Toyota Tundra Complaints (2003)

399 consumer complaints on file.

#10190158May 8, 2007
TIRES:TREAD/BELT
TIRE FAILURE: TOYOTA TUNDRA 2003 EQUIPPED WITH DUNLOP GRAND TREK P265/70R16 TIRES: THE TIRES DEVELOPED 5" LONG CRACKS BETWEEN THE TREADS PARALLEL WITH THE TREADS ON THE WEAR SURFACE. THE TIRES WERE THE ORIGINAL EQUIPPED TIRES ON THE VEHICLE FROM THE MANUFACTURER. THE VEHICLE WAS MANUFACTURED IN 08/03. MILEAGE OF THE VEHICLE WAS 8,126 MILES. THE VEHICLE WAS NONCOMMERCIAL, LIGHT DUTY WORK AND HAS BEEN PARKED IN A CLOSED LOCATION-GARAGE. THERE WAS NO EVIDENCE OF WEATHER CHECKING ON THE TIRES AND THE TREAD DEPTH WAS NEAR NEW. THERE HAS BEEN NO OFF ROAD USE OF THE VEHICLE. THERE HAS BEEN VERY LIMITED TOWING USE OF LESS THAN 1,500 LBS OF TOTAL TOWED WEIGHT. THE TREAD SEPARATION OCCURRED ON THE RIGHT FRONT TIRE.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10188864April 25, 2007
UNKNOWN OR OTHER
THE 2003 TOYOTA TUNDRA ACCESS CAB TRUCK IS NOT COMPATIBLE WITH THE LATCH CARSEAT SYSTEM. THE TOP HOOK ON THE TRUCK IS LARGER IN SIZE THAN THE HOOKS ON THE CARSEATS. IT IS IMPOSSIBLE TO INSTALL A CARSEAT IN EITHER THE RIGHT OR LEFT POSITION IN THE REAR SEAT OF THE TUNDRA. I COMPLAINED TO TOYOTA AND THE DID REDESIGN THE 2004 TUNDRA TO BE COMPATIBLE BUT DID NOT OFFER A SOLUTION FOR THE PROBLEM WITH THE 2003 TUNDRA. MY LOCAL TOYOTA DEALERSHIP MADE A MODIFIED TETHER FOR MY CHILD'S CARSEAT WITH A LARGER HOOK ATTACHED THAT WOULD FIT THE TUNDRA HOOK. TOYOTA AS A MANUFACTURE DID NOT PROVIDE A SOLUTION HOWEVER. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10185365March 16, 2007
ENGINE AND ENGINE COOLING
I BOUGHT MY 2003 TUNDRA NEW.GOT 15,000 MILES ON IT WHEN THE ENGINE LIGHT SHOW.THE DEALER THEY FIXED IT AND AGAIN NOW AT 49,000 MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10184411March 7, 2007
EXTERIOR LIGHTING
LAST WEEK I PURCHASED A 2003 TOYOTA TUNDRA LIMITED 4X4 FROM A USED CAR DEALER. AFTER GETTING THE VEHICLE HOME (8.5 HOURS AWAY), I NOTICED THE LEFT SIDE CARGO LIGHT (EXTERIOR NEXT TO THE 3RD BRAKE LIGHT) WAS BURNED OUT. WHEN I REMOVED THE LENS TO DETERMINE THE LIGHT NUMBER NEEDED FOR REPLACEMENT, I FOUND THE HOUSING TO BE MELTED. UPON INSPECTION, THE BULB WAS THE RECOMMENDED BULB BY THE MANUFACTURER. MY CONCERN IS THAT THIS IS A MANUFACTURER DEFECT THAT COULD CAUSE A FIRE IN THE VEHICLE. I CAN PROVIDE PHOTOS OF THE HOUSING AND THE BULB IF REQUIRED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10183379February 23, 2007
STEERING:LINKAGES:TIE ROD ASSEMBLY
TL*- WHILE DRIVING AT 55 MPHTHE 2003/TOYOTA/TUNDRA RAN INTO THE RETAINER WALL BECAUSE THE TIE ROD ON THE PASSENGER'S SIDE SNAPPED, LIFTING THE TRUCK. ON JANUARY 11 2006 THE DEALER FIXED THE RECALLED TIRE ROD END AND BALL JOINT. THE CONTACT BELIEVED THAT THEY SHOULD HAVE ALSO REPLACED THE ENTIRE ROD ITSELF, THEY DID NOT. HE HAD THE TRUCK FOR SEVENTEEN DAYS WHEN THE TIE ROD SNAPPED. THIS ALMOST KILLED HIS ENTIRE FAMILY. HIS WAS TOLD TO CALL THE HOT LINE BY THE DEALER. THE CURRENT AND FAILURE MILEAGE WERE BOTH 41000.*AK
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10181002January 29, 2007
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
TL* - THE CONTACT OWNS A 2002 TOYOTA TUNDRA PICKUP. THE CONTACT STATED THAT THEREWAS A SAFETY RECALL ON THE LOWER BALL JOINTS. THE CONTACT TOOK THE VEHICLE TO HAVE THE SAFETY RECALL REPAIRED, AND TWO WEEKS LATER WHILE DRIVING AT 30 MPH IN BEAUTIFUL WEATHER, THE LOWER BALL JOINT ON THE FRONT LEFT SIDE CAME APART, AND THE CONTACT'S VEHICLE HIT A SECOND VEHICLE. THE CONTACT STATED THAT THE POLICE DID NOT TAKE A REPORT. THE CONTACTWAS EMPLOYED AS A SENIOR ENGINEER TECHNICIAN, AND HE NEEDED THE VEHICLE TO DO HIS JOB, AND HE HAS NOT BEEN PROVIDED ANOTHER VEHICLE WHILE THE VEHICLE WAS BEING INVESTIGATED. *AK
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10178793January 16, 2007
AIR BAGS:ON-OFF SWITCH ASSEMBLY
TL * - THE CONTACT HAS A 2003 TOYOTA TUNDRA. THE CONTACT STATED THAT HE HAD A SAFETY RECALL NUMBER (05V254000) ON HIS VEHICLE. THE CONTACT TOOK HIS VEHICLE TO THE DEALER 01/16/2007, AND THE DEALER SAID THAT THEY WOULD AFFIX A NEW STICKER TO THE SUN VISOR AND THAT WAS THERE REMEDY. THE CONTACT IS CONCERNED THAT THE SAFETY RECALL STATED MORE TO THE REMEDY THAN WHAT THE DEALER IS WILLING TO REPAIR. THE CONTACT WOULD LIKE TO KNOW WHAT IS CORRECT, WHAT IS STATED IN THE SAFETY RECALL OR WHAT THE DEALER STATED HE WOULD DO. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10177713January 3, 2007
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
I HAVE A 2003 TUNDRA AND THE BRAKES VIBRATE WHEN APPLIED. THIS IS A SAFETY ISSUE ESPECIALLY IN SNOW SLUSH AND RAIN. I REFUSE TO PAY $2,000 FOR A MANUFACTURING DEFECT. I ALSO SEE IT AFFECTS MANY OTHER OWNERS. HOPEFULLY I DON'T GET HURT! *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10168182September 13, 2006
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
EXCESSIVE VIBRATION WHILE SLOWING TO A STOP. STEERING WHEEL SHAKES AND VERY MINOR BRAKE PEDAL PULSATION. FRONT BRAKE PAD REPLACEMENT MINIMIZES ISSUE FOR SHORT PERIOD OF TIME BEFORE RECURRENCE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10167887September 11, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
I HAVE HAD MY ROTORS RESURFACED TWICE ONCE AT 20000 AND JUST NOW AT 40000. JUST ABOUT WENT OFF A CLIFF LAST TIME BECAUSE OF THE VIBRATION. WARPED ROTORS EVERY 20000 MILES SEEMS QUITE MUCH. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10166189August 22, 2006
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
I TOOK MY 2003 TOYOTA TUNDRA IN TO TOYOTA MOTORS, GUAM BECAUSE I HAD A CHECK ENGINE LIGHT. TOYOTA THEN SENT A MESSAGE TO MY VEHICLE SERVICE CONTRACT, WARRANTECH AUTOMOTIVE INC AND THEY SAID THAT THE FUEL FILLER NECK HOSE ASSEMBLY WAS NOT COVERED. READING INFORMATION ON THE INTERNET INDICATES THAT THIS IS A COMMON PROBLEM WITH THE 2003 TOYOTA TUNDRA DUE TO A "OUT OF ROUND" GAS FILLER TUBE. THERE SHOULD BE A RECALL ON THIS PART. PLEASE ASSIST CONSUMERS LIKE MYSELF FOR TOYOTA MOTORS TO INVESTIGATE THIS DEFECT WITH THE 2003 TOYOTA TUNDRA. THE WORD NEEDS TO GET OUT. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162303July 13, 2006
WHEELS, WHEELS:LUGS/NUTS/BOLTS/STUDS
2003 TOYOTA TUNDRA EXTENDED CAB I CHECKED MY FRONT BRAKE PADS. WHEN I REPLACED THE TIRE, TWO LUG BOLTS FAILED AT 70FT/LBS OF TORQUE. THE SPECIFICATIONS ARE TIGHTEN TO 80FT/LBS. WHEN I PURCHASED NEW BOLTS AT A DEALER, THE PARTS COUNTERMAN SAID HE WAS SELLING A LOT OF THESE LATELY. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161489July 5, 2006
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
THE BOLTS ON MY TUDNRA'S LEFT BALL JOINT SHEARED OFF AND THE LEFT FRONT WHEEL COLLAPSED ON JUNE 12, 2006. THE FAILURE OCCURRED IN PAGE, ARIZONA WHILE WE WERE ON VACATION. THE FAILURE OCCURRED AFTER OUR DEALER FIXED THE JOINTS ON APRIL 17, 2006 PURSUANT TO TOYOTA'S RECALL NOTICE FOR THIS PROBLEM. WE CONSIDER OURSELVES FORTUNATE TO BE ALIVE. I AM GIVING SIMILAR NOTICES TODAY TO DEALER AND TOYOTA. OUR TUNDRA IS CURRENTLY AT THE BODY SHOP IN PAGE, AZ. THERE WAS SOME BODY DAMAGE TO THE RIGHT FRONT SIDE. THE WORK WILL BE DONE BY THIS FRIDAY, JUNE 7. WE INTEND TO PICK UP THE CAR THEN. I HAVE THREE OF THE BOLTS THAT CAME OFF (TWO OF THEM THAT I PICKED UP ON THE STREET WERE SHEARED) AND HAVE ASKED THE REPAIR SHOP TO SAVE ALL PARTS THAT THEY REMOVED AND REPLACE. I ALSO HAVE PHOTOS OF THE TUNDRA AT ITS POINT OF REST IN THE STREET. BECAUSE OF TRAFFIC CONTROL PROBLEMS, THE PAGE POLICE RESPONDED TO THIS INCIDENT. THE OFFICER IN CHARGE WAS C. MILLER, BADGE 523. HE ALSO PROVIDED ME WITH A ANOTHER NUMBER (I DON'T KNOW IF THIS IS AN INCIDENT NUMBER): 06/06/1420. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161233July 2, 2006
AIR BAGS:FRONTAL
AIR BAG WARNING LIGHT CAME ON IN LESS THAN 36 MONTHS AFTER WARRANTY EXPIRED DUE TO MILEAGE. COST TO REPAIR EXCEEDED $1,200. SHOULDN'T THESE GOVERNMENT MANDATED SAFETY FEATURES BE COVERED BY A LONGER WARRANTY? *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161060June 29, 2006
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
DT*: THE CONTACT STATED THE STEERING WHEEL WAS HARD TO TURN. THERE IS AN NHTSA RECALL #05V225000 CONCERNING THE FRONT LOWER BALL JOINT. THE CONTACT HAS BEEN WAITING FOR SIX MONTHS TO GET A LETTER FROM THE MANUFACTURER SO THAT THE DEALER WILL REPAIR THE RECALLED PART.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160188June 19, 2006
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
I'M THE OWNER OF A 2003 TOYOTA TUNDRA (LIMITED SLIP DIFFERENTIAL) SR5 4X4. IN APR I BROUGHT MY TRUCK INTO THE UNIVERSAL TOYOTA DEALER HERE IN SAN ANTONIO TX TO REPLACE A MISSING CLAMP AND FOR A RUMBLING NOISE COMING FROM UNDERNEATH THE TRUCK. THE FIRST MECHANIC SAID HE COULDN'T HEAR THE NOISE, AND AGAIN I BROUGHT THE TRUCK BACK IN JUN AS THE NOISE WAS GETTING WORSE. THE LEAD MECHANIC THEN HEARD IT AND SAID THAT THE NOISE IS COMING FROM THE DIFFERENTIAL AND THAT HE HAS ANOTHER TUNDRA DOING THE SAME THING. I ASKED THAT HE CALL THE TOYOTA TECH LINE TO INQUIRE/REPORT THIS. HE NOTIFIED ME THE NEXT DAY THAT THE TOYOTA TECH PERSON SAID THAT THIS IS A NORMAL SOUND AND NOT TO WORRY ABOUT IT. HOWEVER I DO HAVE SOME SAFETY CONCERNS AS I DON'T BELIEVE THIS TO BE A "NORMAL" INDICATION OF WHAT A DIFFERENTIAL SHOULD SOUND LIKE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10159031June 5, 2006
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
DT*: THE CONTACT STATED RECALL WORK WAS PERFORMED A MONTH AGO ON THE VEHICLE, WHILE DRIVING 40 MPH, THE FRONT OF THE VEHICLE DROPPED. THE VEHICLE WAS MOVED OFF THE ROAD AND TOWED TO THE DEALER. A NHTSA RECALL, #05V225000 WAS PERFORMED ON THE VEHICLE CONCERNING, THE FRONT LOWER BALL JOINT HOWEVER, THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP DID OFFER A SECOND REPAIR WITHOUT CHARGE UNDER THE RECALL. UPDATED 11/21/2006 - *NM
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10155808April 21, 2006
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
FUEL TANK FILLER WAS GIVING AS THE REASON OF MY TRUCKS PROBLEM BEFORE IT WAS LOOKED AT BY A TECHNICIAN. I WAS TOLD THAT THIS WAS A COMMON PROBLEM WITH THESE TRUCKS. THE FAULT WOULD CAUSE THE EMISSIONS SYSTEM TO FAIL AND THEREFORE WOULD ALSO BE A HAZARD BECAUSE IT COULD CAUSE A FIRE AT THE TIME THE TRUCK WAS BEING FILLED OR FROM ESCAPING VAPORS. THE PART WAS (IS) BEING REPLACED AND IS COSTLY TO THE CONSUMER. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10155635April 18, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
THE ROTORS ON MY 2003 TUNDRA ARE WARPING EVERY 1,000 MILES OR SO. THIS IS A KNOWN SAFETY PROBLEM AND TOYOTA SHOULD BE RESPONSIBLE FOR REMEDYING THE ISSUE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10154747April 6, 2006
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
THERE IS A FLAWED DESIGN OF THE FUEL FILLER TUBE CAUSING AN INTERMITTENT CHECK ENGINE LIGHT. THIS IS A KNOWN PROBLEM THAT TOYOTA HAS WITH ITS 2003-2004 TUNDRAS. THE PROBLEM AFFECTS FUEL VAPOR EMISSIONS FROM THE GAS TANK. THEY OFFER NO SUPPORT ONCE ONE IS OUT OF WARRANTY EVEN THOUGH THEY ARE AWARE OF THEIR FAULTY DESIGN/BUILD OF THIS PART. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra