MILES AND THEY CHECKED BRAKES OK. THEN I DROVE OFF AND BOOM VIBRATION IN FRONT BRAKES. NOW THEY CLAIM IT IS THE ROTORS AND
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10121403May 19, 2005
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
FAILURE OF RIGHT FRONT SUSPENSION RESULTING IN WHEEL ASSEMBLY COMING OFF OF VEHICLE. WHILE PULLING AWAY FROM A TRAFFIC LIGHT THE RIGHT FRONT WHEEL ASSEMBLY INCLUDING DRIVESHAFT, BRAKE ROTOR AND ALL ATTACHED WIRES AND HOSES CAME OFF THE TRUCK AND ENDED UP UNDER THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10121409May 19, 2005
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
AFTER THE FAILURE OF THE RIGHT FRONT SUSPENSION 1 YEAR EARLIER (SEE ODI#10121403) THE LEFT FRONT SUSPENSION COLLAPSED AS I WAS PULLING INTO MY DRIVEWAY. RESULTS WERE THE SAME AS THE PRIOR FAILURE WITH THE WHEEL ASSEMBLY COMING OFF AND THIS TIME JAMMING UP INTO THE WHEEL WELL. ENTIRE LEFT FRONT SUSPENSION COMPONENTS WERE REPLACED BY SAME SERVICE DEALER. AS WITH PRIOR RIGHT FRONT FAILURE THERE WAS NO WARNING OF IMPENDING FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10121230May 17, 2005
SUSPENSION:FRONT, SUSPENSION, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
THE DRIVERS SIDE FRONT SUSPENSION BALL JOINTS GAVE WAY AS I WAS DRIVING AT 75MPH ON INTERSTATE 40 WEST IN TEXAS AT MILE MARKER 14. THE ENTIRE WHEEL, BREAK, AND AXLE ASSEMBLY DETATCHED AT HI SPEED. THE BREAK LINE WAS SEVERED. THE ASSEMBLY FOLDED UNDER THE TRUCK AND I SKIDDED ON THE WHEEL WITH LITTLE CONTROL UNTIL I COULD MANEUVER OFF OF THE INTERSTATE AND MAINTAIN AN UPRIGHT POSITION WITH THE VEHICLE. THE TWISTED TIE ROD KEPT THE TIRE AND WHEEL ASSEMBLY FROM COMPLETELY SEPARATING FROM THE VEHICLE. THE WEATHER WAS LIGHT SNOW WITH A TEMPERATURE OF ABOUT 34 DEGREES. TIME WAS APPX 9.50 AM. THE TRUCK WAS REPAIRED WITHOUT COMMENT BY STREET TOYOTA OF AMARILLO, TEXAS AT A COST OF APPX. $ 2,200. THE DEALER SAID THERE WAS AN INORDINATE AMOUNT OF WEAR ON THE FRONT END STEERING COMPONENTS. THE TRUCK IS IN GOOD CONDITION WITH A GOOD DOCUMENTED SERVICE RECORD. THE TRUCK HAD BEEN STEERING "LOOSELY" AND I HAD A MECHANIC EXAMINE THE STEERING THE PREVIOUS WEEK. HE SAID IT LOOKED AND DROVE OK, BUT HE COULDN'T REALLY TELL. THE TRUCK HAS NEVER BEEN INVOLOVED IN AN ACCIDENT OR INSURANCE CLAIM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10118720April 29, 2005
ELECTRICAL SYSTEM
****NOTE: REGARDING A 2002 TOYOTA SEQUOIA SINCE THIS IS NOT AN OPTION I CHOSE TUNDRA BECAUSE THIS IS THE CLOSEST TO THE SEQUOIA SIZE. THE VSC TRAC-OFF SYSTEM TURNS ON WHEN DRIVING ON STRAIGHT, DRY FREEWAY. THE TRUCK LOST SPEED AND IT STARTED MOVING TO NEXT LANE. I LOST CONTROL OF THE STEERING. I THOUGHT THAT I WAS GOING TO CRASH. I TOOK IT IN AND I WAS TOLD THAT THE COMPUTER NEEDS TO BE REPLACED. I AM AFRAID TO DRIVE MY TRUCK AGAIN. I AM AFRAID THAT NEXT TIME THAT HAPPENS ON THE BUSY LOS ANGELES FREEWAY, I COULD BE THE VICTIM OF A TERRIBLE TRAGEDY CAUSED BY THE VSC MALFUNCTION.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10118719April 29, 2005
ELECTRICAL SYSTEM, STEERING
REGARDING 2002 SEQOUIA. SINCE SEQOUIA NOT AN OPTION, CHOSE TUNDRA AS IT WAS CLOSEST TO VEHICLE TYPE. DRIVING ON FREEWAY AT SPEED LIMIT, THEN CAR FELT AS IF VEERING OFF TO THE LEFT, IT WAS HARD KEEPING STEERING WHEEL STRAIGHT AND THEN I NOTICED THAT THE TRAC OFF AND VSC LIGHTS WENT ON. IT WAS A CLEAR DAY, FAIRLY SMOOTH SURFACE IN THE CENTER LANE, WHEN THIS INCIDENT OCCURRED. HAD TO PULL OF FREEWAY AND TURN OFF VEHICLE AND THEN RESTART TO RESET THE CAR. THIS IS THE ONLY WAY THE LIGHTS WILL TURN OFF AND THE CAR WILL STEER NORMALLY. THIS IS NOT THE FIRST TIME IT HAS HAPPENED, THIS HAS HAPPENED A SEVERAL TIMES IN THE PAST FEW MONTHS.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10118993April 21, 2005
SERVICE BRAKES, HYDRAULIC
DURING A ROUTINE SERVICE THE FRONT ROTORS WERE FOUND TO BE DEFECTIVE, AS WELL AS THE REAR DRUMS. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10112850March 30, 2005
POWER TRAIN:AUTOMATIC TRANSMISSION, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM, VEHICLE SPEED CONTROL, SUSPENSION
WHILE DRIVING 70 MPH, THE TRANSMISSION STALLED. THE VEHICLE WAS TOWED. DEALERSHIP REPAIRED THE PROBLEM. *AK THE DRIVER HEARD AND FELT A LOUD BUMP IN THE REAR OF THE VEHICLE. THE ENGINE CONTINUED TO RUN BUT THE VEHICLE WOULD NOT MOVE WHEN THE CONSUMER APPLIED THE GAS PEDAL. THERE WAS REAR END GREASE LEAKING FROM THE RIGHT SIDE REAR SHOWING ON THE WHEEL AND TIRE. THE MECHANIC STATED THAT THERE WAS NO CONNECTION BETWEEN THE REAR BRAKE, REAR END LEAKING GREASE, THE DRIVE SHAFT AND THE FAILURE OF THE TRANSMISSION. THE BRAKES WERE A MAJOR PROBLEM, THE CRUISE CONTROL NEVER KEPT SPEED OR SMOOTH, THE LEFT LOWER FRONT BALL JOINT HAD A CATASTROPHIC FAILURE THAT CAUSED THE ENTIRE WHEEL, BRAKE LINE AND ALL ESSENTIAL COMPONENTS ON THE LEFT SIDE OF THE VEHICLE TO COME LOOSE. THE CONSUMER REQUESTED REIMBURSEMENT. *SC THE BRAKES WERE A PROBLEM ON THE VEHICLE, AND THE DRUMS WERE REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10113952March 11, 2005
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
AT 25000 MILES THE CHECK ENGINE LIGHT CAME ON IN MY 2002 TOYOTA TUNDRA. TOOK IT TO THE DEALER FOR SERVICE, WAS ADVISED THAT THE REPAIR WOULD COST $300 TO FIX. THE PROBLEM IS EMISSIONS RELATED AND ATTRIBUTED TO A DEFECTIVE PART ( FUEL FILLER NECK ). THERE IS A TOYOTA TSB OUT DESCRIBING THIS PROBLEM. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10105253February 16, 2005
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT, SUSPENSION
WHILE DRIVING AT 65 MPH, THE VEHICLE SUDDENLY JERKED. THE CONSUMER COULD NOT CONTROL THE VEHICLE WHILE CROSSING INTO ONCOMING TRAFFIC LANES AND COMING TO A STOP ON THE SHOULDER. THE CONSUMER NOTICED THAT THE LOWER BALL JOINT HAD SEPARATED AND THE TIRE (WHEEL ASSEMBLY) HAD FOLDED UNDER THE PASSENGER SIDE OF THE VEHICLE. *JB *SC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10111263February 9, 2005
SUSPENSION, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
WHILE DRIVING 5 MPH DRIVER'S FRONT SIDE COLLAPSED. VEHICLE WAS TOWED TO A DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT BOTH UPPER AND LOWER BALL JOINTS SNAPPED, AND NEEDED TO BE REPLACED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10111143February 8, 2005
SUSPENSION, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
WHILE DRIVING 60 MPH THE BALL JOINTS FAILED. IT CAME COMPLETELY FROM UNDER THE TRUCK. THERE WAS NO WARNING. THERE WAS NO ACCIDENTS. CONSUMER CONTACTED THE DEALER. THERE WERE NO RECALLS. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10109925February 6, 2005
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
I WAS DRIVING MY 2002 EXTENDED CAB 4X4 TUNDRA 1 OR 2 MPH ON AN UNPAVED BUT GRADED ROAD VIEWING REAL ESTATE WHEN THE ENTIRE FRONT PASSENGER SIDE OF THE VEHICLE COLLAPSED JARRING THE TRUCK TO A STOP. I THOUGHT THE ROAD HAD COLLAPSED. IT APPEARS AS IF THE FRONT LOWER BALL JOINT FAILED. I WAS ONLY 7 MILES OFF INTERSTATE I-95, I SHUDDER TO THINK OF THE CONSEQUENCES OF A FAILURE LIKE THIS GOING 70 MPH WITH TRAFFIC. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10104448December 24, 2004
AIR BAGS:FRONTAL
ICY ROAD CONDITIONS CAUSED A DIRECT COLLISION OF MY 2002 TUNDRA WITH A TREE AT APPROXIMATELY 30 MPH. THE FRONT BUMPER RADIATOR AND ALL PARTS IN BETWEEN WERE PUSHED BACK INTO THE ENGINE FROM THIS IMPACT; HOWEVER, THE AIR BAG DID NOT DEPLOY RESULTING IN DRIVER INJURIES.*AK
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10103043December 15, 2004
SUSPENSION, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, POWER TRAIN:DRIVELINE:UNIVERSAL JOINT
I HAVE A 2002 TOYOTA TUNDRA WITH 39,000 MILES ON IT. I WAS GOING 15-20 MPH AND APROACHING A ON RAMP TO THE HIGHWAY WHEN MY FRONT DRIVERS SIDE BALL JOINT SNAPPED. I HAD MY 4 MONTH OLD SON IN THE CAR WITH ME. LUCKILY I WAS ABLE TO STOP WITHOUT GETTING INTO A ACCIDENT BUT WONDER WHAT WOULD HAVE HAPPENED IF WE WERE ON THE HIGHWAY. TOYOTA SAID I MUST HAVE HIT SOMETHING IN ORDER FOR IT TO FAIL AND REFUSED TO CONTACT THE NHTSA AND REFUSED TO COVER THE EXPENSE OF HAVING IT FIXED. $1900.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10108910December 10, 2004
SERVICE BRAKES, HYDRAULIC
BRAKES ARE DEFECTIVE, THE PULSATION OF THE BRAKES IS CRITICAL AND DANGEROUS. *BF THE CONSUMER STATED THAT APPARENTLY THERE WAS A SERVICE ALERT CONCERNING THE PULSATING BRAKES OF THIS VEHICLE GOOD UP TO 36000 MILES. THE CONSUMER HAD THE BRAKES REDONE AT 59000 MILES BEFORE HE RECEIVED THE ALERT. AT 83000 MILES THE PULSATION OF THE BRAKES BECAME DANGEROUS AGAIN. THE CONSUMER WOULD LIKE TO KNOW WHAT RECOURSE TO TAKE IN REFERENCE TO THE DEFECTIVE BRAKES. *TC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10099209November 22, 2004
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
WHEN BRAKING, THE CONSUMER FELT A VIBRATION COMING FROM THE FRONT END. *JB THE ROTORS WERE WARPED. *SC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra